Denka ROM80E-SS User manual

OOVVEENN
IINNSSTTUURRCCTTIIOONN MMAANNUUAALL
ROM80E-SS
GAS COOKER
WITH 5 BURNERS

1
1> The use of the gas ranges produce heat and humidity where are installed
2> Be sure that there is a good air flow, keeping natural air ventilation through
a window or door or by installing a range hood to extracet the air. If
ventilation is not good, this might cause lack of oxygen,what is dangerous
for your health and the gas performance.
3> If the gas range will be working for a long period of time, an extra
ventilation will be necessary to increase the air flow.
4> Air draft should not decrease the good performance of the gas range or
cut the gas flame.
5> To install your gas range to a LPG(Liquefied Petroleum Gas) pie,
check if your house has a gas tap exclusive for the gas range and it this is in good condition.
6> Be sure that your house has an exclusive plug for your gas range and this is in good conditions.
7> Do not install the range on top of carpets.
8> Do not install the range near the refrigerator, as the excessive heat hinders its yield.
The appliance that you have bought may be slightly differently from the one illustrated in this manual.
Please refer to the information related to the model you have.
The appliance you have may carry a different plug than the one illustrated in this manual. The plug that
comes with the product follows the electrical specification of the county where it is sold.
Important
Product description
Parts name
Installation place conditions
01
02
03
04
05
06
07
08
09
sSSealed burners
pan grated
glass lid
burners knobs
base
temperature knob
electric igniter-burners
oven light
timer knob
Oven light(only for some models)
1>. Press the button that indicates the oven light to turn the light on.
2>. To turn the light off, press the button again.
It is normal that all the burners have continuous sparkling when
pressing the electric ignition.
BULB REPLACEMENT
The bulb in the light is a special bulb, and has hight temperature
resistance (230-240~25W).
For replacement, proceed as follows:
01
03
04
05
06
07
08
10
11
09
02
01
03
04
05
06
07
08
09
02

2
80 to 85cm
2cm
Gas range installation
Gas installation
1>This range was designed for use with LP gas
2> Always use a pressure regulator exclusive for your
gas range.The lack of pressure regulator might cause
excess of pressure and leak of gas.Always check for
the validity of the pressure regulator.House and regulartor
should be replaced every 5 years.
Techenical specificaltion of the pressure regulator.
Pressure: 290mm C.A.
Max. consumption: 2kg/h
3> Always use a PVC hose to work from-20 to 100 .Be sure that hose:
does not have joins.
does not go on the back of
the gas range neither close to the hot air exits.
Its less then 125cm long.
4> If possible, install the gas cylinder outside the kitchen,
in a place protected and with air flow.
5> Use a
½ metallice hose to connect to the gas range.
6> Only use a plastic hose when this one does not go
on the back of the gas range.
1> Leave at least 80 to 85cm between the top of the gas
range and any cabinet or range hood install above
prepared to be installed built in.
2> Leave at least 2cm in the back and each side of the gas
range to allow the heat to get out.
3> Make sure not to blok the oven gas exit, including the funnel
or the gas vents,when you install the oven.
Hose installation
1> Place the metal clamp on the hose end.
2> Connect the hose to the oven inlet and tight the clamp.
3> Place the other clamp on the oppsite hose end and
connect it to the pressure regulator. Tight the clamp.
4> Bolt the pressure regulate to the gas cylinder carefully.
5> After the installation, check if there is any gas leak,using
soap or liquid detergent foam.
1>. Avoid accidents. After unpacking the range,keep packing materials away
from children.
2>.Do not allow children to handle the appliance,even when it is disconnected.
3>.Prevent children from touching the range surface and from staying in its
proximity when in use,still hot,or after turn off
Safetly
For children
º C
º C

3
1>. Disconnect the range before cleaning or doing maintenance.
2>. Never unplug the range by pulling on the power cord.Use the plug.
Do not manipulate your gas range plug.Do not bit, twist or tie the power cord.
3>. It is dangerous to modify your gas range sepcifications and characteristics.
Do not install your gas range on top of the power cord.
4>. Connect the range to its own outlet.Do not use an extension cord or adaptor plug.
To avoid any accident,before replacing the light lamp,turn off the cook top burners
and unplug the appliance.use a range lamp of 40W to replace it.
1>. To handle or remove food from the use cooking gloves.
2>. Never leave clothes or flammable materials near the burners
when the range is in use.When using frying oil or butter additional
care must be taken since these products are flammable.
3>. Do not use the oven to store utensils,especially those containing
residues or large quantities of oil or fat.
4>. Containers with curved bases or salient edges must not be used
since they can be easily destabilized when moved.
5>. The handle of the utensil should be positioned so that it is turned inward.
1>. Before cleaning or servicing your gas range,unplug it and cut gase tap.
2>. Cleaning should be done with the appliance cold.
3>. For hygienic and security reasons,you should keep your gas range always clea
5>. Choose the burner size according to the pot you are going to use.
4>. After each use always clean the glass cove of the gas range
How to use the oven:
For the user and/ installer
Care with food and cookware
Instructions for cleaning your range
Before lighting the oven,please remove the following elements:
Dripping pan;
Baking rack.
1>. Identify the oven knob in the middle of the knobs.
2>. Ignition can be manual or electric.
How to use the oven
Timer setting:
1>. To set the time, turn the knob clockwise to the desired time.
(The time can be set up to 60 minutes).
2>. When cooking finish,it will beep.
Manual ignition:
Turn the knob to the maximum position, then at the same time
keep a match close the oven burner.
Electric ignition (only some models) :
Press the ignition button and turn the oven knob counterclockwisely
at the same time until the oven light.
3>. Be sure that the oven is burning, then close door smoothly.Preheat
the oven at maximum temperature for 10 to 20 minutes.

4
Oven racks:
The level to place the baking rack or tray will depend on the type of the food
you want to cook.We recommend:
1>. Use the central slider to bake bread,cakes,etc.
2>. Follow the instructions of the proper recipe.
3>. To bake bread, cookies,pizzas or similar food,use the baking plate on the grate.
Never bake food directly on the upper burner or the tray covering the burner.
1>. Choose the knob of the burner that you want to light.
2>. Ignition can be manual or electric.
Usage of the Rotisserie Rack: (only for some models)
1>. Remove the grill rack and replace with the oven tray.
2>. Put the food on the rosisserie and fix it using the forks,
then install the rod on corresponding support inside the oven.
3>. Turn on the knob"Grill" as indicated in the previous point.
4>. Gently close the door to start roasting.
Important
Accessories:
Rotisserie skewer
The average speed of the motor heat the food equally.
AT the same time,it can guarantee the nutrition of the food.
Burner ignition
Manual ignition:
Turn the knob of the burner you want to light up to maximum position,
then at the same time keep a match close the burner.
Electric ignition (only for some modes):
Press the ignition botton and at the same time turn the knob counterclockwise
until the burners light.
3>. Select the temperature.
4>. Turn the knob to off position to turn off the burner.
4>. Select the temperature.To turn off the oven,turn the knob to the off position.
5>. your gas range can have a thermo control or a thermostat.Oven with a thermostat
will give you more precise temperature as indentified mo the oven konb.
off
off
250
200
220
180
160
130
Oven light(only for some models)
1>. Press the button that indicates the oven light to turn the light on.
2>. To turn the light off, press the button again.
It is normal that all the burners have continuous sparkling when
pressing the electric ignition.
BULB REPLACEMENT
The bulb in the light is a special bulb, and has hight temperature
resistance (230-240~25W).
For replacement, proceed as follows:

5
1>. Do not use any kind of protection on the board(aluminium foil)
as it could cause clogging of the gas nozzle or bad coupling of
the burners parts.
2>. When using the oven avoid touching its glass surface and
internal accessories, wait for them to cool for a reasonable
time before handling them.
3>. When cooking on the oven, avoild contact with glass.Avoid
children in the kitchen when you are cooking.
4>. Never allow kid to sit on the oven door,neither put heavy items on it.
5>. To avoid electrical shocks,unplug the gas range when you replace the oven light.
For a lower and more efficient gas consumption it is advisable to use pans with a diameter
adequate to the burners size(fig.1and 2),preventing the flame to burn in the open(fig.3).It is
advisable to reduce the flame as soon as the liquid starts to boil, and keep the flame to the
minimum necessary to sustain boiling.Make sure there is adequate ventilation in the room
where the range is installed.For an easier ignition,light the burner before placing the pan
over the grill.
Tips and adverside
lmportant
lmportant recommendations
Cleaning and maintenance
Before any cleaning or servicing unplug the gas range and cut gas tap.
1>.To clean the finishing use a soft cloth with a hot soap cloth with a hot
soap water solution with bicarbonate(2 spoonfuls in 1L of water).
2>.To clean the glass front and control panel of the touch pad system,it is
recommended to use a dry paper towel.
3>.Do not use detergents aerlsols, corrosive or strongly abrasive products.
4>.Do not use scrubbers as they may deteriorate the appearance and polish.
When cleaning the board or the burners,you must be careful not to let
food remainders into the oven, pay attention into the gas exit.
lmportant
1>. Disconnect power from the mains outlet or switch off the circuit breaker
of the unit's mains outlet.
2>. Unscrew the covering glass and replace the bulb with a new one of the same type.
3>. Screw the covering glass back in place. 20
30
40
50
10

6
Troubleshooting
PROBLEM POSSIBLE CAUSE
Connection hose or tubing puncture Change the installation
Burners incorrect position Place them in the
correct position.
An oven burner in use accidentallywent off. Call the costumer service
Pressure regulator badly installed Install it correctly
Strong Smells Oil and grease used to manufacture you stove It is normal the first time
you use it.
Noise Metal expansion due to heat Normal.
Electric components
to not function Disconnected stove socket without power
Connect the electriccord.
Check the socket connecting
a lamp.
SOLUTION
Gas Smell
When turning on the
lamp,the roasting rod It is normal.
GENERAL EQUIVALENCES TABLE
LIQUID MEASURES
1 Pinch Less than
¼ teaspoonful 8 Spoonfuls ½ Cup
3 Teaspoonfuls 1 Spoonful 1 Cup 8 Liqude Ounces
2 Spoonfuls 30 grams= 10 Ounce 1 Cup ¼ Liter
4 Spoonfuls ¼ Cup 2Cups ½ Liter
8 Spoonfuls ¼ Cup 4 Cups 1Liter
16 Spoonfuls 1 Cup
EQUIVALENCES FARENHEIT AND CELCIUS GRADES
250
º f = 121º C 400 ºF = 204 º C
275 135
150 66 300 149
325 163
350 177
COMMON MEASURES
225 107 375 191
122º F = 50 ºC
130 54
175 79
200 93
425 218
450 232
475 246
500 260