Kenwood DVF-S500 User manual

DVD/VCD/CD PLAYER
DVF-S500
SERVICE MANUAL
© 2003-10 B51-5890-00 (K/K) PDF
In compliance with Federal Regulations, following are repro-
duction of labels on, or inside the product relating to laser
product safety.
KENWOOD Corp. certifies this equipment conforms to DHHS
Regulations No.21 CFR 1040. 10, Chapter 1, subchapter J.
DANGER : Laser radiation when open and interlock defeated.
AVOID DIRECT EXPOSURE TO BEAM.
Caution : No connection of ground line if disassemble
the unit. Please connect the ground line on
rear panel, PCBs, Chassis and some others.
COMPONENT VIDEO
OUT
OUT
VIDEO OPTICAL
AUDIO
DIGITAL OUTPUT
(PCM/BIT STREAM)
12
OUT
Y
R
C
B
C
Panel
(A60-2373-08)
Button
(K29-8341-08)
Stopper
(J42-0358-08)
Ter, rca 3pin
(E63-1335-08)
Cabinet
(A01-3919-08)
Module
(W02-4537-08)
Button
(K29-8339-08)
Filter
(B11-1594-08)
Window assy
(B10-3996-08)
Button
(K29-8342-08)
Cord assy
(E30-7309-08)
Ter, rca 3pin
(E63-1336-08)

Digital Cable (Optical) ...(1)
(E35-3626-08)
Remote control unit ..........(1)
(A70-1645-08)
Video cord (Yellow) .........(1)
(E30-7311-08)
Audio cord (White / Red) ...(1)
(E30-7310-08)
Batteries (R03/"AAA" -size) ...(2)
DVF-S500
2
ACCESSORIES / CAUTIONS
Accessories
Cautions
"DTS" and "DTS Digital Out" are trademarks of
Digital Theater Systems, Inc.
Manufactured under license from Dolby Laboratories.
"Dolby" and the double-D symbol are trademarks of Dolby
Laboratories.
This product incorporates copyright protection technology that is protected by U.S. patents and other intellectual property rights. Use of this copyright
protection technology must be authorized by Macrovision, and is intended for home and other limited viewing uses only unless otherwise authorized
by Macrovision. Reverse engineering or disassembly is prohibited.
Consumers should note that not all high definition television sets are fully compatible with this product and may cause artifacts to be displayed in the
picture. In case of 525 progressive scan picture problems, it is recommended that the user switch the connection to the "STANDARD DEFINITION"
output. If there are questions regarding our TV set compatibility with this model 525p DVD player, please contact our customer service center.
Caution on condensation
Before transporting or moving this unit, carry out
the following operations.
1. Set the (POWER) key to the ON without loading a disc.
2. Wait a few seconds and verify that the display shown appears.
3. Set the (POWER) key to OFF.
Note related to transportation and movement
Condensation (of dew) may occur inside the unit when there is a great differ-
ence in temperature between this unit and the outside. This unit may not fun-
ction properly if condensation occurs. In this case, leave the unit for a few
hours and restart the operation after the condensation has dried up.
Be specially cautious against condensation in the following circumstances:
When this unit is carried from one place to another across a large difference
in temperature, when the humidity in the room where this unit is installed inc-
reases, etc.
CHAP TRACK HOUR
MIN TITLE
Operation to reset
The microprocessor may fall into malfunction (impossibility to operate
erroneous display, etc.) when the power cord is unplugged while
power is ON or due to an external factor.
In this case, switch off the power, wait for several seconds, and then
switch the power on again.
Return to the factory defaults by resetting the microprocessor is done
as shown as follows.
Unplugg the power cord after turn the (POWER) key OFF.
Then, while holding down the (POWER) key, plug the power cord.
Please note that resetting the microcomputer will clear the contents
of the memory and returns the unit to the state it was in when it left
the factory.
CAUTION
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
In compliance with Federal Regulations, the following are reproductions of labels on, or inside the product relating to laser product safety.
KENWOOD CORP. CERTIFIES THIS EQUIPMENT
CONFORMS TO DHHS REGULATIONS NO. 21 CFR
1040.10, CHAPTER 1, SUBCHAPTER J.
Location: Back Panel
KENWOOD CORPORATION
2967-3, ISHIKAWA-CHO,
HACHIOJI-SHI,
TOKYO, JAPAN
For the U.S.A.

3
Refer to the schematic diagram for the value of resistors and capacitors.
PC BOARD
ACEBD
2
1
3
5
7
4
6
CP601
JACK601
CrCb
OUT
COMPONENT VIDEO
Y
OUT
S-VIDEO
21
OPTICAL
DIGITAL OUT
CN201
CP206
CN401
JACK401
CN403
JACK403
JACK402
D401
CP402
D402
D403
Q205
IC201
IC401
IC202
Q206
Q207
Q402
Q403
Q202
Q201
D202
CP304 CP303
CP305 Q307 Q308
D302
CN302
D301
9110
J222
J208
GND202
L402
C410
J415
R421
J401
C419
C416
C401
C432
C433
C431
C420
C418
C425
L410
C402 C403
C404
C408 C409
C406
C405
C421
C422
L401
C219
XT201
EB C229
C227
J211
J210
C233
R212
J207
J206
J205
J204
J214
J203
J202
R406
J414
L404
L409
L403
J411
J201
J413
R409
R410
R408
J404
J403
191
J418
J410
J409
91
11
115
214
J209
C231
R201
R204
DVD CONTROL SIGNAL
GND201
R203
R202
J223
GREEN BLUE RED
1
9
C441
L405 C429
L407
R420
C436
C435
C434
R419
C437
C414
C417
C430
R401
R402
R403
C428
R417
R418
C415
R422
C413
1
16
17
32
C220
C216 C215 C214 C213 C212 C211 C210 C208 C209
L201
C218
R415R416R414R413
C412
C407
C423
R211
C232
R210
L202
C230
80
1
24
25
40
41
64 65
R213
R215
R209
C228
BE
GND301
12 1 19 1
J321
J302 C(CVBS)
J303 GND(CVBS)
E
21 B
1
EB
J301
R322
19
C324
R324
BE
BEBE
EB
EB
C217
R407
C426
L413
L406R405
MAIN
VIDEO
COMPONENT D2
AUDIO

4Refer to the schematic diagram for the value of resistors and capacitors.
FGIHJ
PC BOARD
CP203
CP204
CP205
D201
CP601
CP501
JACK501
D CONNECTOR
Cr
O
CN201
V.F.D
RMC1
CP101
R L VIDEO
OUT
AUDIO OUT
D101
CN202
S101
S105S102
S108
S106S103
S107
S104
IC202
Q204
Q203
Q206
Q202
Q201
D202
7Q308
CP306 JACK301
CN301
D302
CN302
Q301
Q304
Q302
D304
IC301
IC101
D102 D103
D105
D104
OP/CL
PLAYSTOP
STBY
NEXT
LAST
FF
FR
9110 1
J222
J212
J208
GND
J101
C112
C102
J102 GND
C101
C103 J103
KEY1
C107
KEY2 J104
RMC J105
C113
C104
34 5138
J106 GND
15
142
1
C229
C235
C227
J217
C225
C224
C226
J216
J215
C234
C221
J218
J213
J211
J210
C233
R212
J209
J220
J219
J221
C222
C231
R201
GND203
119112
14
RED
1
9
19
L503
L502
L501
C216 C215 C214 C213 C212 C211 C210 C208 C209 C207 C206 C205 C204 C203 C202 C223 C201
L201
C218
L202
C230
80
1
R213
R215
L204
L203
R107
R110
R113
C115
1
11
12
22 23
33
34
44
C110
R106
R108 R109
R112
R111
C111
R105
C108
C106
R114
C114
R103 R102 R101
C105
C116
L205
R209
C228
C236 R214
R206
BE
BE
BE
B
119
71
85
14
EB
J301
R322
J306
C317
C315
C323
C320
J316
C313
C312
J309
-12V
J310 +12V
C325
C326
C332
J318
J304
J305
J322
J319
J320
J323
R306
R307
YELLOWWHITERED
19
C304
R320R321R316R318
R317
C319 C318 C322
C308
R311
R323
C307 R303
C305
L304
L303
C309
R315
R324
R312
R313
R319
C321
C316
C314
C310
C328
C329
C330
C331
L302
L301
R310
C311
R314
R302 BE
BE
BE
EB
EB
C217
FRONT
COMPONENT D2

ACEBD
2
1
3
5
7
4
6
CP204
CP304
CP205
CP203
CP303
CP306
CP402
Q203
Q302
Q301
D304
Q304
Q207
Q205
Q
(BOTTOM VIEW)
Q204
CN202
CN201
Q201
Q202
CN301
CN401
JACK401
C
B
A
JACK402
JACK403
CN403
Q402
D403
Q403
D401
CP601
S-VIDEO
OPTICAL 1
OPTICAL 2
DIGITAL
OUT
OUT
DIGITAL
D402
D203
Q305
Q303
(Y) TYPE ON
12 11 10
FL2
FL1
-34V
GND(FL)
12 11 10
C236
0.1
1
2
3
4
DVD I/O
CLK
STB
GND
L203
51
C224 22P
C225
L204
52
C226 22P
L205
62
8 7 6 5
V+
OUT2
IN2-
IN2+
1
2
3
4
OUT1 IN1- IN1+ V-
47u16
+
C325 R307
560
220P
C322
R320
12K
47u16
+
C320
3.6K
R316
10K
R318
1000P
C319
R317
12K
220P
C318
+
C323
47u16
R321
10K 3.6K
R319
1000P
C321
C305 220P
R303 100K
+
+
+
C312
C313
R313
R315
3.6K
R310
R311
C326 R306
220P
C308
C304 220P
R302 100K
C311
R314
C310
C309
R312
47u16 10K
47u16 10K
220P
1000P
12K
1000P
3.6K
12K
56047u16
C332
+
4.7u50
100u16
C230
0.1
C231
C232
56
0.1
52
51
62
41
100u16
C219
0.1
C220
+
CON2
38
39
1u50
C229
10MHz
XT201
R213 1M
R209
100K
24
+
AUDIO MUTE
PB7/SO1/DVD OUT STBY LED
44
42
43 45 46
PB5/SCK1/DVD CLOCK PB6/SI1/DVD DATA IN
47
48 49 50
51
52
PI1/INT1/(POWER DOEN) PE0/EC0 PE1/EC1 PE2/RMC PE3/NMI
53
54
55 56
57
58
PI2/DVD STB
59 60
61
62
63
64
12 23 22 21 20 19 18
FL STB
FL CLK
FL DIN
20
19 18
17 16 15 14 13
SMPS CTRL 15
7
6 11 10 9
DVD RST
FAN(LOW) 8
7 3 5 4 2 1
70
65
66
69
68
67
74
73
71
72
77
76
75
80
79
78
PG6/VIDEO MUTE
VDD
NC
AVSS
CON1
KEY2
KEY1
AVREF
VSS
XTAL
EXTAL
RESET(L)
39
38
40
36
37
29
34
33
35
32
30
31
25
27
26
28
4.7K
R204
4.7K
R203
4.7K
R202
10K
R212
10K
R210
0.1
C233
R206
10K
76
8
AUDIO R- 7
C(CVBS)
AMUTE
GND 9
10
8
AUDIO R+
AUDIO L-
6
GND 5
4
AUDIO L+
DVD RST 1
GND
3
2
C209 22P
C208 22P
C207 22P
C203 22P
C206 22P
C205 22P
C204 22P
C223 56P
C202 22P
C201 22P
AUX5
GND
8
7
Y(G)
GND
6
5
Cr(R)
GND
4
3
Cb(B)
GND
2
1
C214 22P
C216 22P
C215 22P
C213 22P
C211 22P
C212 22P
C210 22P
AUX3 9
22P
L201
C217
22P
C218
L202
R201
3.3K
RGB/PROSCAN
GND GND
1
1
AUX3(WIDE)
325487610 9
C
GND(MICOM)
P/SCAN
VIDEO MUTE
3254
Cr(R)
GND(C)
Y(G)
GND
87610 9
VIDEO MUTE
AUDIO MUTE
17 18 1915 16
WIDE
GND
1412 13
Y(G)
Cr(R)
GND
+5V(VIDEO/BUFFER)
13 12 1115 1418 17 1619
VOUT
Cb(B)
GND GND
13 12 1115 14
+5V(OPT)
GND(OPT)
GND(VOUT)
18 17 1619
AUDIO L+
AMUTE
9101178
GND
Cb(B)
GND
C(CVBS)
45623
AUDIO R+
AUDIO R-
AUDIO L-
GND
1
41
8
76
17 18 1915 161412 139101178456231
1234567
+5V(VIDEO
GND(VIDEO)
-12V
GND(AUDIO)
+12V
+12V(FAN)
GND(FAN)
5 4
2
2
5
4
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
CTRAP
MUTE1
CIN
GND
YIN
VCC
GND
PYIN
GND
PYTRAP
VCC
PbIN
GND
PrIN
MUTE2
PrTRAP
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
COUT
TEST
MIXOUT
MIXFB
GND
YTRAP
GND
YOUT
YFB
GND
PYOUT
PYFB
GND
PbOUT
N.C.
PrOUT
R413 100
C423 0.1
C422 1u50
+
R414 82
C421 1u50
+
C420 47u16
R415 100
+
C419 47u16
R416 100
+
C412 47P L402 0.68uH
L403 0.39uH
C414 22P
C417 47P L404 0.68uH
R405 75C410 0.1
R407 75C409 100u16
+
C408 22u16
+
L401 0.68uH C407 47P
+
C406 100u16
C405 22u16
+
R406 75
C404 100u16
C403 22u16
+
+
R403 75
+
C402 330u10 R402 75
+
C401 330u10 R401 75
C316
0.1
100u16
C317
+
C314
C315
100u16
0.1
+
/BUFFER)
R422
C418 C415
0.1
+
100u16
27
R421
27
C416
100u16
C413
0.1
+
C426
0.1
C425
330u10
+
9
8
7
6
5
4
3
2
1
WIDE(LINE3)
P/SCAN
GND
CY
GND(CY)
Cb
GND(Cb)
Cr
GND(Cr)
L406
L405
L407
C428 22P C429 22P C430 22P
L413
C441 22P
65
1
34
2
OUT
+5V
GND
C433
0.1
C434
22u16
+
100uH
L409
4.7K
R419
22P
C437
75
R417
C436
+5V
R418
75
GND
OUT
C432
22P
0.1
C435
22u16
+
L410
100uH
4.7K
R420
330u10
+
C431
1
2
S/PDIF
GND
4.7K
R409 R410
4.7K
3.3K
R408
2
15
15
2
9
8
7
6
5
4
3
2
1
GND
CY
GND(CY)
Cb
GND(Cb)
Cr
GND(Cr)
4.7K
0.01
C222
0.1
C221
41
+12V
+12V
+12V
12V
12V
12V
+12V
+5V+5V
+5V
+5V
+5V+5V
+5V
+5V
+5V
34V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
+5V
22P
4.7K
R215
4.7K
R214
+5V
45
R211
300
10K
R323
0.1
C307
R324
34V
C234
100u16
+
0.1F6.3
+
C237
R308
560
560
R309
300
R325
1
R326
1W
+
MAIN
AUDIO
VIDEO
IC301
IC201
IC401
C
5
MAIN (1/3)
DVF-S500

FGIHJ
CP101CP206
D101
D102D103
S101
S105
S106
S107 S108
S103
S104
S102
D105 D104
CP204
CP304
D201
VIDEO
JACK301
L
R
2
1
OUT
Q207
D202
Q206
CN301
D302
D301
Q308
Q307 CP305
CN401
JACK401
JACK601
CP601
CP501
JACK501
B
C
A
D CONNECTOR
COMPONENT
OUTPUT
VIDEO
S-VIDEO
IC101 : PT6315
IC201 : CXP8463
IC301 : BA4560F
IC401 : BH7862F
Q201-203,207,40
:K
Q206 : K
Q301-303,305 : K
Q307 : K
Q308 K
D101 : B
D102-105,202,20
:1
D201,204,401-40
:1
D301 : 1
:
AUDIO
OUT
Y
CB
CR
Q304 K:
Q204 K:
Q205 K:
CN302
D204
(Y) TYPE ONLY
(J) TYPE ONLY
D302 M:
FAN
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
FL2
-VEE
FL1
+5V
RMC
GND
KEY2
KEY1
STB
CLK
DIN
+5VVST
LED
GND
GND
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
11 10 9 8 7 6 5 4 3 2 1
44
43
42
41
40
39
38
37
36
35
34
23
24
25 26
27
28 29 30
31
32
33
12
13
14
15
16
17
18
19
20
21
22
K2
K1
STB
CLK
DIN
DOUT
OSC
LED4
LED3
LED2
LED1
VSS
VDD
GR01
GR02
GR03
GR04
GR05
GR06
GR07
GR08
GR09
SG10 SG11 SG12 SG13 SG14 SG15 SG16 VEE GR12 GR11 GR10
VSS
VDD
SG1
SG2
SG3
SG4
SG5
SG6
SG7
SG8
SG9
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
S1
S2
S3
S4
S5 S6
S7
S8 S9
S10
S11
S12
S13
S14
S15 S16
G12
G11
G10
G9 G8
G7
G6 G5
G4
G3
G2
G1
38
S1
S2
S3
S4
S5
S6
S7
S8
S9
G1
G2
G3
G4
G5
G6
G7
G8
G9
G10
G11
G12
S16 S15
S14
S13
S12
S11
S10
C104
+
100u16
0.1
C115
C110
0.1
82K
R105
1K 9
R103
C106 220P C107 220P
8
1K
R102
C108 220P
7
1K
R101
9
8
7
12K
R106
OPEN
/CLOSE
R107
3K
R108
5.1K
PLAY
NEXT
10K
FF
R109
10K
R113
STBY SW
R111
3K5.1K
R112
PREV
12K
R110
STOP
FR
KEY2
KEY1
KEY2
KEY1
C113
C114
100u16
+
0.1
C112
100u16
+
C111
0.1
0.1
C103
0.1
C102
0.1
C101
C105 0.1
C116 0.1
12 11 10 9 8 7 6 5 4 3 2 1
FL2
FL1
-34V
GND(FL)
+5V(FL)
GND(MICOM) GND(MICOM)
+5VST
P/DOWN
SMPS CON
FAN CTRL
12 11 10 9 8 7 6 5 4 3 2 1
7
15
39
38
20
19
18
C236
0.1
56
45
C305 220P
R303 100K
C304 220P
R302 100K
1000P
C328
L304
L303
C329
1000P
C330
22P
C331
22P
100u16
C219
0.1
C220
+
38
39
1u50
C229
10MHz
XT201
R213 1M
R209
100K
24
+
23 22
AVSS
CON1
KEY2
KEY1
AVREF
VSS
XTAL
EXTAL
RESET(L)
39
38
40
36
37
29
34
33
35
32
30
31
25
27
26
28
4.7u50
C227
+
1234567
+5V(VIDEO
GND(VIDEO)
-12V
GND(AUDIO)
+12V
+12V(FAN)
GND(FAN)
47u16
C324
+
4.7K
R322
1
2
C316
0.1
100u16
C317
+
C314
C315
100u16
0.1
+
/BUFFER)
9
8
7
6
5
4
3
2
1
WIDE(LINE3)
P/SCAN
GND
CY
GND(CY)
Cb
GND(Cb)
Cr
GND(Cr)
C429 22P C430 22P
441 22P
65
1
34
2
9
8
7
6
5
4
3
2
1
GND
CY
GND(CY)
Cb
GND(Cb)
Cr
GND(Cr)
1
2
3
4
5
6
7
8
9
GND(Cr)
Cr
GND(Cb)
Cb
GND(CY)
CY
GND
P/SCAN
WIDE(LINE3)
14
13
12
11
10
9
8
7
6
5
4
3
2
1
PLUG2
NC
PLUG1
LINE3
NC
LINE2
LINE1
NC
GND(Pr)
Pr
GND(Pb)
Pb
GND(Y)
Y
L503
L501
L502
AC110-240V
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
BUFFER)
GND(VIDEO)
-12V
GND(AUDIO)
+12V
+12V(FAN)
GND(FAN)
SMPSCON
P/DOWN
+5VST
GND(MICOM)
+5V(FL)
GND(FL)
-34V
FL2
FL1
7654321
GND
3.3V
GND GND
+5V
GND
+12V
1
2
3
4
5
6
7
+12V
GND
+5V
GND
GND
3.3V
GND
1
2
3
GND
S/PDIF
GND
1
20
20
1
5
1
+12V
V
12V
V
+12V
+5V
+5V
+5V
+5V
+5V
+5V
+5V +5V
+5V
+5V
+5V +5V
+5V
+5V
+5V
+5V
+5V
+5V
34V
34V
34V
34V
34V
+B
B
50/60Hz
0.1
C228
34V
+5V +5V
-34V7
FL2
FL18
9
GND(FL)
GND(MICOM)
+5V(FL)
SMPSCON
P/DOWN
+5VST
6
5
4
+5V
3
2
1
+5V
34V
+5V(VIDEO/
75
R11
C234
100u16
+
0.1F6.3
+
C237
1
R326
1W
(Y) :
AC100V
50/60Hz
(J) :
L603
L602
L601
C603
56P56P
C602
56P
C601
R501
5.1K
R502
5.1K
1 1W
R327
F2 F2
NP
NX
P16 P15
P14
P13
P12
P11
P10
P9 P8
P7
P6 P5
P4
P3
P2
P1
NX NX
12G 11G 10G
9G 8G 7G 6G 5G 4G 3G 2G 1G
NX
NP
F1 F1
IC101
FRONT
COMPONENT
D2
POWER SUPPLY
DVF-S500
DVD LOADER
Dp
(2G-11G)
12G 11G 10G 9G 8G 7G
a
b
hj
k
m
r
pn
g
f
ce
d
Dp
P16 Dp Dp Col Col
P15
P14
P13
P12
P11
P10
P9
P8
P7
P6
P5
P4
P3
P2
P1
d
e
c
p
n
r
m
g
k
h
j
f
b
a
11G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
10G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
9G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
8G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
7G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
6G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
5G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
4G
d
e
c
p
n
r
m
g
k
h
j
f
b
a
d
e
c
p
n
r
m
g
k
h
j
f
b
a
3G 2G 1G12G
6 MAIN (2/3)
DVF-S500

KMOLN
S108
S103
S104
S102
D105 D104
SENSOR
REMOTE
IC101 : PT6315
IC201 : CXP84632-323Q
IC301 : BA4560F
IC401 : BH7862FS
Q201-203,207,402,403
: KRC102S
Q206 : KRC107S
Q301-303,305 : KRC231S
Q307 : KTC3205Y
Q308 KRC102M
D101 : B30-2664-08
D102-105,202,203,304
: 1N4148WS
D201,204,401-403
: 1SS133T
D301 : 1N4007
:
B LINE
B LINE
DIGITAL LINE
SIGNAL LINE
GND LINE
Q304 KRA107S:
Q204 KRA102S:
Q205 KSC1845F:
D302 MTZ9.1B:
7 6 5 4 3 2 1
G4
G3
G2
G1
10K
STBY SW
3K5.1K
PREV
12K
STOP
FR
C113
C114
100u16
+
0.1
AC110-240V
1
+12V
+5V
+B
B
50/60Hz
75
R114
(Y) :
AC100V
50/60Hz
(J) :
4G 3G 2G 1G
NX
NP
F1 F1
RMC1
VF-S500
7G 6G 5G 4G 3G 2G 1G
b
m
c
Dp
Col Col
7MAIN (3/3)
DVF-S500
CAUTION: For continued safety, replace safety critical components only with man-
ufacturer's recommended parts (refer to parts list). indicates safety critical com-
ponents. For continued protection against risk of fire, replace only with same type
and rating fuse(s). To reduce the risk of electric shock, leakage-current or resis-
tance measurements shall be carried out (exposed parts are acceptably insulated
from the supply circuit) before the appliance is returned to the customer.
The DC voltage is an actual reading measured with a high impedance type volt-
meter. The measurement value may vary depending on the measuring instruments
used or on the product. Refer to the voltage during PLAY unless otherwise speci-
fied; The value shown in ( ) is the voltage measured at the moment of STOP.
DOLBY and the double-D symbol are trademarks of Dolby Laboratories Licensing
Corporation. Noise reduction circuit made under license from Dolby Laboratories
Licensing Corporation.

DVF-S500
A
B
C
D
E
F
G
:
:
:
:
:
:
:
N09-2706-05
N89-3017-46
N89-3008-46
N86-3005-46
N89-3010-45
N85-3008-45
N89-3008-41
φ3x8
φ3x17
φ3x8
φ3x5
φ3x10(BLK)
φ3x8
φ3x8
S108
V.F.D
STANDBY
S104 S107
S103 S106
S102 S105
S101
COMPONENT
VIDEO
DIGITAL
OUTPUT
J402J403
VIDEO
OUT
AUDIO
OUT
J301
S-VIDEO
J401
J601
POWER
COMPONENT
VIDEO
AUDIO
MAIN
622
625 632
610
611
701
605
741
602
603
731
706
727
740
730
730
615
626
621
634
634
FAN
609
629
742
743
744
605
613
619
612
626
615
615
628
624
618
620
714
617
Gx3
Gx2
Gx2
C
Fx2
C
C
C
C
Cx2
Cx2
Cx3
604
623
707
Ax2
Ax2
Ex2
A
C
DD
Cx2
Ex2
Ex2
C
Cx2
D
D
B
B
A
Ax3
1
2
AC
B
Parts with exploded numbers larger than 700 are not supplied.
DVF-S500
8
EXPLODED VIEW (UNIT)

DVF-S500
9
PARTS LIST
Ref. No Add-
ress
New
Parts
Parts No. Description Desti-
nation Re-
marks
C231 CE04LW1C101M ELECTRO 100UF 16WV
C232 CK73GB1H104K CHIP C 0.10UF K
C233 ✽C91-1661-08 FILM 0.1UF K
C234 CE04LW1C101M ELECTRO 100UF 16WV
C236 CK73GB1H104K CHIP C 0.10UF K
C237 ✽C90-5801-08 BACKUP 0.1F 6.3WV
C304,305 CC73GSL1H221J CHIP C 220PF J
C307 CK73GB1H104K CHIP C 0.10UF K
C308,309 CC73GSL1H221J CHIP C 220PF J
C310,311 CK73GB1H102K CHIP C 1000PF K
C312,313 CE04LW1C470M ELECTRO 47UF 16WV
C314 CK73GB1H104K CHIP C 0.10UF K
C315 CE04LW1C101M ELECTRO 100UF 16WV
C316 CK73GB1H104K CHIP C 0.10UF K
C317 CE04LW1C101M ELECTRO 100UF 16WV
C318 CC73GSL1H221J CHIP C 220PF J
C319 CK73GB1H102K CHIP C 1000PF K
C320 CE04LW1C470M ELECTRO 47UF 16WV
C321 CK73GB1H102K CHIP C 1000PF K
C322 CC73GSL1H221J CHIP C 220PF J
C323-326 CE04LW1C470M ELECTRO 47UF 16WV
C328,329 CK73GB1H102K CHIP C 1000PF K
C330,331 CC73GCH1H560J CHIP C 56PF J
C332 CE04LW1H470M ELECTRO 47UF 50WV
C401,402 CE04LW1A331M ELECTRO 330UF 10WV
C403 CE04LW1C220M ELECTRO 22UF 16WV
C404 CE04LW1C101M ELECTRO 100UF 16WV
C405 CE04LW1C220M ELECTRO 22UF 16WV
C406 CE04LW1C101M ELECTRO 100UF 16WV
C407 CC73GSL1H470J CHIP C 47PF J
C408 CE04LW1C220M ELECTRO 22UF 16WV
C409 CE04LW1C101M ELECTRO 100UF 16WV
C410 ✽C91-1661-08 FILM 0.1UF K
C412 CC73GSL1H470J CHIP C 47PF J
C413 CK73GB1H104K CHIP C 0.10UF K
C414 CC73GCH1H220J CHIP C 22PF J
C415 CK73GB1H104K CHIP C 0.10UF K
C416 CE04LW1C101M ELECTRO 100UF 16WV
C417 CC73GSL1H470J CHIP C 47PF J
C418 CE04LW1C101M ELECTRO 100UF 16WV
C419,420 CE04LW1C470M ELECTRO 47UF 16WV
C421,422 CE04LW1H010M ELECTRO 1.0UF 50WV
C423 CK73GB1H104K CHIP C 0.10UF K
C425 CE04LW1A331M ELECTRO 330UF 10WV
C426 CK73GB1H104K CHIP C 0.10UF K
C428-430 CC73GCH1H220J CHIP C 22PF J
C431 CE04LW1A331M ELECTRO 330UF 10WV
C432,433 CE04LW1C220M ELECTRO 22UF 16WV
C434,435 CK73GB1H104K CHIP C 0.10UF K
C436,437 CC73GCH1H220J CHIP C 22PF J
C441 CC73GCH1H220J CHIP C 22PF J
C601-603 CC73GCH1H560J CHIP C 56PF J
CP101 ✽E41-1028-08 CN.FPC 1.25MM L131101500010
CP206 ✽E41-1029-08 CN.FPC 1.25MM L131111500010
✽ New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert. 2
L:Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia
Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai)
Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .
Ref. No Add-
ress
New
Parts
Parts No. Description Desti-
nation
Re-
marks
-✽B60-5394-08 INSTRUCTION MA 5707047420170
- H10-7913-08 CUSHION,SNOW 6230210774000
- H25-1601-08 POLY BAG 6337000240010
-✽W20-0035-08 BOX,GIFT 6007210570040
602 2B ✽K29-8341-08 BUTTON 5097212161000Z
603 2B ✽K29-8342-08 BUTTON 5097212171000Z
604 2A K29-8339-08 BUTTON 5097212131000Z
605 2A,2C ✽E35-3625-08 CABLE,FLAT CAR L301121150010
609 1C ✽E30-7309-08 CORD ASSY L068000000120
610 1A ✽E30-7310-08 CORD,RCA L063028400030
611 1A ✽E30-7311-08 CORD,RCA L063040550000
612 1B ✽A21-5475-08 COVER 4317211168000
613 1B ✽A29-1232-08 COVER 4317211171000
615 2A,2C ✽G11-2949-08 CUSHION 4050210875000
617 2A ✽A22-1985-08 FRAME 3217210431000
618 2A ✽B11-1595-08 LENS 3710210423000
619 1B ✽D40-1826-08 MECHA 8030602800020
620 2A ✽A60-2373-08 PANEL 3067211388000
621 2C ✽W02-4536-08 POWER PUPPY 8208000170010
622 1A ✽A70-1645-08 REMOCON 8300051200010
623 2A B11-1593-08 FILTER 5200210142000
624 2A B11-1594-08 FILTER 5200210152000
625 1A ✽E35-3626-08 CN,WIRE L000102000010
626 2C J19-6161-08 SPACER 4300040561010
628 2A ✽B10-3996-08 WINDOW ASSY 5078211073000
629 1C J42-0358-08 STOPPER 4380040172010
632 1B ✽A01-3919-08 CABINET 3000210396100
634 2C J19-0306-05 CLAMP 4330000310000
FAN 1C ✽F09-0184-08 FAN,DC G720123000010
G N89-3008-41 SCREW,TAP TITE B020030084B10
D101 ✽B30-2664-08 LED,ROUND K500032000100
C101-103 ✽C91-1661-08 FILM 0.1UF K
C104 CE04LW1C101M ELECTRO 100UF 16WV
C105 CK73GB1H104K CHIP C 0.10UF K
C106 CC73GSL1H221J CHIP C 220PF J
C107 C91-0749-05 CERAMIC 220PF K
C108 CC73GSL1H221J CHIP C 220PF J
C110,111 CK73GB1H104K CHIP C 0.10UF K
C112,113 CE04LW1C101M ELECTRO 100UF 16WV
C114-116 CK73GB1H104K CHIP C 0.10UF K
C201-218 CC73GCH1H560J CHIP C 56PF J
C219 CE04LW1C101M ELECTRO 100UF 16WV
C220 CK73GB1H104K CHIP C 0.10UF K
C221 ✽C91-1661-08 FILM 0.1UF K
C222 C91-0769-05 CERAMIC 0.010UF K
C223 CC73GCH1H560J CHIP C 56PF J
C224-226 C91-0729-05 CERAMIC 22PF J
C227 CE04LW1H4R7M ELECTRO 4.7UF 50WV
C228 CK73GB1H104K CHIP C 0.10UF K
C229 CE04LW1H010M ELECTRO 1.0UF 50WV
C230 CK73GB1H104K CHIP C 0.10UF K
✽ New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert. 1
L:Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia
Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai)
Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .
DVF-S500
ELECTRIC PARTS

DVF-S500
10
PARTS LIST
Ref. No Add-
ress
New
Parts
Parts No. Description Desti-
nation Re-
marks
R417,418 RK73GB1J750J CHIP R 75 J 1/16W
R419,420 RK73GB1J472J CHIP R 4.7K J 1/16W
R422 RK73GB1J270J CHIP R 27 J 1/16W
S101-108 S70-0105-08 SW,TACT G180000270010
D102-105 ✽1N4148WS D,SWITCHING CH K005041480010
D201 1SS133T D,SWITCHING K000013300520
D202,203 ✽1N4148WS D,SWITCHING CH K005041480010
D204 1SS133T D,SWITCHING K000013300520
D301 1N4007 D,SWITCHING K000400700520
D302 MTZJ9.1B D,ZENER K06009R144520
D304 ✽1N4148WS D,SWITCHING CH K005041480010
D401-403 1SS133T D,SWITCHING K000013300520
IC101 ✽PT6315 IC,LINEAR-DRIV J127631500010
IC201 ✽CXP84632-323Q IC,CPU MICRO P J020846323230
IC301 BA4560F IC,LINEAR OP J121456000041
IC401 ✽BH7862FS IC,LINEAR-DRIV J127786200000
Q201-203 KRC102S SEMI,CHIP TR/N J522010200210
Q204 KRA102S SEMI,CHIP TR/P J520010200210
Q205 KSC1845F SEMI,TR/GE NPN J5021845F0000
Q206 KRC107S SEMI,TR/GE NPN J5020107S0050
Q207 KRC102S SEMI,CHIP TR/N J522010200210
Q301-303 ✽KRC231S SEMI,CHIP TR/N J5220231M0010
Q304 KRA107S SEMI,CHIP TR/P J5200107S0050
Q305 ✽KRC231S SEMI,CHIP TR/N J5220231M0010
Q307 KTC3205Y SEMI,TR/GE NPN J5023205Y0020
Q308 KRC102M SEMI,BRT/NPN R J6020102M0010
Q402,403 KRC102S SEMI,CHIP TR/N J522010200210
RMC1 ✽W02-4538-08 MODULE,REMOCON E940633800000
VFD ✽HNA-12SM55T DISPLAY,FLT K530125500010
JACK402,3 ✽W02-4537-08 MODULE E100151300010
✽ New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert. 4
L : Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia
Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai)
Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .
Ref. No Add-
ress
New
Parts
Parts No. Description Desti-
nation
Re-
marks
JACK301 ✽E63-1336-08 TER,RCA 3PIN G606030174020
JACK401 ✽E11-0975-08 TER,S 1PIN G600000020020
JACK601 ✽E63-1335-08 TER,RCA 3PIN G606030174010
L201-205 L92-0523-08 BEAD,COIL CHIP 7611010000020
L303,304 L92-0523-08 BEAD,COIL CHIP 7611010000020
L401,402 ✽L33-1672-08 COIL,FILTER-IN D330R68001020
L403 ✽L33-1673-08 COIL,FILTER-IN D330R39100520
L404 ✽L33-1672-08 COIL,FILTER-IN D330R68001020
L405-407 L92-0523-08 BEAD,COIL CHIP 7611010000020
L409,410 L33-1671-08 COIL,FILTER-IN D330101001020
L413 L92-0523-08 BEAD,COIL CHIP 7611010000020
L601-603 L92-0523-08 BEAD,COIL CHIP 7611010000020
XT201 L78-0294-05 RESONATOR,CERA E830100000050
R101-103 RK73GB1J102J CHIP R 1.0K J 1/16W
R105 RK73GB1J823J CHIP R 82K J 1/16W
R106 RK73GB1J123J CHIP R 12K J 1/16W
R107 RK73GB1J302J CHIP R 3.0K J 1/16W
R108 RK73GB1J512J CHIP R 5.1K J 1/16W
R109 RK73GB1J103J CHIP R 10K J 1/16W
R110 RK73GB1J123J CHIP R 12K J 1/16W
R111 RK73GB1J302J CHIP R 3.0K J 1/16W
R112 RK73GB1J512J CHIP R 5.1K J 1/16W
R113 RK73GB1J103J CHIP R 10K J 1/16W
R114 RK73GB1J750J CHIP R 75 J 1/16W
R206 RK73GB1J103J CHIP R 10K J 1/16W
R209 RK73GB1J104J CHIP R 100K J 1/16W
R210 RK73GB1J103J CHIP R 10K J 1/16W
R211 RK73GB1J301J CHIP R 300 J 1/16W
R213 RK73GB1J105J CHIP R 1.0M J 1/16W
R214,215 RK73GB1J472J CHIP R 4.7K J 1/16W
R302,303 RK73GB1J104J CHIP R 100K J 1/16W
R308,309 RK73GB1J561J CHIP R 560 J 1/16W
R310 RK73GB1J362J CHIP R 3.6K J 1/16W
R311 RK73GB1J123J CHIP R 12K J 1/16W
R312 RK73GB1J362J CHIP R 3.6K J 1/16W
R313 RK73GB1J103J CHIP R 10K J 1/16W
R314 RK73GB1J123J CHIP R 12K J 1/16W
R315 RK73GB1J103J CHIP R 10K J 1/16W
R316 RK73GB1J362J CHIP R 3.6K J 1/16W
R317 RK73GB1J123J CHIP R 12K J 1/16W
R318 RK73GB1J103J CHIP R 10K J 1/16W
R319 RK73GB1J362J CHIP R 3.6K J 1/16W
R320 RK73GB1J123J CHIP R 12K J 1/16W
R321 RK73GB1J103J CHIP R 10K J 1/16W
R323 RK73GB1J103J CHIP R 10K J 1/16W
R324 RK73GB1J472J CHIP R 4.7K J 1/16W
R325 RK73GB1J301J CHIP R 300 J 1/16W
R326,327 RS14GB3A010J FL-PROOF RS 1.0 J 1W
R401-403 RK73GB1J750J CHIP R 75 J 1/16W
R405 RK73GB1J750J CHIP R 75 J 1/16W
R407 RK73GB1J750J CHIP R 75 J 1/16W
R413 RK73GB1J101J CHIP R 100 J 1/16W
R414 RK73GB1J820J CHIP R 82 J 1/16W
R415,416 RK73GB1J101J CHIP R 100 J 1/16W
✽ New Parts
Parts without Parts No. are not supplied.
Les articles non mentionnes dans le Parts No. ne sont pas fournis.
Teile ohne Parts No. werden nicht geliefert. 3
L:Scandinavia K : USA P : Canada R : Mexico C : China I : Malaysia
Y : PX(Far East,Hawaii) T : England E : Europe G : Germany V : China(Shanghai)
Y : AAFES(Europe) X : Australia Q : Russia H : Korea M : Other Areas indicates safety critical components .

SPECIFICATIONS
DVF-S500
[Type]
System ...................................................... DVD video player
Signal read system .............................. Semiconductor laser
Wave length ................................ For DVD ; 640 to 660 nm
For CD ; 775 to 805 nm
Laser power class .......................................... Class 1 (IEC)
[Digital / Audio section]
D/A Convertor
D/A conversion ...................................................... 24 Bit
Oversampling ........... 4 fs (Sampling frequency; 48 kHz)
Frequency response
Sampling frequency ; 44.1 kHz ............... 8 Hz ~ 20 kHz
Sampling frequency ; 48 kHz .................. 8 Hz ~ 22 kHz
Sampling frequency ; 96 kHz .................. 8 Hz ~ 44 kHz
Signal to noise ratio ................................. More than 105 dB
Dynamic range ............................... More than 94 dB (16 bit)
Total harmonic distortion ....... Less than 0.007 % (at 1 kHz)
Channel separation ................... More than 85 dB (at 1 kHz)
Wow and flutter .............................. Below measurable limit
Analog output level/impedance ......................... 2 V / 1.2 kΩ
Digital output level/impedance
COAXIAL ............................................... 0.5 Vp-p / 75 Ω
OPTICAL ........ -21 dBm ~ -15 dBm (Wave length 660 nm)
[Video Section]
D/A Convertor
D/A conversion ...................................................... 10 Bit
Oversampling ....... 4 fs (Sampling frequency; 13.5 MHz)
Video output format............................................. NTSC/PAL
Composite video output level
............................ 1 Vp-p (75 Ωload, sync. negative)
S-video output level
(Y-signal) .................. 1 Vp-p (75 Ωload, sync. negative)
(C-signal)
NTSC ............................................ 0.286 Vp-p (75 Ω)
PAL ............................................... 0.300 Vp-p (75 Ω)
Component Video output level
(Y-signal) ................................................... 1 Vp-p (75 Ω)
(Cb-signal) .............................................. 0.7 Vp-p (75 Ω)
(Cr-signal) ............................................... 0.7 Vp-p (75 Ω)
Horizontal resolution .............. 500 lines (Composite output)
Video signal to noise ratio
................... More than 62 dB (Composite output)
[General]
Power consumption ..................................... 15 W (at 240V)
Standby power consumption ..................... 1.2 W (at 240V)
Dimensions ................................... W : 220 mm (8-11/16”)
....................................................... H : 77 mm (3-1/16”)
....................................................... D : 308 mm (12-1/8”)
Weight (net).................................................... 2.8 kg (5.5 lb)
KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be
changed without notice.
Sufficient performance may not be exhibited at extremely cold locations (Where water freezes).
NotesNotes