JohnsonSuisse Venezia JBTV3166 User manual

INSTALLATION GUIDE
Venezia
Wall-Faced Bath
1660 1620
1170
800
660
500
20 20
300
10
20
580
595
1650 795
15
450
120
800
1660
JBTV3166
P.1

INSTALLATION
Installation must be carried out by a licensed plumber in compliance with the Plumbing Code of Australia..
Check local and national building regulations before installation to ensure the below methods comply with
the relevant codes.
Tools required for installation: Silicone Gun, Spirit Level, Tape Measure, Pencil, Adjustable Spanner.
1. Inspect bath thoroughly before installation. Claims for defects and/or damage must be made before
installation commences.
2. Place bath in intended position against the wall and mark out position on the finished floor.
3. Check level by placing spirit level across the width and length of bath, then adjust feet to suit.
Ensure the bath is fully supported on all feet.
4. Install feet-lockers for the back feet (two, close to wall - fig.3 and fig.5), push feet under, and connect
waste to drainage using approved methods [Fig.1 and Fig.4].
5. Apply silicone or polyurethane to feet and bottom of bath skirt to secure to place.
6. Conduct final water test on bath to ensure water drains to waste.
7. Allow silicone 24 hours minimum curing time.
Note: Hot water applied to this product must not exceed 55o
C.
Floor Trap is not included.
Plug & Waste
Plug & Waste Extension
Smart Waste rubber sealSmart Waste
o
100 mm 90 Elbow
Figure 1
INSTALLATION GUIDE
Venezia
Wall-Faced Bath
Villaboard or
water resistant
wall lining
Sealant
Tiles or wall
sheeting
Wall
Structure
Figure 2
Install the Bath into the wall as per detail in Figure 2.
8.
Timber
Support
Figure 3
P.2

Your Venezia Wall-Faced Bath is manufactured using Lucite®
sanitary grade acrylic.
To maintain your bath’s high gloss finish, please follow these simple instructions:
General Cleaning
Wipe acrylic with a mild soap or detergent and lukewarm water solution, using a clean microfiber cloth. Rinse well, wring
out microfiber cloth and wipe again to remove moisture and streaking.
Deep Cleaning
Work into surface a thin, even coat of Ultra Gloss Bathroom Cleaner & Polish, using a soft cotton towel. Lightly
buff off excess residue with a dry portion of your towel.
After polishing, wipe with a clean damp microfiber cloth to completely remove excess residue and remove any
electrostatic
charges which may attract dust particles.
Deep scratches can be removed with fine grit wet/dry sand paper and buffed to a shine using Ultra Gloss.
Caution
Window cleaning fluids, scouring compounds, harsh chemical cleaners, gritty cloths, leaded or ethyl gasoline or strong
solvents such as alcohol, acetone, etc. must not be used.
Do not place hot objects such as hair straighteners and curlers directly onto the surface.
Figure 4
Flexible Connector
Waste Trap
Waste Pipe
Plug & Waste
INSTALLATION and CARE GUIDE
Venezia
Wall-Faced Bath
600 max 40mm pop-down
waste with 600mm
flexible connector
PW8 or PW8B
Figure 5
P.3

FOR FURTHER INFORMATION PLEASE
www.johnsonsuisse.com.au
CONTACT YOUR NEAREST MARBLETREND
OFFICE:
HEAD OFFICE (SYDNEY)
2/97 Banksia St, Botany, NSW 2019
T 1300 717 717 F 1300 746 480
MELBOURNE
31 Koornang Rd, Scoresby, VIC 3179
T 1300 717 717 F 1800 225 315
BRISBANE
1/477 Newman Rd, Geebung, QLD 4034
T 1300 717 717 F 1300 746 480
PERTH
27 Harris Rd, Malaga, WA 6090
T 1300 717 717 F 1800 746 480
ADELAIDE
Rep: Terry Hayes
T 0499 221 201 F 1800 225 315
HOBART
Rep: Bob Moore
T 0428 223 116 F 1800 225 315
DUBBO
Rogers Agencies
6 Richard Ryan Pl, Dubbo NSW 2830
T 02 6882 2733 F 02 6882 2169
www.johnsonsuisse.com.au
WARRANTY INFORMATION
This warranty is provided by:
Bathroom Products Australia Pty Ltd
(ABN 87 079 297 617)
2/97 Banksia St
Botany NSW 2019
P 1300 717 717
F 1300 746 480
E [email protected]
Visit www.johnsonsuisse.com.au to view full warranty terms.
Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a
replacement or refund for the major failure and for compensation for any other reasonably foreseeable loss or damage.
You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure
does not amount to a major failure.
R0.1
GENERAL INFORMATION
Venezia
Wall-Faced Bath
P.4