!!!!!!!!!Hyper Split Hydraulic Log Splitter!
ToolTuff!Direct!LLC,!15000!W44th!Ave,!Ste!B,!Golden!CO!80403!!!!!!!!!!!!!!Page!9!
hydraulic!reservoir.!Please!check!the!tank!window!to!fill!properly.!Fill!about!20!
ounces!of!engine!oil.!See!engine!manual!for!oil!caution.!
!
Caution:!When!tightening!the!breather!cap!on!the!tank,!point!the!hole!away!from!
the!engine!
!
Step$2:!Start!the!engine.!The!hydraulic!pump!should!prime!itself.!With!
the!engine!running,!move!the!hydraulic!valve!lever!toward!the!wedge.!
When!the!cylinder!is!fully!extended,!retract!it.!Replace!this!operation!for!
a!few!times!before!splitting.!!
!
Caution:!If!the!tank!is!overfilled,!it!will!expel!oil!from!the!breather!cap.!If!
the!tank!needs!more!hydraulic!oil,!you!will!see!foam!through!the!
hydraulic!hose!connected!between!tank!and!log!splitter!pump.!Due!to!
the!special!cylinder!for!hyper!split,!the!engine!may!have!some!loud!
noise!when!the!cylinder!is!retracting.!This!is!normal!situation.!You!can!
continue!using!this!log!splitter!without!any!issue.!!
!
STARTING$INSTRUCTIONS$
• Make!sure!the!log!splitter!valve!is!at!neutral!position.!!
• Move!control!lever!to!“OK”!
• Move!chock!lever!to!choice!position.!!
• Grasp!starter!rope!handle!and!pull!out!slowly!until!resistance!is!
felt.!Then!pull!rapidly!with!a!full!stroke.!Repeat!the!last!step!if!
engine!fails!to!start.!!
• When!engine!starts,!leave!control!lever!at!“FAST”.!The!throttle!
must!be!in!the!“FAST”!position!for!maximum!performance.!!
• To!stop!engine,!move!the!throttle!lever!to!“Slow”!and!then!to!
“STOP”.!
!
Step$3:!For!horizontal!operation,!please!a!log!on!the!beam!against!the!
footplate.!Make!sure!the!log!sits!securely!on!the!footplate.!To!split!wood!
in!the!vertical!position,!release!the!beam!lock!pin!on!the!beam!located!
near!the!front!end!of!the!beam.!Carefully!tilt!the!beam!up!until!the!
footplate!is!sitting!squarely!on!the!ground!and!the!log!splitter!is!stable.!
When!the!beam!is!returned!to!the!horizontal!position!makes!sure!the!
beam!is!securely!locked!down.!!
!
