GSWeb Playground Equipment GS-W1005 User manual

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 1
INSTALLATION MANUAL
Safety Checklist after first assembly
●Test intervals of Safety: 6 months
●Test Component and contents:
1. Removing the reticulated system:
- Check of removing condition each rope
- Screwing the turn buckle and conversion the turnbuckle
in anchors plate(see for this workstep turnbuckle assembly)
2. Abrasion condition of rope:
- Checking of all rope surface
- Strengthned of rope: Coating on the surface
3. Attachment condition of the anchors plate and turnbuckle
4. Screwing condition of all bolt
5. Galvanizing condition of the steel component:
- Protection of steel component from corrosion.
●Measure
In case of the appearance the defect detail is
repaired usually within 3 days after checking.
GSWEB PLAYGROUND EQUIPMENT
1046-3, Najeon-ri, Saengnim-myeon, Gimhae-si
Gyeongsangnam-do, 621-821, Republic Of Korea
Tel) +82. 55. 326. 9096~7
Fax) +82. 55. 326. 9022
E-mail) [email protected]
Web site) www.gsweb21.com

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 2
Figure-1: Completed Net
Features
This series is a pyramid-style climbing structure made of steel-loaded Nylon
cables and comes protected against UV.
GS Web uses the highest steel content and the strongest connection
materials in the industry, including a steel-wire core in our edge ropes and
connection points crushed in place with over 75 tons of pressure to ensure
long life of the games and maximum safety for the children.
GS Web Nets help bring movement, balance, exercise and fun back into the
playground.
Ages: 6 to 14 years
Capacity: 134 children
Size: L: 46' 5" / 14.14m
W: 46' 5" / 14.14m
H: 28' 7" / 8.70m
Use zone: L: 56' 3" / 17.14m
W:56' 3" / 17.14m
INSTALLATION & MAINTENANCE INSTRUCTIONS

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 3
Figure-2: Safety area
Safety area and Fall Height zone
10000
21552
10000
Safety area
The requirements for space and safety clearances are taken from
BS-EN 1176-1/ ASTM-F1487/ CSA Z614
The use zone for stationary play equipment shall extend no less than
72 in.(1830mm) from all sides of the play structure.
Fall Height :1500mm (from surface)
The Fall height on the external surface of a pyramid shaped space net
is the highest point attainable on the edge of the structure where an unimpeded fall to
the protective surface is possible. This height is based on the centre of gravity height
of the maximum user.

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 4
Foundation Information
P1 = Depth below Finished Grade (300mm)
P2 = Depth of concrete footings (1000mm & 800mm)
P1 = Depth below Finished Grade (300mm)
P2 = Depth of concrete footings (1000mm & 800mm)
Figure-3 : Excavate enough
materials to allow for proper depth
of concrete footings
Also ensure that there is enough space to
allow the frame to be positioned properly.
Anchor wood support frame to ground
with pickets to prevent the frame from
moving while concrete is poured and sets.
Figure-4: Foundation section view
Foundation
Please refer to GS-W1005 drawing for installation dimension
Finished Grade
(Optional)
Safety area and Fall Height zone
Level Line
Wet concrete
Dry concrete

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 5
Position anchor plate on concrete footing
Figure -5: Footing and anchor plate layout
Note:
Total distance from
front of block to front of
block is 20000mm
Anchor Plate position
1000010000
14142
Foundation Layout
300 1800
1800 STEEL ROUND BAR
Φ25 X L1100
STEEL ROUND BAR
Φ25 X L600

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 6
Figure-6: Wood support frame
(a)
(b)
Assemble wooden support frames *
4 frames (1800mm L x 1800mm W x 1000mm H)
1 frame (1200mm L x 1200mm W x 800mm H)
*Use ½" (min) plywood; not included in package
(a) wood jig for
Anchor plate
(b) wood support frame
for concrete
NOTE: Use anchor plate as guide
for exact measurements.
Concrete Foundation

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 7
Figure-7: Concrete work
[concrete footing work]
Pour wet concrete in the wooden support frame
[Concrete]
Pour concrete* into wooden support frame until flush to top edge
Allow 3-5 days for concrete to cure before proceeding to next step.
*Concrete to be we concrete with minimum 25 MPa / 3500 PSI.
Concrete Footing

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 8
Figure-8: remove wood support frame
Remove wood support frame from dry concrete blocks
After concrete has cured enough, remove frames and replace soil around
the footings to subgrade level
Remove Wood Support Frame

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 9
Figure-9: Concreted blocks -
Clean threads of "L"-Anchors
Figure-10: Attach Anchor plate to footing
with flat washer, locking washer and nut.
(a) Anchor Plate
(b) Post plate
(b) Post plate
(a) Anchor Plate
Anchor Plate Assembly

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 10
STEP-1
Figure-11: Find Nylon String
STEP-2
Figure-12: Insert Post
as following Nylon string
Nylon string
Post Assembly
Insert Post following nylon string
NOTE: Remove string prior to placing cap on post.
Upper post
Lower post
Post Assembly

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 11
Safety area and Fall Height zone
Figure-14: U-bolt assembly.
STEP-4
Figure-15: Post cap assembly.
STEP-3
Figure-13: Insert Post
into the Center of Net.
Place Cap on Post
Thread the mast through the net’s center (per diagrams below,
or following factory-installed guide string). Press the cap
(already attached to the top of the net) into the mast’s top end.
Note: Rubber mallet
may be required to
insert cap into post.
Joint Post and Cap with U-BoltAttaching Cap to Post

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 12
Figure-16: Attach cable to (A) (B) (C)
Safety Cable Attaching
Attach safety cable to anchor plates (A) (B) (C) as shown in Figure 16.
(A) (B) (C) (B)
(C)
M22 X L110 H/T Bolt
Figure-17: Safety cable Assembly
After successfully preparing the net
and mast assembly, attach safety cable with
M22 X L110 H/T Bolt to Anchor plate
as shown below
(A)

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 13
Figure-19: Safety cables attached
Figure-18: Centre Post
(A) (C) (D) (E)
(A)
(E) (B)
(C)
[Working Process]
(B)
(D)
It is strongly recommended that a
machine be used to lift the net into place.
Standing the net

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 14
(A) (B) (C) (D) (E) (F)
(F)
(C)
(B)
(D)
(A)
(E)
After standing up the Net, Attach remaining safety cable and Turnbuckles
Figure-20: Stand Net up
Figure-21: Loosen Turnbuckle:
all the way (about 100mm),
leaving only 4 or 5 threads attached
Stand Net up

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 15
Anchor plate + Turnbuckle
Figure-22: Tightening Turnbuckles
(a)
(a)
(b)
(b)
Figure-23: Turnbuckle assembly
M22 X L110 H/T Bolt
Tighten Cable with Turnbuclke at the Same time
Tighten Cable with Turnbuclke at the Same time
(a) + (a)
(b) + (b)
NOTE: Make sure post is level before tightening and remains level during process.
Attaching Turnbuckle to Anchor Plates

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 16
Figure-24: Completed Net
Maintenance information
Please tighten rope with Turnbuckle properly.
If you tighten the net too much, it may cause damage.
It is also recommended that subsequent checks on tension
should be carried out at monthly intervals and adjusted as required.
This will increase the overall longevity of the product.
Checking: 1 month
Refer to IPEMA and TUV maintance system.
After Net structure tension is completed, the net will
stretch slightly over the first four weeks of use.
Following this initial period, the net needs
to be fully re-tensioned by Turnbuclke
after 1 year.
Tensioning & Maintenance information

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 17
1: main post
2: multi compound rope
3: post cap
4: turn buckle
5: anchor shackle
7: H/T bolt,nut washer
8: U-bolt,nut,washer
9: main post plate
10: L-anchor bolt,nut,washer
11: Anchor plate
1
2
10
6
11
7
4
5
8
3
9
PARTS LIST

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 18
Safety area and Fall Height zone
A weekly check of the activity net is recommended to ensure
that no acts of vandalism have damaged the rope.
Periodic checks on tension will assist in the durability of the product.

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 19
Maintenance
A. General safety measures
On the playground there should be a sign(pictogram) giving the following information:
a) general emergency telephone number;
b) telephone number to contact maintenance personnel;
c) name of the playground;
d) address of playground; and
e) other relevant local information, if applicable.
The entry, exit and emergency paths to and from a playground, intended for use by the public and emergency services, should be accessible and
free of obstacles at all times.
NOTE Attention is drawn to local regulations.
B. Procedures
Defects that occur during operation and which put safety at risk should be corrected without delay. If this is not possible, the equipment should
be secured against use e.g. by immobilization or removal.
There should be written operational procedures covering the measures to be taken in the event of accidents, fire and the like.
Until unsafe equipment is repaired and released for use, access by the public should be prevented. Information about accidents brought to the
attention of the manager should be recorded on a form that includes the following details:
a) date and tie of accident;
b) age and sex of victim and clothing worn, Including footwear;
c) equipment involved;
d) number of children on site at the time of the accident;
e) description of accident;
f) injury sustained including part(s) of body affected;
g) action taken;
h) witness statements;
i) any subsequent equipment modification;
j) weather conditions; and
k) any other relevant information.

SINGLE MAST NET CLIMBER MODEL NO.
GS-W1005
GSWeb Playground Equipment 20
Maintenance
C. Routine maintenance
To reduce accidents, the owner or operator should ensure that an appropriate routine maintenance schedule is established, implemented and
maintained. This should take into account local conditions and the manufacturer's instructions that can affect the necessary inspection frequency.
The schedule should list the components to be maintained and should also give procedures for dealing with complaints and breakdowns.
The routine maintenance of playground equipment and surfaces should consist of preventative measures to maintain their level of safety,
performance and compliance with the relevant part(s) of EN 1176. Such measures should include:
a) tightening of fastenings;
b) re-painting and re-treatment of surfaces;
c) maintenance of any impact attenuating surfaces;
d) lubrication of bearings;
e) markig of equipment to signify loose fill finished surface level;
f) cleaning;
g) removal of broken glass and other debris or contaminants;
h) restoring loose fills to the correct level; and
i)maintenance of free space areas.
D. Corrective maintenance
Corrective maintenance should include measures to correct defects, or th re-establish the necessary levels of safety of the playground equipment
and surfaces. Such measures should include:
a) replacement of fastenings;
b) welding of welding repairs;
c) replacement of worn or defective parts; and
d) replacement of defective structural components.
E. Personal safety
Repairs during operation that could put the safety of maintenance personnel of the public at risk, should be avoided.
F. Equipment alterations
Alterations to parts of a piece of equipment or structure that could affect the essential safety of the equipment should only be carried out after
consultation with the manufacturer or a compete person.