Ecom TI-36 Ex Solar Installation instructions

Safety instructions
TTII--3366 EExx SSoollaarr
BAL TI-36 SOLAR NEU 25.02.2002 9:21 Uhr Seite 1

Contents Page
1. Introduction 11
2. Safety Information 11
3. Faults and Damage 12
4. Safety Regulations 12
5. Ex-Data 13
6. Technical Data 13
7. Repairs 13
8. Cleaning and Maintenance 13
9. Guarantee and Liability 14
10. Conformity Declaration 15
11. Certificate of Conformity 16-17
12. Approval Report 18
12. Approval Report
910
BAL TI-36 SOLAR NEU 25.02.2002 9:21 Uhr Seite 10

3. Faults and Damage
If there is any reason to suspect that the safety of the
unit has been affected then it must be immediately
withdrawn from use and precautionary measures
taken in order to prevent any further use of in the
hazardous area.
The safety and integrity of the unit may be compromi-
sed by, for example:
- External damage to the housing.
- Exposure to excessive loads.
- Incorrect storage of the unit.
- Damage sustained in transit
- Correct certification is illegible.
- Functioning errors occur
- The permitted limitations are exceeded
4. Safety Regulations
The use of the TI-36 Ex Solar meets the
requirements of the regulations providing that the
user observes and applies the requirements as laid
down in the regulations and that improper and
incorrect use of the unit is avoided.
The following safety regulation must be adhered to:
- Should the protective coat of paint against
electrostatic charges be damaged, then the
equipment has to be taken out of service.
1. Introduction
Solar-cell powered, the TI-36 Ex Solar pocket sized
scientific calculator is certified for use in Ex-hazardous
areas classified as Zones 1 & 2 according to
IEC/CENELEC (PTB-authorisation) or for
Zones 0, 1 & 2 according to NEC (FM-authorisation).
With auto switch on and 160 operations available -
displayed to a maximum of 10 significant figures (plus
a two - figure exponent) - calculations and
computations can be carried out as soon as there is
sufficient light on the solar panel.
The internal display register contains three data
memories, thereby allowing simple operations such as
percentage calculations to be carried out, as well as
calculations involving metric conversion systems and
physical constants.
The calculator comes complete with a case, which
helps provide excellent protection against the rigours
of the workplace environment.
As there are no batteries to be replaced or disposed
of, the TI-36 Ex Solar from ECOM represents a real
and active contribution towards environmental protec-
tion. Whilst for the user, the instrument is always ready
for use.
2. Safety Information
Safe operation of the equipment is maintained provi-
ding that all instructions and warnings contained in this
manual are fully observed.
In case of doubt (due to translation and/or printing
errors) reference should be made to the original
German instruction manual.
11 12
BAL TI-36 SOLAR NEU 25.02.2002 9:21 Uhr Seite 12

5. Ex-Data
Certificate of Conformity: PTB 01 ATEX 2133
Ex-Marking: II 2 G EEx ia IIC T4
Permitted for Zone 1, Equipment group II, Gas group C
hazardous gases, vapour or mist, Temperature Class
T4
Report Job Identification No.: 3009965
FM-Marking:
Class 1 Zone 0 AEx ia IIC T6
I.S. Class 1 Division 1 Group A-D T6
Permitted for Zone 0, Equipment group II, Gas group C,
Temperature class T6
6. Technical Data
Power Supply : Solar cells
Working Temperature : 0°C … +40°C
Storage Temperature : -20°C … +50°C
Dimensions : 70 x 140 x 10 mm
Weight : 100g
CE-Indicator : 0102
7. Repairs
The general terms and conditions of ELEX V apply to
repair work. The manufacturer must carry out the repair
work in order to check for the safe functioning of the
protective circuits.
8. Cleaning and Maintenance
The equipment must only be cleaned with a damp cloth
or sponge. Do not use abrasive solutions or scrubbing
equipment for cleaning.It is recommended that the
manufacturer check the functioning and accuracy of
the equipment every two years.
9. Guarantee and Liability
ecom instruments GmbH grants a guarantee, for a
period of 2 years from the date of delivery, for the
operation and material of this product under normal
operating and maintenance
conditions.
This guarantee does not apply to products used
improperly, altered or neglected,
or exposed to accidental damage or abnormal opera-
ting conditions as well as improper handling.
Guarantee claims can only be granted if the defective
equipment is returned to ECOM.
We reserve the right to repair, modify or exchange
any equipment.
The guarantee regulations are the only rights to com-
pensation of a purchase and are valid above all other
contracts or legal guarantee duties. ECOM takes no
responsibility for any consequential damages or los-
ses, including the loss of data, independent of whet-
her legal or illegal actions, or actions treated as other
handling, can be traced back to violation of the gua-
rantee.
In the case of some countries, where the
restrictions of a legal guarantee as well as the excep-
tion or restriction of consequential damage is not per-
mitted, it could be that the above mentioned limita-
tions and exceptions are not valid for every purchase.
Should an appropriate court find any condition of
such regulations ineffective or
non-acceptable, the effectiveness or forcibility of any
other condition, under such guarantee regulations,
remains untouched.
13 14
BAL TI-36 SOLAR NEU 25.02.2002 9:21 Uhr Seite 14

12. Approval ReportCertificate of Conformity
17 18
BAL TI-36 SOLAR NEU 25.02.2002 9:21 Uhr Seite 18

ecom instruments GmbH
Industriestr.2
D-97959 Assamstadt
Tel.: [phone]
Fax: [phone]
E-Mail: [email protected]
Internet: www.ecom-ex.com
Z-Nr. 006B0101, Änderungen vorbehalten!
BAL TI-36 SOLAR NEU 25.02.2002 9:21 Uhr Seite 38