GSWeb Playground Equipment SPACE CRAFT User manual

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
1
INSTALLATION MANUAL
Safety Checklist after first assembly
●Test intervals of Safety: 6 months
●Test Component and contents:
1. Removing the reticulated system:
- Check of removing condition each rope
- Screwing the turn buckle and conversion the turnbuckle
in anchors plate(see for this workstep turnbuckle assembly)
2. Abrasion condition of rope:
- Checking of all rope surface
- Strengthened of rope: Coating on the surface
3. Attachment condition of the anchors plate and turnbuckle
4. Screwing condition of all bolt
5. Galvanizing condition of the steel component:
- Protection of steel component from corrosion.
●Measure
In case of the appearance the defect detail is
repaired usually within 3 days after checking.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
2
INSTALLATION & MAINTENANCE INSTRUCTIONS
Ages : 5 to 12 years
Capacity : 25 children
Size : D : 10‘ 10" / 3.30m
H : 10‘ 11" / 3.32m
Use zone (EN) : D : 23‘ 12" / 7.30m
Use zone (ASTM) : D : 22‘ 10" / 6.96m
◀Completed Net
Features
The series is the 21st Century merry-go-round.
Our special bearing system controls the rotation speed so that the children
can safely enjoy the same exhilarating experience as a merry-go-round.
The GS-SC2200 features GS Web Technology which includes the highest
steel content and the strongest connection materials in the industry,
including a steel-wire core in our edge ropes and connection points crushed
in place with over 75 tons of pressure to ensure long life of the games and
maximum safety for the children.
These games help bring movement, balance, exercise
and fun back into the playground.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
1,525
3,1901,370
1,220
1,990
100
2,000 EN
1,830 ASTM
7,300
6,960
F.L
3
Safety area and Fall Height zone
▼Fall Height and safety area
Safety area
The requirements for space and safety clearances are taken from
BS-EN 1176-1 / ASTM-F1487 / CSA Z614
The use zone for stationary play equipment shall extend no less than
72 in. (1830mm) from all sides of the play structure.
Fall Height : 1990mm (from surface)
The Fall height on the external surface of a pyramid shaped space net
is the highest point attainable on the edge of the structure where an
unimpeded fall to the protective surface is possible. This height is based
on the centre of gravity height of the maximum user.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
1,525
3,190
1,370
1,220
1,990
100
F.L
4
Foundation Information
Foundation
Measure location and dig a hole 1525mm x 1525mm x 1370mm deep
centered on the center of the spacecraft
!Attention
It is very important to keep a bottom of the
lower ring 100 mm apart from Finished level
according to safety standard.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
F.L
5
Overall Assembly
No. 22:
Angle Brace
No.3:
Head
No.2:
Inner Post
No. 21:
Galvanised Base
No.110:
Eye Bolt
No.1:
Outer Post
▲Stand Up the Post
Overall Assembly
1. Lift the assembly and place the post into the assembled base.
Use a backhoe with nylon strap or chain with safety hooks.
2. Level the post and fill with excavated ground, re-compacting excavated ground.
3. Install the protective surface.
4. Remove the Eye Bolt
Overall Assembly ▶

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
6
▲Wooden support frame
Base Assembly
No. 22
Angle Brace
No. 101.
M12 x :35 Bolt set
NO.21 :
Galvanized Base
No. 23:
Base Half Collar
▲Base Assembly
No. 101.
M12 x L35 Bolt set
Assemble all parts of base as shown below

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
7
Net and Ring Assembly
No. 4:
Arm
No. A:
Net
No. B:
Hanger Rope
No. 5:
Upper Ring
1. Thread the net around post.
2. Insert 4 pieces of arm to the head
3. Attach hanger cables to the arms
4. Assemble upper ring and attach hanger cables to the ring
5. Attach net to the ring
▲Completed Upper parts

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
8
▲Arm + Head Assembly
No. 111:
Hex. Bolt Set
No. 114:
M10 x L30 Bolt Set
No. B:
Hanger Rope
No.112:
M10 x L30 Bolt Set
No. 102:
M12 x L25 Bolt Set
▲Arm + Hanger Rope Assembly
Arm assembly
Remove the eye bolt.

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
No. 115
Fix Bolt and Nut
No. 63:
Nylon Joint
No. 5:
Upper Ring
Figure-12
No. 103
M10 x L25 Bolt Set
No. A
NET
Upper Ring assembly
9

GSWeb Playground Equipment E-mail) gswebin[email protected]
Website) www.gsweb21.com
Tel) [phone]
Fax) [phone]
65, Saengnim-daero 259beon-gil, Saengnim-Myeon
Gimhae-si, Gyeongsangnam-do, Republic of Korea
SPACE CRAFT MODEL NO.
Rev_0
2015.05
GS-SC2200
Overall assembly
10
No. 62
Head Cap
No. 6:
Lower Half Ring
No. 41
Deck
Assembly order
1. Lower Ring
2. Deck
3. Adjust floor height with collar on post and the alignment of the rope
4. Tighten all the bolts
5. Install the cap
▲Completed Lower parts