Fogmaster 533010CA User manual

CAUTION
Always read and follow instructions
on the label of the chemical being used.
Do not use to apply flammable liquids.
CONTROL
KNOB
POWER SWITCH
LIQUID
FILTER
NOZZLE POWER
CORD
AIR
INTAKE
OWNER’S MANUAL
Models 533010CA, 533020CA, 533010CE, 533020CE
TANK
READ AND SAVE THESE INSTRUCTIONS

SERVICING DOUBLE-INSULATED APPLIANCES
In a double-insulated appliance, two systems of insulation are
provided instead of grounding. No grounding means is provided on a
double-insulated appliance, nor should a means for grounding be
added.
There are NO USER SERVICEABLE PARTS in the Fogmaster Jr.
USER MAINTENANCE INSTRUCTIONS
Clean with soap and water using a damp cloth. Do not use oil based
cleaners. Do not submerge unit.
The only maintenance required by the Fogmaster jr is occassional
cleaning of the liquid filter. Pull filter off the end of the suction
connector. Rinse filter with running water to remove particles clinging
to its outer surface.
IMPORTANT SAFETY INSTRUCTIONS
PERTAINING TO RISK OF FIRE, ELECTRIC SHOCK OR INJURY
1. Read all the instructions before using the appliance.
2. To reduce risk of injury, close supervision is necessary when an
appliance is used near children. Do not leave unattended. Store
indoors out of reach of children.
3. To disconnect - turn switch to off (“O”) position, then remove plug
from outlet. Unplug from outlet when not in use.
4. Do not unplug by pulling on cord.To unplug, grasp the plug, not
the cord. Protect power cord from heat, oil and sharp edges.
5. This appliance is provided with double insulation and has no
serviceable parts. See additional information for Double Insulated
Appliances in the instructions provided.
6. To reduce the risk of electric shock, do not put Fogmaster Jr. in
water or other liquid. Do not place or store appliance where it can
fall or be pulled into a tub or sink.
7. Always follow label instructions for the chemical being applied.
8. Fog particles can be practically invisible and are easily inhaled.
Avoid breathing fog output.Wear a mask or respirator as
appropriate for the chemical used.
TO AVOID DANGER OF FIRE OR EXPLOSION, DO NOT FOG
FLAMMABLE LIQUIDS, ESPECIALLY IN CLOSED AREAS.
SAVE THESE INSTRUCTIONS

OPERATING INSTRUCTIONS
Prepare Fogging Solution
Dilute fogging chemical as required, mixing
enough solution for your application.Twist tank
counter-clockwise 90° to remove power head. Add
liquid and replace power head, making sure tank
gasket is in place.
Connect to Electric Source
To reduce the risk of electric shock, this appliance has a polarized
plug (one blade is wider than the other).This plug will fit in a polarized
outlet only one way. If the plug does not fit fully in the outlet, reverse the
plug. If it still does not fit, contact a qualified
electrician to install the proper outlet. Do not
change the plug in any way.
If you need a longer power cord, we recommend
a garden-type extension cord. Do not use one that
is cut, frayed or otherwise damaged.To prevent
accidental unplugging, knot the two cords as
shown, or use a cord retainer available at many hardware stores at
modest cost.
Operation
Slide the power switch to the “on” position. A fine mist will form. Adjust
the control knob for the droplet size desired for your work.The
Fogmaster jr can produce a range of droplet sizes, from relatively
coarse ones which settle quickly to fine fog particles which can float a
long distance.
The control knob also regulates the liquid flow rate. After setting the
droplet size, you can calculate the liquid flow rate by timing how long it
takes to dispense a measured amount of liquid.
If possible, make your application in still air. Otherwise, your chemical
may be blown off target. Use an even sweeping motion, making certain
to cover the entire target area. Do not over-apply. Since a fine mist is
difficult to see, it is usually better to calculate fogging time and volume
from the liquid flow rate than to rely on visible indications.
When finished fogging, remove and empty tank. Open control knob
and run unit a few seconds to discharge any liquid remaining in internal
lines. If you have been fogging liquids containing solids or polymers
likely to accumulate, flush residues from internal lines by running unit
with clean water (or the appropriate solvent) briefly.
TANK
GASKET

1051 S.W. 30 Avenue Tel: [phone]
Deerfield Beach, FL 33442 Fax: [phone]
www.fogmaster.com e-mail:[e-mail]
ONEYEAR LIMITED WARRANTY
This product is warranted for one year from the purchase date against
defects in materials and workmanship. If you have a warranty claim, return the
unit freight prepaid to The Fogmaster Corporation or an authorized Service
Center. We will repair or replace (at our option) any defective parts and return
the unit to you.
Motor brushes and tank gaskets are not covered under warranty.
This warranty does not apply to any unit which has been: subject to misuse,
neglect or accident; used for a purpose for which it is not designed; altered in
any manner; serviced by unauthorized parties; or subjected to any but the
specified voltage.
This warranty is limited to the original purchaser only, and does not include
claims for incidental or consequential damages resulting from the non-function
or malfunction of this product or for breach of any express or implied warranties.
Some states do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or exclusion may not apply to
you.This warranty gives you specific legal rights, and you may also have other
rights which vary from state to state.
This Limited Warranty notice replaces any other warranty or guarantee
information accompanying this product or appearing in any literature referring
to this product.Any implied warranties, including merchantability or fitness for a
particular purpose, shall not extend beyond the warranty period.
W53304057_EN_MET_0607
MODEL SPECIFICATIONS
Voltage Current Tank
Model VAC A oz [l]
533010 120 3.0 32 [1]
533020 240 1.5 32 [1]
REPLACEMENT PARTS
Item Part No.
Tank (32 oz) JR100
Tank Gasket, 1/4”(urethane) JR500
Tank Gasket, 1/8”(Buna N) JR501
Suction Tube/Connector JR600
Liquid Filter JR700