KitchenAid KEMC378KSS - ARCHITECT Series 27'' Microwave Combination Double Wall... User manual

OVEN PARTS
1
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
11−06 Litho In U.S.A. (dmm) Part No. 8186460
27" BUILT−IN ELECTRIC
DOUBLE OVEN
THERMAL CONVECTION LOWER
MICROWAVE CONVECTION UPPER

OVEN PARTS
2
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 Literature Parts
8300653 Installation
Instructions
8304066 Use & Care Guide
(Oven)
8304067 Use & Care Guide
(Microwave)
4450786 Cooking Guide
(Lable)
8303852 Tech Sheet (Oven)
4449264 Easy Set Guide
(Oven)
4451052 Guide, Easy Use
(Microwave)
3191638 Safer Cooking Tips
9759133 Safer Cooking Tips
2 Trim, Side
4455430 RH Black
4455432 RH White
4455434 RH Biscuit
4452083 RH S.Steel
4455431 LH Black
4455433 LH White
4455435 LH Biscuit
4452084 S.Steel
3 Hinge Receiver
4455605 Left Hand
4455606 Right Hand
4 4448520 Bumper, Door
5 4452490 Spacer, Foam
6 Screw
8281236 Black
4449041 White
7 4455864 Top Chassis
8 4449809 Screw
9 4452158 Tube, Vent
10 4452163 Lens, Light
11 4448972 Oven Light Assy
12 4452164 Bulb, Light
13 4452336 Insulation,
Bottom Vent
14 4455611 Frame, Front
15 4455381 Gasket, Door
16 9752759 Relay
17 3196176 Screw
18 4449040 Screw
19 4451477 Support, Insulation
20 4451605 Cap, Spacer
21 Rail, Side
4450583 Right Side
4450584 Left Side
22 4449154 Screw
23 4449743 Screw
24 4450038 Screw
25 4455641 Side, Chassis
(R.H. & L.H.)
26 4452233 Back, Chassis
27 Liner, Oven
(Not serviceable)
28 4448444 Grommet
29 4455636 Sensor
30 4449845 Bracket, Support
32 4452152 Bracket, Mounting
(Bottom Vent)
33 9760676 Deflector, Vent
34 4451666 Vent, Center
35 3400832 Screw
37 9759243 Thermostat (TOD)
(Temp.) SPST
43 4455529 Base, Chassis
49 4448933 Retainer, Gasket
50 4451747 Cover, Back
51 Trim, Bottom
4455442 Black
4455444 White
4455446 Biscuit
4455146 Stainless Steel
52 4451755 Chassis, Back
53 4452492 Insulation,
Convection Top
54 4452491 Insulation,
Convection Grill
FOLLOWING PARTS
NOT ILLUSTRATED
INSULATION
4449315 Insulation, Wrap
4450364 Insulation, Back

CONTROL PANEL PARTS
3
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION
1 Switch, Membrane
8302669 Black
8302673 White
8302671 Biscuit
8302659 Stainless Steel
2 Panel, Control
4452602 Black
4452603 White
4452973 Biscuit
4451790 Stainless Steel
3 3400832 Screw
4 4452260 Spacer, Foam
5 8302346 Assy, Control
6 4449745 Screw
7 4451592 Filter
8 4451632 Bracket, Filter
9 4449809 Screw

OVEN DOOR PARTS
4
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
1 8303699 Door Liner
2 Hinge, Door
9760571 R.Side
9760572 L.Side
9760575 R.Side(S.Stl Mdl)
9760576 L.Side(S.Stl Mdl)
3 4449253 Glass, Inner
4 4451721 Insulation, Door
5 4457131 Retainer, Glass
6 4449809 Screw
7 9759224 Glass, Inner
8 4449743 Screw
9 3196184 Screw
10 3400832 Screw
12 Door Glass, Assy
4455393 Black
4455392 White
4455394 Biscuit
4452315 Stainless Steel
13 Door Handle
4452500 Black
4452501 White
4452870 Biscuit
4455850 Stainless Steel
14 Bracket, Handle
4455803 Right Hand
4455804 Left Hand
15 9759229 Bracket(2nd Glass)
16 9759230 Bracket(3rd Glass)
19 4457102 Shield, Heat
4449809 Screw
21 4452325 Seal, Door Top
22 4457113 Shield, Heat (Btm)
23 Retainer, Glass−Clip
4450863 Black
4450864 White
4452119 Biscuit
4451432 S.Steel
24 9759227 Glass, Inner

LATCH PARTS
5
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION
1 4451759 Vent, Exhaust
2 4455178 Elbow, Vent−Top
3 4455177 Elbow, Vent−Bottom
4 8300791 Bracket, Combo
Chassis
5 4451758 Seal, Foam
6 4449154 Screw (2)
7 4449809 Screw
9 4450407 Baffle, Rear
10 9760888 Latch, Motorized
11 6610168 Blower
12 4455191 Plate, Service

6
INTERNAL OVEN PARTS
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 4456104 Element, Broil
2 4449154 Screw
3 4457277 Grill, Broiler
4 4457276 Pan, Broiler
5 3181534 Rack, Roasting
6 4448715 Rack, Oven
7 4452155 Element, Bake
8 4448881 Nut, Hex
9 4451583 Convection Motor
10 4452226 Blade, Fan
11 4448882 Washer, Lock
12 4452227 Nut
13 4451355 Jack, Meat Probe
14 4448948 Probe, Meat
15 4455036 Tray, Bake
17 4450039 Cover, Bake Tray
18 4449809 Screw
20 4452157 Element,
Convection
21 4448418 Cover, Fan

CABINET AND STIRRER PARTS
7
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460

CABINET AND STIRRER PARTS
8
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 4375437 Bracket, Capacitor
3 4375252 Rubber Ring
4 4375038 Screw
5 4375314 Air Duct, Magnetron
6 4375253 Support, Tube
7 4375421 Plug, Ceramic
8 4375255 Bushing
9 4375256 Reflector
10 4375257 Chamber, Reflector
12 4375450 Duct, Inlet
13 4375316 Insulation, Switch
14 4375322 Fan Wheel
15 4375317 Duct, Air
16 4375415 Block, Slide
17 4375248 Cover Plate, Upper
18 4375251 Screw
19 4375318 Lens, Lamp
20 4375319 Spring
21 4375320 Reflector
23 4452220 Rack
24 4393536 Crisp Plate
25 4375436 Capacitor
26 4375424 Magnetron
27 4375321 Fuse
28 4375231 Block, Fuse
29 4375278 Motor, Blower
30 4375279 Thermostat
31 4375423 Thermostat
32 4375281 Thermostat
33 4375408 Q Tube Assembly
34 4375438 Transformer
35 4375406 Ring Turntable
36 4375407 Shaft, Turntable
39 Bracket, Hinge
4375412 Left
4375413 Right
42 4375331 Plate, Grill
43 4375332 Bracket
44 4375441 Cap, Fan
46 Switch Holder
4375412 Left
4375413 Right
47 4375258 Nut
48 Insulation
4375409 Left Side
4375410 Right Side
49 4375411 Plate, Side−
Bottom
50 4375425 Valve
51 4375428 Screw to Valve
52 4375427 Thermoactuator
53 4375426 Air Bleed
54 4375439 Shield, Heat
Right
55 4375422 Sensor, Temp.
56 4375420 Insulation
57 4375419 Duct, Heater
58 4375416 Washer
59 4375417 Element, Heater
60 4375418 Fan
61 4375429 Motor, Fan
62 Left−Threaded Nut
Serviced With
Motor Item 61
63 4375430 Thermostat
64 4375431 Shield, Heat
65 4375432 Insulation
66 4375433 Chamber, Heat
67 4375437 Isolation Plate
68 4375338 Cover Plate
71 Side Plate
4375341 Left
4375342 Right
72 4455915 Turntable
73 4375346 Switch
74 4375347 Motor, Turntable
75 4375348 Lamp
76 4375349 Rectifier

MICROWAVE COMPARTMENT PARTS
9
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION
1 Support Rails
4452551 Right Side
4452552 Left Side
2 4449809 Screw
3 4452547 Rear Channel
4 4449809 Screw

TOP VENTING PARTS
10
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 4450377 Cover, Top
2 4448935 Baffle, Blower
3 4450920 Blower
4 4451789 Plate, Mounting
Transformer
5 4452104 Transformer,
(Lights)
6 8303844 Exhaust Duct
7 4450027 Bracket, Duct
8 4449964 Grommet
112432 Nut
9 4454949 Holder, Fuse
10 4454976 Fuse
11 4449868 Block, Terminal
12 4452559 Side, Combo
13 4456144 Vent, Control
Panel
14 Side, Control Top
4451597 Right
4451598 Left
15 4452244 Back, Control
16 4450550 Cover, Top Rear
17 4448664 Clamp
18 4452366 Cover, Top Front
19 4455038 Transformer,
Control Panel
20 4452247 Plate, Cover
4449809 Screw (4)
21 4451934 Suppressor
22 313806 Screw (2)
23 4449809 Screw
24 3400080 Screw
25 4450038 Screw
26 4449154 Screw

11
MICROWAVE DOOR PARTS
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
1 4448937 Glass, Middle
2 8303555 Frame, Door
3 4450038 Screw
4 Bracket, Mounting
4449141 Right Side
4449142 Left Side
5 4449083 Filler, Side
6 Handle, Door
4452500 Black
4452501 White
4452870 Biscuit
4455850 Stainless Steel
7 Glass, Outer
4452210 Black
4452788 White
4452994 Biscuit
4452258 S.Steel
8 4449809 Screw
9 4452330 Bracket, Handle
10 Retainer, Glass−Clip
4450863 Black
4450864 White
11 4375339 Door, Plate
12 4375414 Frame, Inner
13 4375330 Strap, Door
14 4375313 Screw
15 Hinge, Door
4375323 Left
4375324 Right
16 4451008 Spring,Torsion(LH)
17 3196184 Screw (4)
18 4451008 Spring,Torsion(RH)
4452398 RH, SS Model

OPTIONAL PARTS
12
For Models:KEMC378KBL04, KEMC378KWH04, KEMC378KBT04, KEMC378KSS04
(Black) (White) (Biscuit) (Stainless Steel)
8186460
Illus. Part
No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION Illus. Part No. No. DESCRIPTION
PAINT, TOUCH−UP (1/2oz.)
72017 White
261869 Cord Brown
72032 Black
4392899 Biscuit
PAINT, SPRAY
350930 White
261900 Citrine White
830864 Black
4392901 Biscuit
ADHESIVE
591014 Adhesive
Loctite (1/3 oz.)
482338 Sealer, Silastic
(3 oz.)
SPLICING WIRES−−25FT.
LENGTH
242828 Wire (12 Ga.
150 c Black)
242820 Wire (14 Ga.
150 c Black)
242821 Wire (14 Ga.
150 c Blue)
242822 Wire (14 Ga.
150 c Brown)
242830 Wire (14 Ga.
200 c Brown)
242823 Wire (14 Ga.
150 c Green)
242824 Wire (14 Ga.
150 c Orange)
242825 Wire (14 Ga.
150 c Red)
242831 Wire (14 Ga.
200 c Red)
242827 Wire (14 Ga.
150 c Yellow)
FOLLOWING PARTS
NOT ILLUSTRATED
4378950 Filler Kit (BL)
4378951 Filler Kit (WH)
4378952 Filler Kit (AL)
814381 Kit, Pin Hinge
4448950 Screw,
Installation
WIRING HARNESS PARTS
8301909 Harness, Latch
8303838 Harness,
Main Filter
4449809 Screw
8301923 Harness, Main
4450831 Ground (M/W)
4450800 Screw
4449809 Screw
4450950 Conduit, Combo
4450800 Screw
313438 Clip, Harness
4454835 Tie, Cable
4452400 Lead, Ground