Generac Power Systems Mobile Power MLG25 User manual

Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 1 of 4
6/12
Mobile Lite Generator – MLG25 Specifications
ENGINE
Isuzu®4LE1NYGV-01 -naturally aspirated, diesel engine
oPrime – 32.1 hp @ 1800 rpm
o4 cylinder
o2.2 L displacement
oInterim Tier IV approved
Polyethylene fuel tank
o56 gal. capacity
o31 hr. run time – full load
o3 ½” fill port
Fuel consumption at prime:
o100% - 1.80 gph (6.81 Lph)
o75% - 1.35 gph (5.11 Lph)
o50% - 0.90 gph (3.41 Lph)
Cooling system capable of operating at 120°F ambient
Rubber vibration dampers isolate engine/generator from frame
Full flow oil filter, spin on type
Fuel filter with replaceable element
Dry type cartridge air filter
60 Hz engine/generator
GENERATOR
Marathon Electric®
oBrushless
o4 pole
oClass H insulation
Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUT
3 position selector switch
oSingle phase – 120 / 240V Zig Zag
oThree phase – 120 / 208V Low Wye
oThree phase – 277 / 480V High Wye
16 kW / 16 kVA – standby, single phase
15 kW / 15 kVA – prime, single phase
20 kW / 25 kVA – standby, three phase
18 kW / 23 kVA – prime, three phase
SYSTEM CONTROLS
Microprocessor-based controller
oBacklit, 128x64 pixel resolution display
o-40°F to 185°F operating temperature range
oThermostatically controlled LCD heater
25

MLG25 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 2 of 4
6/12
oSix LED indicators w/ lamp test
Alarm / Fault (Red)
Ready / Manual (Red)
Running (Green)
Warning (Yellow)
Ready / Auto (Green)
Supplying Load (Green)
Push buttons for easy operation
oManual or Auto Start
oEngine Start or Stop
oAlarm Cancel & Fault Reset
oScrolling Arrows for Diagnostic Information
System kW output display
Line output & frequency display
Engine diagnostic display
Oil pressure
Engine temperature
Fuel level
Battery
System hours
Running hours
kW hours
Time to service
oAlarm list – warnings / shutdowns are date & time stamped
Fuel level: warning – 15%; shutdown – 5%
Overspeed protection: shutdown – 115%
Oil pressure: warning – 25 psi; shutdown – 20 psi
Coolant temperature: warning – 220°F; shutdown – 230°F
Battery voltage: over – 15VDC; under – 11VDC
Generator over voltage: warning – 110%; shutdown – 111%
Generator under voltage: warning – 87%; shutdown – 86%
Generator over frequency: warning – 105%; shutdown – 110%
Generator under frequency: warning – 95%; shutdown – 90%
Over current shutdown
ELECTRICAL SYSTEM AND CONTROLS
90A breaker
Convenience receptacles with individual breakers
o(2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o(2) 240V 30 Amp twistlock outlets (Nema L6-30R type)
o(2) 240V 50 Amp twistlock outlets (Non-Nema 6369)
oLug terminals for single and three phase output
720 CCA wet cell battery

MLG25 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 3 of 4
6/12
ENCLOSURE
Generac Mobile Power decals
Steel, 14-gauge, sound attenuated enclosure
oUV & fade resistant, high temperature cured, white polyester powder paint
oInsulated and baffled
o68 dB(A) at 23 feet – prime power
Fully lockable enclosure
Stainless steel hinges, door latches and exterior hardware
Emergency stop switch located on front panel
License plate holder with light
Multi-lingual operating/safety decals
Document holder with operating manual including AC/DC wiring diagrams
TRAILER
DOT approved tail, side, brake, and directional lights
oRecessed rear lights
Transportation tie downs
Safety chains with spring loaded safety hooks
Single wall polyethylene fenders
2” ball hitch
2200 lb. leaf spring axle
2000 lb. tongue jack with footplate
ST205/75R15 tubeless tires – 6 ply
48” track width
WEIGHTS & DIMENSIONS
Dry weight: 1640 lbs (744 kg)
Operating weight: 2038 lbs (924 kg)
105 x 68 x 56 in
(2.67 x 1.73 x 1.42 m)
WARRANTY
Engine and generator covered under OEM warranty – consult factory for details
CERTIFICATIONS
CSA certified

MLG25 Generac Specifications Continued:
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: [phone] Fax: [phone] www.m-p-llc.com Page 4 of 4
6/12
MLG25 Options
ENGINE OPTIONS
Heated fuel filter
Lower radiator hose – engine heater
Oil drain valve kit
ELECTRICAL CONTROLS OPTIONS
720 CCA gel cell battery
685 CCA gel cell battery
Battery disconnect
Battery charger – 2A trickle
VOLTAGE OUTPUT OPTIONS
Alternative receptacle panel – consult factory for configurations
COOLANT OPTIONS
60/40 Coolant – cold weather applications
ENCLOSURE OPTIONS
Interior cabinet light
Level indicator
Tamper pack
Liquid containment / Quiet pack
Lift structure
FUEL TANK OPTIONS
56 gal. fuel tank
Tethered fuel tank cap
TRAILER OPTIONS
6 pin or 7 spade electrical connectors
Outrigger package
Tube and sleeve jack
Spare tire/wheel kit
HITCH OPTIONS
2.5” lunette ring
3” lunette ring
3” HD lunette ring
2 5/16” ball
Combination hitch – 2.5” lunette ring / 2” ball