Garden Oasis HYFP30205-19 User manual

READ BEFORE USE!
OWNER'S MANUAL
Propane cylinders sold separately
Factory No.: HYFP30205-19 Style No.: 65209
WARNING
For Outdoor Use Only!
Use Propane Gas Only !
WARNING
WARNING
Improper installation,
adjustment,alteration,service or maintenance can
cause injury or property damage. Read the
installation, operating and maintenance instructions
thoroughly before installing or servicing this
equipment. If the information in this manual is not
followed exactly, a fire or explosion may result
causing property damage, personal injury or loss of
life.
WARNING
- USE PROPANE GAS ONLY!
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
WARNING
DANGER
Battery may contain mercury. Do not deposit in fire
or put in trash. Recycle manage as hazardous waste.
WARNING
Turn off gas supply when the firebowl is not in use.
vicinity
of
this
or
any
other
appliance
.
- Installation and service must be performed
by a qualified installer, service agency or gas
supplier.
WARNING
If the firebowl is stored indoors, detach and
leave Propane Gas cylinder outdoors.
WARNING
This firebowl must be attended at all times!
WHAT TO DO IF YOU SMELL GAS:
• “Do not try to light any appliance.”
• “Do not touch any electrical switch; do not use any
phone in your building.”
• “Immediately call your gas supplier from a
neighbor’s phone. Follow the gas supplier’s
instructions.”
• “If you cannot reach your gas supplier, call the fire
department.”
1

Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily
injury or death, or in a fire or an explosion causing damage to property.
*Do not use this firebowl for cooking.
*Remove the PVC Cover from the firebowl before opening the appliance.
*Do not lay the PVC Cover over the firebowl until it is turned off and completely cooled down.
*Do not burn any other materials than are supplied with and intended for use in this firebowl.
*Do not pour water into firebowl.
*The installation of this product must conform with local codes or, in the absence of local codes, with either the National
Fuel Gas Code,ANSI Z223.1/NFPA 54, OR CAN/CGA-B149.1, National Gas and Propane Installation Code.
*Do not use this firebowl if any part has been under water.
*Do not store a spare or disconnected propane cylinder under or near this firebowl.
*After a period of storage, and/or non use, the propane firebowl should be checked for gas leaks and burner obstructions before use.
*Do not operate the propane firebowl if there is a gas leak present.
*Never use a flame to check for gas leaks.
*Combustible materials should never be within 48 inches of the top, back or sides of your propane firebowl.
*Do not put any other fireplace cover or anything flammable on, or beneath the firebowl.
*The propane firebowl should never be used by children. Children must be supervised when they are anywhere near the appliance.
*Users should be alerted to the hazards of high surface temperatures and keep a safe distance to avoid burning or clothing ignition.
*Pay attention when operating the firebowl. It is hot in use and should never be left unattended. Do not transit it while in operation.
*Should fire go out while burning, turn the gas valve off. Follow the instruction and wait five minutes before attempting to relight.
*Never use charcoal or any other solid fuel in the firebowl. Never parch clothing or other flammable materials on or near the firebowl.
*Never lean over the open firebowl or place hands or fingers on the upper portion of an operational unit.
*Keep ventilation openings in cylinder enclosure(FIREBOWL BODY) free and clear of debris.
WARNING
#############################################################################################################################
*Clean the battery contacts and also those of the device prior to battery installation.
*Remove batteries from equipment which is not to be used for an extended period of time.
*Remove used batteries promptly.
*The max inlet supply pressure "Max.gas supply 11 inch w.c. (2.74kPa).
*Use LP cylinders only with these required measurements: 12"(30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.)
capacity maximum.
2

• Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least annually by a
qualified service person. More frequent cleaning may be required as necessary. It is imperative that control compartment, burners and
circulating air passageways of the appliance be kept clean.
• Young children should be carefully supervised when they are in the area of the appliance.
• A statement that the LP-gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP-gas
######################
###########################################################################################
Children and adults should be alerted to the hazards of high surface temperatures and should stay away to
avoid burns or clothing ignition.
• Clothing or other flammable materials should not be hung from the appliance, or placed on or near the appliance.
• Any guard or other protective device removed for servicing the appliance must be replaced prior to operating the appliance.
• Specific size and capacity of the cylinder to use used.
• Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least
annually by a qualified service person.
Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and any gas
control which has been under water.”
Caution:
Only use the pressure regulator and hose assembly supplied with this firebowl. Replacement pressure regulator and hose
assemblies must be specified or supplied by BOND MANUFACTURING CO.
• Instructions to the effect that this appliance shall be used only outdoors in a well-ventilated space and shall not be used in a building, garage
or any other enclosed area.
WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Refer to the owner’s
information manual provided with this appliance. For assistance or additional information consult a qualified installer, service agency or the
gas supplier.
The LP-gas supply cylinder must be disconnected when this appliance is not in use
Only cylinder marked “propane” shall be used.
gppyy p g
cylinders of the U.S. Department of Transportation (DOT).
• Storage of an appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance. Cylinders must be stored
outdoors in a well-ventilated area out of reach of children. Disconnected cylinders must have threaded valve plugs tightly installed and must
not be stored in a building, garage or any other enclosed area.
•How to disconnect a gas bottle
Turn OFF control knob and LP cylinder valve. Turn coupling nut counterclockwise by hand only - do not use tools to
disconnect .Loosen cylinder screw beneath bottom shelf, then lift LP cylinder up and out of shelf. Place dust cap on cylinder
valve outlet whenever the cylinder is not in use.
WARNING !
3

Accessories
* Do not light or use gas unit if lava rocks are wet. Ensure lava rocks are completely dry before igniting as intense heat could cause
the rock to crack.
* Lava Rocks could hit somebody's face or eyes during initial start of this unit , so please keep away from the firebowl for the first 20
minutes after it has been ignited.
ABCDE
ITEM DESCRIPTION QTY
A LAVA ROCKS 1 BOX
B BATTERY(AAA) 1PC
CFIREBOWL 1PC
D DOOR 1PC
E PVC COVER 1PC
ABCDE
4

ITEM SPECIFICATION QTY ITE
M
SPECIFICATION QTY
1 Body 1
2 Door 1
3 Burner 1 15 M6 Nuts 3
4Fire Bowl 1 16 M6X15 screws 3
5 Heat Insulation Board 1 17 M4X10screws 5
6 Ignition Pin 1 18 M4 nuts 5
7 Thermocouple 1
8 Gas Valve 1
9 Control Knob 1
10 Pulse Ignition 1
11 Regulator 1 20 Feet 4
12 Guard 1
13 Grounding Wire 1
ASSEMBLY INSTRUCTIONS
*If you have opened the carton and removed all packages, please disregard the STEP 1 and 2. See the
STEP 3 directly.
* Please keep these owner's manual for future reference.
114 M5*120cross recessed round head
screws
19 M8*30 Wing screw 1
5

STEP 1. (1)
Open the carton and turn it upside down,
make sure the 4 pieces of the carton being
open up as below Figure STEP 1.
(2) Lift off the carton carefully and be wary
of the accessories inside falling away. Take
away the box containing lava rocks.
(3)
Take all the packing materials away except
for the polyfoam rounding the top of the
firebowl.
See Figure STEP 1.
STEP 2.
(1)
Turn the firebowl heads up on a flat
ground.
(2) Cut off the binding tape on the
polyfoam and remove all the polyfoam
rounding the top of the firebowl.
(3) Cut off the tie fastened the regulator
at the metal stand and set it free for
installation to Pronane Tank.
See Figure STEP 2.
STEP 3.
(I) Check each part before using the
product. Make sure the gas supply system is
turned "OFF" before assembling. See Figure
I.
(II) Open the storing door on the firebowl for
the gas tank. See Figure I.
(III) Put the gas tank in the metal stand.
6

(III)
Put
the
gas
tank
in
the
metal
stand.
Make sure the gas tank sits on the metal
stand completely. Turn the wing screw on
the outer part of metal stand clockwise to
secure the gas tank tightly. See
Figure VI.
connecting and operating conditions.
(IV) Locate the battery, remove the plastic
cover first. Unscrew the rubber cap of the
Electric Ignitor, place a AAA battery into the
battery case. Make sure the positive pole
("+") towards the cap. Screw the cap back
to the battery case tightly.
See Figure II.
(V)
Place the lava rocks averagely in the fire
bowl on the top of the firebowl. See Figure
III.
** DO NOT COVER THE IGNITION
SCREEN when placing the lava rocks into
the fire bowl. Always keep Ignition Screen
visible.
** Connect the Pressure-Regulating Valve to
the
g
as tank. See Fi
g
ure IV.
This screen must be clear and free of
obstructions at all times to insure proper
operation.
WARNING
the
gas
tank.
See
Figure
IV.
1) Turn the cylinder valve clockwise to close
the gas supply on the gas tank.
2) Screw Regulator Coupling clockwise by
hand only. Make sure it is fastened.
See WARNING and Fi
g
ures :
7

TIPS: Before Beginning ●Read the instructions thoroughly.
●For future reference, save this instruction sheet.
●Check and make sure that all parts are present.
TO LIGHT
B
e
f
ore each use, ins
p
ect all hose. Re
p
lace hose i
f
there are an
y
si
g
ns o
f
cuttin
g
, wear or abrasion.
Perform leak test in a well ventilated area outside and where no source of spark can occur.
Remove battery from igniter. Open tank valve fully (counter-clockwise). Turn the on/off valve at the unit to the
‘off’ position to pressurize the hose assembly. Use a soapy water solution to check all the connections leaks
before attempting to light the appliance. If a leak is found, turn the tank valve off and do not use the
appliance until repairs can be made.
The burner of the firebowl must be
covered by lava rocks completely.
Otherwise the flame may be
extinguished occasionally. See the
Figure CORRECT and INCORRECT
for reference.
INCORRECTCORRECT
f,p pfygfg,
(1) Turn the cylinder valve on the gas tank counter-clockwise to open the gas supply.
(2) Close the storing door on the firebowl for the gas tank.
(3) Light the firebowl as below steps:
A. Press and hold the Electric Ignitor. Meanwhile, push and turn the Control Knob counter-clockwise to the "LOW" position. Keep
pushing the Control Knob to light the burner .
B. After ignition, release the Electric Ignitor. Continue to push and hold the Control Knob for 45 seconds.
C. If ignition does NOT immediately take place in seconds, push and turn the Control Knob clockwise to "OFF". Wait 5 minutes,
then repeat the lighting procedure as above.
Caution:
*If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk
of injury.
LO
W
HI GH
OFF
IGNI TER- PUSH
8

ROUTINE CARE
※Keep your firebowl free and clear from combustible materials.
Observe flame height when lit:
Flame should possibly be a yellow/blue color between 2 to
10 inches high.
TO EXTINGUISH
※Push the Control Knob and turn clockwise to the "OFF" position.
※Turn the cylinder valve on the gas tank clockwise to close the gas supply if not for use in a long time.(See below figure)
LO
W
HI GH
OFF
IGNI TER- PUSH
py
※Visually inspect burner from obstructions, keep fireplace free and clear from debris.
※After the burner and lava rocks are completely cooled down, use a soft brush to get rid of the mild stains,
loose dirt and soil. Wipe with a soft cloth.
STUBBORN STAINS
※Stubborn stains, discoloration and possibly rust pitting can occur from exposure to harsh outdoor conditions.
※Be careful not let any powder or solvent come in contact with painted or plastic components as damage may occur.
※Store the firebowl in a cool dry place away from direct sunlight.
※The propane cylinder must be disconnected and removed from the firebowl before the appliance can be stored indoors.
※Use Manufacturer approved or supplied replacement parts and accessories only. Otherwise may void the warranty of this
product and result in a hazardous condition.
※Make sure both the gas and the firebowl are turned off before changing battery. Please refer to the process of assembling
battery.
MAINTENANCE
※Please contact the Manufacturer for information regarding replacement hoses, thermocouples, ignitors, lava rocks, ceramic
logs,etc.
LO
W
HI GH
OFF
IGNI TER- PUSH
9

10