DèLonghi BG400 User manual

4
5
INTRODUCTION
Thank you for choosing a De’Longhi product.
Please take few moments to read the instructions to avoid risks
or damage to the appliance.
Symbols used in these instructions
Important warnings are identied by the symbols below.
It is important to respect the warnings.
Failure to respect the warnings could lead to electric shock,
serious injury, burns, re or damage to the appliance.
Danger!
Failure to observe the warning may result in life threatening
injury by electric shock.
Important!
Failure to observe the warning could result in injury or damage
to the appliance.
Danger of burns!!
Failure to observe the warning could result in burns or scalds.
Please note:
This symbol indicates recommendations and important
information for the user.
IMPORTANT SAFEGUARDS
READ ALL INSTRUCTIONS
Danger!
- Before plugging the appliance into the mains,
make sure that:
• The voltage indicated on the appliance rating
plate corresponds to your mains voltage;
• The mains socket is earthed. Failure to follow
these important safety instructions absolves the
manufacturer of all liability.
- Do not use the appliance outdoors.
- Never unplug from the mains socket by pulling
on the cable.
- Do not operate any appliance with a damaged
cord or plug or after the appliance malfunctions,
or has been damaged in any manner. Return
appliance to the nearest authorized service
facility for examination, repair or adjustment in
order to avoid a hazard.
- Unplug from outlet when not in use and
before cleaning. Allow to cool before putting
on or taking o parts, and before cleaning the
appliance.
- The grill plate connections must be dried
thoroughly before using again.
- Do not let cord hang over edge of table or
counter, or touch hot surfaces.
Important!
- This appliance is designed to cook food. Do not
use appliance for other than intended use.
It must never be modied or tampered with in
any way.
- Wait until the appliance is completely cold
before putting away.
- Do not move the appliance during use. Extreme
caution must be used when moving the grill
containing hot oil or other hot liquids.
- The appliance is designed and produced for
domestic use only.
- Only the appropriate De'Longhi connector must
be used: PPH-BG500-818 for the BG500/BG500C
appliance; PPH-BG400-817 for the BG400
appliance.
- The appliance is not intended for use by persons
(including children) with reduced physical,
sensory or mental capabilities, or lack of
experience and knowledge, unless they
have been given supervision or instruction
concerning use of the appliance by a person
responsible fortheir safety. Children should be
supervised to ensure that they do not play with
the appliance.
- Close supervision is necessary when the grill is
used by or near children.
- Keep the appliance and its cord out of reach of
children.
- Always use the appliance on a dry, level, heat
resistant surface at a height of at least 85 cm,
out of reach of children.
- Do not pull on the power cord, but rather on the

4
5
plug, to separate the appliance from the mains.
- Always attach plug to appliance rst, then plug
cord in the wall outlet. To disconnect, turn the
control to "l" position, then remove plug from
wall outlet.
- Do not leave the appliance unattended when it
is switched on, as this may be a source of danger.
- To protect against electric shock do not immerse
cord, plug or connector in water or other liquid.
- If necessary clean the connector body with a
damp cloth.
- The use of accessory attachments not
recommended by De’Longhi may cause injuries.
- WARNING: TO REDUCE THE RISK OF FIRE OR
ELECTRIC SHOCK, ONLY AUTHORIZED PERSONNEL
SHOULD DO REPAIRS.
Danger of burns!!
- Do not touch hot surfaces. Use handles or knobs.
- The temperature of accessible surfaces may be
high when the appliance is operating. Always
use the handgrip or oven gloves if necessary.
- Do not place ammable products near the
appliance.
- Do not place on or near a hot gas or electric
burner, or in a heated oven.
- WARNING: Charcoal or similar combustible fuels
must not be used with this appliance.
- CAUTION: Cook only with the drip tray in place.
Pour o the drip tray only when the appliance is
completely cool. Pay caution when pull out the
drip tray in order to avoid pour out of liquids.
Please note:
- Toavoidtheriskof re, donot cookfoodwrapped
in plastic lm or tinfoil or in plastic bags.
SAVE THESE
INSTRUCTIONS
For Household use only
Short cord instructions
- A short power cord is provided to reduce risks resulting
from becoming entangled in or tripping over a longer cord.
- Longer, detachable power supply cords or extension cords
are available and may be used if care is exercised in their
use.
- If an extension cord is used, the marked electrical
rating should be at least as great as the electrical rating
of the appliance. If the appliance is provided with 3-
wire, grounding type cord, the extension should be a
GROUNDING TYPE 3 - WIRE CORD. The longer cord should
be arranged so that it will not drape over the counter-top
or table top where it can be pulled on by children or tripped
over.
- Your product is equipped with a polarized alternating
current line plug (a plug having one blade wider than the
other). This plug will t into the power outlet only one
way. This is a safety feature. If you are unable to insert the
plug fully into the outlet, try reversing the plug. If the plug
should still fail to t, contact your electrician to replace
your obsolete outlet. Do not defeat the safety purpose of
the polarized plug.
DESCRIPTION (pag. 3)
1. Connector
2. Oil Drip Tray
3. Base
4. Safety Interlock
5a. Grill plate with non stick coating (only BG400 model);
5b. Grill and griddle plate with non stick coating (only BG500
model); Grill and griddle plate with ceramic coating (only
BG500C model).
6. Grill plate handles
7. Appliance handles
8. Fat Spray protector (Only on BG500C)
9. Spatula (Only on BG500C)
The unit can have dierent grill plate based on model.
• The grilling plate with the ribbed surface is suitable for the
typical grilling of steaks, cutlets or the like.
• The at plate with the smooth surface is used to
fry hellsh, eggs, sliced vegetables or the like (Only on
BG500\BG500C).

6
7
TECHNICAL DATA
BG400
Voltage: 120 V ~ 60Hz
Power: 1500 W
Size LxHxD: 480 x 90 x 345
Weight: 3,920Kg
BG500
Voltage: 120 V ~ 60Hz
Power: 1500 W
Size LxHxD: 570 x 90 x 345
Weight: 4,250Kg
BG500C
Voltage: 120 V ~ 60Hz
Power: 1500 W
Size LxHxD: 570 x 130 x 345
Weight: 4,640Kg
INSTALLATION AND MAINTENANCE
Before rst use
• Remove all packaging materials and any promotional
labels from the grill plate and the tray.
• Detach the connector and clean the grill plate by washing
with soap and water in a sink.
Rinse and dry thoroughly. Make sure the connector inlet on
the plate is fully dry.
• If the skillet is used on countertop made in solid surface
material (e.g. Silestone®, Corian®, etc.), follow carefully the
indications of countertop manufacturer and/or supplier.
• Condition the grill surface by applying a light coating of
vegetable oil. Wipe o excess oil.
Preparing the unit
• Set base on countertop. Insert in the drip tray. Match the
grill plate to the base as shown in gure. The terminal /
socket of the grill plate should be on the same side as the
safety interlock.
• Do not use the appliance if it is not installed following the
sequence as shown on page 3.
Switching the unit on
• Plug the connector fully into the terminal of the grill plate.
The connector cannot be plugged in completely unless the
grill plate is tted properly to the base.
• Plug the power cord into the wall outlet.
• Adjust the temperature dial to maximum setting.
The indicator light will light on. Preheat 4-6 minutes. The
light will cycle on and o during preheat.This is normal.
• Be sure the temperature control dial is on MAX for best
browning results and grill marks when barbecuing
hamburger, steaks, hot dogs, sausage, sh steaks, chicken
breasts and other meat.
Use MIN or MED setting to reheat previously cooked foods,
to keep foods warm, and when grilling more delicate foods
with lower cooking temperature.
Switching the unit o
• Turn the connector temperature dial to "l"position when
cooking is completed.
• Unplug the power cord from the wall outlet and allow to
cool before cleaning or removing any part.
• Hold the unit by the handles when turning it over.
• Never transport the unit when is hot. To transport the grill
plate use the handles (6).To transport the whole appliance
use the appliance handles (7).
Cooking times
• Use the following table as a guideline for food amounts and
cooking times.
Recipe cooking times are estimate. Cooking time will vary
based on the temperature of the grill, the surrounding air,
and the food itself.
The food to be cooked should always be at room
temperature. Never put frozen food directly onto the grill
plate.
Watch food carefully and adjust the cooking time as
necessary. Turn frequently for more even cooking.

7
Food Approx. Time (minutes) Doneness test
Steak 8 to 15 Until desired doneness
Bacon 8 to 15 Desired doneness
Pork chops, Boneless 15 to 20 Until no longer pink
Chicken pieces 25 to 30 Pierce with knife; juice run clear
1/2”thick Hamburgers 8 to 10 No pink meat
Sausage / patties 12 to 15 No pink meat
Hot dog 8 to 10 Hot through
Whole sh 8 to 10 Opaque and akes with fork
Fish llets 10 per inch thickness Opaque and akes with fork
GRILLING TIPS
• For best results, preheat the cooking plate before grilling.
• Tender slices of meat are generally more suitable for
grilling. Somewhat tougher meat will become tender if it
has been marinated overnight.
• To prevent scratching the cooking surface when turning
over the food, always use plastic or wood spatula. Never cut
foods on the plate surface.
• If cooking vegetables, sh, or lean meat, spray the cooking
surface with a light coating of vegetable oil. If cooking meat
with any amount of fat, or if the food has been marinated,
there is no need to treat the grill.
• Never cook meat too long.
• If the food being cooked sticks to the cooking plate, wipe
down the cooking plate from time to time with a paper
towel dipped in oil.
Please note:
• The rst time you use the Grill; it may have a slight odor and
may smoke a bit.This is normal and common to appliances
with nonstick surfaces.
• A plastic cleaning spatula can be used for cleaning the
grilling plate after you have nished cooking and the unit
has cooled down completely (at least 30 minutes). Using
the cleaning tool on a hot surface for too long will cause
the plastic to melt.
CARE AND CLEANING
• When nished cooking, unplug from the outlet and allow
the grill to cool completely before cleaning. Never transport
the unit when it is hot.
• Pull out the connector. If cleaning is necessary, wipe over
unit with a slightly damp cloth. DO NOT IMMERSE THE
CONNECTOR IN WATER OR ANY OTHER LIQUID.
• Lift the cooking plate o the base and pour o any excess
grease liquid from the drip tray.
The cooking plate and the drip tray can be washed in the
dishwasher. Frequent washing could reduce the properties
of the ceramic coating.
The metal body must be cleaned by hand.
• Do not use steel wool pads or harsh, abrasive cleaners
on the cooking surface as they may damage the nonstick
coating. Never use a caustic oven cleaner as this will
damage the cooking surface.
• To remove cooked on food, use a plastic spatula. Be sure to
clean the handles after each use.
Dry thoroughly with a soft cloth or paper towel.
• The power cord assembly must not be placed in the
dishwasher.
• The appliance inlet must be carefully dried before the
appliance is used again.
DISCLAIMER
Updates to hardware components are made regularly. Therefore
some of the instruction, specications and pictures in this
documentation may dier slightly from your particular situation.
All items described in this guide for illustration purposes only
and may not apply to particular situation. No legal right or
entitlements may be obtained from the description made in this
manual.

8
TM
LIMITED WARRANTY
This warranty applies to all products with De’Longhi or Kenwood brand names.
What does the warranty cover?
We warrant each appliance to be free from defects in material and workmanship. Our obligation under this warranty is limited to
repair at our factory or authorized service center of any defective parts or part thereof, other than parts damaged in transit. In the
event of a products replacement or return, the unit must be returned transportation prepaid. The repaired or replacement model will
be returned at the company expense.
This warranty shall apply only if the appliance is used in accordance with the factory directions, which accompany it, and on an
Alternating current ( AC ) circuit.
How long does the coverage last?
This warranty runs for one year (1) from the purchase date found on your receipt and applies only to the original purchaser for use.
What is not covered by the warranty?
The warranty does not cover defects or damage of the appliance, which result from repairs or alterations to the appliance outside
our factory or authorized service centers, nor shall it apply to any appliance, which has been subject to abuse, misuse, negligence or
accidents. Also, consequential and incidental damage resulting from the use of this product or arising out of any breach of contract or
breach of this warranty are not recoverable under this warranty. Some states do not allow the exclusion or limitation of incidental or
consequential damage, so the above limitation may not apply to you.
How do you get service?
If repairs become necessary, see contact information below:
U.S. Residents: Please contact our toll free hotline at 1-800-322-3848 or log onto our website at www.delonghi.com
Residents of Canada: Please contact our toll free hotline at 1-888-335-6644 or log onto our website at www.delonghi.com
Residents of Mexico: Please contact our toll free number 01-800-711-8805 for assistance or log onto our website at www.
delonghi.com
The above warranty is in lieu of all other express warranties and representations. All implied warranties are limited to the applicable
warranty period set forth above. This limitation does not apply if you enter into an extended warranty with De’Longhi. Some states/
countries do not allow limitations on how long an implied warranty lasts, so the above exclusions may not apply to you. De’Longhi
does not authorize any other person or company to assume for it any liability in connection with the sale or use of its appliance.
How does country law apply?
This warranty gives you specic legal rights, and you may also have other rights, which vary from state to state/country to country.