Equip 5GF Series User manual

Installation and
Installation and
Maintenance
Maintenance
Instructions
Instructions
EQUIP 5GF
GLASS FILLERS
Limited One Year Warranty
Equip warrants to the original purchaser (other
than for purposes of resale) that such product is
free from defects in material and workmanship for
a period of one (1) year from the date of purchase.
During this one-year warranty period, if the product
is found to be defective, Equip shall, at its option,
repair and/or replace it. To obtain warranty service,
products must be returned to...
Equip Foodservice Accessories
Attn: Warranty Repair Department
P.O. Box 1088, 2 Saddleback Cove
Travelers Rest, SC 29690
Shipping, freight, insurance, and other trans-
portation charges of the product to Equip and
the return of repaired or replaced product to the
purchaser are the responsibility of the purchaser.
Repair and/or replacement shall be made within
a reasonable time after receipt by Equip of the
P/N: 098-003148-45EQ Rev. 0
Date: 04-05-11
Drawn: TEH
Checked: JRM 04-07-11
Approved: JHB 04-07-11
returned product. This warranty does not cover
Items which have received secondary finishing
or have been altered or modified after pur-
chase, or for defects caused by physical abuse
to or misuse of the product, or shipment of the
products.
Any express warranty not provided herein,
and any remedy for Breach of Contract which
might arise, is hereby excluded and disclaimed.
Any implied warranties of merchantability or
fitness for a particular purpose are limited to
one year in duration. Under no circumstances
shall Equip be liable for loss of use or any spe-
cial consequential costs, expenses or damages.
Some states do not allow limitations on how
long an implied warranty lasts or the exclusion
or limitation of incidental or consequential
damages, so the above limitations or exclusions
may not apply to you. Specific rights under
this warranty and other rights vary from state
to state.

2
sink back
7, 8 20 21
1
Instructions
Installation: (5GF-W-F & 5GF-W)
1. Turn off water supply and drain lines.
Hand tighten no.20 firmly against no.1
and remove no.21 from no.1.
2. Drill 7/8” hole in sheet metal. Insert no.1
through hole and screw no.21 on back of no.1,
leaving no.20 free to turn.
3. Apply teflon tape or pipe joint compound to
threads of water supply line. Connect no.1to
water supply line outlet, tightening as far as possible.
4. Tighten no.20 and no.21 so they are flush against surface of sink back.
5. Turn on water supply and check for leaks.
Flow Adjustment:
To adjust water flow, loosen no.7 with a wrench, then use
screwdriver to turn no.8 to desired setting. Tighten no.7 when flow
adjustment is complete.
1
7, 8
23
24
26
25
countertop
22
Installation: (5GF-8P & 5GF-8P-WS)
1. Turn off water supply and drain lines.
2. Unscrew and remove no.26 and no.25
from no.23. Position no.24 to cover threads
of no.23.
3. Place no.23 through 7/8” hole in
countertop. Replace no.25 and no.26 onto
no.23 and tighten with a wrench at bottom
side of countertop.
4. Screw no.1into no.22 and tighten firmly.
5. Apply teflon tape or pipe joint compound
to threads of no.23, connect to water supply
line inlet.
6. Turn on water supply and check for leaks.
To adjust water flow, please refer to
flow adjustment note for 5GF-W-F &
5GF-W models.

3
Instructions
10
11
10
12
13
6
54
3
2
1
16171819
15
14
7
8
920 21 22
23
24
25
26
5GF-W-F
5GF-W
5GF-8P
5GF-8P-WS

4
Part Numbers
Equip Glass Filler Assembly Parts List
5GF-W-F, 5GF-W, 5GF-8P, 5GF-8P-WS
1 Asm, Body - Glass Filler & Pin N/A
2 Washer *
3 Tip, Glass Filler *
4 Screw, Handle *
5 Nut, Handle *
6 Lever Arm, Blue Lexan *
7 Nut, Volume Control N/A
8 Stem, Volume Control N/A
9 Washer, Volume Control N/A
10 Washer, Bonnet *
11 Packing Stem *
12 Spring *
13 Pushbutton N/A
14 Hexcap N/A
15 O-Ring *
16 Asm, Stem N/A
17 Holder, Seat Washer N/A
18 Stem N/A
19 Washer, Seat *
20 Flange (5GF-W-F) N/A
21 Locknut (5GF-W-F) N/A
(Items 22 thru 26 used on 5GF-8P & 5GF-8P-WS models)
22 Pedestal Cube N/A
23 Pedestal - 8” N/A
24 Flange N/A
25 Washer, Pedestal N/A
26 Locknut N/A
Note: Items marked with (*) are included in 5GF-RK Repair
Parts Kit. Those marked with (N/A) are for instructional
purposes only.