Frigidaire FRS23KF6EB4 Service User guide

SNOITCENNOCGULPROTCENNOCREKAMECI
rebmuNeriWroloCeriW:otstcennoC
1wolleY/neerGdnuorG
2wolleYevlaVretaW
3kcalBen
iL
4eulB.tLlartueN
ICE MAKER INFORMATION
Test Cycling
Remove cover by inserting screwdriver in notch at bottom and prying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until holding switch circuit is completed. All
components of ice maker should function to complete the cycle.
Water Fill Volume
The water fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 102 to
130cc (3.4 to 4.3 oz.).
When a water valve is
replaced, the fill volume
must be checked.
SERVICE DATA SHEET - 240389629
R134a
ICE & WATER - AUTOMATIC DEFROST
SIDE BY SIDE MODELS
IMPORTANT SAFETY NOTICE
The information provided herein is designed to assist qualified repair
personnel only. Untrained persons should not attempt to make
repairs due to the possibility of electrical shock. Disconnect power
cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
P-3
P-4
P-2
P-1
GREEN/YELLOW
GREEN/YELLOW
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
NOTE: This product comes equipped with an Electronic Defrost
Control.To initiate defrost, depress the fresh food light switch 5
times in 6 seconds (light bulb must be working). To terminate
defrost, depress the fresh food light switch 5 times in 6 seconds.
ATADECNAMROFREP
GNITTESLORTNOCTNIOP-DIMTASGNINEPOROODONDNADAOLON
roticapaCtratS/nuRhtiWAepyTtneibmA)C°81
(F°56tneibmA)C°23(F°09
emiTgnitarepO%04ot23%56ot55
erutarepmeTrezeerFF°4ot°0
C°61-ot°81-
F°3ot°1-
C°61-ot°81-
e
rutarepmeTrotaregirfeRF°93ot°43
C°4ot°1
F°93ot°43
C°4ot°1
(erusserPediSwoL
)ni-tuc gisp21ot5
aPk38ot43
gisp21ot5
aPk38ot43
(erusserPediSwoL
)tuo-tuc gisp2ot2-
aPk41ot41-
gisp2ot2-
aPk41ot41-
(erusserPediShgiH
)elcycfo3/1tsaL gisp511ot09
aPk397ot126
gisp551ot031
aPk9601ot698
)elcycfo3/1tsaL(egattaW051ot021061ot031
)gninnuR(spmA5.1ot2
.15.1ot2.1
egatloVesaB)xamcav721(cav511)xamcav721(cav511
SNOITACIFICEPSTSORFED
eziStenibaC
tatsomrehTretaeH
ni-tuCtuo-tuCsttaWsmhO
'62&'32F°52
C°4-
F°74
C°8
05403
.emitnurro
sserpmocfosruoh27ot6yrevesetunim42tsorfeD)CDA(-remiTcinortcelE
ROTOMNAFRESNEDNOC
sttaWMPRspmA
)sledomemoS-ratSygrenE(1.3tfahSetisoppOWC0011gninnuR30.
0.8tfahSetisoppOWC0522g
ninnuR70.
SNOITACIFICEPSREKAMECI
lacirtcelE)xamcav721(cav511ztreH06
tatsomrehT)C°9(F°84tasnepO)C°9-(F°51tasesolC
egatt
aWretaeH561

DISPENSER
NCNO
LOCKOUTRESET
NO NCNCNO
LIGHTCRUSH
NO NCNCNO
CUBEFAST ICE
NO NCNCNO
FAST FREEZE
WATER DISP.
SWITCH
ICE DISP.
SWITCH
NO NC
COMM
SLATE
BROWN
COMM
NC
NO
ORANGE
WHITE
BLACK
S4 S7 S6 S5 S2 S3 S1
YELLOW (V IN) BLACK (DC GRD) SLATE (ICE PADDLE) ORANGE (WATER PADDLE) RED (+5 VDC) WHT/YEL (CUBE) BLUE (LIGHT) PURPLE (AUGER) WHT/RED (WATER) WHT/GRN (FAST ICE/WATER)
DC POWER SUPPLY
AND RELAYS
LT. BLUE (NEUTRAL)
TAN (WATER VALVE)
ORG/WHT (FAST FREEZE/ICE)
PURPLE (AUGER)
RED/BLK (120 VAC)
BLU/WHT (CUBE)
ELECTRONIC DISPENSER
ELECTRO-MECHANICAL DISPENSER
LIGHT
EVAP FAN
DOOR SWITCH
FRZR. COLD CNTRL
NEUTRAL
F.F. COLD CNTRL
DEFROST POWER
1
2
3
4
5
6
7
8
9
POWER
241526901C
3
6
S
S
5
2
1
L
M
M
C
*SOME P.T.C. MODELS.
CAPACITOR IS ONLY USED WITH
*
RUN CAPACITOR
STARTER
PTC
MOTOR
COMP.
OVERLOAD
RUN
START
GRN/YEL
RED
LT. BLU
P.T.C. STARTER WITH RUN CAPACITOR
I/M
WATER
VALVE
TWO
WATER
DISPENSER
VALVE
TWO
WATER
VALVE
ONE
SEE
COMPRESSOR
WIRING
COND. FAN
YEL/RED
LT. BLU
CRISP.
LIGHT
DISPENSER HOUSING HEATER
SPLICE
DIODE
DIODE
DIODES TO BE
POLARIZED AS
SHOWN.
DEFROST
THERM.
FRZR.
FAN
FRZR DOOR
GROUND
AUGER ASS'Y
ICE
MAKER
DEFROSTHEATER
DRAIN
TROUGH GRN/YEL
BLACK
BLU/WHT
YELLOW
YEL/RED
PURPLE
LT. BLU
LIGHT SWITCH
(FRZR)
LIGHT SWITCH
(REFRIG)
GRN/YEL
BLACK
LT. BLU
YEL/BLK
ORG/WHT
RED
BROWN
RED/WHT
BLUE
RED
YELLOW
TAN
YEL/BLK
BLACK
LT. BLU
GRN/YEL PURPLE TAN BLU/WHT LT. BLU RED
RIBBED
NON-RIBBED
BLUE
GRN/YEL
RED/WHT
BROWN
LT. BLU
SPLICE
SPLICE
ALL WIRE CONNECTIONS
MARKED BY " " SYMBOL.
SEE
DISPENSER ASS'Y
WIRING
ORG/WHT
CABINET
GROUND
COMPRESSOR
GROUND
MID LEVEL
LIGHT
COMPRESSOR
DEF THERMO
MOLEX
7 8 9 10 11 12
123456
P2
BOTTOM
FAST FREEZE
ORANGE
#3
#2
FRZR.
CONTROL
DAMPER
SWITCH
DAMPER
MOTOR
SWITCHES SHOWN IN THE DAMPER OPEN POSITION
LIGHT SOCKET
COLD
CONTROLS
SHOWN IN THE
ON POSITION.
FRESH FOOD
CONTROL
VIOLET W/
HT
RED/BLK
DAMPER MOTOR
PURP/WHT
DAMPER SW. COMMON
EVAP. FAN
DAMPER MOTOR
C
NO
(NEUTRAL)
(LINE)
REFRIG. LIGHT
FRZR. LIGHT
CRISPER LIGHT
REFRIG. LIGHT SWITCH
MOTOR,AUGER
FREEZER LIGHT /
SAFETY SWITCH
MAIN WATER VALVE
DISPENSER WATER VALVE
ACTUATOR,ICE DOOR
I/M WATER VALVE
AUTO
ICEMAKER
THERM.
COIL HEATER DEFROST
B
RED GREEN
COND. FAN
SEE
COMPRESSOR
WIRING
J12
J9
HEATER,ICE DOOR
SEE
DISPENSER ASS'Y
WIRING
ADAPTIVE
DEFROST
III
J11
J7
MID LEVEL LIGHT
FREEZER CONTROL
FRESH FOOD
CONTROL
J5
J8 J2 J6
J1 J4
FAST ICE
NEUTRAL WIRE
J10
J3
TAN (WATER VALVE)
NO NC
COMM
RED/BLK (120 VAC)
PURPLE (AUGER)
COMM
NC
NO
ICE DISP.
SWITCH
WATER DISP.
SWITCH