Hark HK0514 User manual

Owner’s Manual
Assembly, Care & Safety Instructions
Item No. HK0514
CARBON MONOXIDE HAZARD WARNING
Burning wood gives off carbon monoxide which can
cause death.
DO NOT burn wood chips inside homes, vehicles,
tents, garages or any enclosed areas.
Use only outdoors where it is well ventilated.
This manual contains important information
necessary for the proper and safe use of this unit.
Read and follow all warnings and instructions before
using smoker and during use.
Keep this manual for future reference.
Some parts may have sharp edges. Handle with care.
Failure to follow these warnings and instructions properly could result in personal injury or death.
OUTDOOR USE ONLY. DO NOT EXPOSE TO RAIN.
ELECTRIC SMOKER
grill roast smoke

TABLE OF CONTENTS
Page
Safety Instructions and Warnings 3 - 5
Parts List 6
Assembly Instructions 7 - 8
Curing Procedures 9
Operating Instructions 10 - 15
Types of Smoking 16
Warranty Information 17

3
IMPORTANT SAFETY INSTRUCTIONS AND WARNINGS
READ ALL INSTRUCTIONS THOROUGHLY BEFORE USE:
• This manual contains important information that is necessary for safe and proper use of
the Hark Electric Smoker.
• Read and follow the warnings and instructions carefully before and during the use of the
smoker.
• Keep this manual for future reference.
• Burning wood gives off carbon monoxide. This can cause death.
PRIOR TO USE
• The Hark Electric Smoker is for outdoor use only. Never burn wood chips inside your
home, vehicle, tent, garage, or any other enclosed area.
• The smoker should only be used on a level, stable surface. This will prevent tipping over
causing potential injury or property damage.
• The unit must be placed on the ground. Never place unit on tables or counters.
• Do not plug in the smoker until it is fully assembled and ready to use.
• Only use in an approved, grounded electrical outlet.
• Never use during an electrical storm.
• Never expose the smoker to rain or water.
• Do not immerse cord, plug or control panel in water or any liquid. This could cause
electric shock.
• To reduce the risk of electric shock, keep cord dry and off the ground.
• Always keep children and pets away from the smoker. Never allow children to operate
the smoker. When children and pets are in the area surrounding the smoker, close
supervision is absolutely necessary.
• This appliance is not intended for use by persons (including children) with reduced
physical, sensory or mental capabilities, or lack of experience and knowledge, unless
they have been given supervision or instruction concerning the use of the appliance by a
person responsible for their safety.
• Do not bump or impact the smoker.
• Never operate this appliance after it has malfunctioned or after the unit has been
damaged. Contact Hark Enterprises for assistance. Toll Free 1300 799 787 (excludes
mobiles) or on 03 9857 0999.

4
IMPORTANT SAFETY INSTRUCTIONS AND WARNINGS (cntd.)
PRIOR TO USE (cntd.)
• Never allow any other activities to take place in the vicinity of the smoker during or after use.
• Alwayskeepareextinguisherhandywhenoperatingthesmoker.
• Do not allow the electrical cord to hang carelessly or to touch hot surfaces.
• If the electrical supply cord is damaged, it must be replaced by a special cord or
assembly available from the manufacturer or its service agent.
• Do not place on or near a gas, or electric burner, or in a heated oven.
• Never operate any electrical appliance with a damaged plug or cord.
• Never use this smoker as a heater (refer Carbon Monoxide Hazard).
• Use of alcohol, prescription or non-prescription medication may impair one’s ability to
assemble or operate the electric smoker properly.
EXTENSION CORD USE
• Longer detachable power-supply cords or extension cords may be used if care is
exercised in their use.
• If a longer detachable power-supply cord or extension cord is used:
1. The marked electrical rating of the extension cord should be at least as great as the
electrical rating of this appliance.
2. The cord should be arranged so that it will not drape over a countertop or tabletop
where it can be pulled on by children or tripped over unintentionally.
• Outdoor extension cords should be used with outdoor products.
• The connection to an extension cord should be kept dry and off the ground.
• Do not operate unless cord is fully uncoiled.
DURING USE
• THE HARK ELECTRIC SMOKER IS FOR OUTDOOR USE ONLY.
• The smoker unit becomes hot while in use and for a period after use. Always use caution
near hot surfaces.
• Always use a protective BBQ mitt or oven glove when handling the smoker in operation.
• Do not move appliance when in use. Always allow the smoker to cool completely before
moving or storing.

5
IMPORTANT SAFETY INSTRUCTIONS AND WARNINGS (cntd.)
DURING USE (cntd.)
• Always use caution when adding wood chips once the smoker is in operation. The wood
chip tray and side access chute are always hot when the smoker is in use.
• Never cover cooking racks with aluminium foil. The foil will trap heat, causing severe
damage to the electric smoker.
• The drip tray is only for the bottom of the electric smoker. Never put drip tray on cooking
racks. This could cause damage to the electric smoker.
• Accessory attachments that are not supplied by Hark Enterprises are not recommended
and may cause injury.
• Never use the electric smoker for anything other than its intended purpose. This unit is
not for commercial use.
AFTER USE
• Extreme caution must be used when moving an appliance containing hot oil or other hot
liquids.
• Do not store electric smoker with hot ashes still inside. Store only when all surfaces are
cold, cleaned and ashes have been removed.
• Ensure the unit has fully cooled before cleaning and storing.
• Do not clean this product with a water spray or pressure cleaner.
• To disconnect the electric smoker, turn control panel off then remove the plug from the
outlet.
• Unplug from the outlet when not in use and prior to cleaning. Allow unit to cool
completely before adding or removing racks, wood chip tray or water bowl.
• Dispose of cold ashes by placing them in aluminium foil.
• THE HARK ELECTRIC SMOKER IS AN ELECTRIC APPLIANCE AND MUST THEREFORE BE
STORED UNDER COVER, PROTECTED FROM RAIN AND MOISTURE. THE COVER IS TO
KEEP THE UNIT CLEAN, NOT TO PROTECT FROM EXPOSURE TO WATER.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.

6
PARTS LIST
Part No. Qty
ES1 – Large Cooking Racks 2
ES2 - Large Jerky Racks 2
ES3 – Small Cooking Rack 1
ES4 - Sausage Hanging Rack 1
ES5 – Water Pan 1
ES6 – Drip Pan 1
ES7 – Wood Chip Tray 1
ES8 – Cabinet 1
ES9 - PVC Cover 1
FOR MISSING PARTS, CALL HARK ENTERPRISES PTY LTD
Toll Free (excludes mobiles): 1300 799 787;
MelbourneOfce:0398570999
1.0
ES1
ES2
ES1
ES2
ES3
ES5
ES6
ES7
ES8
ES4
ES9

7
ASSEMBLY INSTRUCTIONS
Tools required: Phillips Head Screwdriver
Step 1 – Install Handle
Remove two screws from the back of the appliance. Align
handle with the two holes on the back. Install the handle by
fastening a screw into each hole & tighten.
Step 2 – Install Wood Chip Chute Handle
Remove two screws from wood chip chute handle. Align
handle with two holes on wood chipe chute. Install by
fastening screw into handle and tighten.
Step 2 – Install Wood Chip Tray
Slide the wood chip tray into the corresponding supports,
insuring that the tray is placed to completely enclose the
heating element with the two surfaces of the tray.
Step 3 – Drip Pan Placement
SettheDripPanontheooroftheinsideofthesmoker,
below the wood chip tray. The raised edges of the pan
should face up in order to catch any juices that may drip
from the food overhead.
Be sure that the pan does not obstruct the smoker door
from closing.
2.0

8
ASSEMBLY INSTRUCTIONS (cntd.)
Step 4 – Install Water Pan
Slide water pan onto the supports directly above the wood
chip chute and below the supports for the fourth rack.
Step 5 – Rack Placement
Set the metal racks on the support shafts, located on the
sidewalls inside the smoker. It is not necessary to use all
5 metal racks when smoking. Racks can be set at various
heights according to the size of the food being smoked.
Note: The small rack always rests on the lowest support
shaft, adjacent to the wood chip tray.
Step 6 – Sausage Rack Placement
The sausage rack can be placed on the top shelf support
shafts. This will allow the greatest height for hanging foods.
Note: All other cooking racks must be removed to use the
sausage rack.
Step 7 – Front Leg Adjustment
The height of the front legs of the smoker can be adjusted
by either screwing them in or out.
The smoker should only be used on a level stable surface.
PLEASE SEE CURING INSTRUCTIONS PRIOR TO USE
2.0

9
CURING PROCEDURES
1. Remove the racks from the protective wrapping and wash in warm soapy water. Rinse
well, dry and put aside.
2. With a wet towel, wipe the inside of the smoker to remove any residue.
3. Once the inside is dry, spray some vegetable or olive oil onto a dry towel and wipe the
inside walls liberally.
4. Heat the smoker to 110°C. Place ¼ cup of wood chips into the wood chip chute. Ensure
that no chips remain in the chute after loading.
5. Smoke for two hours.
6. Congratulations! Your smoker is ready to use.
Note: Wood chips are not included.
Wood Chip Guide
Wood Flavour Poultry Fish Ham Beef Pork Lamb
Hickory
Strong & pungent. Sweet,
smoky-baconlikeavour. • • • •
Apple
Light, fruity smoke, providing a
slightlysweetavour. • • •
Oak
Clean,assertivesmokeavour. • • • •
Mesquite
Bold , hearty & unique. smoky
avour.Slightlysweet. • •
Pecan
Subtle yet rich. • • •
3.0
3.1

10
HOW TO USE THE POP-UP DIGITAL DISPLAY
Thedisplaypanelcanbeexposedbyrmlypressingthe
button located in front of the display panel. The display
panel will open and rotate upwards.
DO NOT CLOSE POP-UP DIGITAL CONTROL PANEL UNDER
ANY CIRCUMSTANCES DURING OPERATION OF SMOKER.
Control Panel Operating Instructions
Setting the Temperature:
• Push ON button.
• Push TEMP button; LED display will blink.
• Set the temperature by using and .
• Push TEMP again to set the preferred temperature.
Note: Heating will not begin until the timer is set.
Setting the Timer:
• Push TIME button; LED display for hours will blink.
• Set the hours by using and .
• Set the minutes by using and .
• Push TIME again for timer to begin.
HEATING WILL START AT THIS TIME. HEAT WILL TURN OFF WHEN TIME HAS EXPIRED.
Resetting the Control Panel:
If control panel shows an error message, turn electric smoker off by:
• Holding the ON / OFF button down until the display goes blank.
• Turn off the power point
• Unplug unit from the power point
• Wait ten seconds, plug unit back into the power point
• Turn back on at the power point
• Then turn electric smoker on
This will reset the control panel.
4.0
4.1

11
5.0 HOW TO USE WOOD CHIP CHUTE
• When the smoker reaches the desired temperature, pour ¼ - ½ a cup of your favourite
wood chips, into the wood chip chute.
• Add more chips as required. But never use more than a ¼ - ½ a cup of wood chips at
a time.
DO NOT USE WET WOOD CHIPS. WOOD CHIPS MUST BE DRY BEFORE THEY CAN BE USED
FOR SMOKING.
Adding wood chips during the smoking process
Caution: Keep smoker door closed when adding wood chips.
Note: The wood chip chute will be hot even if the handle is not.
• Add wood chips to the smoker by repeating the process mentioned above.
• Temperaturemayspikebrieyafterwoodisadded.Itwillstabiliseafterashorttime.Do
not adjust.
WHEN DOOR IS OPENED, A FLARE-UP MAY OCCUR. SHOULD THE WOOD CHIPS FLARE-UP,
IMMEDIATELY CLOSE THE DOOR. WAIT FOR THE WOOD CHIPS TO BURN DOWN, THEN OPEN
THE DOOR AGAIN.
DO NOT SPRAY WITH WATER.
5.1

12
6.0 PREPARING MEATS FOR SMOKING
The following steps are recommended to ensure normal, sanitary procedures when preparing
raw products for smoking:
Clean Wash hands and surfaces often
Separate Ingredients Do not cross contaminate ingredients or utensils
Cook Properly Use two thermometers, one to measure the internal temperature
of the food and one for the smoker.
Smoke Food To a safe internal temperature and level of doneness
Poultry Breast 77°C
Whole Poultry 82°C
Beef, Veal, Lamb Roast 63 - 77°C
Pork 71 - 77°C
Chill Refrigerate meat and poultry within 2 hours of removing it from
a smoker.
Source: USDA Pamphlet on Smoked Foods
Marinating or Brining
Curing, brining or marinading of meats with salt brine was considered necessary when
smoking was used primarily as a form of food preservation. Today, although hot smoking
does not require curing in order to preserve the food, there are other reasons for brining or
marinadingfoods.Marinadesnotonlyimparttheirownavour,butmoisturisethemeatand
complementthesmokeavourswhilealsoinhibitingbacterialspoilage.Youcanalsoutilise
marinadestoavourandtenderiselargecutsofmeatfromboththeinside(usingmarinade
injectors) as well as the outside of the meat.
Brining Fish
Fishisusuallysoakedinabrinesolutionpriortosmoking.Thisaddstothetasteofyoursh
andisalsotherststepinpreservingthem.
Basic Brine Solution
• 385 grams of non –iodised salt
• ¾ of a cup of Brown Sugar
• Mixed in 5 litres of water
Stir until completely dissolved and then place the sh in the solution being careful all is
completely covered.
Store in the fridge for between 4 – 8 hours. The longer you leave it in the solution the more
avourthatwillbeabsorbedbythesh.Itdependsonyourindividualtasteandhowsaltyyou
likeyoursh.
Removetheshfromthebrinesolutionandpatdrywithapapertowel.Allowtodryoutofthe
sunforanhour.Theshwillhaveaglazedlmonitandwillstickytotouch.
Theshisnowreadytosmoke.
6.1

13
Rubs
After the brining or marinading process is complete, you may wish to use a dry rub to add
additionalavour.Youcanapplytherubliberallyonthesurfaceofthemeatastherubwill
losesomeoftheiravourinthepresenceofheat.Besuretorstapplyvegetableoil,ora
basting spray to the meat to provide a sticky surface for the rub to adhere to.
Placing Meat in the Smoker
1. After the smoker is cleaned and the meat prepared, place the meat into your electric
smoker.
2. Add the liquid of your choice to the water pan.
3. Close the door and set the time and temperature digitally.
4. Then add wood chips via the wood chip chute.
5. DO NOT OPEN THE SMOKER DOOR IN THE FIRST HOUR OF THE SMOKING PROCESS.
Let the smoke do its work and do not worry if there is no smoke later in the process.
Too much smoke is not good for the cooking process.
6.2
6.3

14
7.0 USING YOUR SMOKER
General Points
• Toavoidabitteravouronyourfood,besurethatyoursmokerhasbeencleanedpriorto
commencing the smoking process. And if you don’t need the racks during the smoking
process, take them out prior to commencing.
• Temperatures cannot be set above 135°C. This smoker is ideally designed for low
temperature slow cooking (93°C to 100°C).
• The wood chip chute door must be closed and the wood chip tray must be in place while
cooking.Improperloadingmaycausewoodchipstocatchreortonotgenerateany
smoke.
• Woodchipsareessentialtogeneratesmokeandgivethemeatapleasantsmokyavour.
Moderation in the use of wood chips is recommended. Too much smoke will give smoked
meatsanunpleasantbitteravour.Whilelearningtosmoke,itisbettertounderestimate
the amount of smoke required. Typically about ¼ - ½ cup at a time.
• Your smoker will produce an abundance of smoke and leak out anyplace it can, including
the door seals. This is normal.
• Over time, discolouration on the interior surface of the smoker will occur. This is normal.
• Check and empty drip pan after every use.
• The smoker door should stay closed throughout the cooking process. Open the door only
when truly required. Once open, close your smoker door as soon as possible. Leaving
the door open for an extended period of time will result in the rapid loss of heat and may
causesmokingwoodchipstocatchre.
Commencing the Smoking Process
To commence using your smoker, refer to the following steps:
1. After the smoker is cleaned and the meat prepared, place the meat into your electric
smoker.
2. Add the liquid of your choice to the water pan, (some people use apple juice wine or
herbal concoctions) so that the smoker will maintain moisture and steam during the slow
cook. If and when necessary, add more liquid as required.
3. Close the door and set the time and temperature digitally.
4. Then add wood chips via the wood chip chute.
5. DO NOT OPEN THE SMOKER DOOR IN THE FIRST HOUR OF THE SMOKING PROCESS.
Let the smoke do its work and do not worry if there is no smoke later in the process.
Too much smoke is not good for the cooking process.
7.1
7.2

15
8.0
7.3 Smoking Hints & Tips
• When hot smoking, the ideal smoking temperature is around 105°C with a range from
90°C to 115°C. The goal remains to get the internal temperature of the meat up to its
safe level for consumption as determined by using a meat thermometer. When the meat
reaches the desired temperature, it is important to remove the meat from the smoker to
avoid drying out. For long smoking periods, baste the meat during those occasions when
you open the smoker to check meat temperatures and ensure there is enough liquid in
the water pan.
• Successful smoking also requires practising good temperature control. Maintaining
proper temperature is critical.
− Temperaturesthataretoolowcanincreasethecookingtimedramaticallyandcould
allow bacterial build-up to reach unhealthy levels.
− Temperaturesthataretoohighcancookthemeattooquicklyandfailstobenetfrom
thetenderisingandavourenhancementprocess.
Fortunately your digital smoker control will control the temperature, particularly if you
donotopenthesmokerdoortoooften.Slowcookinggivesthenaturalbresinthemeat
time to breakdown and become tender.
• Toomuchsmoke,orinadequateairow,cancauseabitteravourintheproductsbeing
smoked. While there is debate amongst the grill masters, most cooks believe that the
smokyavourobtainedafterthersttwohoursisenough.Smokingfoodisentirelyup
toyourpersonalpreferenceandyouwillnditisbesttoexperimentonwhatbestsuits
your tastes.
CLEANING YOUR SMOKER
• Always unplug the smoker and allow ample time to cool before cleaning and storing.
• Wash the cooking racks, water pan and drip pan, in a mild detergent. Rinse soapy residue
off and dry thoroughly before storing.
• Clean wood chip tray before or after every use to remove residual ash build up. Dispose
of cold ashes by placing them in aluminium foil.
• Clean the exterior and interior by wiping down with a damp cloth (do not use soap or
chemicals). Be sure to be careful when cleaning the door seal and inside seam. Dry
thoroughly prior to storage.
• Do not use any type of steam dishwashing detergent for cleaning.
• Do not use any type of spray or pressure cleaners.
• Place cover over the smoker and store in a dry, enclosed location away from moisture
and rain. The smoker is an electric appliance and therefore should not be left outside,
even with the cover on.

16
9.0 TYPES OF SMOKING
Dry Smoking Dry smoking uses indirect heat with a low, smouldering heat source to
slowlycookfoods,whileinfusingthemwithasmokeavour.
Wet Smoking Wet smoking or water smoking is more often employed when smoking.
A pan of water, fruit juices, wine or other liquids are used to maintain
moisture and tenderness throughout the smoking process.
Hot Smoking Hot smoking is the process of smoking food at the same time as it is
cooked. Foods for hot smoking would normally be eaten soon after they
are prepared. Hot smoked foods may be cured (brined) or marinated or
basted.Additionally,rubsmaybeusedtotenderizeorenhanceavour
aswellastomoisturiseandcomplementsmokyavours.
Todaysmokingistrulyaboutavouringandtenderisingsomeofthetoughercutsofmeatthat
don’t cook well using other cooking methods. What you smoke is mostly a matter of personal
taste, but the most popular smoked items include ribs, brisket and pork shoulder. Most forms
ofwildgameaswellaspoultry,fowlandsh,produceexcellentresultswhenslowsmoked.
You will learn that the amount of “smoke” required during the process is far less than one
might expect. Often the best option is to keep the door to the smoker closed and to do nothing.
Continually opening the smoker is completely unnecessary.
The greatest attribute that you need when smoking food is patience!
The process of smoking food is done at low temperatures over a long period of time. The Hark
Electric Smoker allows you to control both the temperature and time digitally and takes all
the guess work out of the smoking process.
Over time, experience will allow you to adapt the smoking process to your individual
preferences and tastes. Ultimately, practice and patience are necessary, as smoking is more
an “art” than a science; and nothing beats your own expertise and experience in personalising
the smoking process.
We hope you enjoy your Hark Electric Smoker. Please refer to our website for more tips and
smoking recipes.
www.hark.com.au

17
Electric Smoker
Warranty Details
The product is guaranteed to be free from defects in workmanship and parts for a period
of 12 months from the date of purchase. Defects that occur within this warranty period,
under normal use and care, will be repaired, replaced or refunded at our discretion. The
benets conferred by this warranty are in addition to all rights and remedies in respect of
the product that the consumer has under the Competition and Consumer Act 2010 and
similar state and territory laws.
Our goods come with guarantees that cannot be excluded under the Australian Consumer
Law. You are entitled to a replacement or refund for a major failure and for compensation
for any other reasonably foreseeable loss or damage. You are also entitled to have the
goods repaired or replaced if the goods fail to be of acceptable quality and the failure does
not amount to a major failure.
After Sales Support
Telephone: [phone]
[phone]
Email: [email protected]
YEAR
WARRANTY
grill roast smoke

Hark Enterprises Pty Ltd
Unit 11, 41-49 Norcal Rd, Nunawading, VIC, 3131
T: 03 9857 0999; 1300 799 787
E: [e-mail] W: www.hark.com.au