Zanussi ZCM 700 X User manual

MIXED FUEL
COOKER
ZCM 700 X
INSTRUCTION BOOKLET
Please read this instruction booklet before using the appliance

2
Important Safety Information
You MUST read these warnings carefully before installing or using the
appliance. If you need assistance, contact our Customer Care Department
on 08705 727727
Installation
●This cooker must be installed by qualified
personnel, according to the manufacturer’s
instructions and to the relevant British Standards.
●This cooker is heavy. Take care when moving it.
Do not move the cooker using the oven door
handle. When moving it, take care not to make it
slide on the floor, because this will damage the
cooker’s feet.
●Any gas installation must be carried out by a
registered CORGI installer.
●Remove all packaging before using the cooker.
●Ensure that the gas and electrical supply complies
with the type stated on the rating plate, located
near the gas supply pipe.
●Do not attempt to modify the cooker in any way.
Child Safety
●This cooker is designed to be operated by adults.
Do not allow children to play near or with the
cooker.
●The cooker gets hot when it is in use. Children
should be kept away until it has cooled.
●Children can also injure themselves by pulling
pans or pots off the cooker.
During Use
●This cooker is intended for domestic cooking only.
It is not designed for commercial or industrial
purposes.
●When in use a gas cooker will produce heat and
moisture in the room in which it has been
installed. Ensure there is a continuous air supply,
keeping air vents in good condition or installing a
cooker hood with a venting hose.
●When using the cooker for a long period time, the
ventilation should be improved, by opening a
window or increasing the extractor speed.
●Do not use this cooker if it is in contact with
water. Do not operate the cooker with wet hands.
●Ensure the control knobs are in the ‘OFF’ position
when not in use.
●When using other electrical appliances, ensure the
cable does not come into contact with the hot
surfaces of the cooker.
●Unstable or misshapen pans should not be used on
the hob burners as unstable pans can cause an
accident by tipping or spillage.
●Never leave the cooker unattended when cooking
with oil and fats.
●This cooker should be kept clean at all times. A
build-up of fats or foodstuffs could result in a
fire.
●Never use plastic dishes in the oven or on the hob
burners.
Never line any part of the oven with
aluminium foil.
●Always ensure that the oven vent which is located
at the centre back of the hob is left unobstructed to
ensure ventilation of the oven cavity.
●Perishable food, plastic items and areosols may be
affected by heat and should not be stored above
the cooker.
Service
●This cooker should only be repaired or serviced by
an authorised Service Engineer and only genuine
approved spare parts should be used.
Environmental Information
●After installation, please dispose of the packaging
with due regard to safety and the environment.
●When disposing of an old appliance, make it
unusable, by cutting off the cable.
Keep this instruction book for future
reference and ensure it is passed on
to any new owner.

3
This appliance is manufactured according
to the following EEC directives:
73/23 EEC - 90/683 EEC - 93/68 EEC -
89/336 EEC current edition.
Contents
Guide to Use the instructions
The following symbols will be found in the text to
guide you throughout the Instructions:
Safety Instructions
Step by step instructions for an
operation
Hints and Tips
☞
i
Important Safety Information.............. 2
Description of the Cooker.................... 4
Control Panel ...................................... 5
The Oven Cavity .................................................5
Accessories ..........................................................5
Operation ............................................ 6
Before the First Use of the Oven .......... 8
Using the Oven .................................... 8
Using the Conventional Oven ............ 10
Cooking Chart ...................................................11
Using the Fan Oven
& Defrosting function ........................ 12
Roasting Chart ................................................... 14
Cooking Chart ...................................................14
Defrosting Chart ................................................15
Grilling.............................................. 16
Cleaning the Hob ............................... 17
Cleaning the Oven ............................. 18
If something goes wrong.................... 20
Peace of Mind for 12 Months ............. 21
Service and Spare Parts ..................... 21
Instructions for the Installer ............. 22
Technical Data ...................................................22
Important Safety Requirements......... 23
Feet Assembly ...................................................25
Splash back Assembly .......................................26
Installation........................................ 27
Electrical connections ....................... 29
Commissioning.................................. 30
Conversion from Natural to LPG Gas.. 31
For the User For the Installer

4
Description of the Cooker
Splash back
Rapid burner
Semi-rapid burner
Auxiliary burner
Semi-rapid burner
Double-crown
burner
Adjustable foot
Oven door
window
Oven door
handle
Control
panel
Storage drawer
(on request)
INSTALLATION
Any gas installation must be carried out by
a registered CORGI installer, and in
accordance with existing rules and
regulations.
The relevant instructions are to be found in the
second section of this manual.
Please ensure that when the appliance is installed, it
is easily accessible for the engineer in the event of a
breakdown.
WHEN THE COOKER IS FIRST INSTALLED
Once the cooker has been installed, it is
important to remove any protective
materials, which were put on in the factory.

5
1. Electric ignition push button
2. Back left burner control knob (rapid)
3. Front left burner control knob (semi-rapid)
4. Central burner control knob (double crown)
5. Front right burner control knob (auxiliary)
Control Panel
The Oven Cavity
Grill element Oven Light
Accessories
Oven fan
Grill trivet
Grill/roasting pan
Removable
handles
100
150
200
MAX
50
0
51
0
3
54
76543
1289
1110
Telescopic shelf
supports
6. Back right burner control knob (semi-rapid)
7. Oven function control knob
8. Oven thermostat control knob
9. Minute minder control knob
10. General control lamp
11. Oven control lamp

6
HOB BURNERS
To light a burner, turn the relevant control knob
anticlockwise to maximum position. At the same time
push the electric ignition button which is marked with
a little spark. Upon ignition, keep the knob pushed
down about 5 seconds, then adjust the flame as
required.
If the burner does not ignite, turn the control knob to
zero, and try again.
When switching on the mains, after
installation or a power cut, it is quite normal
for the spark generator to be activated
automatically.
To ensure maximum burner efficiency, you should
only use pots and pans with a flat bottom fitting the
size of the burner used (see table).
If you use a saucepan which is smaller than
the recommended size, the flame will spread
beyond the bottom of the vessel, causing the
handle to overheat.
As soon as a liquid starts boiling, turn down
the flame so that it will barely keep the
liquid simmering.
Take care when frying food in hot oil or fat,
as the overheated splashes could easily
ignite.
If the control knobs become difficult to turn,
please contact your local Electrolux Service
Centre.
Burner minimum maximum
diameter diameter
Large (rapid) 160 mm. 260 mm.
Medium (semi-rapid) 120 mm. 240 mm.
Small (Auxiliary) 80 mm. 160 mm.
Central (2 crown) 180 mm. 260 mm.
Operation
i
i

7
Oven Function Control Knob
Oven Light - The oven light will be on without
any cooking function
Conventional cooking - The heat comes from
both the top and bottom element, ensuring even
heating inside the oven.
Fan cooking and defrost setting - This function
allows you to roast or roast and bake
simoultaneously using any shelf. It can also be
used to assist in thrawing of frozen food (see
page 12).
Grill - The heat comes only from the top
element.
Electric Oven
Thermostat Control Knob
Turn the thermostat control knob clockwise to select
temperatures between 50°C and 250°C (MAX).
Minute minder
The minute minder will mark the end of a timed
period with an acoustic alarm. The maximum timing
is 60 minutes.
Turn the Minute Minder knob clockwise to the
maximum time position, then turn it back to the
required time.
The Minute minder will not affect in any way the
oven operation, if it is in use.
0
51
0
3
54
OFF
100
150
200
50
OFF

8
Before the First Use of the Oven
Remove all packaging, both inside and
outside the oven, before using the oven.
Before first use, the oven should be heated without
food. During this time, an unpleasant odour may be
emitted. This is quite normal.
☞1. Switch the oven function control knob to
conventional cooking .
2. Set the thermostat control knob to MAX.
3. Open a window for ventilation.
4. Allow the oven to run empty for
approximately 45 minutes.
This procedure should be repeated with the fan
cooking and grill function for approximately 5-10
minutes.
Using the Oven
• Always cook with the oven door closed.
• Stand clear when opening the drop
down oven door. Do not allow it to fall
open - support the door using the door
handle, until it is fully open.
• The oven has four shelf levels, and is
supplied with two shelves. Level 2 and 4
from the bottom are supplied with
special telescopic shelf supports (see
next page).
The shelf positions are counted from the
bottom of the oven as shown in the
diagram.
• Do not place cookware directly on the
oven base.
i
4
3
2
1
NORMAL SHELF
ANTI-TIP SHELF
metal tabs
Your oven is supplied with one normal shelf for use
on the telescopic shelf supports and one anti-tip shelf. The anti-tip shelf has four small metal tabs on its frame to prevent it from sliding out from the shelf
supports.

9
Condensation and steam
When food is heated it produces steam in the same
way as a boiling kettle. The oven vents allow some of
this steam to escape. However, always stand back
from the oven when opening the oven door to
allow any build up of steam or heat to release.
If the steam comes into contact with a cool surface on
the outside of the oven, e.g. a trim, it will condense
and produce water droplets. This is quite normal and
is not a fault with the oven.
To prevent discoloration, regularly wipe away
condensation and also soilage from surfaces.
Hints andTips
Telescopic shelf supports
The oven shelf supports are provided with telescopic
shelf supports at level 2 and 4 from the bottom.
1. Pull the right and left hand telescopic shelf
supports completely out, as shown in the
diagram.
2. Place the shelf or the dripping pan on the
telescopic shelf supports, as shown in the
diagram, then gently push them all inside
the oven.
Do not attempt to close the oven door if the
telescopic shelf supports are not completely
inside the oven. This could damage the door
enamel and glass.
The anti-tip shelf is not designed for use on
the telescopic shelf supports.
Please, do not use the anti-tip shelf on the
telescopic shelf supports, as it will be
unstable and may fall.
☞
Cookware
• Use any oven proof cookware which will
withstand temperatures of 250°C.
• Baking trays, oven dishes, etc. should not be
placed directly against the grid covering the fan at
the back of the oven, or placed on the oven base.
• Do not use baking trays larger than 30 cm x 35 cm
(12 in x 14 in) as they will restrict the circulation
of heat and may affect performance.
i
The effects of dishes
on cooking results
Dishes and tins vary in their thickness, conductivity,
colour, etc. which affects the way they transmit heat
to the food inside them.
AAluminium, earthenware, oven glassware and
bright shiny utensils reduce cooking and
underneath browning.
BEnamelled cast iron, anodized aluminium,
aluminium with non-stick interior and coloured
exterior and dark, heavy utensils increase cooking
and underneath browning.

10
Using the Conventional Oven
When using this setting, heat comes from both the top
and bottom elements. This allows you to cook on a
single level and is particularly suitable for dishes
which require extra base browning such as pizzas,
quiches and flans.
Gratins, lasagnes and hotpots which require extra top
browning also cook well in the conventional oven.
This form of cooking gives you the opportunity to
cook without the fan in operation.
☞
How to Use the
Conventional Oven
1. Turn the oven function control knob to the required
cooking function ( ).
2. Turn the thermostat control to the required tempe-
rature.
THINGS TO NOTE
● The oven light will come on when the oven
function control knob is set.
● The thermostat control light will remain on until
the correct temperature is reached. It will then
cycle on and off to show that temperature is being
maintained.
The middle shelf position allows for the best heat
distribution. To increase base browning simply lower
the shelf position. To increase top browning, raise the
shelf position.
The material and finish of the baking trays and
dishes used will affect base browning. Enamelware,
dark, heavy or non-stick utensils increase base
browning, while oven glassware, shiny aluminium or
polished steel trays reflect the heat away and give less
base browning.
Always place dishes centrally on the shelf to ensure
even browning.
Stand dishes on suitably sized baking trays to prevent
spillage onto the base of the oven and make cleaning
easier.
Do not place dishes, tins or baking trays directly on
the oven base as it becomes very hot and damage will
occur.
For faster preheating use the fan oven function to
preheat the oven until the oven indicator neon goes
out, then swich the selector to the conventional oven
setting.
i
Hints andTips
Single level cooking gives best results. If you
require more than one level cooking use the fan
oven function.
i

11
Cooking Chart
Biscuits, cookies 170-200 3 25-20 min.
Bread, yeast doughs 200-230 2 35-45 min.
Casseroles 140-170 2 90-180 min.
Small cakes 170-180 2 18-25 min.
Cakes Madeira 160-180 2 60-90 min.
Rich fruit 130-140 2 60-150 min.
Choux pastry, eclairs 200-230 2 30-35 min.
Fish 200-230 2 or 3 20-40 min.
Fruit pies, plate tarts, crumbles 180-210 2 50-65 min.
Meringues 90-100 2 90-150 min.
Milk puddings 140-160 2 90-150 min.
Paté, terrine (in bain marie) 160-180 1 60-90 min.
Pizzas 200-230 2 25-30 min.
Puff pastry, vol au vents 230-260 2 15-25 min.
Quiches, flans 170-200 2 50-60 min.
Scones 210-220 2 8-12 min.
Soufflé 200-230 2 35-45 min.
Stuffed vegetables 230-250 2 34-45 min.
Roast meat + poultry: see chart at page 16
Yorkshire pudding 200-230 2 40-50 min.
Keeping warm, heating dishes 90-100 2
Food Thermostat Runner Time
Position

12
The air inside the oven is heated by the element
around the fan situated behind the back panel. The
fan circulates hot air to maintain an even temperature
inside the oven.
The advantages of cooking with this function are:
✓ Faster Preheating
As the fan oven quickly reaches temperature, it is
not usually necessary to preheat the oven
although you may find that you need to allow an
extra 5-7 minutes on cooking times. For recipes
which require higher temperatures, best results
are achieved if the oven is preheated first, e.g.
bread, pastries, scones, souffles, etc.
✓Lower Temperatures
Fan oven cooking generally requires lower
temperatures than conventional cooking.
Follow the temperatures recommended in the
chart at page. 14. Remember to reduce
temperatures by about 20-25°C for your own
recipes which use conventional cooking.
✓Even Heating for Baking
The fan oven has uniform heating on all runner
positions. This means that batches of the same
food can be cooked in the oven at the same time.
However, the top shelf may brown slightly
quicker than the lower one.
This is quite usual. There is no mixing of flavours
between dishes.
☞
How to Use the Fan Oven
1. Turn the oven function control knob to .
2. Turn the thermostat control to the required tempe-
rature.
THINGS TO NOTE
● The oven light will come on when the oven
function control knob is set.
● The thermostat control light will remain on until
the correct temperature is reached. It will then
cycle on and off to show that temperature is being
maintained.
Using the Fan Oven & Defrosting function
Runner positions are not critical, but make sure the
shelves are evenly spread.
When cooking more than one dish in the fan oven,
place dishes centrally on the shelves rather than
several dishes on one shelf.
When the oven is full, you may need to allow slightly
longer cooking time.
A shelf may be placed on the floor of the oven. Place
dishes on a shelf in this position rather than on the
oven base, to allow air circulation around the food.
When the oven is full of the same food, e.g. equal
trays of small cakes or equal size victoria sandwich
cakes, then they will be cooked in the same time and
removed from the oven together. When different sizes
of trays or types of food, e.g. biscuits and cakes are
cooked, they will not necessarily be ready together.
The fan oven can be used to heat foods through
without thawing first, e.g. fruit tarts, mince pies,
sausage rolls, and other small pastry items. Use a
temperature of 190-200°C and allow 20-40 minutes
(depending on the quantity of food in the oven).
The use of too high temperatures can cause uneven
browning. Check with the recommendations for oven
temperatures given in the cooking charts, but be
prepared to adjust the temperature by 10°C if
necessary. Remember to reduce temperatures by
about 20-25°C for your own conventional recipes.
When roasting do use the trivet in the meat tin. Fat
and meat juices will drain into the meat tin below and
can be used to make gravy. The trivet also prevents
splashes of fat from soiling the oven interior.
The meat tin should not be placed on a heated
hotplate or burner as this may cause the enamel to
crack.
i
Hints andTips

13
☞
How to Use Defrosting
1. Turn the oven function control knob to .
2. Ensure the thermostat control knob is in the OFF
position.
The oven fan operates without heat and circulates the
air, at room temperature, inside the oven. This
increases the speed of defrosting. However, please
note that the temperature of the kitchen will influence
the speed of defrosting.
This function is particularly suitable for delicate food
which could be damaged by heat, e.g. cream filled
gateaux, iced cakes, pastries, bread and other yeast
products.
i
Hints andTips
• Cover food with a lid, aluminium foil or plastic
film to prevent drying out during defrosting.
• ALWAYS COOK THOROUGHLY
IMMEDIATELY AFTER THAWING.
• Frozen food should be placed in a single layer
when ever possible and turned over half way
through the defrosting process.
• Only joints of meat and poultry up to 2 kg. (4 lb.)
are suitable for defrosting in this way.
Refer to the table at page 15 for approximate
defrosting times.

14
This chart is intended as a guide only. It may be necessary to increase or decrease the temperature to suit your
individual requirements. Only experience will enable you to determine the correct setting for your personal
requirements.
Cooking Chart
Food Thermostat Runner Time
Position
Biscuits, cookies 2 trays 160-190 1-3 18-25 min.
Bread, yeast doughs 2 trays 170-200 1-3 35-45 min.
Cakes, Victoria sandwich 2 trays 160-170 1-3 20-28 min.
Choux pastry, eclairs 2 trays 170-200 1-3 30-35 min.
Fruit pies, plate tarts, crumbles 2 trays 170-200 1-3 50-65 min.
Meringues 2 trays 70-90 1-3 90-150 min.
Puff pastry, vol au vents 2 trays 200-230 1-3 20-35 min.
Scones 2 trays 200-210 1-3 8-12 min.
Meat Thermostat Cooking
Beef 170°-180°C 20-30 min per 1/2 kg (1 lb) and 20-30 min over
Lamb 170°-180°C 25-35 min per 1/2 kg (1 lb) and 25-35 min over
Pork 170°-180°C 25-35 min per 1/2 kg (1 lb) and 25-35 min over
Chicken 170°-180°C 15-20 min per 1/2 kg (1 lb) and 20 min over
Turkey and groose 170°-180°C 15-20 min per 1/2 kg (1 lb) up to 3 1/2 kg (7 lb)
then 15 min per 1/2 kg (1 lb)
Duck 170°-180°C 25-35 min per 1/2 kg (1 lb) and 25-35 min over
Pheasant 170°-180°C 35-40 min per 1/2 kg (1 lb) and 35-40 min over
Rabbit 170°-180°C 20 min per 1/2 kg (1 lb) and 20 min over
When roasting, ensure the meat is cooked thoroughly, use a meat thermometer if preferred to check the centre
temperature has reached the required temperature (see table below).
Roasting Chart

15
Defrosting Chart
Chicken 1000 g. 100-140 20-30 Place the chicken on an inverted
saucer on a large plate. Defrost open
and turn at half time or defrost
covered with foil. Remove giblets
as soon as possible.
Meat 1000 g. 100-140 20-30 Defrost open and turn at
half time or cover with foil
Meat 500 g. 90-120 20-30 As above
Trout 150 g. 23-35 10-15 Defrost open
Strawberries 300 g. 30-40 10-20 Defrost open
Butter 250 g. 30-40 10-15 Defrost open
Cream 2 x 200 g. 80-100 10-15 Defrost open (cream is
easy to whip even if parts
of it are still slightly frozen)
Cake 1400 g. 60 60 Defrost open
Food Defrosting time
(Mins) Standing time
(Mins) Notes
The times quoted in the chart should be used as a guide only, as the speed of defrosting will depend on the kitchen
temperature. For example, the colder the ambient temperature, the longer the defrosting time.

16
Grilling
Grilling must be carried out with the oven
door closed. The grill pan handles must be
removed from the pan.
☞
How to Use the Grill
1. Turn the oven control function knob to .
2. Turn the thermostat control knob on the required
temperature.
3. Adjust the grid and grill pan runner position to
allow for different thicknesses of food. Position
the food close to the element for faster cooking
and further away for more gentle cooking.
Preheat the grill on a full setting for a few minutes
before sealing steaks or toasting. Adjust the heat
setting and the shelf as necessary, during cooking
During cooking, the thermostat control light will
operate in the same way as described for the fan oven
function.
- Most foods should be placed on the grid in the grill
pan to allow maximum circulation of air to lift the
food out of the fats and juices. Food such as fish,
liver and kidneys may be placed directly on the grill
pan, if preferred
- Food should be thoroughly dried before grilling to
minimise splashing. Brush lean meats and fish lightly
with a little oil or melted butter to keep them moist
during cooking
- Accompaniments such as tomatoes and mushrooms
may be placed underneath the grid when grilling
meats
- When toasting bread, we suggest that the top runner
position is used.
- The food should be turned over during cooking, as
required.
The grill element is controlled by the thermostat.
During cooking, the grill cycles on and off to
prevent overheating.
Hints andTips
i
OI
L
Bacon rashers 2-3 each side
Beefburgers 6-10 each side
Chicken joints 10-15 each side
Chops: 7-10 each side
10-15 each side
Fish: 8-12 each side
4-6 each side
Kebabs 10-15 each side
Kidneys: 4-6 each side
Liver: 5-10 each side
Sausages 10-15 turn as required
Steaks: 3-6 each side
6-8 each side
7-10 each side
Browning only 3-5
Food Conventional Grill
Time (Min)
lamb
pork
whole trout/herring
fillets plaice/cod
lamb/pig
lamb/pig
rare
medium
well

17
Before any maintenance or cleaning can be
carried out, you must DISCONNECT the
hob from the electricity supply.
The hob is best cleaned whilst it is still warm, as
spillage can be removed more easily than if it is left
to cool.
The HobTop
Regularly wipe over the hob top using a soft cloth
well wrung out in warm water to which a little
washing up liquid has been added. Avoid the use of
the following:
- household detergent and bleaches;
- impregnated pads unsuitable for non-stick saucepans;
- steel wool pads;
- bath/sink stain removers.
Should the hob top become heavily soiled, it is
recommended that a cleaning product such as Hob
Brite or Bar Keepers Friend is used.
Pan Supports
When washing the pan supports, take care when
drying them as the enamelling process occasionally
leaves rough edges. If necessay, remove stubborn
stains using a paste cleaner.
The Burners
The burner caps and crowns can be removed for
cleaning.
Wash the burners caps and crowns using hot soapy
water, and remove marks with a mild paste cleaner. A
well moistened soap impregnated steel wool pad can
be used with caution, if the marks are particularly
difficult to remove.
After cleaning, be sure to wipe dry with a soft cloth.
Cleaning the Hob

18
Before cleaning always allow the cooling
fan to cool the oven down before switching
off at the electricity supply.
The oven should be kept clean at all times.
A build-up of fats or other foodstuffs could
result in a fire, especially in the grill pan.
Cleaning materials
Before using any cleaning materials on your oven,
check that they are suitable and that their use is
recommended by the manufacturer.
Cleaners that contain bleach should NOT be used as
they may dull the surface finishes. Harsh abrasives
should also be avoided.
External cleaning
Regularly wipe over the control panel, oven door and
door seal using a soft cloth well wrung out in warm
water to which a little washing up liquid has been
added.
To prevent damaging or weakening the
door glass panels avoid the use of the
following:
• Household detergent and bleaches
• Impregnated pads unsuitable for non-
stick saucepans
• Brillo/Ajax pads or steel wool pads
• Chemical oven pads or aerosols
• Rust removers
• Bath/Sink stain removers
Clean the outer and inner door glass using warm
soapy water. Should the inner door glass become
heavily soiled it is recommended that a cleaning
product such as Hob Brite, or Bar Keepers Friend is
used.
DO NOT clean the oven door while the
glass panels are warm. If this precaution is
not observed the glass panel may shatter.
If the door glass panel becomes chipped or
has deep scratches, the glass will be
weakened and must be replaced to prevent
the possibility of the panel shattering.
Contact your local Service Centre who will
be pleased to advise further.
Cleaning the Oven

19
Oven Cavity
The enamelled oven cavity is best cleaned whilst the
oven is still warm.
Wipe the oven over with a soft cloth soaked in warm
soapy water after each use. From time to time it will
be necessary to do a more thorough cleaning, using a
proprietary oven cleaner.
If the soilage has become set, after the oven has
cooled down, the following process will help to
soften the splatters to help make cleaning easier.
☞1. Place the grill/ meat pan on the oven shelf
positioned in the lowest runner.
2. Add a few drops of washing-up liquid to the
pan and fill to about 12 mm. with boiling
water from the kettle.
3. Close the oven door, turn the oven function
knob on fan oven and set the thermostat
knob on 50°C.
4. After 15 minutes, turn off the thermostat
and allow the fan oven to continue without
heat for a further 5 minutes, when the
temperature of the water will have cooled
down.
5. Carefully remove the pan of water from the
oven and use normal oven cleaners to clean
away soil residues.
6. Leave a little of the soapy water to soak into
any burned on spillage on the floor of the
oven for a longer time if necessary.
Oven Shelves and Shelf Supports
To clean the oven shelves and the shelf supports, soak
in warm soapy water and remove stubborn marks
with a well wetted soap impregnated pad. Rinse well
and dry with a soft cloth.
The shelf supports can be removed for easy cleaning
(see diagram). Please, ensure the retaining nuts are
secure when refitting the shelf support.
When cleaning the shelf supports, take care not
to remove the lubricating grease behind the
telescopic runners. This is meant to ensure
their good operation.
i
Oven lamp replacement
Disconnect the appliance.
Unscrew the lamp and substitute it with another
suitable for higher temperature (300°C) having the
following characteristics:
Tension: 230-240V (50Hz)
Power: 25W
Convection: E14

20
If after all these checks, the cooker still does not
work, contact your local Zanussi Service Force
Centre.
When you contact them, they will need the following
information:
1. Your name, address and post code.
2. Your telephone number
3. Clear and concise details of the fault
4. The model and the serial number (which can be
found on the rating plate)
5. Date of purchase
If something goes wrong
SYMPTOM
■The cooker does not operate.
■The gas ring burns unevenly
■The oven does not come on
■The oven temperature light does not come on
■The oven light does not come on
■It takes too long to finish the dishes, or they are
cooked too fast.
■Steam and condensation settle on the food and the
oven cavity.
■The oven fan is noisy
SOLUTION
◆Check that the unit is plugged in and the electrical
supply is switched on
◆Check that the RCCB has not tripped (if fitted)
◆Check the mains fuse has not blown
◆Check the correct control knob has been turned.
◆Check the main jet is not blocked and the burner
crown is clear of food particles.
◆Check the burner cap and crown have been
replaced correctly, e.g. after cleaning.
◆Check the oven is in manual operation and that
both a cooking function and temperature have been
selected.
◆The socket switch or the switch from the mains
supply to the cooker are ON.
◆Select a temperature with the thermostat control
knob
◆Select a function with the oven function control
knob.
◆Select a function with the oven function control
knob
◆Check the light bulb, and replace it if necessary
(see "Replacing the Oven Light")
◆The temperature may need adjusting
◆Refer to the contents of this booklet, especially to
the chapter “Using the Oven”.
◆Leave dishes inside the oven no longer than 15-20
minutes after the cooking is completed.
◆Check that shelves and bakeware are not vibrating
in contact with the oven back panel.
Please note that it will be necessary to provide proof
of purchase for any in-guarantee service calls.
In-guarantee customers should ensure that the
above checks have been made as the engineer will
make a charge if the fault is not a mechanical or
electrical breakdown.