KOBE 8924 User manual

OUTDOOR GAS GRILL 6+1+1
USE AND CARE MANUAL
Item 8924
2531-21
TECHNICAL DATA
Edututor
Kannistontie 5
36220 Kangasala, Finland
Gas Grill
PIN-NUMBER 2531CS-0116
SERIES NUMBER G8611-S/8924/PO8854
Country of
Destination
Appliance
Category
Gas and Supply
Pressure
Main
Burner
Side
Burner
Back
Burner
6 burner + SB + BB
Nozzle
dia Ø
Nozzle dia
Ø
Nozzle dia
Ø
Total Nominal Heat Inputs (Hs)
BE, CY, DK, EE, FI,
HU, LT, NL, NO, SE,
SI, SK, RO, HR, TR,
BG, LU, MT
I 30B/P
(30)
Butane/Propane
30 mbar
0.90 mm
0.85 mm
0.90 mm
27.7 kW / 2017 g/h
12/2/2021
THIS GAS GRILL IS FOR OUTDOOD USE ONLY!
IMPORTANT! READ ALL INSTRUCTIONS AND FUNCTIONS BEFORE USING THIS DEVICE!
KEEP THESE INSTRUCTIONS FOR FUTURE NEEDS!
OPERATIONS OTHER THAN THOSE SPECIFIED IN THIS MANUAL ARE PROHIBITED!
NOT FOR PROFESSIONAL USE!

IMPORTANT
Read all instructions and operations before operating this unit.
The instructions reduce the risk of injury.
Failure to observe instructions may result in fire or damage to the product.
The owner is responsible for ensuring that the grill is correctly assembled, installed and maintained in good condition.
Failure to observe this manual may lead to property damage and/or personal injury.
WARNINGS
Children over 8 and persons with physical, sensory or mental disabilities, or inexperienced persons, may only use the
device under supervision, or if they are properly trained to use the product safely and they understand hazards related
to the use of the device.
Do not let children play with the device. Keep children under 3 away from the device unless they are continuously
supervised. Do not let children clean or otherwise interact with the device without supervision.
Note: Certain parts of the device may become very hot and cause burns. Be particularly careful when children or
people with disabilities are in the vicinity of the device.
Only to be used outdoors.
Read the instructions before using the appliance.
Accessible parts maybe very hot, keep young children away.
Do not move the appliance during use.
Turn off the gas supply at the gas container after use.
Any modification of the appliance may be dangerous.
Parts sealed by the manufacturer or his agent must not be altered by the user.
Attention:
Some parts of this appliance become very hot, take special care when children or elderly are present.
For your safety:
Never light a gas grill with gasoline or comparable fluids!
Suggestion: user should not change the assembly that the manufacturer packaged.
Connect the pressure regulator and hose to the device correctly.
Do not keep the gas container inside the grill trolley when in use. The gas container must not be placed inside
the device.
IF YOU SMELL GAS:
Switch off the gas supply.
Switch off all burners.
Ventilate the area.
Check for any leaks as described in this manual.
If the odour does not dissipate, connect the gas supplier immediately.
PRECAUTIONS
Test any connections for leaks whenever changing containers and before use.
Never look for leaks with matches or a flame.
Do not store or use gasoline or other flammable vapours or liquids in the vicinity of the device.
Do not store any other LP gas bottles near the device.
ASSEMBLY
WARNING: Although efforts have been made to remove any sharp edges during manufacturing, all parts should be
handled carefully in order to avoid injury.
Necessary tools:Screwdriver or a flat screwdriver/key.
Read all instructions carefully before use. Find a spacious, clean area for assembling the grill. Review the
parts list and diagram when in doubt. Some parts of the grill are large. The grill should be assembled by two
persons.
NOTE: Make sure all plastic covers are removed before assembly!

Content of this manual:
1. Assembly
2. Preparation
3. Installation
4. Side burner
5. Warning and safety points
6. Lightning instructions
7. Storage
8. Cleaning instructions
9. Trouble shooting
10. Safety hints
11. Warranty
12. Environmental protection
1. Assembly
Make sure your grill is assembled properly. Detailed assembly instructions are packed with each grill giving specific
assembly procedures for each model. Follow these instructions carefully to ensure the correct and safe assembly of
the grill.
Caution: Although we take every effort to ensure that the assembly process is as easy as possible, it is inherent with
fabricated steel parts that corners and edged can cause cuts if improperly handled during assembly procedures. Be
careful while handling any parts during assembly. It is strongly recommended that you protect hands with a pair of
work gloves.
2. Preparation
To use this grill, you need a bottle of LPG and the proper gas pressure regulators. The controllers must conform to the
latest version of EN16129 and national regulations.
This appliance must only be used with an approved hose and regulator.
Energy saving tips
Reduce the opening time of the lid.
Turn the grill off as soon as cooking is completed.
Preheat the gas grill for 10 to 15 minutes only (Except for the first use).
Do not use a higher setting than required.
3. Installation
After purchasing your gas bottle, you will then be ready to set it up with your gas grill. Connect the hose and regulator
to the gas container at the right side of the gas grill. The hose dimension is 8mm diameter.
a) When changing the gas bottle which shall be carried out away from any source of ignition. Position the gas
bottle at the side of your gas grill, not underneath, keeping in mind that the bottle must be kept away from heat and
in a safe position.
b) When ready to use your gas grill insert the regulator into the gas bottle valve and check that it’s firmly attached.
The maximum length of hose shall not exceed 1.5m.
Warning: Before attempting to light your gas grill you must refer to your lighting instructions and warning /
safety points.
Warning: Always test gas line for leaks at connector with soap water finishing all connections.
How to disconnect a gas bottle
Check the hose before each use, searching for cracking, cuts or any abrasions. If the hose is found to be faulty in any
way do not attempt to use your gas grill.
When changing your gas bottle ensures that there are no sources of ignition close by i.e. fires, cigarettes, naked
flames etc. Make sure that the appliance is switched off.
Ensure that the hose is not subjected to twisting which will affect the gas flow when using your gas grill. Also, the
hose must not have undue tension and must not touch any part of the gas grill which may be hot.
STEP1

Container replacement
The container features a regulator with a switch for switching the gas supply on or off.
Connecting/disconnecting the gas container
See low pressure regulator instructions.
GENERAL
Although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness
check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure
unknowingly being applied to the unit. Periodically check the whole system for leaks following the procedures listed
below. If the smell of gas is detected at any time you
should immediately check the entire system for leaks.
BEFORE TESTING
Make sure that all packing material is removed from the grill including tie-down straps.
NEVER perform leak test with an open flame.
Make a soap solution of one-part liquid detergent and one part water. You will need a spray bottle, brush, or rag to
apply the solution to the fittings.
TO TEST
1. Make sure the control valves are in the OFF position and turn on the gas supply.
2. Check all connections from the gas regulator and supply valve up to and including the connection to the manifold
pipe assembly (the pipe that goes to the burners). Soap bubbles will appear where a leak is present.
3. If a leak is present, immediately turn off the gas supply and tighten the leaky fittings.
4. Turn the gas back on and recheck.
5. Should the gas continue to leak from any of the fittings, turn off the gas supply.
Always check for leaks after every gas tank change.
1. Install Regulator Hose.
2. Install Gas Tank & Regulator Hose.
Do not use the grill until all connections have been checked and do not leak.
4. Side burners
To get the maximum yield with the minimum consumption of gas it is handy to keep the following points in mind:
Once the burner has been alighted, adjust the flame according to your needs, from “Maximum” to “Minimum” position.
Use proper pan size (with flat bottom only) for each burner.
When the content of the pan starts to boil, turn the knob down to “Reduced rate position” (small flame).
Always put a lid on the pan.
Suggestions use Ø pans in 20-24cm.
Under the side tables, burner height has larger openings, the oxygen can reach the burners easily and ensures even
fire.
5. Warning and safety points
Please read the following points before using your gas grill:
Do not operate gas grill if there is a gas leak. Turn off the gas supply.

After each connection, always check the gas hose connector for leaks with soap and water.
The lid must always be open when the burner is lit.
Use barbecue gloves and steady long-arm grill equipment when grilling.
Prepare for an accident or fire. Find out where first aid kits and fire extinguishers are stored and how to use them.
Keep electrical wires and gas supply hose away from hot surfaces.
Do not attempt to disconnect any gas fitting part if your gas grill is being used, on the gas grill or the gas regulator /
bottle.
Care is advised when operating your gas grill, you should never leave unattended when in use. Turn off the gas
supply at the gas container after use.
Do not heat an unopened glass or metal jar on the grill. Pressure can build up, causing the jar to explode and
serious injury or damage to the grill.
The gas grill must be cleaned regularly, recommended after each use.
Do not block the burning openings. Do not block the vents.
Be careful not to damage burner ports or venturi / nozzle openings when cleaning burner or valves.
Do not attempt to use this appliance in a garage or any enclosed area. Appliance must be keep away from
flammable materials, etc. We recommend keeping a distance of at least 0.5 to 1.0 meter clear of any flammable
materials.
Any modification of the appliance may be dangerous.
WARNING:The handle black area
(See above picture for reference) will become hot when the gas grill in use. BE CAREFUL! Do not
touch the black area.
Minimum clearances from combustible
materials must be:
Rear – 600 mm
Sides – 500 mm
Top – 1000 mm
6. Lighting instructions
Caution: The lid must be open when lighting the burner!
Do not stand with your face directly over the gas grill when lighting it.
Pilot Gas Control Ignition:
1. With all gas controls on the Gas grill in the “OFF” position, turn the gas cylinder valve to the on position at the
regulator. To create a spark, you must push the control knob in (A) and hold in this position for 3-5 seconds to
allow gas flow and then turn anticlockwise to” HIGH” (B). It can spark to the burner lighting tube (C). You will hear
a “snap” from the igniter, and you will also see orange flame coming from the burner lighting tube at the left side of
the burner (D).
2. Continue to hold the burner control knob in for two seconds after the “snap”, this will allow gas to flow completely
down the burner tube (E) and insure ignition.
3. When the burner is a light, adjacent burners will cross light when their controls are turned to “HIGH”
4. At “High” setting the burner flame should be longer than with a minimum of orange flame. Turn the gas control fully
anticlockwise for minimum setting.
5. Should you have any difficulty lighting your gas grill following the above steps, contact your dealer for advice.

Warning: If the burner still does not light, turn the burner control knob to” OFF” and wait 5 minutes to let the
gas clear before lighting again.
7. Storage
Your Gas Bottle must be stored in a well-ventilated area and must be disconnected from your gas grill when not being
used. Ensure that you are outdoors and away from any sources of ignition before attempting to disconnect your gas
bottle from your gas grill.
When you are using your gas grill after a period of storage, please ensure to check for gas leaks and check for any
obstructions in the burner etc. before using. Also follow the cleaning instructions to ensure gas grill is safe.
If gas grill is stored outdoors ensure to check that all areas under the front panel are free from any obstructions
(insects etc.) This area must be kept free as this may affect the flow of combustion or ventilation air.
8. Cleaning instructions
Maintenance is recommended that every 90 days for your gas grill, but it is absolutely necessary to perform
maintenance at least once a year. By doing so you will extend the life of your gas grill.
Your gas grill is easy to clean with minimum effort, just follow these helpful hints for cleaning convenience.
a) Turn on the burner for 15 to 20 minutes. Spilled grease burns off the grill and grill levels. Make sure the unit is cold
before continuing.
b) The grids shall be cleaned regularly with soap and water.
c) The inside of the grill lid should also be washed with water and soap.
d) Remove stubborn dirt with a wire brush, steel wool or scouring pad from the cast iron parts.
e) Regularly inspect the burners for insects or spiders that may clog the gas system and prevent gas flow.
Thoroughly clean the burner tubes and make sure there is nothing that could clog them.
f) We recommend using a pipe rack to clean the tube area.
g) Any modification to this equipment may be dangerous and is not permitted.
9. Trouble Shooting
Troubleshooting:
Problem
Possible cause
Prevention/solution
Grease fire or
excessive flames
above the grill
Grease accumulated on the
burners.
Switch off the LPG container. Leave the lid open
and let the flames go out. Once the grill has
cooled down, remove any food residue and
excessive grease from the burners, grease tray,
grease collector, griddle pan and other surfaces.
Gas leaking from a
damaged hose
Damaged hose.
Switch off the gas supply from the LPG
container. Replace the damaged
hose/valve/regulator. Check the LPG container
and connectors for leaks.
LPG container leak
Mechanical problem due to long
period of storage or misuse.
Switch off the LPG container valve.
LPG container valve
leak
Container valve malfunction due to
misuse or mechanical problem.
Switch off the LPG container valve. Return the
LPG container to the place of purchase.
Gas leak between the
LPG container and
regulator connector
Incorrect connection; loose
connection; faulty rubber fitting.
Switch off the LPG container valve, disconnect
the regulator and check the rubber fitting for
damages; check the LPG container for leaks
and check the regulator's connection to the LPG
container.
Flames come through
the control panel
Partial blockage of the burner pipe
has resulted in a fire.
Switch off the burners and the LPG container
valve. Once the fire has been put out and the
device has cooled down, remove the burner and
check for any spider’s webs or rust. See the
Cleaning Instructions section of the manual for
details.

The burner does not
ignite with the igniter
Gas-related problem:
1. You are igniting the wrong
burner.
2. The burner is not connected to
the control valve.
3. The burner is clogged.
4. No gas flow.
5. Steam built up in the LPG
container coupling nut.
6. The coupling nut is not properly
connected to the LPG container
valve.
1. See the control panel and the use and
maintenance section for instructions.
2. Make sure the valve is inside the burner
pipes.
3. Make sure the burner pipes are not blocked
by spider’s webs or other debris. See the Use
and maintenance section of the manual for
details.
4. Make sure the gas LPG container is not
empty. If the LPG container is not empty, see
Sudden drop in gas flow.
5. Switch off the control knobs, disconnect the
coupling nut from the LPG container.
Reconnect and try again.
6. Turn the coupling nut between a half turn and
a quarter turn.
The burner does not
ignite with the igniter
Electrical problem:
1. Broken electrode, sparks
observed.
2. The electrode tip is incorrectly
positioned.
3. The wire and/or electrode is
covered by food debris.
4. Loose or disconnected wiring.
5. Short-circuit in the wiring
(sparks) between the igniter and
the electrode.
6. Button is stuck, causing sparks
between the igniter and the
electrode.
1. Replace the electrode.
2. The electrode tip should point towards the
burner opening. The distance should be 3.2–
4.8 mm.
Adjust if necessary.
3. Clean the wiring and/or electrode with a
cotton tip dipped in sanitizer.
4. Reconnect the wiring or replace the
electrode/wiring.
5. Replace the igniter wire.
6. Replace the igniter.
7. Check the cable insulation and connection.
Replace the wiring if the insulation is damaged.
The burner cannot be
lit with a match.
1. See Gas related problem on the
previous page.
2. The match is used incorrectly.
1. See the Use and maintenance section of the
manual for details.
Sudden drop in gas
flow or low flame
Grease accumulation.
Very greasy meat.
Burner is on too high.
Clean the burners and inside the grill.
Trim any excess fat before grilling
Flame goes out
Strong or gusty wind.
Low LPG.
Gas flow valve was triggered.
Position the front of the grill towards the wind or
adjust the flame.
Fill the LPG container.
See the section Sudden drop in gas flow.
Flame goes out
Strong or gusty wind.
Low LPG.
Gas flow valve was triggered.
Position the front of the grill towards the wind or
adjust the flame.
Fill the LPG container.
See the section Sudden drop in gas flow.
Continuous grease fire
Grease dripping on the burners.
Switch off the control knobs. Switch off the gas
supply from the LPG container. Close the lid and
wait for the fire to go out. Once the grill cools
down, take out and clean all parts.
Flame flashback (fire
in the burner pipes)
The burner and the pipes are
clogged.
Switch off the control knobs.
Clean the burner and/or pipes.
See the Maintenance and use instructions for
the section related to cleaning the burner
Flames
Grease accumulation.
Very greasy meat.
Burner is on too high.
Clean the burners and inside the grill.
Trim any excess fat before grilling.
Adjust (lower) the temperature.
One burner is not lit by
other burners
Grease accumulation or food debris
in the transfer pipe.
Clean the transfer pipe with a steel brush.
If the steps above do not resolve the issue, visit the store where you purchased the gas grill.
10. Gas grill Safety Hints
Stand your gas grill on a safe level surface, away from inflammable items such as wooden fences or overhanging tree
branches.
Never use your gas grill indoors!
Once lit do not move your gas grill or leave it unattended.
Keep children and pets at a safe distance from the gas grill.
Keep a fire extinguisher handy.
The gas grill will become hot when in use, so handle lids etc. with the help of gloves.

Ensure that the appliance has completely cooled down before storing.
Use outdoors only!
Read the instructions before using the gas grill.
Assessable parts may be very hot, Keep young children away!
Do not move the gas grill during using.
Turn off the gas supply at the gas container after use.
Any modification of the appliance may be dangerous and be not permitted.
11. Warranty
The warranty for this product is 1 year from the date of purchase.
The warranty is void if the product is used for purposes other than its original purpose, or if the product is used for
commercial / professional or rental use.
The warranty does not cover damage resulting from natural conditions or damage resulting from improper storage.
For warranty issues, contact your dealer.
12. Environmental protection
When disposing of the packaging of the product, follow the recycling rules of different materials and local instructions
of waste management.
The appliance should not be disposed of with mixed waste.
Edututor Oy Kannistontie 5, 36220 Kangasala, Finland

KAASUGRILLI 6 + 1 + 1 poltinta
KÄYTTÖ- JA KUNNOSSAPITO-OPAS
Tuote 8340
2531-21
TEKNISET TIEDOT
Edututor
Kannistontie 5
36220 Kangasala, Finland
Kaasugrilli
PIN-NUMERO 2531CS-0116
SARJANUMERO G8611-S/8924/PO8854
Kohdemaat
Kaasuluokka
Kaasutyyppi
ja syöttöpaine
Pääpoltin
Sivupoltin
Takapoltin
6 poltin + sivupoltin + takapoltin
Suuttimen
halkaisija
Ø
Suuttimen
halkaisija
Ø
Suuttimen
halkaisija
Ø
Nimellislämpöteho (Hs)
BE, CY, DK, EE, FI,
HU, LT, NL, NO, SE,
SI, SK, RO, HR, TR,
BG, LU, MT
I 30B/P (30)
LPG-
kaasuseokset
(butaani /
propaani) 30
mbar
0.90 mm
0.85 mm
0.90 mm
27.7 kW / 2017 g/h
TÄMÄ KAASUGRILLI ON TARKOITETTU VAIN ULKOKÄYTTÖÖN!
TÄRKEÄÄ! LUE KAIKKI OHJEET JA TOIMINNOT ENNEN TÄMÄN LAITTEEN KÄYTTÄMISTÄ!
SÄILYTÄ NÄMÄ OHJEET TULEVAA TARVETTA VARTEN!
MUU KUIN KÄYTTÖOHJEESSA MÄÄRITELTY KÄYTTÖ ON KIELLETTY!
EI AMMATTIKÄYTTÖÖN!

HUOMIO
Lue ohjeet huolellisesti läpi ennen käyttöönottoa.
Ohjeet vähentävät loukkaantumisriskiä.
Jos ohjeita ei noudateta saattaa seurauksena olla vaarallinen tulipalo tai tuotteen vioittuminen.
Ostajan vastuulla on huolehtia siitä, että grilli on kunnolla koottu, asennettu ja se pidetään kunnossa. Tämän
käyttöohjeen noudattamatta jättäminen saattaa johtaa henkilövahinkoon ja/tai omaisuusvahinkoon.
VAROITUKSET
Tätä laitetta voivat käyttää vähintään 8-vuotiaat lapset ja sellaiset henkilöt, joiden fyysiset, aistinvaraiset tai henkiset
ominaisuudet ovat alentuneet tai joilla ei ole kokemusta ja tietoa, jos heitä valvotaan tai heitä on opastettu käyttämään
laitetta turvallisesti ja jos he ymmärtävät laitteen käyttöön liittyvät vaarat.
Lapset eivät saa leikkiä laitteella. Alle 3-vuotiaat lapset on pidettävä poissa, ellei heitä jatkuvasti valvota.
Lapset eivät saa puhdistaa laitetta eivätkä he saa tehdä laitteen hoitotoimenpiteitä ilman valvontaa.
Huomio:Laitteen eräät osat voivat tulla erittäin kuumiksi ja voivat aiheuttaa palovammoja. Erityistä huomiota on
kiinnitettävä, kun lapset ja herkät ihmiset ovat läsnä.
Vain ulkokäyttöön.
Lue ohjeet ennen laitteen käyttämistä.
Säilytä tämä opas tulevaa tarvetta varten.
Älä siirrä laitetta käytön aikana.
Varoitus: kosketeltavat osat saattavat olla hyvin kuumia. Pidä pienet lapset loitolla.
Käännä kaasun tulo kaasupullosta kiinni käytön jälkeen.
Kaikenlainen laitteen muuntelu voi olla vaarallista.
Käyttäjä ei saa muuttaa valmistajan tai sen edustajan sinetöimiä osia.
Laite on pidettävä käytön aikana kaukana syttyvistä aineista.
Älä koskaan sytytä kaasugrilli bensiinillä tai vastaavilla nesteillä!
Laitteen käyttäminen muuhun kuin suunniteltuun tarkoitukseen voi aiheuttaa vaaraa.
Paineensäädin ja letku ovat kytkettävä laitteeseen oikein.
Älä pidä kaasupulloa grillivaunun sisällä käytön aikana. Kaasupulloa ei saa sijoittaa laitteen sisään.
JOS HAISTAT KAASUA:
Katkaise kaasuntulo pullosta.
Sammuta kaikki liekit.
Tuuleta alue.
Tarkasta vuodot kuten kerrottu tässä käyttöoppaassa.
Jos haju ei häviä, ota välittömästi yhteys kaasun toimittajaan.
VAROTOIMET
Vuototestaa kaikki liitännät aina pullon vaihdon jälkeen ja ennen jokaista käyttöä.
Älä koskaan etsi vuotoja tulitikulla tai liekillä.
Älä säilytä tai käytä bensiiniä tai muita syttyviä höyryjä ja nesteitä tämän laitteen lähellä.
Mitään LP-kaasupulloa, jota ei ole liitetty käyttöön, ei saa säilyttää tämän laitteen lähellä.
KOKOAMINEN
VAROITUS: Vaikka grillin valmistuksessa on tehty kaikki mahdollinen terävien reunojen poistamiseksi, käsittele
kaikkia osia varovasti loukkaantumisten välttämiseksi.
Tarvittavat työkalut: Joko ristipääruuvimeisseli tai tasapäinen ruuvimeisseli tai avain.
Lue kaikki ohjeet huolellisesti ennen aloittamista. Etsi iso, siisti alue, jolla voit koota grillisi. Tutustu
osaluetteloon ja kokoonpanokaavioon tarpeen mukaan. Grillin kokoamisessa käsitellään monia isoja osia,
kahden henkilön osallistuminen laitteen kokoamiseen on suositeltavaa.
HUOMAUTUS: Varmista, että kaikki muovisuojat on poistettu ennen kokoamista!