ICOP Technology Vega86-6240 User manual

Vega86-6240
VIA Mark CoreFusion 533MHz
EBX CPU Module
with 6S/2USB/GPIO/VGA/LCD/AUDIO/2LAN/CF
256MB SDRAM Onboard
User’s Manual
(Revision 1.1A)

ii
Copyright
The information in this manual is subject to change without notice for continuous improvement in
the product. All rights are reserved. The manufacturer assumes no responsibility for any
inaccuracies that may be contained in this document. And makes no commitment to update or to
keep current the information contained in this manual.
No part of this manual may be reproduced, copied, translated or transmitted, in whole or in part,
in any form or by any means without the prior written permission of the ICOP Technology Inc.
Copyright 2007 ICOPTechnology Inc.
Manual No. IUM6240000-01 Ver.1.0A April, 2007
Manual No. IUM6240000-01 Ver.1.1A December, 2007
Trademarks Acknowledgment
Vega86is the registered trademark of ICOP Technology Inc.
Other brand names or product names appearing in this document are the properties
and registered trademarks of their respective owners. All names mentioned herewith
are served for identification purpose only.

iii
T a b l e o f C o n t e n t s
T ab l e o f C o n t e nt s.............................................................iii
C h a p t e r 1 Introduction……………………………………………1
1.1 Packing List............................................................1
1.2 Product Description................................................2
1.3 Specification...........................................................3
1.4 Board Dimension....................................................5
C h a p t e r 2 Installation……………………………………………..6
2.1 Board Outline.........................................................6
2.2 Connectors & Jumpers Location............................8
2.3 Connectors & Jumpers Summary...........................9
2.4 PinAssignments &Jumper Settings......................11
2.5 System Mapping...................................................23
C h a p t e r 3 Driver Installation……………………………………25
Appendix ………………………………………………………………..26
A. STN Flat Panel Data Output......................................26
B. TFT Flat Panel DataOutput.........................................27
C. Flat Panel BIOS Setting............................................29
D. Flat Panel Wiring and lighting………………………….31
Warranty............................................................................................32

Vega86-6240 Vega86EBX CPU Module 1
C h a p t e r 1
Introduction
1.1 Packing List
Product Name Package
Vega86-6240
Embedded Vega86 CPU All-in-One Board
Manual & Drivers CD x 1
RS232 cable x6
VGA cable x1
PRINTER cable x1
AUDIO cable x 3
FDD cable x 1
IDE cable x 1
USB cable x 1 (USB port x 2)
PS/2 Mouse cable x 1
PS/2 Keyboard cable x 1

Vega86-6240 Vega86EBX CPU Module 2
1.2 Product Description
The Vega86 Single-Board-Computer series (powered by VIA Mark CoreFusion processor) offers
high performance, cost-effectiveand energy efficient processor with integrated ProSavage4 SA
graphics controller, which is the powerful embedded x86 platform for Windows XP Embedded,
WEPOS, and embedded Linux application.
The complete board consists of the Mark CoreFusion processor and the VT82C686B PCI-ISA
South Bridge, Realtek RTL8100B 10/100 Fast Ethernet Controller, etc. The processor integrates
VIA’s high-performance ProSavage4 3D / 2D graphics controller, LCD and Flat Panel display
interfaces, with further superior performance between the CPU, SDRAM and PCI bus with
pipelined, burst, and concurrent operation. The South Bridge is PC98 / PC99 compliant with
integrated UltraDMA-100/ 66 / 33 IDE, 2 (or 3) USB (1.1) ports, Super-I/O functions (floppy disk
drive interface and serial / parallel ports), and AC-97 link supporting digital audio functions.
The Vega86 SBC supports SDRAM up to 256MB. As to the DRAM controller, it meets the
standard PC133 Synchronous DRAM (SDRAM). The Synchronous DRAM interface allows zero
wait state bursting between the SDRAM and the data buffers at 133MHz.
The Vega86 SBC integrates S3 Graphics and 128-bit ProSavage4 graphics accelerators that
bring mainstream graphics performance to the Value PC with leading-edge 2D, 3D and DVD
video acceleration into a cost effective package.Vega86 SBC also combines the industry’s first
integrated AGP 4X solution with Microsoft Direct-X texture compression and massive 2Kx2K
textures to deliver unprecedented 3D performance and image quality for the Value PC mobile
market.
Vega86 SBC’s South Bridge supports four levels (doubleword) of line buffers, DMA transfers and
delay transaction to allow efficient PCI bus utilization and (PCI-2.2 compliant). The VT82C686B
also includes anintegrated Super I/O, integrated DS12885 style real time clock with extended
256 byte CMOS RAM, integrated master mode enhanced IDE controller with full scatter / gather
capability, integrated two (or three) USB (1.1) interface with root hub and two function ports with
built-in physical layer transceivers, Distributed DMA support and integrated AC-97 link for basic
audio functions.
Regarding the network architecture application, Vega86 SBC equips with the Realtek RTL8100B,
which is a highly integrated, cost-effective single-chip Fast Ethernet controller able to provide
32-bit performance, PCI bus master capability, and full compliance with IEEE 802.3u
10/100Base-T specifications and IEEE 802.3x Full Duplex Flow Control.

Vega86-6240 Vega86EBX CPU Module 3
1.3 Specification
Features Vega86-6240
CPU VIA Mark CoreFusion 533MHz
Chipset VIA VT82C686B
BIOS AMI BIOS
System Memory 256 MB SDRAM onboard
Cache L1:64KB L2:64KB
Bus Interface PC/104 Standard Compliant (Optional: PCI-104)
Watchdog Timer None
VGA
Integrated 2D/3D AGP4X graphics with MPEG2
Accelerator, Shared system memory 8M/16M/32M
VGA, SVGA, XGA, SXGA and DSTN/TFT Flat Panel
interface support
LAN
Realtek 8100B 10/100Mbps Ethernet Controller
Half/Full duplex capability
Audio
VIA VT1612A AC97 Codec
Full compatible with AC97 2.2 version
I /O Interface Enhanced IDE port (UltraDMA-100/66/33) x1
RS232 port x4
RS232/485 port x2 (RS485 with Auto Direction)
Parallel port x1
FDD port x1
USB port x2 (USB 1.1 version)
16-bit GPIO port x1
10/100Mbps Ethernet port x2

Vega86-6240 Vega86EBX CPU Module 4
Connectors
2.54mm 40-pin box header for IDE x1
2.54mm 34-pin box header for FDD x1
2.54mm 26-pin box header for Printer x1
2.54mm 10-pin box header for RS-232 x6
2.54mm 3-pin header for RS-485 x2
2.54mm 2-pin header for Reset x1
2.54mm 10-pin box header for USB (2 USB ports) x1
2.54mm 20-pin box header for 16-bit GPIO x1
2.54mm 5-pin box header for keyboard x1
2.54mm 5-pin header for Mouse x1
2.0mm 44-pin box header for LCD x1
2.0mm 4-pin wafer for Line-in/Line-out/MIC-in x3
3.96mm 7-pin Male Power Connector x1
0.8mm 124-pin MiNi PCI connector x1
External RJ-45 LAN connector x2
Type I/II Compact Flash slot x1
Flash Disk Support
40-pin IDE Flash Disk( EmbedDisk 16MB or above)
Type I/II CF Card
Power Requirement Single Voltage +5V @2.5A
Dimension 146 X 203mm (5.75 x 8 inches)
Weight 310g
Operating
Temperature -20oC ~ +60oC

Vega86-6240 Vega86EBX CPU Module 5
1.4 Board Dimension

Vega86-6240 Vega86EBX CPU Module 6
C h a p t e r 2
Installation
2.1 Board Outline

Vega86-6240 Vega86EBX CPU Module 7
To guarantee the stability & maximum performance of original design, Vega86-6240
must be used with the manufacturer designated passive heat sink shown as below
photo.
(Note1: PCI-104 Connector is optional)

Vega86-6240 Vega86EBX CPU Module 8
2.2 Connectors & Jumpers Location
Connectors & Jumpers

Vega86-6240 Vega86EBX CPU Module 9
2.3 Connectors & Jumpers Summary
Summary Table
Nbr Description Type of Connections Pin nbrs.
J1 FDD Pin Header, 2.54, 17x2 34-pin
J2 Reset Pin Header, 2.54, 1x2 2-pin
J3 USB Box Header, 2.54, 5x2 10-pin
J4 PS/2 Keyboard Box Header,2.54, 1x5 5-pin
J5 PS/2 Mouse Pin Header,2.54, 1x5 5-pin
J6 10/100Base-TEthernet LAN 1
RJ45 Connector 8-pin
J7 LCD Box Header, 2.0, 22x2 44-pin
J8 LCD Volts Sel. (5V or 3.3V) Pin Header, 2.54, 3x1 3-pin
J9 IDE Connector Box Header, 2.54, 20x2 40-pin
J11 CF Card Master/Slave Select
Pin Header, 2.54, 2x1 2-pin
J12 Power Connector Terminal Block 5.0, 2x1 2-pin
J13 Power Connector Pin Header, 3.967x1 7-pin
J15 FAN ( Reserved Power-output
for FAN) Molex Header, 2.0, 2x1 2-pin
J16 PC104 Connector – 64 pin Box Header, 2.54,32x2 64-pin
J17 PC104 Connector – 40 pin Box Header, 2.54,20x2 40-pin
J18 GPIO Box Header, 2.54,10x2 20-pin
J19 GPRS connector Box Header, 2.0, 22x2 44-pin
J20 SIM card holder SIM card,2.54,32x2 6-pin
J21 PRINT Pin Header, 2.54,13x2 26-pin
J22 COM1 Connector Pin Header, 2.54, 5x2 10-pin
J23 RS232/RS485 Select (COM 1)
Pin Header, 2.54, 3x1 3-pin
J24 RS-485-1 (Auto Direction) Molex Header, 2.54, 3x1 3-pin
J25 COM2 Pin Header, 2.54, 5x2 10-pin
J26 RS232/RS485 Select (COM 2)
Pin Header, 2.54, 3x1 3-pin
J27 RS-485-2 (Auto Direction) Molex Header, 2.54, 3x1 3-pin
J28 COM3 Pin Header, 2.54, 5x2 10-pin
J29 COM4 Pin Header, 2.54, 5x2 10-pin
J30 COM5 Pin Header, 2.54, 5x2 10-pin
J31 COM6 Pin Header, 2.54, 5x2 10-pin
J32 LINE OUT Molex Header, 2.0, 4x1 4-pin
J33 MIC IN Molex Header, 2.0, 4x1 4-pin
J34 LINE IN Molex Header, 2.0, 4x1 4-pin

Vega86-6240 Vega86EBX CPU Module 10
J35 MINI_PCI _Type- ⅢType- Ⅲ connector 124-pin
J37 10/100Base-TEthernet LAN 2
RJ45 Connector 8-pin
J38 VGA Pin Header, 2.54, 5x2 10-pin
CF1 Compact Flash Type I/II CF Connector 50-pin
PWR-
LED PowerActive LED(Red)
LED-SMD
IDE-
LED IDEActive LED(Orange) LED-SMD
LAN1-
LED0 LANActive LED(Green) LED-SMD
LAN1-
LED1 LAN Link LED (Orange) LED-SMD
LAN2-
LED0 LANActive LED(Green) LED-SMD
LAN2-
LED1 LAN Link LED (Orange) LED-SMD
Modem-
LED ModemActive LED(Orange) LED-SMD
SP1 BUZZER

Vega86-6240 Vega86EBX CPU Module 11
2.4 Pin Assignments & Jumper Settings
J1: FDD
Pin # Signal Name
Pin # Signal Name
1 GND 2 DENSEL
3 GND 4 NC
5 GND 6 DRV1
7 GND 8 INDEX\
9 GND 10 MTR0\
11 GND 12 DS1\
13 GND 14 DS0 \
15 GND 16 MTR1\
17 GND 18 DIR\
19 GND 20 STEP\
21 GND 22 WD\
23 GND 24 WG\
25 GND 26 TR0\
27 GND 28 WP\
29 GND 30 RD\
31 GND 32 HDSEL\
33 GND 34 DSKCHG\
J2: RESET
Pin # Signal Name
Pin # Signal Name
1 RST_SW 2 GND
J3: USB
Pin # Signal Name
Pin # Signal Name
1 VCC 2 VCC
3 -DATA1 4 -DATA0
5 +DATA1 6 +DATA0
7 GND 8 GND
9 GND 10 GND

Vega86-6240 Vega86EBX CPU Module 12
J4: PS/2 Keyboard
Pin # Signal Name
Pin # Signal Name
1 KBCLK 2 KBDAT
3 NC 4 GND
5 IRQ12 6 +5V
J5: PS/2 Mouse
Pin # Signal Name
Pin # Signal Name
1 MSCLK 2 IRQ12
3 NC 4 GND
5 +5V
J6: LAN 1
Pin # Signal Name
Pin # Signal Name
1 TD+ 2 TD-
3 RO+ 4 NC
5 NC 6 RO-
7 NC 8 NC

Vega86-6240 Vega86EBX CPU Module 13
J7: LCD Connector
Pin # Signal Name
Pin # Signal Name
1 LCDVCC 2 LCDVCC
3 FPD0 4 FPD1
5 FPD2 6 FPD3
7 FPD4 8 FPD5
9 FPD6 10 FPD7
11 FPD8 12 FPD9
13 FPD10 14 FPD11
15 FPD12 16 FPD13
17 FPD14 18 FPD15
19 FPD16 20 FPD17
21 FPD18 22 FPD19
23 FPD20 24 FPD21
25 FPD22 26 FPD23
27 FP24 28 FP25
29 FPD26 30 FPD27
31 FPD28 32 FPD29
33 GND 34 GND
35 FPD30 36 FPCLK
37 FPD31 38 FPDEN
39 FPD32 40 FPHS
41 FPD34 42 FPVS
43 ENVEE 44 ENVDD
(Please refer to Appendix A, B for STN and TFT Flat Panel Data Output)
J8: LCD Volts Sel.
Pin # Signal Name
Pin # Signal Name
1-2 +5V 2-3 +3.3V

Vega86-6240 Vega86EBX CPU Module 14
J9: IDE
Pin # Signal Name
Pin # Signal Name
1 PCIRST- 2 GND
3 IDED7 4 IDED8
5 IDED6 6 IDED9
7 IDED5 8 IDED10
9 IDED4 10 IDED11
11 IDED3 12 IDED12
13 IDED2 14 IDED13
15 IDED1 16 IDED14
17 IDED0 18 IDED15
19 GND 20 VCC
21 IDEREQ 22 GND
23 IDEIOW 24 GND
25 IDEIOR 26 GND
27 ICHRDY 28 GND
29 IDEACK 30 GND
31 IRQ14 32 NC
33 IDESA1 34 PD_80P
35 IDESA0 36 IDESA2
37 IDECS0 38 IDECS1
39 DASP 40 GND
J11: CF Card Master/Slave Select
Pin # Signal Name
CLOSE Master
OPEN Slave
J12: Power Connector (Terminal Block 5.0mm)
Pin # Signal Name
1 +5V
2 GND

Vega86-6240 Vega86EBX CPU Module 15
J13: Power Connector (Wafer 7P-3.96mm 180 ﾟ)
Pin # Signal Name
Pin # Signal Name
1 +5V 2 GND
3 GND 4 +12V
5 NC 6 GND
7 +5V 8
J15: FAN
Pin # Signal Name
1 +5V
2 GND

Vega86-6240 Vega86EBX CPU Module 16
J16: PC104 Connector – 64pin
Pin # Signal Name
Pin # Signal Name
1 IOCHCHK * 2 GND
3 SD7 4 RESETDRV
5 SD6 6 +5V
7 SD5 8 IRQ9
9 SD4 10 -5V
11 SD3 12 DRQ2
13 SD2 14 -12V
15 SD1 16 OWS
17 SD0 18 +12V
19 IOCHRDY 20 GND
21 AEN 22 SMEMW *
23 SA19 24 SMEMR *
25 SA18 26 IOW *
27 SA17 28 IOR *
29 SA16 30 DACK3 *
31 SA15 32 DRQ3
33 SA14 34 DACK1 *
35 SA13 36 DRQ1
37 SA12 38 REFRESH *
39 SA11 40 SYSCLK
41 SA10 42 IRQ7
43 SA9 44 IRQ6
45 SA8 46 IRQ5
47 SA7 48 IRQ4
49 SA6 50 IRQ3
51 SA5 52 DACK2 *
53 SA4 54 TC
55 SA3 56 BALE
57 SA2 58 +5V
59 SA1 60 OSC
61 SA0 62 GND
63 GND 64 GND

Vega86-6240 Vega86EBX CPU Module 17
J17: PC104 Connector – 40pin
Pin # Signal Name
Pin # Signal Name
1 GND 2 GND
3 MEMCS16 *
4 SBHE *
5 IOCS16 * 6 SA23
7 IRQ10 8 SA22
9 IRQ11 10 SA21
11 IRQ12 12 SA20
13 IRQ15 14 SA19
15 IRQ14 16 SA18
17 DACK0 * 18 SA17
19 DRQ0 20 MEMR *
21 DACK5 * 22 MEMW *
23 DRQ5 24 SD8
25 DACK6 * 26 SD9
27 DRQ6 28 SD10
29 DACK7 * 30 SD11
31 DRQ7 32 SD12
33 +5V 34 SD13
35 MASTER * 36 SD14
37 GND 38 SD15
39 GND 40 NC
J18: GPIO
Pin # Signal Name
Pin # Signal Name
1 GND 2 VCC
3 GPIO 0 4 GPIO 8
5 GPIO 1 6 GPIO 9
7 GPIO 2 8 GPIO 10
9 GPIO 3 10 GPIO 11
11 GPIO 4 12 GPIO 12
13 GPIO 5 14 GPIO 13
15 GPIO 6 16 GPIO 14
17 GPIO 7 18 GPIO 15
19 VCC 20 GND