Dometic CRX110 User manual

CRX50, CRX65, CRX80, CRX110,
CRX140
Compressor refrigerator
Installation and Operating Manual. . . . . . . 15
Réfrigérateur à compression
Instructions de montage
et de service . . . . . . . . . . . . . . . . . . . . . . . . .39
Nevera con compresor
Instrucciones de montaje y de uso . . . . . . .65
EN
FR
ES
WARNING
Cancer and Reproductive Harm
www.P65Warnings.ca.gov
CUS
REFRIGERATION
CRX
CRX50-65-80-110-140-IO-US.book Seite 1 Mittwoch, 15. Juli 2020 10:16 10

© 2020 Dometic Group. The visual appearance of the contents of this manual is
protected by copyright and design law. The underlying technical design and the
products contained herein may be protected by design, patent or be patent
pending. The trademarks mentioned in this manual belong to Dometic Sweden AB.
All rights are reserved.
CRX50-65-80-110-140-IO-US.book Seite 2 Mittwoch, 15. Juli 2020 10:16 10

CRX
3
CRX 50
1
2
3
5
4
6
7
1
1
2
3
5
4
6
7
CRX 65
2
CRX50-65-80-110-140-IO-US.book Seite 3 Mittwoch, 15. Juli 2020 10:16 10

CRX
4
1
2
3
5
4
6
7
CRX 80
3
4
1
2
3
5
4
6
7
CRX 110
CRX50-65-80-110-140-IO-US.book Seite 4 Mittwoch, 15. Juli 2020 10:16 10

CRX
5
55
1
2
3
5
4
6
7
CRX 140
6CRX50, CRX65, CRX80
1
2
3
4
8
7
6
5
3s
CRX50-65-80-110-140-IO-US.book Seite 5 Mittwoch, 15. Juli 2020 10:16 10

CRX
6
7
CRX110ACDC, CRX140ACDC
1
2
3
4
8
6
5
1
2
3
4
8
7
6
5
3s
CRX110DC
CRX50-65-80-110-140-IO-US.book Seite 6 Mittwoch, 15. Juli 2020 10:16 10

CRX
7
ca. 50 mm (2 inch)
ca. 50 mm (2 inch)
AB
CRX 50-140 CRX 50-140
11
22
33
4
8
CRX 140
ca. 20 mm
(0.79 inch)
CRX50-65-80-110-140-IO-US.book Seite 7 Mittwoch, 15. Juli 2020 10:16 10

CRX
8
2
1
9
1
2
0
CRX50-65-80-110-140-IO-US.book Seite 8 Mittwoch, 15. Juli 2020 10:16 10

CRX
9
a
b
c
CRX50-65-80-110-140-IO-US.book Seite 9 Mittwoch, 15. Juli 2020 10:16 10

CRX
10
tØ 2,5 mm²
876543210
0
2
4
6
8
10
12
l/m
Ø/mm²
12 Vg
d
Ø/mm²
l/m
24 V
0 2 4 6 8 10 12 14 16 18 20 22 24 26 28
0
2
6
10
14
e
CRX50-65-80-110-140-IO-US.book Seite 10 Mittwoch, 15. Juli 2020 10:16 10

CRX
11
1
rd
bk
f
1
2
g
CRX50-65-80-110-140-IO-US.book Seite 11 Mittwoch, 15. Juli 2020 10:16 10

CRX
12
12 V/24 V
10 A
–
–
+
+
2
1
rd/bk
rd
bk
bk
100 – 240 V~
h
1
Vent Lock
i
380 mm (14.96 inch)
534 mm (21.02 inch)
500 mm (19.69 inch)
CRX 50
j
CRX50-65-80-110-140-IO-US.book Seite 12 Mittwoch, 15. Juli 2020 10:16 10

CRX
13
CRX 65
448 mm (17.64 inch)
525 mm (20.67 inch)
545 mm (21.46 inch)
k
CRX 80
475 mm (18.7 inch)
640 mm (25.20 inch)
528 mm (20.79 inch)
l
CRX50-65-80-110-140-IO-US.book Seite 13 Mittwoch, 15. Juli 2020 10:16 10

CRX
14
CRX 110
520 mm (20.47 inch)
745 mm (29.33 inch)
558 mm (21.97 inch)
m
CRX 140
525 mm (20.67 inch)
812 mm (31.97 inch)
620 mm (24.41 inch)
n
CRX50-65-80-110-140-IO-US.book Seite 14 Mittwoch, 15. Juli 2020 10:16 10

EN
CRX Explanation of symbols
15
Please read this instruction manual carefully before installation and first
use, and store it in a safe place. If you pass on the product to another
person, hand over this instruction manual along with it.
Table of contents
1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
4 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
5 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
6 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
7 Installing and connecting the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . 22
8 Using the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
9 Cleaning and maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31
10 Limited warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
11 Disposal. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
12 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
13 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
1 Explanation of symbols
D
!
DANGER!
Safety instruction: Indicates a hazardous situation that, if not avoided,
will result in death or serious injury.
WARNING!
Safety instruction: Indicates a hazardous situation that, if not avoided,
could result in death or serious injury.
CRX50-65-80-110-140-IO-US.book Seite 15 Mittwoch, 15. Juli 2020 10:16 10

EN
Safety instructions CRX
16
!
A
I
2 Safety instructions
The manufacturer accepts no liability for damage in the following cases:
• Faulty assembly or connection
• Damage to the product resulting from mechanical influences and incorrect
connection voltage
• Alterations to the product without express permission from the manufacturer
• Use for purposes other than those described in the operating manual
2.1 General safety
DDANGER!
Failure to obey these warnings will result in death or serious injury.
DANGER OF ELECTROCUTION
• On boats: If the device is powered by the mains, ensure that the
power supply has a residual current circuit breaker.
!WARNING!
Failure to obey these warnings could result in death or serious injury.
DANGER OF ELECTROCUTION
• Installations in washrooms and areas exposed to water, must be
performed by a qualified technician.
• Do not operate the device if it is visibly damaged.
• If this device's power cable is damaged, it must be replaced by the
manufacturer, customer service or a similarly qualified person in order
to prevent safety hazards.
CAUTION!
Safety instruction: Indicates a hazardous situation that, if not avoided,
could result in minor or moderate injury.
NOTICE!
Indicates a situation that, if not avoided, can result in property damage.
NOTE
Supplementary information for operating the product.
CRX50-65-80-110-140-IO-US.book Seite 16 Mittwoch, 15. Juli 2020 10:16 10

EN
CRX Safety instructions
17
• This device may only be repaired by qualified personnel. Inadequate
repairs may cause serious hazards.
• Disconnect the cooling device from the power supply
– before each cleaning and maintenance
– after every use
HEALTH HAZARD
• This device can be used by children aged from 8 years and above and
persons with reduced physical, sensory or mental capabilities or lack
of experience and knowledge if they have been given supervision or
instruction concerning use of the device in a safe way and understand
the hazards involved.
• Children shall not play with the device.
• Cleaning and user maintenance shall not be made by children without
supervision.
• Children aged from 3 to 8 years are allowed to load and unload
refrigerating devices.
EXPLOSION HAZARD
• Do not store any explosive substances such as spray cans with a
flammable propellant in the cooling device.
!CAUTION!
Failure to obey these cautions could result in minor or moderate injury.
HEALTH HAZARD
• Food may only be stored in its original packaging or in suitable
containers.
DANGER OF CRUSHING
• Do not put your fingers into the hinge.
ANOTICE!
DANGER OF DAMAGE
• Check that the voltage specification on the type plate is the same as
that of the power supply.
• Never pull the plug out of the socket by the connection cable.
• If the refrigerator is connected to the DC socket: Disconnect the
refrigerator and other electric consumers from the battery before
connecting the quick charging device.
CRX50-65-80-110-140-IO-US.book Seite 17 Mittwoch, 15. Juli 2020 10:16 10

EN
Safety instructions CRX
18
• If the refrigerator is connected to the DC socket: Disconnect the
refrigerator or switch it off when you turn off the engine. Otherwise
you may discharge the battery.
• The refrigerator is not suitable for storing substances which are caustic
or contain solvents.
• Keep the drainage outlet clean at all times.
• Do not open the refrigerant circuit under any circumstances.
• Never transport the device in a horizontal position, so that no oil can
leak out of the compressor.
• Make sure that the refrigerator circuit is not damaged during transpor-
tation. The refrigerant in the refrigerator circuit is highly flammable.
In the event of any damage to the refrigerator circuit:
– Avoid naked flames and sparks.
– Air the room well.
• Set up the device in a dry location where it is protected against
splashing water.
2.2 Operating the device safely
DDANGER!
Failure to obey these warnings will result in death or serious injury.
DANGER OF ELECTROCUTION
• Do not touch exposed cables with your bare hands. This applies
especially when operating the device from the AC mains.
!CAUTION!
Failure to obey these cautions could result in minor or moderate injury.
DANGER OF ELECTROCUTION
• Before starting the cooling device, ensure that the power supply line
and the plug are dry.
HEALTH HAZARD
• Opening the door for long periods can cause significant increase of
the temperature in the compartments of the device.
• Clean regularly surfaces that can come in contact with food and
accessible drainage systems.
• Store raw meat and fish in suitable containers in the device, so that it is
not in contact with or can drip onto other food.
CRX50-65-80-110-140-IO-US.book Seite 18 Mittwoch, 15. Juli 2020 10:16 10

EN
CRX Scope of delivery
19
• If the device is left empty for long periods:
– Switch off the device.
– Defrost the device.
– Clean and dry the device.
– Leave the door open to prevent mould developing within the
device.
• If you connect the device to a battery, make sure that no food comes
into contact with the battery acid.
ANOTICE!
DANGER OF DAMAGE
• Do not use electrical devices inside the cooling device unless they are
recommended by the manufacturer for that purpose.
• Do not place it near naked flames or other heat sources (heaters, direct
sunlight, gas ovens etc.)
•Danger of overheating!
Always ensure sufficient ventilation so that the heat generated during
operation can dissipate. Make sure that the device is sufficiently far
away from walls and other objects so that the air can circulate.
• Ensure that the ventilation vents are not covered.
• Do not fill the inner container with ice or fluid.
• Never immerse the appliance in water.
• Protect the appliance and the cable against heat and moisture.
• Make sure that foodstuffs do not touch the walls of the cooling area.
3Scopeofdelivery
Quantity Description
1 Refrigerator with shelves
1 Water drain outlet
1 Installation and operating manual
CRX50-65-80-110-140-IO-US.book Seite 19 Mittwoch, 15. Juli 2020 10:16 10

EN
Accessories CRX
20
4Accessories
Available as accessories (not included in the scope of delivery):
If you have any questions, please contact the dealer or your service partner directly.
5 Intended use
The refrigerator is designed for installation in caravans and motorhomes and on
boats. It is recommended the unit is installed into a fixed position. Once it is installed,
only the front of the appliance may be accessible
The refrigerator is only suitable for cooling, freezing and storing foodstuffs. The
refrigerator is not intended for the proper storage of medicine.
For DC only version: The refrigerator must only be supplied at safety extra low
voltage corresponding to the marking on the refrigerator.
!
6 Technical description
The CoolMatic CRX series cooling appliances can cool products and keep them
cool. Products can be deep-frozen in the freezer compartment. If the refrigerator is
operated without a freezer compartment, frozen products can be stored in the short
term using the fast-cooling function.
All materials used in the refrigerator are compatible for use with foodstuffs.
The refrigerant circuit is maintenance-free.
Description Explanation Ref. no.
Rectifier Suitable for CRX50DC, CRX65DC, CRX80DC,
CRX110DC.
Transforms an input voltage of 100 – 240 Vwto 24 Vg,
so that the refrigerator can be connected to an AC
power supply.
9600000445
Mounting
Frames
Flush-mount and standard mounting frames are available
for all CRX models.
Various
CAUTION! HEALTH HAZARD
Please check if the cooling capacity of the refrigerator is suitable for stor-
ing the food you wish to cool.
CRX50-65-80-110-140-IO-US.book Seite 20 Mittwoch, 15. Juli 2020 10:16 10