Pit Boss PB410FP Installation instructions

MODEL / MODÈLE : PB410FP
PART / PIÈCE : 10730, 10890
410
FOR OUTDOOR AND HOUSEHOLD USE ONLY.
NOT FOR COMMERCIAL USE. FUEL NOT INCLUDED.
POUR UN USAGE EXTÉRIEUR ET DOMESTIQUE SEULEMENT.
PAS POUR USAGE COMMERCIAL. CARBURANT NON INCLUS.
CIRCULAR
FIREPIT/GRILL
IMPORTANT, READ CAREFULLY, RETAIN
FOR FUTURE REFERENCE. MANUAL MUST
BE READ BEFORE OPERATING!
FOYER/GRIL
CIRCULAIRE
IMPORTANT, PRENEZ CONNAISSANCE DE
CE DOCUMENT ET CONSERVEZ-LE POUR
RÉFÉRENCE ULTÉRIEURE VOUS DEVEZ LIRE
CE GUIDE AVANT D’UTILISER LE FOYER!
BRASERO/PARRILLA
CIRCULAR
IMPORTANTE, LEER DETENIDAMENTE,
CONSERVAR PARA REFERENCIA FUTURA.
LEA EL MANUAL ANTES DEL USO!
WARNING: PLEASE READ THE ENTIRE MANUAL BEFORE INSTALLATION AND USE. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH. CONTACT
LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS AND INSTALLATION INSPECTION REQUIREMENTS IN YOUR AREA.
AVERTISSEMENT: VEUILLEZ LIREL’INTÉGRALITÉDUMANUEL AVANTL’INSTALLATIONET L’UTILISATION.LE NON-RESPECT DE CES INSTRUCTIONSPEUTENTRAÎNER DES DOMMAGES AUXBIENS, DESBLESSURES
OU MÊME LA MORT. COMMUNIQUEZ AVEC LES AUTORITÉS LOCALES EN MATIÈRE D’INCENDIE ET DE BÂTIMENT CONCERNANT LES RESTRICTIONS ET LES EXIGENCES D’INSTALLATION DANS VOTRE RÉGION.
ADVERTENCIA: LEA EL MANUAL COMPLETO ANTES DE INSTALAR Y UTILIZAR. INCUMPLIR ESTAS INSTRUCCIONES PODRÍA CAUSAR DAÑOS MATERIALES, LESIONES CORPORALES, E INCLUSO LA MUERTE.
CONSULTE A SUS FUNCIONARIOS LOCALES DE CONSTRUCCIÓN Y CONTROL DE INCENDIOS PARA INFORMARSE SOBRE LAS RESTRICCIONES Y LOS REQUISITOS DE INSPECCIÓN DE INSTALACIONES EN SU REGIÓN.
ASSEMBLY AND OPERATION
ASSEMBLAGE ET FONCTIONNEMENT | MONTAJE Y OPERACIÓN

2
ENGLISH
 
MAJOR CAUSES OF UNCONTROLLED FIRES ARE A RESULT OF POOR CARE
AND A FAILURE TO MAINTAIN REQUIRED CLEARANCE TO COMBUSTIBLE
MATERIALS. IT IS OF UTMOST IMPORTANCE THAT THIS PRODUCT BE
USED ONLY IN ACCORDANCE WITH THE FOLLOWING INSTRUCTIONS.
Plese red nd understnd ths entre mnul before ttemptn to ssemble nd operte the
product Ths wll ensure ou receve the most enoble nd trouble-free use of our new frept
We lso dvse ou retn ths mnul for future reference
DANGERS AND WARNINGS
You must contact your local home association, building or fire officials,
or authority having jurisdiction, to obtain the necessary permits, mission
or information on any installation restrictions, such as any firepit being
installed on a combustible surface, inspection requirements or even ability
to use, in your area.
1 A mnmum clernce of 24m (96 nches) from combustble constructons to the sdes of
the frept, nd 24m (96 nches) from the bc of the frept to combustble constructons
must be mntned Do not position on combustible floors, or floors protected
with combustible surfaces unless proper permits and permissions are obtained by
authorities having jurisdiction. Do not use n vehcles, tents, ndoors or n n enclosed,
unventlted re Do not plce under overhed combustble celn, overhn, or cnop of
trees eep our frept n n re cler nd free from combustble mterls, solne nd
other flmmble vpors nd lquds
Do not leave fire unattended. Use of an all-class (class ABC) approved fire
extinguisher is valuable to keep on site. If an uncontrolled fire does occur,
call the Fire Department.
2 Ths frept s desned for burnn wood, chrcol or fre los onl
Do not use spirit, petrol, gasoline, lighter-fluid or kerosene for lighting or
refreshing a fire in your firepit. Keep all such liquids well away from the
appliance when in use.
3 Ensure tht the mesh cover s secured over the fre bowl whle n use Durn use, the
hndle on the mesh cover cn rech extreme tempertures tht cn cuse serous nur It
s recommended to use the poer, het-resstnt brbecue mtts or loves when usn the
frept Do not use ccessores not specfed for use wth ths unt Do not put  cover or
nthn flmmble on the unt when n use Ensure the frept nd mesh cover hve cooled
before plcn  cover over the frept

3
ENGLISH
4 Do not trnsport our frept whle n use or whle the frept s hot Ensure the fre s
completel out nd tht the frept s completel cool to the touch before movn
5 Prts of the frept m be ver hot nd serous nur m occur Do not touch surfce whle
n use eep oun chldren nd pets w whle n use
This unit is not recommended for children, persons with reduced physical,
sensory or mental capabilities, or lack of experience and knowledge, unless
they are under direct supervision or instruction by a person responsible for
their safety.
6 Product m hve shrp edes or ponts Contct m result n nur Hndle wth cre
DISPOSAL OF ASHES
Ashes should be plced n  metl contner wth  tht-fttn ld The closed contner of shes
should be plced on  non-combustble floor or on the round, well w from ll combustble
mterls, pendn fnl dsposl When shes re dsposed b burl n sol, or otherwse locll
dspersed, the should be retned n  closed contner untl ll cnders hve thorouhl cooled
CARBON MONOXIDE (“  ”)
Crbon monoxde s  colorless, odorless, tsteless s produced b burnn s, wood, propne,
chrcol or other fuel Crbon monoxde reduces the blood’s blt to crr oxen Low blood
oxen levels cn result n hedches, dzzness, weness, nuse, vomtn, sleepness, confuson,
loss of conscousness or deth Follow these udelnes to prevent ths colorless, odorless s from
posonn ou, our fml, or others
 See  doctor f ou or others develop cold or flu-le smptoms whle coon or n the vcnt
of the unt Crbon monoxde posonn, whch cn esl be msten for  cold or flu, s often
detected too lte
 Alcohol consumpton nd dru use ncrese the effects of crbon monoxde posonn
Crbon monoxde s especll toxc to mother nd chld durn prennc, nfnts, the elderl,
smoers, nd people wth blood or crcultor sstem problems, such s nem, or hert dsese

4
ENGLISH
  
Safety Information ........................................2
Parts & Specs....................................................5
Assembly Preparation................................... 6
Assembly Instructions
Mounting The Legs .........................................6
Assembling The Base Ring............................. 6
Mounting The Base Ring.................................7
Installing The Table Panels.............................7
Assembling The Cooking Grid.......................8
Assembling The Charcoal Pan .......................8
Assembling The Lid..........................................8
Securing The Cooking Grid ............................9
Installing The Fire Bowl Components.........9
Instructions For Use
First Use – Burn-Off..................................... 10
Lighting Instructions .....................................10
Tending The Fire..............................................10
Extinguishing The Fire...................................10
Care & Maintenance......................................11
Replacement Parts........................................12
Warranty
Conditions ........................................................13
Exceptions........................................................13
Ordering Replacement Parts........................14
Contact Customer Care..................................14
Warranty Service ...........................................14
COPYRIGHT NOTICE
Copyright 2021. All right reserved. No part of this manual may be copied,
transmitted, transcribed, stored in a retrieval system, in any form or by any
means without expressed written permission of,
Dansons
8877 N. Gainey Center Dr., Scottsdale, AZ 85258
www.pitboss-grills.com
Customer Care
USA: [phone]
Canada (Toll-Free): 1-877-942-2246

5
ENGLISH
Part# Description
1 Swing Handle (x1)
2 Lid Ring (x1)
3 Lift Handle (x1)
4 Cooking Grid (x1)
5 Lid (x1)
6 Charcoal Pan Handle (x2)
7 Charcoal Pan (x1)
8 Table Panel (x3)
9 Table Panel with Hole (x1)
10 Table Support Bracket (x4)
11 Fire Bowl (x1)
12 Anchor Pin (x1)
13 Base Ring (x4)
14 Leg (x4)
A Screw (x48)
B Nut (x17)
C Screw (x4)
D Wrench (x1)
NOTE: Due to ongoing product development, parts are subject to
change without notice. Contact Customer Care if parts are missing
when assembling the unit.
  
12
34
5
7
6
8
11
10
12
13
14
 
 
9
MODEL ASSEMBLED (WxDxH) WEIGHT COOKING AREA

410 1,150  1,150  874
/ 45.2 .  45.2 .  34.4 .
28.0 
/ 61.7 
3,116.1 
/ 483.0 

6
ENGLISH
 
1.   
Parts Required:
1 x Fire Bowl (#11)
4 x Leg (#14)
12 x Screw (#A)
Installation:
• Place a piece of cardboard on the
floor to prevent scratching the unit
and parts during assembly.
• Mount a Leg to the Fire Bowl using
three screws through the pre-
drilled holes. Install screws from the
inside of Fire Bowl. Repeat the same
procedure for other Legs.
IMPORTANT: Do not tighten the screws
until the base ring is mounted on the
legs, then tighten all the screws.
2.    
Parts Required:
4 x Base Ring (#13)
4 x Screw (#A)
Installation:
• Insert one Base Ring into another
and fasten them with screw. Repeat
the same procedure to install the
other two Base Rings.
IMPORTANT: Ensure all inside brackets
are facing the same direction.
 
Parts are located throughout the shipping carton, including inside the fire bowl. Unpack the unit
and parts by removing all packaging materials. Before assembly, review all parts and reference the
parts list. If any part is missing or damaged, do not attempt to assemble. Shipping damage is not
covered under warranty. Contact your dealer or Pit Boss® Customer Care for parts.
www.pitboss-grills.com
USA: [phone] | Canada: 1-877-942-2246
Tool required for assembly: Phillips screwdriver (not included) and wrench (included).
1
2
11
 
14
13
13 13
13
14
14
14


7
ENGLISH
3.    
Parts Required:
16 x Screw (#A)
Installation:
• Place the assembled Base Ring
overtop of the Fire Bowl and align
on legs, as shown in illustration.
• Mount each Base Ring bracket to
each aligning Leg using four screws.
4.    
Parts Required:
3 x Table Panel (#8)
1 x Table Panel with Hole (#9)
4 x Table Support Bracket (#10)
12 x Screw (#A)
12 x Nut (#B)
Installation:
• First, locate the post tubing on the
side of the Fire Bowl. Install the
Table Panel with Hole onto this side
of the Fire Bowl by inserting the
two pins into the fixed pin brackets.
Install the other Table Panels around
the Fire Bowl in the same manner.
Note illustration 4A.
IMPORTANT: The Table Panel with hole
must align with post tubing in order to
install Cooking Grid in later steps.
• Secure the Table Panels to the Fire
Bowl with a Table Support Bracket:
mount the bottom to the Fire Bowl
using a screw and nut (fastened
from the inside), mount the top to
the Table Panels with a screw and
nut (hole furthest from Fire Bowl).
Repeat for all sides. Complete the
installation using a screw and nut
to secure the Table Panels together
(hole closest to Fire Bowl). Note
illustration 4B.
3
4
4

8
8
9


10
8

8
ENGLISH
5.    
Parts Required:
1 x Swing Handle (#1)
1 x Lift Handle (#3)
1 x Cooking Grid (#4)
4 x Screw (#C)
Installation:
• Mount the Swing Handle to the
side of the Cooking Grid using two
screws. Note illustration 5A.
• Mount the Lift Handle to the top of
the Cooking Grid using two screws.
Note illustration 5B.
6.    
Parts Required:
2 x Charcoal Pan Handle (#6)
1 x Charcoal Pan (#7)
4 x Screw (#A)
4 x Nut (#B)
Installation:
• Place a Charcoal Pan Handle to one
inside edge of the Charcoal Pan and
using two screws and nuts. Repeat
same procedure for opposing side.
7.   
Parts Required:
1 x Lid Ring (#2)
1 x Lid (#5)
1 x Nut (#B)
Installation:
• Insert the Lid Ring into the top of
the Lid and secure using one nut.
6
7
5
5
1
3




7
6
6

9
ENGLISH
8.    
Parts Required:
1 x Anchor Pin (#12)
Installation:
• Insert the Cooking Grid post into
the Table Panel with Hole. Note 8A.
• Secure the Cooking Grid at the
desired height using the Anchor Pin.
Note 8B.
9.    

Parts Required:
1 x Lid (#5)
1 x Charcoal Pan (#7)
Installation:
• Insert the Charcoal Pan into the Fire
Bowl. Place the Lid on the top of the
Fire Bowl It will rest on the edges.
Note illustration 9A.
NOTE: To maintain the searing and
grilling performance of your Cooking
Grids, regular care and maintenance is
required.
• The unit is completely assembled.
Use the Lift Handle to raise and
lower the Cooking Grid. Use the
Swing Handle to move the Cooking
Grid side to side. Note 9B.
CAUTION: Handles can become hot
during use. If adjustment is needed,
use a heat resistant glove or mitt.
8
8
9
9
12
5
7

10
ENGLISH
  
   
Before cooking on your firepit for the first time, it is important to complete a burn-off. Light the
firepit and let it burn for for 20 to 30 minutes to rid it of any foreign matter.
 
1. Swing the Cooking Grid to the side. Remove the Lid and set aside.
NOTE: When cooking in the Firepit, remove the Lid of the Charcoal Pan to
prevent grease build-up.
2. Place one lighter cube (or solid firestarter) and one handful of small amount of kindling
at the bottom of the Charcoal Pan.
3. Place firewood on top of kindling or Firestarter.
4. Use either a long handled lighter or match to light kindling or firestarter.
WARNING: Do not use gasoline, white spirit, lighter fluid, alcohol or other
similar chemicals for lighting or relighting.
  
1. Using a heat resistant glove or mitt, swing the Cooking Grid to the side. Remove the Lid
and set it aside.
2. Observe the fire in the Fire Bowl. If the heat is low and more fire is desired, place
additional firewood carefully and directly on the hot coals.
WARNING: Hot embers may result in injury if disturbed too quickly. Careful
to not disturb the ash in the Charcoal Pan.
  
1. To extinguish the fire, allow all coals to burn out.
WARNING: Do not use water to put out the Firepit. This can be harmful to
the structure of the firepit and heavily decrease its lifetime.