Jayco CLASS C2013 GREYHAWK User manual

2013 GREYHAWK
CLASS C MOTORHOMES
0188485.2013

GREYHAWK CLASS C TABLE OF CONTENTS
I
WARNING: READ ALL INSTRUCTIONS IN THIS MANUAL AND COMPONENT
MANUFACTURER SUPPLIED INFORMATION BEFORE USING YOUR RV.
This manual has been provided by Jayco, Inc. for the sole purpose of providing
instructions concerning the operation and maintenance of this vehicle and its
components. Nothing in this manual creates any warranty, either expressed or
implied. The only warranty offered by Jayco, Inc. is as set forth in the limited
warranty applicable to this vehicle.
The owner’s failure to provide required service and/or maintenance could result in
the loss of warranty. The owner should review Jayco’s limited warranty and the
limited warranties that apply to specific components that are offered with this
vehicle.
Instructions are included in the manual for operating various components which are
optional on some vehicles. In addition, the owner should refer to individual
manufacturer’s operating instructions contained in the owner’s packet.

TABLE OF CONTENTS GREYHAWK CLASS C
II
Section 1: WARRANTY &SERVICE
About This Manual.................................................................................... 1-1
Chassis Guide...................................................................................................... 1-1
Customer Relations.............................................................................................. 1-4
Customer Responsibility....................................................................................... 1-3
Dealer Responsibility............................................................................................ 1-3
Jayco Customer First Emergency Roadside Assistance ...................................... 1-6
JayPlus™ Extended Service Contract.................................................................. 1-6
Jayco Travel Club................................................................................................. 1-5
Manufacturing Process......................................................................................... 1-3
Motorized Limited Warranty.................................................................................. 1-9
Motorized Rental Limited Warranty .....................................................................1-14
A Notice To Jayco Dealers..................................................................................1-13
Obtaining Emergency Warranty Repair................................................................ 1-6
Obtaining Service At Jayco .................................................................................. 1-7
Obtaining Service For Separately Warranted Items ............................................. 1-7
Replacement Parts............................................................................................... 1-8
Reporting Safety Defects...................................................................................... 1-2
Safety Alerts......................................................................................................... 1-1
Suggestions For Obtaining Service...................................................................... 1-4
Update Your Contact Information......................................................................... 1-5
Warranty Packet................................................................................................... 1-1
Section 2: OCCUPANT SAFETY
Combination Carbon Monoxide/Propane Alarm ................................................... 2-4
Cold Weather Usage............................................................................................ 2-8
Condensation ....................................................................................................... 2-8
Extended Dry Camping ...................................................................................... 2-7
Fire Extinguisher ................................................................................................. 2-1
Fire Safety............................................................................................................ 2-1
Formaldehyde....................................................................................................... 2-7
Other Fire Safety Information ............................................................................... 2-1
Secondary Means Of Escape............................................................................... 2-1
Smoke Alarm........................................................................................................ 2-2
SECTION 3: PRE-TRAVEL INFORMATION
Exterior Compartments......................................................................................... 3-1
Loading Your RV.................................................................................................. 3-1
Trailer Plug........................................................................................................... 3-4
Using The Rear Hitch ........................................................................................... 3-2
Vehicle Labels...................................................................................................... 3-1
Weighing Your Motor Home ................................................................................. 3-5
Weight Labels....................................................................................................... 3-4
SECTION 4: VEHICLE OPERATION
Braking & Stopping................................................................................... 4-6
Changing A Tire.................................................................................................... 4-8
Child Safety Restraint Systems............................................................................ 4-2
Driver & Front Passenger Seat .......................................................................... 4-2
Emergency Stopping............................................................................................ 4-9
Emergency Towing..............................................................................................4-10
Entrance Door ...................................................................................................... 4-1

GREYHAWK CLASS C TABLE OF CONTENTS
III
Front Axle Tire Alignment..................................................................................... 4-6
Instrument Panel................................................................................................... 4-3
Keys/Locks........................................................................................................... 4-1
Leveling Jacks...................................................................................................... 4-4
Parking Brake....................................................................................................... 4-6
Power Entry Door Step......................................................................................... 4-1
Rear Vision Camera ............................................................................................. 4-3
Seat Belts............................................................................................................. 4-2
Side View Power Mirrors ...................................................................................... 4-3
Tires...................................................................................................................... 4-7
Wheel Lugs/Wheel Liners..................................................................................... 4-8
Wheel Bearings & Brakes..................................................................................... 4-9
SECTION 5: SLIDEOUT SYSTEMS
Operating the Slideout.......................................................................................... 5-2
Transit Bars (If So Equipped) ............................................................................. 5-1
Troubleshooting the Slideout................................................................................ 5-3
SECTION 6: 30 AMP ELECTRICAL SYSTEM
120-volt Circuit Breakers .................................................................................... 6-2
120-volt AC System ............................................................................................ 6-2
12-volt Battery Disconnect .................................................................................. 6-6
12-volt DC Outlet (If So Equipped) .................................................................... 6-10
12-volt DC System .............................................................................................. 6-6
12-volt Fuse Panel .............................................................................................. 6-8
30 amp Power Cord ............................................................................................ 6-3
Approximate Electrical Load Ratings ................................................................ 6-11
Auxiliary Start System ......................................................................................... 6-6
Calculating Electrical Load ................................................................................. 6-5
Chassis Batteries ................................................................................................ 6-8
Command Center ............................................................................................... 6-2
Electrical System Maintenance ........................................................................... 6-1
Generator ........................................................................................................... 6-9
GFCI Receptacle Outlet ...................................................................................... 6-5
House Batteries .................................................................................................. 6-7
In Case Of An Electrical Fire .............................................................................. 6-1
Inverter ............................................................................................................. 6-10
Isolator Solenoid ................................................................................................. 6-8
Replacing Light Bulbs ....................................................................................... 6-10
Power Converter ............................................................................................... 6-4
SECTION 7: FUEL &PROPANE SYSTEM
Calculating Propane Usage.................................................................................. 7-8
Cooking With Propane Gas.................................................................................. 7-8
Exhaust Gas Fumes............................................................................................. 7-2
Fuel Economy....................................................................................................... 7-2
Fuel Safety ........................................................................................................... 7-1
Propane Gas Container........................................................................................ 7-5
Propane Gas System............................................................................................ 7-3
Propane Leak Test ............................................................................................... 7-4
Propane Safety Procedures.................................................................................. 7-5
Traveling With Propane...................................................................................... 7-10
Using The Propane System.................................................................................. 7-7

TABLE OF CONTENTS GREYHAWK CLASS C
IV
SECTION 8: PLUMBING SYSTEM
12-volt Water Pump & Switch............................................................................... 8-3
Bathroom Tub/Shower ........................................................................................ 8-7
Black & Grey Tank Drains .................................................................................8-14
Black Tank Flush (If So Equipped) .....................................................................8-15
Black/Grey Water Holding Tanks .......................................................................8-13
Black/Grey Water System ..................................................................................8-13
City Water Fill ..................................................................................................... 8-9
City Water Tank Fill ...........................................................................................8-10
Country Water Fill ..............................................................................................8-10
Draining the Fresh Water System ....................................................................... 8-8
Faucets ............................................................................................................... 8-6
Fresh Water Holding Tank .................................................................................. 8-2
Fresh Water System ........................................................................................... 8-1
Hardware & Sink or Shower Fixtures .................................................................. 8-7
Monitor Panel ..................................................................................................... 8-1
Outside Shower .................................................................................................. 8-6
Plumbing System Maintenance .......................................................................... 8-1
Sanitization ........................................................................................................8-11
Toilet ..................................................................................................................8-15
Utility Center ....................................................................................................... 8-8
Utility Center Normal Setting ...........................................................................8-10
Water Heater .................................................................................................... 8-3
Water Pressure Regulator (Customer Supplied) ................................................ 8-2
Water Purification System ................................................................................... 8-7
Winterization........................................................................................................8-12
SECTION 9: HEATING &COOLING
Air Conditioner ..................................................................................................... 9-1
Attic Fan .............................................................................................................. 9-1
Ducting & Return Air ........................................................................................... 9-1
Furnace ............................................................................................................ 9-1
Thermostat .......................................................................................................... 9-1
SECTION 10: APPLIANCES
BBQ Grill (If So Equipped) ..................................................................................10-2
Cooking With Propane ........................................................................................10-1
In Case of Grease Fire ......................................................................................10-2
Kitchen Range & Oven (If So Equipped) .........................................................10-1
Oven (If So Equipped).........................................................................................10-2
Microwave ...........................................................................................................10-1
Refrigerator..........................................................................................................10-1
SECTION 11: ELECTRONICS
Exterior Television (If So Equipped) ...................................................................11-2
Television Power Supply .................................................................................11-1
Television Roof Antenna .....................................................................................11-1
SECTION 12: INTERIOR
ABS Plastics .......................................................................................................12-4
Bed Storage ........................................................................................................12-2
Booth Dinette (If So Equipped) ...........................................................................12-1
Cabinetry & Tables .............................................................................................12-3

GREYHAWK CLASS C TABLE OF CONTENTS
V
Cleaning The Interior ......................................................................................... 12-1
Countertops ....................................................................................................... 12-3
Décor Items ........................................................................................................ 12-3
Flooring............................................................................................................... 12-4
Free Standing Table & Chairs (If So Equipped) ................................................. 12-1
Furniture Upholstery .......................................................................................... 12-2
Hide-A-Bed (If So Equipped) .............................................................................. 12-1
Interior Wall Panel .............................................................................................. 12-4
Pantry................................................................................................................. 12-3
Privacy Drape Installation................................................................................... 12-2
SECTION 13: EXTERIOR
Chassis Maintenance ........................................................................................ 13-4
Cleaning The Exterior......................................................................................... 13-1
Exterior Roof & Sidewall Vents .......................................................................... 13-4
Frame ................................................................................................................ 13-4
Patio Awning ...................................................................................................... 13-1
Roof Ladder (If So Equipped)............................................................................. 13-1
Sealants.............................................................................................................. 13-4
Windows............................................................................................................. 13-4
SECTION 14: TRAVEL/CAMPING/STORAGE CHECKLISTS
Departing Camp Checklist ................................................................................. 14-3
Motor Home Storage .......................................................................................... 14-4
Ready to Leave Checklist................................................................................... 14-2
RV Start-Up ........................................................................................................ 14-1
SECTION 15: ADDITIONAL INFORMATION
Featured Components Quick Reference Chart .................................................. 15-1
Change of Address/Ownership Form.................................................................. 15-3

TABLE OF CONTENTS GREYHAWK CLASS C
VI
THIS PAGE IS INTENTIONALLY BLANK

CLASS C MOTOR HOMES SECTION 1 – WARRANTY & SERVICE
1 - 1
Congratulations! Thank you for selecting a Jayco RV. We are excited to
welcome you to our growing RV family. Jayco is the largest privately held
manufacturer of recreation vehicles in the world. We are committed to being the
most respected name in RVs. We invite you to drop by our Visitors Center located
in Middlebury, Indiana. To book a group tour or check our scheduled factory tour
times (free admission, closed holidays) please call 1-800-RV-JAYCO.
ABOUT THIS MANUAL
This manual is a guide to the operation and maintenance of your RV. Jayco RVs
are available in several sizes and models, so accessories and components may
differ. Some equipment described in this manual may not apply to your RV. If you
find the components vary significantly from what is described, contact your dealer
to ensure you have the correct information. Nothing in this manual creates any
warranty, either expressed or implied, nor does it cover every possible detail of
equipment, standard or option, installed on or in your RV.
Information, illustrations and specifications in this manual reflect the most current
available at the time of publication approval, are subject to change and not
intended to indicate actual size.
WARRANTY PACKET
The Warranty Packet contains original equipment manufacturer (OEM) operator
manuals, warranty cards and/or registrations. It is important you complete and
mail the warranty cards and registrations within the prescribed time limits to avoid
loss of warranty coverage. This manual and the Warranty Packet should be
considered a permanent part of the RV. If the RV is sold, they should remain with
the RV for the next owner.
CHASSIS GUIDE
Throughout this manual, frequent reference is made to the vehicle’s Chassis
Guide.
The Chassis guide refers to the chassis manufacturer’s owner manual, warranty
cards and/or registrations. The chassis guide has pertinent information regarding
the transmission, tires, etc. consult the Chassis Guide for operating safety,
maintenance, servicing instructions and warranty coverage.
SAFETY ALERTS
Your safety, and the safety of others, is very important. To help you make
informed decisions, we have provided operating procedures and other information
on safety labels affixed to your RV and in this manual.
Please call your dealer or Jayco Customer Service if you are unsure how to
proceed. Always use the appropriate safety gear when servicing or maintaining
your RV.
This is the safety alert symbol. It is used to alert you to potential personal
injury hazards. Obey all safety messages that follow this symbol to avoid possible
injury or death.

SECTION 1 – WARRANTY & SERVICE CLASS C MOTOR HOMES
1 - 2
REPORTING SAFETY DEFECTS
In the United States
If you believe that your RV has an alleged defect that could cause a crash or
cause injury or death, you should immediately inform the National Highway Traffic
Safety Administration (NHTSA) and Jayco.
If NHTSA receives similar complaints, it may open an investigation, and if it finds
that a safety defect exists in a group of vehicles it may order a recall and remedy
campaign. However, NHTSA cannot become involved in individual problems
between you, your dealer or Jayco. For additional information, please refer to the
NHTSA website at www.safercar.gov.
To contact NHTSA by phone:
Call the Department of Transportation (DOT) Vehicle Safety Hotline at 1-888- 327-
4236 and a NHTSA representative will record your complaint information (TTY: 1-
800-424-9153 or 1-202-484-5238).
To contact NHTSA by mail:
Office of Defects Investigations/CRD
NVS-216
1200 New Jersey Ave SE
Washington, DC 20590
In Canada
If you believe your RV has an alleged safety defect, you should contact Transport
Canada and Jayco. Transport Canada prefers to be called instead of posted mail
or email as it enables their investigators to confirm that your information is correct,
and to answer your questions accurately. For additional information, please refer
to the Transport Canada website at www.tc.gc.ca.
DANGER
This indicates an imminently hazardous situation which, if not
avoided, will result in death or serious in
j
ur
y
.
WARNING
This indicates a potentially hazardous situation which, if not avoided,
will result in death or serious injury.
CAUTION
This indicates a potentially hazardous situation which, if not avoided,
will result in minor or moderate injury.
NOTICE
This indicates a potentially hazardous situation which, if not avoided,
may result in property damage