INVENTIA MT-151 User manual

Telemetry Module
GSM/GPRS Telemetry Module for
monitoring and control
User Manual
MT-151 LED V2
Class 1 Telecommunications Terminal Equipment for
GSM 850/900/1800/1900
UMTS 800/850/900/1900/2100
INVENTIA Sp. z o.o.
MT-151 LED V2
v2.03

Wszelkie prawa zastrzeżone. Żaden fragment niniejszego dokumentu nie może być powielanylub kopiowanyw
żadnej formie bezwzględu na stosowaną technologię – graficzną, elektroniczną lub mechaniczną, włączając
fotokopiowanie i/lub zapis cyfrowy, równieżw systemach przechowywania i wyszukiwania dokumentów – bez
pisemnej zgodyWydawcy.
Nazwyproduktów wymienionych w niniejszym dokumencie mogą być Znakami Towarowymi i/lub zastrzeżonymi
Znakami Towarowymi należącymi do odpowiednich Właścicieli. Wydawca i Autor oświadczają, że nie roszczą do tych
znaków towarowych żadnych praw.
Pomimo, że niniejsze opracowanie tworzone było zzachowaniem wszelkiej należytej staranności, zarówno
Wydawca jak i Autor nie ponoszą żadnej odpowiedzialności za błędylub pominięcia w jego treści jak równieżza
stratywynikłe zwykorzystania zawartej w niniejszym opracowaniu informacji lub ewentualnie towarzyszącego jej
oprogramowania. Wżadnym wypadku Wydawca lub Autor nie będą odpowiedzialni za utratę zysku lub inne straty,w
tym handlowe, spowodowane lub rzekomo związane, bezpośrednio lub pośrednio, zniniejszym opracowaniem.
All rights reserved. No parts of this work maybe reproduced in anyform or byanymeans - graphic, electronic, or
mechanical, including photocopying, recording, taping, or information storage and retrieval systems - without the
written permission of the publisher.
Products that are referred to in this document maybe either trademarks and/or registered trademarks of the
respective owners. The publisher and the author make no claim to these trademarks.
While everyprecaution has been taken in the preparation of this document, the publisher and the author assume no
responsibilityfor errors or omissions, or for damages resulting from the use of information contained in this
document or from the use of programs and source code that mayaccompanyit.In no event shall the publisher and
the author be liable for anyloss of profit or anyother commercial damage caused or alleged to have been caused
directlyor indirectlybythis document.
Mobicon MT-151 LED V2 User Manual
© 2019 Inventia Sp. z o.o.
Publisher:
MT-151 LED V2
v2.03.01
1/2/2019
Edition:
Firmware compability:
2.03
INVENTIASp. z o.o.
ul. Kulczyńskiego 14
02-777 Warszawa
Tel: [phone]
[e-mail]
www.inventia.pl
Require MTManager:
5.2.3.27 or higher

I
Index
© 2019 Inventia Sp. z o.o.
INDEX
I Module destination 1
II GSM requirements 2
III How to use the manual 3
IV Required programs 4
V Module design 5
................................................................................................................................... 51 Hardware resources
.......................................................................................................................................................... 6Binary inputs .......................................................................................................................................................... 6Binary outputs
.......................................................................................................................................................... 6Analog inputs 4-20mA
.......................................................................................................................................................... 6Analog inputs 0-10V
.......................................................................................................................................................... 6Serial ports .......................................................................................................................................................... 6Ethernet port .......................................................................................................................................................... 6USBport .......................................................................................................................................................... 7SD card reader
.......................................................................................................................................................... 7Real time clock
................................................................................................................................... 72 Internal resources
.......................................................................................................................................................... 7Logger .......................................................................................................................................................... 7Registers .......................................................................................................................................................... 8Counters .......................................................................................................................................................... 8Timers .......................................................................................................................................................... 8MT2MT buffer .......................................................................................................................................................... 8Constant parameters
.......................................................................................................................................................... 8System flags .......................................................................................................................................................... 8Control program
................................................................................................................................... 103 LEDs
................................................................................................................................... 104 SIM cardsslots
................................................................................................................................... 105 Antenna
................................................................................................................................... 106 Power supply
................................................................................................................................... 107 Enclosure
VI Connection diagrams 11
................................................................................................................................... 111 Binary inputs
................................................................................................................................... 122 Binary outputs
................................................................................................................................... 123 Analog inputs 4-20mA
................................................................................................................................... 134 Analog inputs0-10V
................................................................................................................................... 145 Communication ports
................................................................................................................................... 156 GSM antenna
................................................................................................................................... 167 SIM card installation
................................................................................................................................... 178 SD memory card installation
................................................................................................................................... 189 Power supply

Mobicon MT-151 LED V2 User Manual
II
© 2019 Inventia Sp. z o.o.
VII Starting the module 19
VIII Interfaces and communication methods 21
................................................................................................................................... 211 Serial ports
.......................................................................................................................................................... 21Transparent mode
.......................................................................................................................................................... 21Modbus Master mode
.......................................................................................................................................................... 22Modbus Slave mode
.......................................................................................................................................................... 22Flex Serial .......................................................................................................................................................... 23M-Bus
................................................................................................................................... 242 Ethernet port
.......................................................................................................................................................... 24Modbus TCP Client
.......................................................................................................................................................... 25Modbus TCP Server
................................................................................................................................... 253 Remote communication
.......................................................................................................................................................... 25Dual-SIM
................................................................................................................................... 254 SNMP protocol
................................................................................................................................... 275 IEC 60870-5-104 protocol
IX Configuration 29
................................................................................................................................... 291 Header
.......................................................................................................................................................... 29Module name
.......................................................................................................................................................... 29Module type .......................................................................................................................................................... 30Module serial number
.......................................................................................................................................................... 30Modem firmware version
.......................................................................................................................................................... 30IMEI number .......................................................................................................................................................... 30Firmware version
.......................................................................................................................................................... 30Configuration file version
.......................................................................................................................................................... 30Configuration identifier
.......................................................................................................................................................... 30Last configuration date
.......................................................................................................................................................... 31Last reading time
................................................................................................................................... 312 General
.......................................................................................................................................................... 31Device identifier
.......................................................................................................................................................... 31Module IP .......................................................................................................................................................... 32Configuration password
.......................................................................................................................................................... 32Configuration read disable
.......................................................................................................................................................... 32Error display time
.......................................................................................................................................................... 32Recipient UDP port
.......................................................................................................................................................... 33UDP data frame format
.......................................................................................................................................................... 33GPRS transmission retries number
.......................................................................................................................................................... 33Transmission timeout
.......................................................................................................................................................... 33Time synchronization
.......................................................................................................................................................... 34Module phone number (SIM1/SIM2)
.......................................................................................................................................................... 34Set local time
.......................................................................................................................................................... 34Transmission channel
.......................................................................................................................................................... 35Address .......................................................................................................................................................... 35Time sync interval (days)
................................................................................................................................... 353 GSM
.......................................................................................................................................................... 35Number of SIM cards
.......................................................................................................................................................... 35Use of GPRS .......................................................................................................................................................... 36Use of SMS .......................................................................................................................................................... 36SIM1 ......................................................................................................................................................... 36Address IP
......................................................................................................................................................... 36SIMcard PINnumber
......................................................................................................................................................... 37APNname

III
Index
© 2019 Inventia Sp. z o.o.
......................................................................................................................................................... 37Authorization
......................................................................................................................................................... 37APNuser name
......................................................................................................................................................... 37APNpassword
......................................................................................................................................................... 37GPRS testing interval (ping)
......................................................................................................................................................... 38GPRS testing address (ping)
......................................................................................................................................................... 38Roaming .......................................................................................................................................................... 38SIM2 ......................................................................................................................................................... 38Address IP
......................................................................................................................................................... 39SIMcard PINnumber
......................................................................................................................................................... 39APNname......................................................................................................................................................... 39Authorization
......................................................................................................................................................... 39APNuser name
......................................................................................................................................................... 39APNpassword
......................................................................................................................................................... 40GPRS testing interval (ping)
......................................................................................................................................................... 40GPRS testing address (ping)
......................................................................................................................................................... 40Roaming .......................................................................................................................................................... 40GPRS ......................................................................................................................................................... 41Sender IPaddress control
......................................................................................................................................................... 41Wait time after disconnection
.......................................................................................................................................................... 41SMS ......................................................................................................................................................... 41Daily SMS limit
......................................................................................................................................................... 42Number of SMS sending retries
......................................................................................................................................................... 42SMS limit exceed information
......................................................................................................................................................... 42Recipient of SMS limit exceed information
......................................................................................................................................................... 42Answer for blank SMS
......................................................................................................................................................... 42Incoming SMS handling
......................................................................................................................................................... 44Buffer address holding incoming SMS (HREG)
......................................................................................................................................................... 44Buffer address holding sender phone number (HREG)
......................................................................................................................................................... 44Buffer address holding outgoing SMS (HREG)
......................................................................................................................................................... 45Buffer address holding receiver phone number (HREG)
......................................................................................................................................................... 45Formats ......................................................................................................................................... 45Date format ......................................................................................................................................... 45Time format
......................................................................................................................................................... 46Symbolic names ......................................................................................................................................... 46Number of symbolic names
......................................................................................................................................... 46Symbolic name table
......................................................................................................................................................... 46Macros ......................................................................................................................................... 47Number of macros
......................................................................................................................................... 47Macro table
.......................................................................................................................................................... 47Authorized numbers
......................................................................................................................................................... 47Number of phone numbers
......................................................................................................................................................... 47Number of IPaddresses
......................................................................................................................................................... 48Numbers fromSIMphone-book always allowed
......................................................................................................................................................... 48Phone ......................................................................................................................................................... 48IP
................................................................................................................................... 494 Resources
.......................................................................................................................................................... 49Binary inputs (I1 - I16)
......................................................................................................................................................... 49Name ......................................................................................................................................................... 49Input type ......................................................................................................................................................... 49Filtering ......................................................................................................................................................... 49Flow calculation trigger
......................................................................................................................................................... 50Flow scaling
......................................................................................................................................................... 50Impulse weight - multiplier
......................................................................................................................................................... 50Impulse weight - divider
......................................................................................................................................................... 51Offset - engineering units
......................................................................................................................................................... 51Hi alarm- engineering units
......................................................................................................................................................... 51Lo alarm- engineering units
......................................................................................................................................................... 51Alarmhysteresis - engineering units

Mobicon MT-151 LED V2 User Manual
IV
© 2019 Inventia Sp. z o.o.
.......................................................................................................................................................... 52Binary outputs (Q1 - Q12)
......................................................................................................................................................... 52Name ......................................................................................................................................................... 52Input type ......................................................................................................................................................... 52Filtering .......................................................................................................................................................... 52Analog inputs 4-20mA (AI1 - AI4)
......................................................................................................................................................... 52Sampling frequency
......................................................................................................................................................... 53Name ......................................................................................................................................................... 53Engineering units
......................................................................................................................................................... 53Low reference - internal units
......................................................................................................................................................... 53Low reference - engineering units
......................................................................................................................................................... 54High reference - internal units
......................................................................................................................................................... 54High reference - engineering units
......................................................................................................................................................... 54HiHi alarm- engineering units
......................................................................................................................................................... 54Hi alarm- engineering units
......................................................................................................................................................... 54Lo alarm- engineering units
......................................................................................................................................................... 55LoLo alarm- engineering units
......................................................................................................................................................... 55Alarmhysteresis - engineering units
......................................................................................................................................................... 55Deadband - engineering units
.......................................................................................................................................................... 55Analog inputs 0-10V (AV1 - AV2)
......................................................................................................................................................... 55Name ......................................................................................................................................................... 56Engineering units
......................................................................................................................................................... 56Low reference - internal units
......................................................................................................................................................... 56Low reference - engineering units
......................................................................................................................................................... 56High reference - internal units
......................................................................................................................................................... 56High reference - engineering units
......................................................................................................................................................... 57HiHi alarm- engineering units
......................................................................................................................................................... 57Hi alarm- engineering units
......................................................................................................................................................... 57Lo alarm- engineering units
......................................................................................................................................................... 57LoLo alarm- engineering units
......................................................................................................................................................... 57Alarmhysteresis - engineering units
......................................................................................................................................................... 58Deadband - engineering units
.......................................................................................................................................................... 58Counters (CNT1 - CNT16)
......................................................................................................................................................... 58Incrementing input
......................................................................................................................................................... 58Active edge of incrementing input
......................................................................................................................................................... 58Decrementing input
......................................................................................................................................................... 59Active edge of decrementing input
......................................................................................................................................................... 59Counting range (32 bits)
.......................................................................................................................................................... 59Timers ......................................................................................................................................................... 59Synchronous timers (CT1 - CT16)
......................................................................................................................................... 59Start [HH:MM] ......................................................................................................................................... 59Period ......................................................................................................................................... 60Days of week ......................................................................................................................................... 60Days of month ......................................................................................................................................... 60Months
......................................................................................................................................................... 61Asynchronous timers (CK1 - CK16)
......................................................................................................................................... 61Activating input ......................................................................................................................................... 61Reset input ......................................................................................................................................... 61Timer time unit ......................................................................................................................................... 62Counting range in timer units
.......................................................................................................................................................... 62Constant parameters
......................................................................................................................................................... 62Number of constant parameters
......................................................................................................................................................... 62Number of constant parameters (textual)
......................................................................................................................................................... 62Parameter 1 - 128
......................................................................................................................................................... 62Parameter 1....72 (textual)
.......................................................................................................................................................... 62SD card ......................................................................................................................................................... 62Use of card
......................................................................................................................................................... 63Start ......................................................................................................................................................... 63Period

V
Index
© 2019 Inventia Sp. z o.o.
......................................................................................................................................................... 63Delete data older than
......................................................................................................................................................... 63Delete data when low on memory
................................................................................................................................... 635 Communication ports
.......................................................................................................................................................... 64Modbus ID- Port 1
.......................................................................................................................................................... 64Modbus ID- Port 2
.......................................................................................................................................................... 64Modbus ID- Ethernet
.......................................................................................................................................................... 64Modbus ID- GPRS
.......................................................................................................................................................... 64Port 1/Port 2 ......................................................................................................................................................... 64Operating mode
......................................................................................................................................................... 65Interface type
......................................................................................................................................................... 65Transmission speed
......................................................................................................................................................... 66Number of data bits
......................................................................................................................................................... 66Stop bits ......................................................................................................................................................... 66Parity ......................................................................................................................................................... 66Modbus ......................................................................................................................................................... 67Transparent mode ......................................................................................................................................... 67Max. data packet size
......................................................................................................................................... 67Data frame delimiter
......................................................................................................................................... 67Channel reservation time
......................................................................................................................................................... 67Modbus Master mode
......................................................................................................................................... 67Delay after error in communication with Slave
......................................................................................................................................... 68Number of read/write data blocks
......................................................................................................................................... 68Response timeout [s]
......................................................................................................................................... 68Data blocks (read/write)
................................................................................................................................... 68Modbus Slave ID
................................................................................................................................... 68Address space in Slave
................................................................................................................................... 69Mapped space address - Slave
................................................................................................................................... 69Mapped space size
................................................................................................................................... 69Mapped space address - Module
................................................................................................................................... 69Mapped space refresh interval
......................................................................................................................................................... 69Flex Serial mode ......................................................................................................................................... 70Max. data packet size [byte]
......................................................................................................................................... 70Data frame delimiter [s]
......................................................................................................................................................... 70M-Bus mode ......................................................................................................................................... 70Transmission speed [bod]
......................................................................................................................................... 70Number of device
......................................................................................................................................... 70Addressing ......................................................................................................................................... 71M-BUS device (DEVx)
................................................................................................................................... 71Name ................................................................................................................................... 71Addressing method
................................................................................................................................... 71Address ................................................................................................................................... 71Serial number ................................................................................................................................... 72Restart communication before reading
................................................................................................................................... 72Bytes order ................................................................................................................................... 72Pooling interval [min]
................................................................................................................................... 72Number of variables
................................................................................................................................... 72Variable table
.......................................................................................................................................................... 74Ethernet ......................................................................................................................................................... 74Use of Ethernet
......................................................................................................................................................... 75Ethernet port speed
......................................................................................................................................................... 75Sender IPaddress control
......................................................................................................................................................... 75IPaddress......................................................................................................................................................... 75Subnet mask
......................................................................................................................................................... 76Default gateway
......................................................................................................................................................... 76IProuting table entry count
......................................................................................................................................................... 76Routing IP ......................................................................................................................................................... 76Authorized IPaddresses
......................................................................................................................................... 76Number of IPaddresses

Mobicon MT-151 LED V2 User Manual
VI
© 2019 Inventia Sp. z o.o.
......................................................................................................................................... 76IP ......................................................................................................................................................... 77Modbus TCPClient ......................................................................................................................................... 77Delay after error in communication w ith Server
......................................................................................................................................... 77Number of read/write data blocks
......................................................................................................................................... 77Response timeout
......................................................................................................................................... 78Ethernet IP ......................................................................................................................................... 78Server Modbus ID
......................................................................................................................................... 78Address space in Server
......................................................................................................................................... 78Mapped space address - Server
......................................................................................................................................... 78Mapped space size
......................................................................................................................................... 79Mapped space address - Module
......................................................................................................................................... 79Mapped space refresh interval [s]
.......................................................................................................................................................... 79Routing tables
......................................................................................................................................................... 79Number of Modbus routing table rules
......................................................................................................................................................... 79Number of Transparent routing table rules
......................................................................................................................................................... 80Modbus routing table
......................................................................................................................................................... 81Transparent routing table
................................................................................................................................... 816 Communication
.......................................................................................................................................................... 81MT2MT buffer
......................................................................................................................................................... 82Active ......................................................................................................................................................... 82Buffer address
......................................................................................................................................................... 82Buffer size
.......................................................................................................................................................... 82Logger ......................................................................................................................................................... 82Primary transmission channel
......................................................................................................................................................... 83Primary Recipient
......................................................................................................................................................... 83Alternative transmission channel
......................................................................................................................................................... 83Alternative Recipient
......................................................................................................................................................... 83Recipient UDPport
......................................................................................................................................................... 83Number of logger data blocks
......................................................................................................................................................... 83Logger data block table
.......................................................................................................................................................... 84Events ......................................................................................................................................................... 84Number of events
......................................................................................................................................................... 84Event table
.......................................................................................................................................................... 84Data blocks ......................................................................................................................................................... 85Number of data blocks
......................................................................................................................................................... 85Data block table
.......................................................................................................................................................... 85Rules ......................................................................................................................................................... 85Number of rules
......................................................................................................................................................... 85Recipient UDPport
......................................................................................................................................................... 85Rule ......................................................................................................................................... 85Name ......................................................................................................................................... 86Triggering event ......................................................................................................................................... 86Transmission type
......................................................................................................................................... 86Receiver ......................................................................................................................................... 86SMS text ......................................................................................................................................... 87Data block
.......................................................................................................................................................... 87SNMP ......................................................................................................................................................... 87Community string - read
......................................................................................................................................................... 87Community string - read/write
......................................................................................................................................................... 87Trap handling
......................................................................................................................................................... 87Request handling
......................................................................................................................................................... 88Traps ......................................................................................................................................... 88Number of trap receivers
......................................................................................................................................... 88Number of traps ......................................................................................................................................... 88Trap data source......................................................................................................................................... 88Trap receivers ......................................................................................................................................... 88Trap table
......................................................................................................................................................... 90Requests

VII
Index
© 2019 Inventia Sp. z o.o.
......................................................................................................................................... 90Number of request receivers
......................................................................................................................................... 90Request count ......................................................................................................................................... 90Request receivers
......................................................................................................................................... 90Request table ................................................................................................................................... 90Triggering bit ................................................................................................................................... 91Triggering slope................................................................................................................................... 91Receiver address
................................................................................................................................... 91OID ................................................................................................................................... 91Destination register address
................................................................................................................................... 92Read flag ................................................................................................................................... 92Error flag
.......................................................................................................................................................... 92Spooler ......................................................................................................................................................... 92Triggering event
......................................................................................................................................................... 93Transmission channel
......................................................................................................................................................... 93Address .......................................................................................................................................................... 93IEC 60870-5-104
......................................................................................................................................................... 93Common address
......................................................................................................................................................... 93T1 [s] ......................................................................................................................................................... 93T2 [s] ......................................................................................................................................................... 94T3 [s] ......................................................................................................................................................... 94K ......................................................................................................................................................... 94W ......................................................................................................................................................... 94Number of variables
......................................................................................................................................................... 94Event count
......................................................................................................................................................... 94Time synchronization
......................................................................................................................................................... 95Variable table
......................................................................................................................................................... 95Group table
......................................................................................................................................................... 95Event table
................................................................................................................................... 967 Presets
.......................................................................................................................................................... 96Counters (CNT1 - CNT16)
X Problem solving 98
................................................................................................................................... 981 LED signaling
.......................................................................................................................................................... 98Binary inputs I1 - I16
.......................................................................................................................................................... 98Binary outputs/inputs Q1 - Q12
.......................................................................................................................................................... 99GSM status .......................................................................................................................................................... 99Signal level .......................................................................................................................................................... 100GSM activity.......................................................................................................................................................... 100Serial ports activity
.......................................................................................................................................................... 100Ethernet status
.......................................................................................................................................................... 101Module status
................................................................................................................................... 1012 MT-151 LED Error signaling
.......................................................................................................................................................... 102Standard errors
................................................................................................................................... 1033 Unlocking the SIM card
XI Technical parameters 104
................................................................................................................................... 1041 General
................................................................................................................................... 1042 GSM modem
................................................................................................................................... 1043 Power supply
................................................................................................................................... 1044 Binary inputs
................................................................................................................................... 1055 Binary outputs
................................................................................................................................... 1056 Analog inputs 4-20mA
................................................................................................................................... 1057 Analog inputs0-10V