IEI Technology MODAT-335 User manual

MODAT-335A Field Service Terminal
Page I
User Manual
MODEL:
MODAT-335A
Android-Based Field Service Terminal with 3.5” Touchscreen,
TI Sitara™ AM3715 CPU, Wi-Fi, Bluetooth, GPS,
Barcode Reader, RFID Reader and Camera
Rev. 1.00 – 5 February, 2014

MODAT-335A Field Service Terminal
Page II
Revision
Date Version Changes
5 February, 2014 1.00 Initial release

MODAT-335A Field Service Terminal
Page III
Copyright
COPYRIGHT NOTICE
The information in this document is subject to change without prior notice in order to
improve reliability, design and function and does not represent a commitment on the part
of the manufacturer.
In no event will the manufacturer be liable for direct, indirect, special, incidental, or
consequential damages arising out of the use or inability to use the product or
documentation, even if advised of the possibility of such damages.
This document contains proprietary information protected by copyright. All rights are
reserved. No part of this manual may be reproduced by any mechanical, electronic, or
other means in any form without prior written permission of the manufacturer.
TRADEMARKS
All registered trademarks and product names mentioned herein are used for identification
purposes only and may be trademarks and/or registered trademarks of their respective
owners.

MODAT-335A Field Service Terminal
Page IV
WARNING
This device complies with Part 15 of the FCC Rules. Operation is subject to the following
two conditions:
(1) this device may not cause harmful interference, and (2) this device must accept any
interference received, including interference that may cause undesired operation.
NOTE: This equipment has been tested and found to comply with the limits for a Class
B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to
provide reasonable protection against harmful interference in a residential installation.
This equipment generates, uses, and radiates radio frequency energy and, if not
installed and used in accordance with the instructions, may cause harmful interference
to radio communications.
However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or television
reception, which can be determined by turning the equipment off and on, the user is
encouraged to try to correct the interference by one or more of the following measures:
—Reorient or relocate the receiving antenna.
—Increase the separation between the equipment and receiver.
—Connect the equipment into an outlet on a circuit different from that to which the
receiver is connected.
—Consult the dealer or an experienced radio/ TV technician for help.
You are cautioned that any change or modifications to the equipment not expressly
approve by the party responsible for compliance could void your authority to operate
such equipment.
IMPORTANT NOTE:
FCC Radiation Exposure Statement:
This equipment complies with FCC radiation exposure limits set forth for an
uncontrolled environment. This equipment should be installed and operated with
minimum distance 20cm between the radiator & your body.

MODAT-335A Field Service Terminal
Page V
Table of Contents
1 INTRODUCTION.......................................................................................................... 1
1.1 OVERVIEW.................................................................................................................. 2
1.2 MODEL VARIATIONS ................................................................................................... 2
1.3 FEATURES................................................................................................................... 3
1.4APPLICATIONS ............................................................................................................ 3
1.5 EXTERNAL OVERVIEW................................................................................................ 3
1.5.1 Front Panel........................................................................................................ 4
1.5.1.1 LED Indicators............................................................................................ 5
1.5.2 Left Panel........................................................................................................... 5
1.5.3 Right Panel......................................................................................................... 6
1.5.4 Top Panel ........................................................................................................... 7
1.5.5 Bottom Panel...................................................................................................... 7
1.5.6 Back Panel......................................................................................................... 8
1.6 SPECIFICATIONS ......................................................................................................... 9
1.7 DIMENSIONS..............................................................................................................11
2 UNPACKING............................................................................................................... 12
2.1.1 Packing List ..................................................................................................... 13
2.1.2 Optional Items.................................................................................................. 15
3 INSTALLATION ......................................................................................................... 16
3.1ANTI-STATIC PRECAUTIONS...................................................................................... 17
3.2 INSTALLATION PRECAUTIONS................................................................................... 17
3.3 CHARGING THE SYSTEM........................................................................................... 18
3.3.1 Using the Optional Cradle............................................................................... 20
3.4 INSTALLING THE OPTIONAL BARCODE TRIGGER GRIP.............................................. 21
3.5 I/O CONNECTORS..................................................................................................... 23
3.5.1 Headset Jack.................................................................................................... 23
3.5.2 Mini USB Client Connector............................................................................. 23
3.6 DOCKING CABLE I/O CONNECTORS (OPTIONAL) ..................................................... 25

MODAT-335A Field Service Terminal
Page VI
3.6.1 RS-232 Serial Port........................................................................................... 26
3.6.2 USB Client Plug............................................................................................... 27
3.6.3 USB Host Connector........................................................................................ 28
3.7 POWERING ON/OFF .................................................................................................. 29
3.8 RESETTING THE SYSTEM .......................................................................................... 31
4 USING THE MODAT-335A........................................................................................ 32
4.1 FUNCTION BUTTONS ................................................................................................ 33
4.2 HOME SCREEN ......................................................................................................... 34
4.3 SETTINGS ................................................................................................................. 35
4.3.1 WIRELESS & NETWORKS.............................................................................. 35
4.3.1.1 More Settings............................................................................................ 36
4.3.2 Sound................................................................................................................ 37
4.3.3 Display............................................................................................................. 38
4.3.4 Storage............................................................................................................. 39
4.3.5 Battery.............................................................................................................. 39
4.3.6 Apps.................................................................................................................. 40
4.3.7 Location Access................................................................................................ 41
4.3.8 Security ............................................................................................................ 42
4.3.9 Language & Input............................................................................................ 43
4.3.10 Backup & Reset.............................................................................................. 44
4.3.11 Add account.................................................................................................... 44
4.3.12 Date & Time................................................................................................... 45
4.3.13 Accessibility ................................................................................................... 46
4.3.14 Developer Options......................................................................................... 47
4.3.15 About Tablet ................................................................................................... 48
4.4 FILE MANAGER........................................................................................................ 49
4.5 CAMERA................................................................................................................... 50
4.6 BARCODE SCANNER SETUP TOOL............................................................................. 51
4.7 RFID READER (MODAT-335-AD41-E-R10 ONLY) ................................................ 52
A SAFETY PRECAUTIONS......................................................................................... 54
A.1 SAFETY PRECAUTIONS ............................................................................................ 55
A.1.1 General Safety Precautions............................................................................. 55
A.1.2 Anti-static Precautions .................................................................................... 56

MODAT-335A Field Service Terminal
Page VII
A.1.3 Product Disposal............................................................................................. 56
A.2 MAINTENANCE AND CLEANING PRECAUTIONS........................................................ 57
A.2.1 Maintenance and Cleaning.............................................................................. 57
A.2.2 Cleaning Tools................................................................................................. 58
B INTERNATIONAL STANDARDS COMPLIANCE............................................... 59
B.1 EN 60601-1, EN 60601-2 ....................................................................................... 60
B.2 FCC......................................................................................................................... 60
C HAZARDOUS MATERIALS DISCLOSURE......................................................... 61
C.1 HAZARDOUS MATERIALS DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS
ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ....................................... 62

MODAT-335A Field Service Terminal
Page VIII
List of Figures
Figure 1-1: MODAT-335A ...............................................................................................................2
Figure 1-2: MODAT-335A Front Panel ..........................................................................................4
Figure 1-3: MODAT-335A Left Panel.............................................................................................5
Figure 1-4: MODAT-335A Right Panel ..........................................................................................6
Figure 1-5: MODAT-335A Top Panel.............................................................................................7
Figure 1-6: MODAT-335A Bottom Panel.......................................................................................7
Figure 1-7: MODAT-335A Rear Panel............................................................................................8
Figure 1-8: MODAT-335A Dimensions (units in mm)................................................................11
Figure 3-1: MODAT-335A Mini USB Port....................................................................................19
Figure 3-2: Connecting the USB Cable to the Power Adapter.................................................19
Figure 3-3: Battery Charging LED...............................................................................................20
Figure 3-4: Connecting the USB Cable to the Charging Cradle ..............................................20
Figure 3-5: Inserting the MODAT-335A to the Charging Cradle ..............................................21
Figure 3-6: Barcode Trigger Grip Installation............................................................................22
Figure 3-7: MODAT-335A with the Barcode Trigger Grip.........................................................22
Figure 3-8: Mini USB Connection................................................................................................23
Figure 3-9: USB Client..................................................................................................................24
Figure 3-10: USB Mass Storage Screen.....................................................................................25
Figure 3-11: Docking Cable Connection ....................................................................................25
Figure 3-12: Serial Device Connector.........................................................................................26
Figure 3-13: Serial Port Pinouts..................................................................................................27
Figure 3-14: USB Connection......................................................................................................27
Figure 3-15: USB Host Mode.......................................................................................................29
Figure 3-16: Power Button...........................................................................................................30
Figure 3-17: Power-off Confirmation Screen.............................................................................30
Figure 3-18: Reset Button............................................................................................................31
Figure 4-1: Function Buttons ......................................................................................................33
Figure 4-2: Move and Trash Item on Home Screen...................................................................34
Figure 4-3: Wireless and Networks Settings .............................................................................35
Figure 4-4: More Settings Menu..................................................................................................36

MODAT-335A Field Service Terminal
Page IX
Figure 4-5: Sound Menu...............................................................................................................37
Figure 4-6: Display Menu.............................................................................................................38
Figure 4-7: Storage Menu ............................................................................................................39
Figure 4-8: Battery Menu .............................................................................................................39
Figure 4-9: Apps Menu.................................................................................................................40
Figure 4-10: Location Access Menu...........................................................................................41
Figure 4-11: Security Menu..........................................................................................................42
Figure 4-12: Language & Input Menu .........................................................................................43
Figure 4-13: Backup & Reset Menu ............................................................................................44
Figure 4-14: Add Account Menu .................................................................................................45
Figure 4-15: Date & Time Menu...................................................................................................45
Figure 4-16: Accessibility Menu..................................................................................................46
Figure 4-17: Developer Options Menu........................................................................................47
Figure 4-18: About Tablet Menu..................................................................................................48
Figure 4-19: OI File Manager .......................................................................................................49
Figure 4-20: Possible Storage Devices ......................................................................................50
Figure 4-21: Camera Application ................................................................................................50
Figure 4-22: Barcode Reader Setup Tool...................................................................................51
Figure 4-23: Barcode Reader Setup Page..................................................................................51
Figure 4-24: RFID Application .....................................................................................................52
Figure 4-25: Tag Information.......................................................................................................53

MODAT-335A Field Service Terminal
Page X
List of Tables
Table 1-1: Model Variations...........................................................................................................2
Table 1-2: MODAT-335A Specifications .....................................................................................10
Table 2-1: Packing List.................................................................................................................14
Table 2-2: Optional Items List .....................................................................................................15
Table 3-1: RS-232 Serial Port Pinouts ........................................................................................27
Table 4-1: Function Buttons........................................................................................................33