PAGE 8
2.02 OPERATING SAFETY
1. Read and understand the Operator's Manual and all safety
signs before operating, servicing, adjusting or unplugging.
2. Do not allow riders on the Husky Liquid Manure Lagoon
Pump or the tractor during operation, transport or filling.
3. Do not operate a PTO driven system unless the required
shields are in place and secured.
4. Never wear loose fitting clothing, keep hands, feet, hair and
clothing away from all moving and/or rotating parts, while
working with machinery, use personal protective clothing and
eye and ear protection as needed.
5. Stop tractor engine, disengage PTO clutch, set park brake,
remove ignition key and wait for all moving parts to stop before
servicing, adjusting, repairing or unplugging.
6. Before applying hydraulic pressure to the system, make sure
everyone is clear and that all connections are tight and all
components are in good repair.
7. Never enter manure tank or manure storage facility without
wearing appropriate breathing gear that carries an independent
supply of oxygen.
8. Always use a tractor of sufficient size and weight to maintain
vehicle stability during transport and during use.
9. Clean or install reflectors and SMV emblem before
transporting and add extra lights for transporting during times of
limited visibility.
10. Make sure parking brake on the tractor is set and block
wheels so it cannot roll.
11. Make sure the PTO is not run on too great an angle it will
cause vibration and could shear a pin in the PTO or it could cause
the PTO to break and increase the danger of injury.
12. Review all safety instructions annually.
Think SAFETY! Work SAFELY!
2.03 MAINTENANCE
SAFETY
1. Read and understand all the information contained in the
Operator's Manual regarding maintenance, adjusting and
operating Husky Liquid Manure Lagoon Pump.
2. Block the frame up securely and firmly if adjustments and
maintenance to the Liquid Manure Lagoon Pump require raising
the wheel and tire assemblies off the ground.
3. Exercise extreme caution when working around or with
high-pressure hydraulic systems. Depressurize the system when
connecting or disconnecting the hose couplers.
4. Wear heavy gloves and eye protection when searching for
suspected hydraulic leaks. A high- pressure concentrated stream
of hydraulic fluid can pierce the skin. If such an event happens,
seek immediate medical attention as infection and toxic reaction
could develop.
5. Do not attempt any adjustment or maintenance to any system
of the Husky Liquid Manure Lagoon Pump when the implement
is in motion.
6. Be very careful and exercise extreme caution when working
around or near a rotating PTO shaft.
7. Do not operate PTO system unless the rotating shield and all
other guards are in place.
8. Never wear ill-fitting, baggy or frayed clothing and never
have unkempt long hair when working around or on any of the
drive system components.
9. Stop the engine, place all controls in neutral, remove the
ignition key, set the park brake and wait for all moving parts to
stop before servicing, adjusting, repairing or unplugging any
system or component.
10. Never enter tank or manure storage facility without wearing
appropriate breathing gear that carries an independent supply of
oxygen. The buddy system is also a recommended procedure.
