SNOITCENNOCGULPROTCENNOCREKAMECI
rebmuNeriWroloCeriW:otstcennoC
1wolleY/neerGdnuorG
2wolleYevlaVretaW
3kcalBen
iL
4eulB.tLlartueN
ICE MAKER INFORMATION
Test Cycling
Removecoverbyinsertingscrewdriverinnotchat bottomandprying
cover from housing. Use screwdriver to rotate motor gear
counterclockwise until Holding Switch circuit is completed. All
components of ice maker should function to complete the cycle.
Water Fill Volume
Thewater fill adjustment
screw will change the fill
time. One full turn is
equal to 20cc (.68 oz.).
The correct fill is 95 to
105cc (3.2 to 3.6 oz.).
When a water valve is
replaced, the fill volume
must be checked.
CAUTION: All electrical parts and wiring must be shielded
from torch flame. Do not allow torch to contact insulation; it
will char at 200°F and flash ignite (burn) at 500°F. Excessive
heat will distort the plastic liner.
SERVICE DATA SHEET
IMPORTANT SAFETY NOTICE
Theinformationprovidedhereinis designedtoassist qualifiedrepair
personnel only. Untrained persons should not attempt to make
repairsdue to thepossibility of electricalshock. Disconnect power
cord before servicing.
IMPORTANT
If any green grounding wires are moved during servicing, they
must be returned to their original position and properly secured.
ATADECNAMROFREP GNITTESLORTNOCTNIOP-DIMTASGNINEPOROODONDNADAOLON
nuRnoitcudnIronuRroticapaCtneibmA)C°81(
F°56tneibmA)C°23(F°09
emiTgnitarepO%53ot52%55ot54
erutarepmeTrezeerFF°8ot°2 C°31-ot°71- F°5ot°0 C°51-ot°81-
eru
tarepmeTerutaregirfeRF°04ot°53 C°4ot°2 F°04ot°53 C°4ot°2
(erusserPediSwoL
)ni-tuc
gisp61ot8 aPk011ot55 gisp61ot8 aPk011ot55
(erusserPediSwoL
)tuo-tuc
gisp4ot1 aPk82ot7 gisp4ot1 aPk82ot7
(erusserPediShgiH
)elcycfo3/1tsaL
gisp021ot011 aPk728ot857 gisp571ot051 aPk7021ot4301
)elcycfo3/1tsaL(egattaW581ot041581ot041
)gninnuR(spmA6.1o
t1.16.1ot1.1
egatloVesaB)xaMCAV721(CAV511)xaMCAV721(CAV511
SNOITACIFICEPSTSORFED
eziStenibaC tatsomrehTretaeH
ni-tuCtuo-tuCsttaWsmhO
'12&'81 F°52 C°4- F°74 C°8 57353
'71&'51,'
41 F°52 C°4- F°74 C°8 52314
emiTnuRrosserpmoCfosruoH01yrevEsetuniM03tsorfeD-remiTlacinahceM emiTnuRrosserpmoCfosruoH27-6yrevEsetun
iM42oTpUtsorfeD)CDA(remiTcinortcelE
ROTOMNAFRESNEDNOC
sttaWMPRspmA
3.2tfahSetisoppOWC0011gninnuR51.
SNOITACIFICEPSREKAMECI
lacirtcelE)xaMCAV721(CAV511ztreH06
tatsomrehT)C°9(F°84tasnepO)C°9-(F°51tasesolC
egatt
aWretaeH561
STANDARD -AUTOMATIC
DEFROST TOP FREEZER
MODELS (R134a) P/N: 241643400
NOTE: Some products come equipped with an Electronic
DefrostControl. To initiatedefrost, depressthefresh foodlight
switch 5 times in 6 seconds (light bulb must be working). To
terminatedefrost,depressthe fresh food light switch 5 times
in 6 seconds.
ORANGE
WHITE WHITE
ORANGE
ORANGE
ORANGE
ORANGE
POWER
ICE MAKER
ICE MAKER
I
CE MAKER
ICE MAKER
WATER VALVE
LINE
HOLD
SWITCH
THERMOSTAT
SHUT-OFF
SWITCH
WATER FILL
SWITCH
(THERMAL CUTOUT IN LINE ATTACHED TO MOLD BODY)
MOLD HEATER
MOLD MOUNTING
PLATE
165 WATTS
MOTOR
NEUTRAL
BLK
BLK
BLK
BLK BLU
C
C
C
NO
NO
NO
NC
NC
NC
WHITE
WHITE
BRN
RED
GRN / YEL
GRN / YEL
RED
RED
ORANGE
ORANGE
ORANGE
P-3
P-1 P-2
P-4
