GSWeb Playground Equipment PLAY DOME User manual

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
1
INSTALLATION MANUAL
Safety Checklist after first assembly
●Test intervals of Safety: 6 months
●Test Component and contents:
1. Removing the reticulated system:
- Check of removing condition each rope
- Screwing the turn buckle and conversion the turnbuckle
in anchors plate(see for this work step turnbuckle assembly)
2. Abrasion condition of rope:
- Checking of all rope surface
- Strengthened of rope: Coating on the surface
3. Attachment condition of the anchors plate and turnbuckle
4. Screwing condition of all bolt
5. Galvanizing condition of the steel component:
- Protection of steel component from corrosion.
●Measure
In case of the appearance the defect detail is
repaired usually within 3 days after checking.
Caution!!
You have to construct foundation same level.
You have to keep foundation certain distance.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
2
INSTALLATION & MAINTENANCE INSTRUCTIONS
Ages : 5 to 12 years
Capacity : 46 children
Size : L : 26’3” / 8. 00m
W : 22’12” / 7. 00m
H : 13’2” / 4.0 00m
Use zone : L : 11.5 m
(ASTM/EN) W : 11.5 m
▲Completed Net
Features
The series is a steel-framed climbing structure made of steel-
loaded Nylon cables and comes protected against UV.
The GS-PD8003 features GS Web Technology which includes the
highest steel content and the strongest connection materials in
the industry, including a steel-wire core in our edge ropes and
connection points crushed in place with over 75 tons of pressure
to ensure long life of the games and maximum safety for the
children.
GS Web Nets help bring movement, balance, exercise and fun
back into the playground.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
3
Safety area and Fall Height zone
▲Fall Height and safety area
Safety area
The requirements for space and safety clearances are taken from
BS-EN 1176-1 / ASTM-F1487 / CSA Z614
The use zone for stationary play equipment shall extend no less than
72 in. (1830mm) from all sides of the play structure.
Fall Height : 1,855mm (from surface)
The Fall height on the external surface of a pyramid shaped space net
is the highest point attainable on the edge of the structure where an
unimpeded fall to the protective surface is possible. This height is based
on the center of gravity height of the maximum user.
H(300)
1,855 (Fall Height)
8,000
4,000
?8,000
?11,480
500
SAND OR RUBBER MAT
SAFETY ZONE
(ASTM)
SAFETY ZONE
(EN)
1,740
1,830
F.L
G.L
11,660
11,480

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
4
Foundation layout
▲Attach Frame plate to footing
Foundation
Please refer to the concrete foundation layout drawings for exact
installation dimensions.
Ø8000
60°
30°

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
CON'C
300
1000
CON'C
2 x 2 - 3/8" x L125
Set Anchor
POST PLATE
500
800
800
800
CON'C
4 x 6 - 5/8" x L200
SET-ANCHOR
1000
300
<FRONT VIEW> <PLAN>
<FRONT VIEW>
<PLAN>
300
300
5
Foundation layout
Foundation
! Attention
Do not drill holes on the concrete first.
After checking the tension of the stair net and
setting its distance, put the anchor plate on
concrete.
<Foundation 1>
<Foundation 2>

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
6
Overall Assembly
Overall Assembly
Assemble the parts in the following order:
1. Check number of the parts and locations as next drawing.
(Post’s location is very important.)
No. 6, 6-1
Post 6, 6-1
No. 16
Platform 16
No. 15
Platform 15
No. 5, 5-1
Post 5, 5-1
No. 14
Platform 4
No. 4, 4-1
Post 4, 4-1
No. 3, 3-1
Post 3, 3-1
No. 13
Platform 3
No. 2, 2-1
Post 2, 2-1
No. 1, 1-1
Post 1, 1-1

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
7
Overall Assembly
Pipe (Lower part)
GALVANIZED STEEL PAINTED POST
Frame Assembly
Assemble the parts in the following order:
1. Screw down the Lower part Pipe on the Concrete.
2. Bolt the components together as above picture.
... cont'd next page
No 61:
Pipe Connector
No. 101:
M12 x L25
Pipe (upper part)
No. 102:
M16 x L60

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
8
Overall Assembly
Net Assembly
Assemble the parts in the following order:
1. Check the stair net’s location.
2. Put the net in place.
3. Check the net height as the picture. No.6, 6-1
Post 6, 6-1
H:750
H:1600 H:2250
H:2800
H:3300 Leave 200mm interval
from the above bracket.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
9
BOLT
EYE BOLT
POST
▲Assemble GSWeb clamp in the attach with stainless steel post
NUT
4. Attach the net jointed eye bolt & GSWeb clamp to the post
5. Repeat with each element
Overall Assembly

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
10
No.103
Bolt for Clamp x 2
No. 62
GSWeb Clamp
POST
No. 105:
M10 x L35
No. 106:
M10 x L30
No.11~14
Platform
Welded Flange
No. 104:
M10 x L35
5. Repeat with Platform
Overall Assembly
INSIDE
OUTSIDE
INSIDE
OUTSIDE

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
11
Tensioning & Maintenance information
Maintenance information
Please tighten rope with Turnbuckle properly.
If you strain the net too much, it may cause damage.
It is also recommended that subsequent checks on tension
should be carried out at monthly intervals and adjusted as required.
This will increase the overall longevity of the product.
Checking: 1 month
Refer to IPEMA and TUV maintenance system.
After Net structure tension is completed, the net will
stretch slightly over the first four weeks of use.
Following this initial period, the net needs
to be fully re-tensioned by Turnbuckle after 1 year.
A weekly check of the activity net is recommended to ensure
that no acts of vandalism have damaged the rope.
Periodic checks on tension will assist in the durability of the product.
▲Completed Net

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
12
Maintenance
A. General safety measures
On the playground there should be a sign(pictogram) giving the following information:
a) general emergency telephone number;
b) telephone number to contact maintenance personnel;
c) name of the playground;
d) address of playground; and
e) other relevant local information, if applicable.
The entry, exit and emergency paths to and from a playground, intended for use by the public and emergency services, should be accessible
and free of obstacles at all times.
NOTE Attention is drawn to local regulations.
B. Procedures
Defects that occur during operation and which put safety at risk should be corrected without delay. If this is not possible, the equipment
should be secured against use e.g. by immobilization or removal.
There should be written operational procedures covering the measures to be taken in the event of accidents, fire and the like.
Until unsafe equipment is repaired and released for use, access by the public should be prevented. Information about accidents brought to
the attention of the manager should be recorded on a form that includes the following details:
a) date and tie of accident;
b) age and sex of victim and clothing worn, Including footwear;
c) equipment involved;
d) number of children on site at the time of the accident;
e) description of accident;
f) injury sustained including part(s) of body affected;
g) action taken;
h) witness statements;
i) any subsequent equipment modification;
j) weather conditions; and
k) any other relevant information.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
PLAY DOME MODEL NO.
Rev_1
2017.11
GS-PD8003
13
Maintenance
C. Routine maintenance
To reduce accidents, the owner or operator should ensure that an appropriate routine maintenance schedule is established, implemented and
maintained. This should take into account local conditions and the manufacturer's instructions that can affect the necessary inspection
frequency. The schedule should list the components to be maintained and should also give procedures for dealing with complaints and
breakdowns.
The routine maintenance of playground equipment and surfaces should consist of preventative measures to maintain their level of safety,
performance and compliance with the relevant part(s) of EN 1176. Such measures should include:
a) tightening of fastenings;
b) re-painting and re-treatment of surfaces;
c) maintenance of any impact attenuating surfaces;
d) lubrication of bearings;
e) marking of equipment to signify loose fill finished surface level;
f) cleaning;
g) removal of broken glass and other debris or contaminants;
h) restoring loose fills to the correct level; and
i) maintenance of free space areas.
D. Corrective maintenance
Corrective maintenance should include measures to correct defects, or th re-establish the necessary levels of safety of the playground
equipment and surfaces. Such measures should include:
a) replacement of fastenings;
b) welding of welding repairs;
c) replacement of worn or defective parts; and
d) replacement of defective structural components.
E. Personal safety
Repairs during operation that could put the safety of maintenance personnel of the public at risk, should be avoided.
F. Equipment alterations
Alterations to parts of a piece of equipment or structure that could affect the essential safety of the equipment should only be carried out
after consultation with the manufacturer or a compete person.