FSN MTS800A Installation and maintenance instructions

Matrix Switcher
MTS800A Video Management System
Installer User’s Guide
Before connecting, operating or adjusting this product, please
read this instruction booklet carefully and completely.

FSN1979 - 6/2017
2 - English
Table of Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Symbol Denitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Caution . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
MTS800A Sample System Conguration . . . . . . . . . . . . . . 10
Connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Connect Input Video Sources . . . . . . . . . . . . . . . . . . . . . 12
Connect Output Video Destinations . . . . . . . . . . . . . . . . . 13
Connect Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Connect a Remote Control Device . . . . . . . . . . . . . . . . . . 15
Methods of Operation . . . . . . . . . . . . . . . . . . . . . . . . 16, 17
Streaming Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . 18, 19
General Specication . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Input/Output Connectors. . . . . . . . . . . . . . . . . . . . . . . . 21
Timing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Mechanical Drawing . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Troubleshooting, Cleaning Instructions . . . . . . . . . . . . . . . 24
Fuse Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
The specications and information in this document are subject to change without notice.

FSN1979 - 6/2017
12345678
12345678
ENTER INPUT
MENU OUTPUT
< SYSTEM >
1. Network IP
English - 3
Overview
MTS800A is an all-in-one medical device switcher solution that manages several independent input/
output systems typically found in a surgical environment. MTS800A uses a stand alone PC, or a tablet PC
with touch screen user interface to control video switching. Streaming is also available, and live preview
of the active video signal can be seen on the controlling PC.
As a single location that controls a variety of medical OR video systems, MTS800A brings eciency and
simplicity to the busy operating room during surgical procedures. Supported video includes:
t Y%7*%GVMMNBUSJYTXJUDIJOHVQUP869("
t Y4%)%(4%*GVMMNBUSJYTXJUDIJOH
t Y3(#%46#GVMMNBUSJYTXJUDIJOHVQUP869("
t Y$7#4GVMMNBUSJYTXJUDIJOH
t /FUXPSLWJEFPTUSFBNJOHEFMBZNBZBQQMZEFQFOEJOHPOUIFFOWJSPONFOU
5IJT.54"*OTUBMMFS6TFST(VJEFXBTDSFBUFEUPQSPWJEFBCBTJDVOEFSTUBOEJOHPGUIFQSPEVDUT
hardware features and functions. Many of the regularly used features of the system are controlled by
the remote control tablet or PC, and the user interface.

FSN1979 - 6/2017
4 - English
Symbol Denitions
The following symbols appear on the product, its labeling, or the product packing. Each symbol
carries a special denition, as dened below:
AC Voltage Switches on power
Switches o power Contained spare fuse
%BOHFSPVT)JHI7PMUBHF Consult accompanying
documents
Indicates protective earth
ground 4FSJBM/VNCFS
Indicates top-bottom direction Fragile
Do not get wet .BYJNVN4UBDLJOH
.FEJDBM&RVJQNFOUJTJOBDDPSEBODFXJUI6-BOE$"/$4"$/P
601.1 in regards to electric shock, re hazards, and mechanical hazard.
Indicates proof of conformity to applicable European Economic Community
Council directives and to harmonized standards published in the ocial journal
of the European Communities.
Tested to comply with FCC
Class B standard. Equipotentiality.
This symbol indicates that the waste of electronic equipment must not be
disposed as unsorted municipal waste and must be collected separately.
Please contact the manufacturer or other authorized disposal company to
decommission your equipment.
Refer to the instruction manual/ booklet.

FSN1979 - 6/2017 English - 5
Safety and Instructions
Please read the following safety instructions as they are designed to prevent damage to property
and harm to the user.
Warning / Caution
Failure to follow directions noted by this symbol could result in bodily harm or damage
to equipment.
Notational Conventions
Prohibited Important to read and understand at all times
Do not disassemble Disconnect the plus from outlet
Do not touch Grounding to prevent an electrical shock
Power
6TFPOMZBQSPQFSQMVHBOEWPMUBHF
Improper power may cause electric shock or equipment damage.
To avoid the risk of electric shock, this equipment must only be connected to a power
supply with protective grounding.
Installation
Do not connect any other wires or accessories to this system which do not comply.
An improper wire may cause electric shock or equipment damage.
Insert wires rmly so that they do not come loose.
A bad connection may cause fault.
Operating environment
#FTVSFUPDPOUBDUUIJTQSPEVDUTTVQQMJFSXIFOJOTUBMMJOHZPVSTZTUFNJOBMPDBUJPOXJUI
heavy dust, high or low temperatures, high humidity, or chemical substances.
Failure to do so may cause serious damage to your system.
Others
If this system does not operate normally, in particular, if there are any unusual
sounds or smells coming from it, unplug it immediately.
Please contact supplier when you want to use this system with unknown
equipment. Please power o and pull out the power cord when you want to move
this system.

FSN1979 - 6/2017
6 - English
Caution
CAUTION
RISK OF ELECTRICAL SHOCK
DO NOT OPEN
This symbol alerts the user that important literature concerning the operation of this unit
has been included. Therefore, it should be read carefully in order to avoid potential problems.
This symbol warns the user that un-insulated voltage within the unit may have sucient
magnitude to cause electrical shock. Therefore, it is dangerous to make contact with any part
inside the unit.
5PSFEVDFUIFSJTLPGFMFDUSJDTIPDL%0/05SFNPWFDPWFSPSCBDL5IFSFBSFOPVTFSTFSWJDFBCMF
parts inside. Refer servicing to qualied service personnel.
5PQSFWFOUöSFPSTIPDLIB[BSETEPOPUFYQPTFUIJTVOJUUPSBJOPSNPJTUVSF"MTPEPOPUVTFUIJT
VOJUTQPMBSJ[FEQMVHXJUIBOFYUFOTJPODPSESFDFQUBDMFPSPUIFSPVUMFUTVOMFTTUIFQSPOHTDBOCF
fully inserted.
The equipment is designed to meet the medical safety requirements for a patient vicinity device.
This device may not be used in connection with life support equipment.
 6OEFSXSJUFST-BCPSBUPSJFT6-$MBTTJöDBUJPO
UL safety Compliance:
5IJTTZTUFNJT6-$MBTTJöFE8*5)3&41&$550&-&$53*$4)0$,'*3&"/%.&$)"/*$"-
)";"3%40/-:*/"$$03%"/$&8*5)6-$"/$4"$/0
EEC Safety Compliance:
5IJTTZTUFNNFFUTUIFSFRVJSFNFOUTPG&/TPBTUPDPOGPSNUPUIF.FEJDBM%FWJDF
%JSFDUJWF&&$HFOFSBMTBGFUZJOGPSNBUJPO6TF7SBUJOH1UZQFQMVHPOMZJOUIF64
This system is intended for connection to a separate medical grade power supply.
Caution: Make sure the power cord is the correct type that is required in your area.
This system has a universal power supply that allows operation in either 100 - 120V AC or
7"$WPMUBHFBSFBTOPVTFSBEKVTUNFOUJTSFRVJSFE
6TFUIFQSPQFSQPXFSDPSEXJUIDPSSFDUBUUBDINFOUQMVHUZQF*GUIFQPXFSTPVSDFJT7"$
VTFBQPXFSDPSEXIJDIJTB)PTQJUBM(SBEF1PXFS$PSEXJUI/&."TUZMFQMVHMBCFMFEGPS
WPMUT"$XJUI6-BOE$6-BQQSPWBMT
*GUIFQPXFSTPVSDFJTB7"$TVQQMZVTFUIFUBOEFN5CMBEFUZQFBUUBDINFOUQMVHXJUI
HSPVOEDPOEVDUPSQPXFSDPSEUIBUNFFUTUIFSFTQFDUJWF&VSPQFBODPVOUSZTTBGFUZSFHVMBUJPOT

FSN1979 - 6/2017 English - 7
5IFIPTQJUBMHSBEFQMVHGPSNFEJDBMQSPEVDUTJOUFOEFEGPSVTFJO%FONBSLIBT%&.,0BQQSPWBM
and is rated 13 amps at 250Vac. Plug is recommended for use in medical applications and
TQFDJöDBUJPOTBSFCFJOHBEEFEUPUIFTUBOEBSE4#%1MVHNBUFTXJUINBLFST%BOJTI
IPTQJUBMHSBEFTPDLFU)PTQJUBMTPDLFUTIBWFTMJHIUMZEJòFSFOUTIBQFEPQFOJOHTBMMPXJOHPOMZUIF
hospital plug, not the standard Danish plug, to be inserted, to protect the AC circuit in specic
medical settings.
FCC WARNING :
This equipment has been tested and found to comply with the limits of a Class B digital device,
pursuant to Part 15 of the FCC rules. These limits are designed to provide reasonable protection
against interference. This system can radiate radio frequency energy and, if not installed and
used in accordance with the instructions, it may interfere with other radio communications
equipment.
There is no guarantee that interference will not occur in a particular installation. If this equipment
is found to cause harmful interference to radio or television reception, the user is encouraged to
try to correct the interference by carrying out one or more of the following measures:
1. Reorient or relocate the receiving antenna.
2. Increase the distance between this system and the subject of interference.
3. Plug this system into an outlet on a dierent electrical circuit than that to which the subject of
interference is connected.
4. $POTVMUUIFEFBMFSPSBOFYQFSJFODFESBEJP57UFDIOJDJBOGPSIFMQ
NOTICES TO USER :
This device complies with part 15 of the FCC Rules. Operation is subject to the following two
conditions:
UIJTEFWJDFNBZOPUDBVTFIBSNGVMJOUFSGFSFODFBOEUIJTEFWJDFNVTUBDDFQUBOZ
interference received, including interference that may cause undesired operation.
This equipment generates or uses radio frequency energy. Changes or modications to this
FRVJQNFOUNBZDBVTFIBSNGVMJOUFSGFSFODFVOMFTTUIFNPEJöDBUJPOTBSFFYQSFTTMZBQQSPWFEJO
the instruction manual.
The user could lose authority to operate this equipment if an unauthorized change or
modication is made.
8"3/*/(%POPUUPVDIJOQVUPSPVUQVUDPOOFDUPSTBOEUIFQBUJFOUTJNVMUBOFPVTMZ
6TFS2VBMJöDBUJPO
MTS800A image processing system should be used by qualied sta who have a corresponding
specialized qualication and who have been instructed in the use of the system.

FSN1979 - 6/2017
8 - English
Recycling :
Follow local governing ordinances and recycling plans regarding the recycling or disposal of this
equipment.
Servicing
%POPUBUUFNQUUPTFSWJDFUIFTZTUFNZPVSTFMGBTPQFOJOHPSSFNPWJOHDPWFSTNBZFYQPTFZPVUP
dangerous voltages or other hazards, and will void the warranty. Refer all servicing to qualied
TFSWJDFQFSTPOOFM6OQMVHUIFTZTUFNGSPNJUTQPXFSTPVSDFBOESFGFSTFSWJDJOHUPRVBMJöFE
personnel under the following conditions:
- If the power cord or plug is damaged or frayed.
- If liquid has been spilled into the system.
- If objects have fallen into the system.
- *GUIFTZTUFNIBTCFFOFYQPTFEUPSBJOPSNPJTUVSF
- *GUIFTZTUFNIBTCFFOTVCKFDUFEUPFYDFTTJWFTIPDLCZCFJOHESPQQFE
- If the enclosure has been damaged.
- If the system seems to be overheated.
- If the system emits smoke or abnormal odor.
- If the system fails to operate in accordance with the operating instructions.
Accessories
6TFPOMZBDDFTTPSJFTTQFDJöFECZUIFNBOVGBDUVSFSPSTPMEXJUIUIFTZTUFN
Classication
Protection against electric shock : Class I including AC/DC power.
"QQMJFE1BSUT/P"QQMJFE1BSUT
%FHSFFPGTBGFUZJOUIFQSFTFODFPGøBNNBCMFBOFTUIFUJDTNJYUVSFXJUIBJSPSXJUIPYZHFOPS
XJUIOJUSPVTPYJEF/PUTVJUBCMFGPSVTFJOUIFQSFTFODFPGBøBNNBCMFBOFTUIFUJDTNJYUVSFXJUI
PYZHFOPSXJUIOJUSPVTPYJEF
Mode of operation: Continuous.

FSN1979 - 6/2017
1
2
3
4
5
6
7
English - 9
Item Description 1BDL2UZ
1.54".BUSJY4XJUDIFS ..................................................1
26TFS(VJEF ..................................................................1
3"$QPXFS$PSEGU.FEJDBM(SBEF .......................................1
4%46#DBCMFGU ...........................................................2
5%7*DBCMFGU...............................................................2
6#/$DBCMFGPS(4%*GU ..................................................2
7$7#4DBCMFGPS7JEFPGU ..................................................2
Package Contents
Verify that you received all components of your respective package.
Inspect each component and verify that none of the components have been tampered with in any way.

FSN1979 - 6/2017
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
ENTER INPUT
MENU OUTPUT
1-8
DVI-D
1-4
3G-SDI
1-4
RGB
1-4
CVBS
1 - 8 1 - 4 1 - 4 1 - 4
10 - English
MTS800A Sample System Conguration
Boom or Stand
Monitors
Wall
Mount
Monitors
IP Address
MTS800A
Tablet with
Control
Interface
Video Sources
to be Switched