Dacor DHW301 User manual

In s t a l l a t I o n In s t r u c t I o n s
MI l l e n n I a™ Wall Mo u n t ra n g e
Ho o d s
For use with models:
DHW301
DHW361
DHW421
DHW482
Part No. 101743 Rev. B

ta b l e o f co n t e n t s
be f o r e Yo u be g I n ...
IMPORTANT:
INSTALLER• :Intheinterestofsafetyandtominimize
problems,readtheseinstallationinstructions
completelyandcarefullybeforeyoubeginthe
installationprocess.Leavetheseinstallation
instructionswiththecustomer.
CUSTOMER• :Keeptheseinstallationinstructionsfor
futurereferenceandthelocalelectricalinspector’suse.
Ifyouhavequestionsorproblemswithinstallation,contact
yourDacordealerortheDacorCustomerServiceTeam.
Dacor Customer Service Team
Phone:  (800)793-0093
Website: www.Dacor.com
© 2007 Dacor, all rights reserved
All specifications are subject to change without notice. Dacor assumes no liability for changes to specifications.
Important Safety Instructions .......................................... 1
Product Specifications .................................................. 3-4
GeneralSpecifications....................................................... 3
Dimensions......................................................................... 3
PreparingforInstallation.................................................... 4
ElectricalPowerSupplyInstallation................................... 4
PlanandInstalltheDuctWork........................................... 4
Installation Instructions............................................... 6-11
VerifythePackageContents.............................................. 6
MountingBracketInstallation............................................. 7
ChimneyMountingBracketInstallation.............................. 7
HangingtheRangeHood................................................... 8
FinalInstallation................................................................. 9
VerifyingProperOperation............................................... 10
InstallationChecklist..........................................................11
Notes................................................................................. 12

1
IM p o r t a n t sa f e t Y In s t r u c t I o n s
IM p o r t a n t sa f e t Y In s t r u c t I o n s
Important Information About Safety
Instructions
TheImportant Safety Instructions andwarningsinthese
instructionsarenotmeanttocoverallpossibleproblems
andconditionsthatcanoccur.Usecommonsenseand
cautionwheninstalling,maintainingoroperatingthisorany
otherappliance.
AlwayscontacttheDacorCustomerServiceTeamabout
problemsandconditionsthatyoudonotunderstand.
Safety Symbols and Labels
DANGER
ImmediatehazardswhichWILLresultinsevere
personalinjuryordeath.
WARNING
HazardsorunsafepracticeswhichCOULDresultin
severepersonalinjuryordeath.
CAUTION
HazardsorunsafepracticeswhichCOULDresultin
minorpersonalinjuryorpropertydamage.
DANGER
IMPORTANT:Ifyousmellgas:
Donotuseorlightanyappliance.•
Donottouchanyelectricalswitchoruseanyelectricaldevices,includingthetelephone,inyourbuilding.•
Fromaneighbor’sphone,immediatelycallthegassupplier.Followthegassupplier’sinstructions.•
Ifyoucannotcontactthegassupplier,callthefiredepartment.•
IMPORTANT:Donotstoreorusecombustible,flammableorexplosivevaporsandliquids(suchasgasoline)onorin
thevicinityofthisoranyotherappliance.Alsokeepitemsthatcouldexplode,suchasaerosolcans,awayfromthe
cooktop.Donotstoreflammableorexplosivematerialsinadjacentcabinetsorareas(includingaboveandbelowthe
cooktop).
WARNING
TOREDUCETHERISKOFFIRE,ELECTRICSHOCK,ORINJURYTOPERSONS,OBSERVETHEFOLLOWING:

a)Usethisunitonlyinthemannerintendedbythemanufacturer.Ifyouhavequestions,contactthemanufacturer.
b)Beforeservicingorcleaningunit,switchpoweroffatservicepanelandlocktheservicedisconnectingmeansto
preventpowerfrombeingswitchedonaccidentally.Whentheservicedisconnectingmeanscannotbelocked,
securelyfastenaprominentwarningdevice,suchasatag,totheservicepanel.
READANDSAVETHESEINSTRUCTIONS

2
IM p o r t a n t sa f e t Y In s t r u c t I o n s
WARNING
Donot1. installoroperatethishoodifithasbeendamaged,dropped,hasdamagedelectricalconduitorwiresoris
notworkingproperly.Iftheproductisdamagedwhenreceived,immediatelycontactthedealerorbuilder.
Usethisrangehoodonlyforitsintendedpurposeasoutlinedintheuseandcaremanual.2. Donotusethisrange
hoodtoventhazardousorexplosivematerialsorvapors.Ifyouhavequestions,contactthemanufacturer.
Thecustomershouldnotinstall,repairorreplaceanypartoftherangehoodunlessspecificallyrecommendedin3.
theliteratureaccompanyingit.Aqualifiedservicetechnicianshouldperformallotherservice.Contactthenearest
Dacorauthorizedservicerepresentativeat(800)793-0093,oratwww.Dacor.comforexamination,repairor
adjustment.
Keepallpackagingmaterialsawayfromchildren.Plasticbagscancausesuffocation.4.
Thisrangehoodmustbeinstalledandgroundedbyaqualifiedinstalleraccordingtotheseinstallation5.
instructions.Allinstallationworkandelectricalwiringmustbeperformedinaccordancewithallapplicablecodes
andstandards,includingfire-ratedconstruction.
Installorlocatethisapplianceonlyinaccordancewiththeseinstallationinstructionsandtherequirements6.
specifiedbythemanufacturerofthecooktoporrange.Improperinstallation,adjustment,alteration,serviceor
maintenancecancauseseriouspersonalinjuryorpropertydamage.
Donotuseanextensioncordoradapterplugwiththisappliance.7.
Sufficientairisneededforpropercombustionandexhaustingofgasesthroughtheflue(chimney)offuelburning8.
equipmenttopreventbackdrafting.Followtheheatingequipmentmanufacturer’sguidelinesandsafetystandards
suchasthosepublishedbytheNationalFireProtectionAssociation(NFPA),andtheAmericanSocietyfor
Heating,RefrigerationandAirConditioningEngineers(ASHRAE)andthelocalcodeauthorities.
Whencuttingordrillingintothewallorceiling,donotdamageelectricalwiringandotherhiddenutilities.9.
Theinstallermustshowthecustomerthelocationofthefuseorjunctionboxsothatthecustomerknowswhere10.
andhowtoturnthepoweroff.
Beforeinstallingorservicingtherangehood,switchpoweroffatthefuseorjunctionboxandlocktheelectrical11.
paneldoortopreventpowerfrombeingswitchedonaccidentally.Whentheelectricalpanelcannotbelocked,
securelyfastenaprominentwarningdevice,suchasatag,totheservicepanel.
Readtheuseandcaremanualcompletelybeforeusingtheappliance.12.
Donottamperwiththecontrols.13.
Neverallowthefilter(s)tobecomeblockedorclogged.Donotallowforeignobjects,suchascigarettesor14.
napkins,tobesuckedintothehood.
Cleanthefilter(s)andallgrease-ladensurfacesoftentopreventgreasefiresandmaintainperformance.15.
Ifthecooktopandrangehoodarenearawindow,useanappropriatewindowtreatment.Avoidlongdrapesor16.
otherwindowcoveringsthatcouldblowoverthecooktopandhood,resultinginafirehazard.
Alwaysruntheblower(s)wheneverthecooktopisoperating.17.
Neverleavetherangeorcooktopunattendedwhenaburner(orelement)isinuse.Boil-oversandgreasyspills18.
maysmokeand/orignite.
Donotleavechildrenaloneorunattendedintheareawherethecooktopandrangehoodareinuse.Neverallow19.
childrentositorstandonanappliance.Donotletchildrenplaywitharange,cooktoporrangehood.Donot
storeitemsofinteresttochildrenaboveoraroundthecooktop,rangeorrangehood.
Theminimumverticaldistancebetweenthecooktopsurfaceandtheexteriorpartofthehoodmustbenoless20.
than30”(762mm).Theverticaldistancemaybelongerfortherangeorcooktopbeingused.Consulttherange
orcooktopinstallationinstructionsfortheminimumandmaximumverticaldistancefromtheappliancebeing
used.
Aminimumoftwopeoplearerequiredtosafelyinstallthisappliance.21.
To reduce the risk of fire, electric shock, serious injury or death when using your range hood, follow basic
safety precautions, including the following:

3
Di m e n s i o n s
*18”1/4on48-inchmodel(DHW482)withexhaustcowling
IMPORTANT:Theminimuminstalleddistancefromthe
hoodtothecooktopsurfacemustbenolessthan30
inches.Theminimumspecifieddistancemaybehigher
fortheparticularrangeorcooktopinuse.Checkthe
manufacturersspecificationsforthecooktoporrange.
IM p o r t a n t sa f e t Y In s t r u c t I o n s
WARNING
TOREDUCETHERISKOFINJURYTOPERSONSINTHEEVENTOFARANGETOPGREASEFIRE:22.
SMOTHERFLAMESwithaclose-fittinglid,cookiesheetormetaltray,thenturnofftheburner.BECAREFULa.
TOPREVENTBURNS.Iftheflamesdonotgooutimmediately,EVACUATEANDCALLTHEFIRE
DEPARTMENT.
NEVERPICKUPAFLAMINGPAN-youmaybeburned.b.
DONOTUSEWATER,includingwetdishclothsortowels-aviolentsteamexplosionmayresult.c.
UseafireextinguisherONLYif:d.
YouhaveaClassABCextinguisher,andyoualreadyknowhowtooperateit.•
Thefireissmallandcontainedintheareawhereitstarted.•
Thefiredepartmentisbeingcalled.•
Youcanfightthefirewithyourbacktoanexit.•
pr o d u c t specIfIcatIons
Ge n e r a l sp e c i f i c a t i o n s
ALL MODELS
Blower 600CFM(1200forunitswith2blowers)
withelectronicspeedcontrol
BlowerSpeeds 4
Lights 12Vac,20Whalogen
Filters Baffletype,dishwashersafe
Exhaust 8-inch
Finish 430stainlesssteel
Voltage 120Vac,60Hz(seebelowforcurrent
rating)
Circuit
Requirement
120Vac,15Ampgrounded,dedicated
circuit,minimum
MODEL SPECIFIC
MODEL NUMBER
DHW301 DHW361 DHW421 DHW482
Blowers 1 1 1 2
Lights 2234
Filters 1 1 1 2
Maximum
CurrentDraw 3.38A 3.38A 3.55A 6.75A
Tolerances:+1/16”,-0
(+1.6mm,-0),
unlessotherwisestated

4
pr e p a r I n g f o r In s t a l l a t I o n
pl a n a n D in s t a l l t h e Du c t Wo r k
Allductworkmaterials(includingscrewsandducttape)•
mustbepurchasedseparatelybythecustomer.When
planningnewductwork,alwayslookfortheshortest,
mostdirectroutetotheoutside.Ventingcanbedone
throughtheroofordirectlythroughthebackwalltothe
outside.
Thehoodexhaustconnectstoan8-inchroundduct.•
Youcanincreasetheductsizeovertheductrunif
desired.Topreventabackdraft,neverdecreasethe
ductsizeovertherun.
Donotrelyonducttapealonetosealductjoints.•
Fastenallconnectionswithsheetmetalscrewsand
tapealljointswithcertifiedsilvertapeorducttape.
Usesheetmetalscrewsasrequiretosupporttheduct
weight.
Topreventback-drafts,adamperattheductoutletmay•
alsoberequired.
Makesureductworkdoesnotinterferewithfloorjoists•
orwallstuds.

Carefullycheckthelocationwherethehoodistobe
installed.Thehoodshouldbeplacedforconvenient
access.Makecertainthatelectricalpowercanbeprovided
intheselectedlocation.
Plantheinstallationsothatallminimumdimensionsare
metorexceeded(seepage3).Dimensionsshownprovide
minimumclearances,unlessotherwisenoted.
Allcontactsurfacesbetweenthehoodandanycabinetsor
wallsmustbesolidandatrightangles.
Installtherangehoodandcookingappliance(s)sothat
theycanberemovedifserviceisrequired.
el e c t r i c a l po W e r su p p l y
in s t a l l a t i o n
Electrical Specifications
Itistheowner’sresponsibilitytoensurethattheelectrical
connectionofthisapplianceisperformedbyaqualified
electrician.Theelectricalinstallation,includingminimum
supplywiresizeandgrounding,mustbeinaccordance
withtheNationalElectriccodeANSI/NFPA*(orlatest
revision)andlocalcodesandordinances.
*Acopyofthisstandardmaybeobtainedfrom:
NationalFireProtectionAssociation
1BatterymarchPark
Quincy,Massachusetts02269-9101
Installing the Electrical Connection
The electrical connection box must be:
Connectedtoa120Vac,60Hzdedicated,grounded,•
circuitprotectedbya15Ampcircuitbreakerortime
delayfuse.
Locatedaminimumof17”(43cm)abovethebottomof•
therangehood.
WARNING
Theelectricalservicetotherangehoodshouldbe•
installedonlybyalicensedelectrician.
Observeallgoverningcodesandordinancesduring•
planningandinstallation.Contactyourlocalbuilding
departmentforfurtherinformation.
Aqualifiedtechnicianmustcompletetheinstallation•
ofthisbuilt-inappliance.Theownerisresponsibleto
makesurethehoodisproperlyinstalled.
WARNING
Toreducetheriskoffireandtoproperlyexhaust•
air,besuretoductairoutsidethehouseorbuilding.
Donotventexhaustairintospaceswithinwallsor
ceilingsorintoattics,crawlspacesorgarages.
Tapeallductjointssecurely• topreventcombustion
by-products,smokeorodorsfromenteringthehome.
Doingsowillalsoimprovesystemefficiency.
Donotexhaustmorethanone• ventintoasingleduct
run.
Useonly• ductworkconstructedofmaterialsdeemed
acceptablebystate,municipalandlocalcodes.
Rangehoodsmayinterrupttheproperflowof•
smokeandcombustiongasesfromfurnaces,gas
waterheatersandfireplaces.Toavoiddrawing
lethalgasesintothehome,followthemanufactures
recommendationforthesedevicesandconsultNFPA
andASHRAErecommendations.
DO NOT• installanadditionalin-lineorexternal
blowertoincreasethelengthoftheductrun.Even
smalldifferencesbetweenblowerairflowratescan
greatlyreducetheairdrawbythehood.

5
Calculating the Maximum Duct Run Length
Themaximumstraightductlengthforthehoodis50
feet.Foreachelbowandtransitionaddedtotheduct
work,acertainnumberoffeetmustbesubtractedfrom
themaximumstraightlengthtocompensateforwind
resistance.Todeterminethelengththeductworkcannot
exceed,subtractalloftheequivalentlengthsoftheelbows
andtransitionslistedbelowfrom50feet.
Duct Work Equivalent Lengths
DUCT PIECE SUBTRACT
90°elbow(8”Dia.) 7feet
45°elbow(8”Dia.) 3feet
31/4”x10”to8”round 4foot
Wallcapwithdamper 30feet
Roofcap 30feet
Duct Work Design Tips
Whereverpossible,reducethenumberoftransitions•
andturnstoasfewsharpanglesaspossible.Two
staggered45°anglesarebetterthanone90°.
Keepturnsasfarawayfromthehoodexhaustas•
possible,withasmuchspacebetweeneachbendas
possible.
Forbestperformance,useroundductinsteadof•
rectangular,especiallywhenelbowsarerequired.
Ifmultipleelbowsareused,trytokeepaminimumof•
24”ofstraightductbetweenthem.
Avoid“S”or“backtoback”configurationsofadjacent•
elbows.
Inregionswheretheweathergetsextremelycold,•
thermalbreaks,suchasashortsectionofnon-metallic
duct,shouldbeusedtoavoidindoorheatloss.The
breakshouldbelocatedasclosetothepassthrough
pointtotheoutsideaspossible.
Donotuseflexiblemetalduct.•
Donot• useductworkthatissmallerincross-sectional
areathantherecommendedsizeduct(8”round).
Duct Work Installation
Install all of the duct work, except for the portion that
will be located inside the hood chimney:
Determinetheverticalcenterlinefortherangehood.1.
Thecenterlineforthehoodisusuallythesameasthe
centerlineoftherangeorcooktop.
Usingapencil,marktheverticalcenterlineonthewall2.
fromwherethebottomofhoodwillbelocatedtowhere
thetopofthechimneywillbelocated.
Drawahorizontalline24incheslongat90°tothe3.
verticalcenterlinewherethebottomofthehoodwillbe
located.Theminimumallowabledistancefromthetop
ofthecooktoptothebottomofthehoodis30”.
Installtheductworksothattheconnectiontothehood4.
willbecenteredonthehood’scenterline.Alsoallow
fora1”clearancebetweentheductworkandthewall
wherethehoodwillbemounted.The1”clearancewill
allowroomforthechimneymountingbracketonthe
ceiling.
pr e p a r I n g f o r In s t a l l a t I o n

6
Ve r i f y t h e pa c k a G e co n t e n t s
Unpackthepartsboxandverifythatallrequired
componentshavebeenprovided.Ifanyitemismissingor
damaged,pleasecontactthedealerimmediately.Donot
installadamagedorincompleteappliance.
 Hoodassemblywithfilter(s)
 Chimneyassembly(2piece)
 Chimneymountingbracket
 Mountingbracket*
 Blowerexhaustcowling(2blowerunitsonly)
 Mountingandassemblyhardware
 Useandcaremanual
*NOTE:Themountinghardware
includedwiththehardwarepacket
issuitableformountingtobrick
andmasonryonly.Ifmountingthe
rangehoodtodrywall,
Dacorstronglyrecommendsthe
usingasturdyanchoringsystem
designedforusewithdrywall.
Inaddition,Dacorstrongly
recommendsthatyouinstalla
reinforcedmountingblockbetween
thestudsbehindallhoodmounting
locations.
Makesureyouhaveeverything
necessaryforproperinstallation
beforeproceeding.
A
A
B
C
D
E
F
G
In s t a l l a t I o n In s t r u c t I o n s
B
C
D
E
F
G

7
In s t a l l a t I o n In s t r u c t I o n s
WARNING
Theelectricalservicetotherangehoodshouldbe•
installedonlybyalicensedelectrician.
Donotinstalltherangehoodunlesstheelectrical•
serviceprovidedmeetstherangehoodspecifications.
Observeallgoverningcodesandordinancesduring•
planningandinstallation.Contactyourlocalbuilding
departmentforfurtherinformation.
Aqualifiedtechnicianmustcompletetheinstallation•
ofthisbuilt-inappliance.Theownerisresponsibleto
makesurethehoodisproperlyinstalled.
Toavoidanelectricshockhazardandproperty•
damage,locateelectricwiresandwaterpipesand
avoiddrillinginthevicinity.
mo u n t i n G Br a c k e t in s t a l l a t i o n
Measurethedistancebetweenthebottomofthehood1.
andthemountingbracketholeonthehoodbeing
installed.Usingapencil,drawashortlineonthewall
thesamedistanceabovethehorizontallinepreviously
drawnonthewall.
Findthemountingbracketintheshippingbox.Put2.
thebracketagainstthewallandlineupthetopofthe
bracketwiththeshortlinejustdrawn.
Lineuptheverticallinedrawnonthewallwiththe3.
centerholeonthebracket.
Markthethreemountingholepositionsthroughthe4.
holesinthebracket.Makesuretheyarelevel.
Drillthemountingholes...5.
If mounting the hood to brick or masonry:
Drillthree5/16”X11/2”holesinthelocations•
marked.
Insertthreeoftheprovidedwallanchorsintothe•
holes.Theanchorsprovidedareforattachingthe
hoodtomasonryorbrickonly.
Attachthemountingbracketsecurelytothewall(36.
places).
ch i m n e y mo u n t i n G Br a c k e t
in s t a l l a t i o n
Locatethechimneymountingbracketandpositionit1.
againsttheceilingasshown.Centeritonthecenter
linedrawnonthewall.
Marktheceilingandthewallintwoplaceseach,2.
throughtheholesinthebracket.Removethebracket
fromtheceiling.
Drillfour5/16”holesthroughthefourspotsmarkedon3.
theceilingandwall.
Insertthefouroftheprovidedwallanchorsintothefour4.
holesontheceilingandwall.
Placethechimneymountingbracketagainsttheceiling5.
andattachitusingfourincluded11/2”screws.
If mounting the hood to drywall:
Drillthreeappropriatesizedpilotholesforthe•
mountinghardwarebeingused.Thedrywall
mountinghardwaremustbepurchasedseparately.
MOUNTING BRACKET
ANCHOR
CHIMNEY
MOUNTING
BRACKET
MOUNTING BRACKET
HOLE
ANCHOR
MOUNTING BRACKET

8
In s t a l l a t I o n In s t r u c t I o n s
ha n G i n G t h e ra n G e ho o D
WARNING
Hangingtherangehoodrequirestwopeople.Donot•
attempttoliftthehoodwithoutassistance.
Attachthehoodjunctionboxtothetopofthehood1.
usingtwomachinescrewsasshown.
Removethefilter(s)toreduceweightandavoid2.
damage.
Liftthehooduponbothsidesandputthemounting3.
holeonthetopofthehoodoverthelipofthemounting
bracket.Gentlyloweritintoplace.
Inserttwoprovidedmachinescrewsintothetwoholes4.
abovethemountingbracketontherangehood.Tighten
thescrewsuntiltheymakecontactwiththebracket,
thentightenthemasnecessarytomakeminorleveling
adjustmentstothehood.
Inserttwomachinescrewsthroughthefrontofthe5.
mountingbracketandtightenthemintoplace.
Onmodelswithtwoblowers:Puttheexhaustcowling6.
overthebloweroutletsonthetopofthehood.Fasten
thecowlinginplacewith14machinescrews.
MOUNTING
BRACKET

9
Insidetheexhaustoutlet(s)therearemetalorplastic7.
damperflaps.Theflapsclosetohelppreventback-
draftswhenthebloweristurnedoff.Removethe
shippingtapeandmakesurealltheflapsopenand
closefreelybeforeproceeding.
fi n a l in s t a l l a t i o n
Connecting to the Duct Work
WARNING
Donotusescrewstoattachtheductworktothe•
hoodexhaustoutlet.Useducttapeonly.Screwsmay
preventthedamperflapsonthetopofthehoodfrom
opening.
Installthelastoftheductworkbetweenthehood•
exhaustandthepreviouslyinstalledductwork.Attach
theducttothehoodexhaustwithducttapealone.Use
sheetmetalscrews(notprovided)andducttapeonthe
remainingjoints.
In s t a l l a t I o n In s t r u c t I o n s
Final Electrical Installation
WARNINGS
Toavoidelectricalshockorfirehazard,makesure•
thepowersupplyatthefuseorjunctionboxisturned
offbeforeproceedingwithfinalinstallation.
Improperconnectionofthehoodelectricalwiringmay•
createanelectricshockorfirehazardandmayresult
indamagetothehoodselectricalsystem.
Donotgroundthehoodtotheneutral(white)power•
supplywire.Connectthehoodgroundwiretoa
separate,properlygroundedwireinstalledbya
licensedelectrician.
Connect the house power supply wires to the wires
coming out of the top of the hood junction box:
Connectthewhitewirefromthehoodtotheneutral1.
(white)powersupplywire.
Connecttheblackwirefromthehoodtothehot(black)2.
powersupplywire.
Connectthegreenandyellowwirefromthehoodto3.
thehouseground(green)wirefromthejunctionbox.
BLACK TO BLACK
YELLOW/GREEN
TO GREEN
WHITE TO WHITE

10
Ve r i f y i n G pr o p e r op e r a t i o n
Turnonpoweratthejunctionorfusebox.1.
Ifthecontrolpanelisnotlit,removethefilter(s)and2.
turnonthemainpowerswitchlocatedbehindthefilters
onthebottomofthehood.Replacethefilter(s).
Touchthelightkey.Verifythatallthelightscomeon.3.
Touchthelightkeyagaintoturnthelightsoff.4.
Touchtheblower5. “+”keyonceandrelease.Verifythat
onelightisshowingontheblowerspeedindicatorand
thattheblowerisonatlowspeed.
Touchandreleasetheblower6. “+”repeatedly,three
times.Verifythatwitheachtouchofthekeythenumber
oflightsontheblowerspeedindicatorincreasesand
thattheblowerspeedincreases.
Touchandholdtheblower7. “-”keyuntiltheblower
turnsoff.
If the hood fails to operate properly:
Verifythatpowerissuppliedtothehood.•
Checktheelectricalconnectionstoensurethatthe•
installationhasbeencompletedcorrectly.
Repeattheabovetest.•
Iftheappliancestilldoesnotwork,contactan•
authorizedDacorservicecompanyat(800)793-0093.
Donotattempttorepairtheapplianceyourself.Dacor
isnotresponsibleforservicerequiredtocorrectafaulty
installation.
In s t a l l a t I o n In s t r u c t I o n s
Installing the Chimney
IMPORTANT:Becarefulnottopinchtheelectricalwires
whileinstallingthechimney.
Removetheprotectiveplasticcoveringfromboth1.
piecesofthechimneyassembly.Donotremovethe
protectivetapestripsfromtheinsideofthechimney.
Theyprotectthetelescopingpiecesfromscratching
duringinstallation.
Carefullyslidebothsectionstogethersothatonlythe2.
ventsonthetopsectionshow.
Holdthechimneyverticallywiththeventsup.3.
Carefullyputthechimneyoverthetopoftheductwork4.
extendingoutofthetopofthehood,takingcarenotto
scratchthesurfaces.Makesurethewiringistuckedin
behindthechimney.
Movethechimneyuptowardtheceiling.Lineupthe5.
holesonthesideofthechimney,abovethevents,with
theholesonthesideofthechimneymountingbracket.
Attachthesidesofthechimneytothebracketusing6.
twosheetmetalscrews,oneoneachside.
Carefully,slidethebottomportionofthechimneydown7.
untilitrestsonthetopoftherangehood.
Reinstalltherangehoodfilter(s)beforeoperation.
CHIMNEY
MOUNTING
BRACKET
VENT
DUCT WORK
HOOD



CHIMNEY

11
in s t a l l a t i o n ch e c k l i s t
WARNING
Toensureasafeandproperinstallation,thefollowing•
checklistshouldbecompletedbytheinstallerto
ensurethatnopartoftheinstallationhasbeen
overlooked.
Properinstallationistheresponsibilityofthe•
homeowner.Theimportanceofproperinstallationof
yourDacorrangehoodcannotbeoveremphasized.
Isthemountingbracketproperlyattachedtothewall
□
accordingtotheinstructionsonpage7?
Isthehoodproperlytightlysecuredtothemounting□
bracketwiththemachinescrews(seepage8)?
Istheductworkcompletelyinstalled?Arealljoints
□
attachedwithsheetmetalscrewsandwrappedwith
ducttape(seepages4and9)?
Istherangehoodwiredandgroundedaccordingto□
theseinstructionsandinaccordancewithallapplicable
electricalcodes(seepage9)?
Arethefiltersproperlyinstalledaccordingtotheuse□
andcaremanual?
Hasproperoperation□ beenverified(seepage10)?
Haveanyproblemsbeennotedonthewarrantycard□
orduringtheon-linewarrantyactivation?Hasthe
warrantybeenactivatedon-lineorthewarrantycard
filledoutcompletelyandmailed?
In s t a l l a t I o n In s t r u c t I o n s

12
no t e s

Dacor ●1440 Bridge Gate Drive, Diamond Bar, CA 91765 ●Tel: [phone] ●FAX: [phone] ●www.Dacor.com