La Marzocco GB/5 User manual
manual
gb5 &fb80
Named for Giovanna Bambi and designed with classic La Marzocco
styling and spirit, the GB/5 combines harmonious aesthetics and
powerful technological advancements With gracious lines and
curves. The GB/5 is an understated companion to any coffee bar,
while its unmatched temperature stability provides steady brew
water and steam even at the peak of the morning rush.
EN
gb5 &fb80
Chapters
page 2
page 4
page 6
page 11
page 14
page 15
page 17
page 18
page 19
EN
gb5 &fb80
Chapters
page 2
page 4
page 6
page 11
page 14
page 15
page 17
page 18
page 19
PoweredbyTCPDF(www.tcpdf.org)
EN
2
1)
2)
3)
Note: In case of doubt, do not go on any further and
contact your dealer or retailer immediately. They
will send out specialized personnel authorized to
perform service on the espresso machine.
4)
5)
6)
7)
8)
9)
machine.
10)
11)
The manufacturer shall not be held responsible for
any damages caused by improper and/or irrational
use.
12)
WARNING
THIS MACHINE IS FOR PROFESSIONAL USE ONLY AND
SHOULD BE INSTALLED IN LOCATIONS WHERE ITS
USE AND MAINTENANCE IS RESTRICTED TO TRAINED
PERSONNEL. CHILDREN ARE FORBIDDEN TO OPERATE
OR PLAY WITH THE MACHINE.
EN
3
13)
14)
15)
16)
17)
18)
In case the
Everything set out in this operating manual is also
valid for the “FB/80” series. The only differences
are the external dimensions of the machine.
19) COMMON DIMENSIONS, WEIGHTS, AND
FEATURES
77 107
GB/5
FB/80 2 gr. 3 gr. 4 gr.
A [mm]
B [mm]
C [mm]
WEIGHT [kg]
475 485
63
475 485 475 485
622 627
750 755 950 955 1190 1195
622 627 622 627
63 79 105
B
B
C
C
WARNING
AS ALREADY MENTIONED IN THE PRECEDING
NOTES, THE MANUFACTURER SHALL NOT BE HELD
RESPONSIBLE FOR DAMAGE TO OBJECTS, ANIMALS
AND/OR PEOPLE WHENEVER THE MACHINE HAS NOT
BEEN INSTALLED ACCORDING TO THE INSTRUCTIONS
CONTAINED IN THIS MANUAL, AND IS NOT USED TO DO
WHAT IT WAS DESIGNED FOR (I.E. PREPARING COFFEE
AND HOT DRINKS).
WARNING
THIS MACHINE IS NOT SUITABLE FOR OUTDOOR USE.
JETS OF WATER SHOULD NOT BE USED TO CLEAN THE
MACHINE, NOR SHOULD IT BE PLACED WHERE WATER
JETS ARE USED.
WARNING
THE COFFEE MACHINE MUST BE PLACED IN A
HORIZONTAL POSITION ON A COUNTER HIGHER THAN
80 CM FROM THE GROUND.
EN
4
AV
EE
MP
12 13
5
6
9 1 8 4 2 3 7 10 8 9
11
15
14a 14b
This operating manual refers exclusively to the following models, of our own manufacture:
Fig. 1 - Model AV & EE with 2, 3, or 4 groups
Legend
1
2
3
4
5
6
7Digital Display
8Steam Wand
9
10
11
12
13
14a
14b
15
EN
5
1) General description
2) Description of the various parts
replenished.
WARNING
THE MACHINE IS INTENDED TO BE PERMANENTLY
CONNECTED TO FIXED WIRING, AND IT IS MANDATORY
THAT A RESIDUAL CURRENT DEVICE (RCD) WITH
A RATED RESIDUAL OPERATING CURRENT NOT
EXCEEDING 30 mA IS INSTALLED.
EN
6
3. Installation
8000 35 2800 5000 8000 3/5 WIRES x 10mm²
3 X WIRES
220V
THE DETAILS ON THE LEFT DESCRIBE
HOW TO CONNECT EACH WIRE TO THE PLUG.
RESPECT ALSO THE LOCAL SAFETY
REGULATIONS.
MODEL/SERIES GROUP V/Hz
RATED
POWER
(W)
RATED
INPUT (A)
COFFEE
BOILER
WATTAGE
STEAM
BOILER
WATTAGE
TOTAL
WATTAGE
POWER CORD
SIZE (mm²)
GB/5 2GR 4600 21 1400 3000 4600 3/5 WIRES x 4mm²
FB/80 2GR 4600 21 1400 3000 4600 3/5 WIRES x 4mm²
GB/5 3GR 6100 28 1900 4000 6100 3/5 WIRES x 6mm²
FB/80 3GR 6100 28 1900 4000 6100 3/5 WIRES x 6mm²
GB/5 4GR 8000 35 2800 5000 8000 3/5 WIRES x 10mm²
FB/80 4GR
POWER CORD:
1 X BLUE (NEUTRAL)
1 X BROWN (PHASE)
1 X YELLOW & GREEN (GROUND)
5 X WIRES
380V
1 X BROWN (PHASE)
1 X GRAY (PHASE)
1 X BLACK (PHASE)
1 X BLUE (NEUTRAL)
1 X YELLOW & GREEN (GROUND)
AC220V/50-60Hz
A
C208V-240V/50-60H
z
AC380V/50-60Hz
AC220V/50-60Hz
A
C208V-240V/50-60H
z
AC380V/50-60Hz
AC220V/50-60Hz
A
C208V-240V/50-60H
z
AC380V/50-60Hz
AC220V/50-60Hz
A
C208V-240V/50-60H
z
AC380V/50-60Hz
AC220V/50-60Hz
A
C208V-240V/50-60H
z
AC380V/50-60Hz
AC220V/50-60Hz
A
C208V-240V/50-60H
z
AC380V/50-60Hz
(not provided)
(not provided)
Water
Mains
Valve
X
Fig. 3 - Installation NomenclatureFig. 2 - Installation Guide
Drain Grate
Drain Tray
WARNING
THIS APPLIANCE IS NOT INTENDED FOR USE BY
PERSONS (INCLUDING CHILDREN) WITH REDUCED
PHYSICAL, SENSORY OR MENTAL CAPABILITIES,
OR WITH LACK OF EXPERIENCE AND KNOWLEDGE,
UNLESS THEY HAVE BEEN GIVEN SUPERVISION
OR INSTRUCTION CONCERNING THE USE OF THE
APPLIANCE BY A PERSON RESPONSIBLE FOR THEIR
SAFETY.
WARNING
THE COFFEE BOILER AND STEAM BOILER CONTAIN
WATER AT ELEVATED TEMPERATURE. WATER
TEMPERATURE OVER 125°F / 52°C CAN CAUSE SEVERE
BURNS INSTANTLY OR DEATH FROM SCALDING (COFFEE
BOILER 207°F/97°C-STEAM BOILER 256°F /124°C)
EN
7
2) Accessories
drainage
a 3/8”G (BSP) (3/8”
Compression for USA and Canada)
100 mm
4 in.
HERE THE POSITION
OF THE POWER CORD
335 mm
13 in.
170 mm
6,7 in.
180 mm
7 in.
HERE THE POSITION
OF THE DRAIN TUBE 160 mm
6,3 in.
160 mm
6,3 in.
WATER INLET HOSES
102 mm
4 in.
80 mm
3 in.
415 mm
16,5 in.
POSITION OF THE HIGH LEGS MACHINE
545mm (2 groups)
21,5 in. (2 groups)
745 mm (3 groups)
29 in. (3 groups)
985 mm (4 groups)
38,5 in. (4 groups)
FROM ∅100 TO ∅120 mm
FROM ∅4 in. TO ∅4,7 in.
HERE THE POSITION WHERE WE
SUGGEST TO MAKE THE HOLE
ON THE TABLE
250 mm (2 groups)
10 in. (2 groups)
350 mm (3 groups)
13,5 in. (3 groups)
470 mm (4 groups)
18,5 in. (4 groups)
1) Installation on the counter
Fig. 4 - Installation on the counter
WARNING
IN ORDER TO PREVENT CRACKS OR LEAKAGE:
DO NOT STORE OR INSTALL THE COFFEE
MACHINE IN PLACES WHERE TEMPERATURE
MAY CAUSE WATER IN BOILER OR
HYDRAULICSYSTEM TO FREEZE.
WARNING
AT EACH INSTALLATION, THE MACHINE SHOULD BE
EQUIPPED WITH A NEW SET OF TUBES FOR PLUMBING
AND RELATED GASKETS.
EN
8
machine is installed and terminating
Note:
3) Water test kit
cards.
4) Water supply connection
installed.
EN
9
Note:
5) Electrical connections
a) Power supply cord
b) Water pump motor power cord
c) Quick connection between the water pump and
the espresso coffee machine
-
WARNING
HAZARDOUS VOLTAGE! DISCONNECT FROM
POWER SUPPLY BEFORE SERVICING
CAUTION
BEFORE MAKING ANY ELECTRICAL CONNECTIONS MAKE
SURE THAT THE 2 STRAIN RELIEF CONNECTORS ARE
FIRMLY SECURED TO THE BODY OF THE MACHINE IN
ORDER TO PREVENT INADVERTENT STRESS ON THE
POWER CABLES.
WARNING
THE MOTOR PUMP MUST BE SITUATED CLOSE TO THE
MACHINE IN AN ACCESSIBLE PLACE FOR MAINTENACE
BUT NOT FOR ACCIDENTAL INTERFERENCE AND WHERE
THERE IS AN OPTIMAL AIR CIRCULATION
EN
-
6) Waste water drain connection
WARNING
THE MANUFACTURER DECLINES ANY RESPONSIBILITY
FOR ANY EVENT LEADING TO LIABILITY SUITS
WHENEVER GROUNDING HAS NOT BEEN COMPLETED
ACCORDING TO CURRENT LOCAL, NATIONAL, AND
INTERNATIONAL REGULATIONS AND ELECTRICAL
CODES, OR OTHER ELECTRICAL PARTS HAVE BEEN
CONNECTED IMPROPERLY.
WARNING
- U.S.A. AND CANADA ONLY -
DO NOT CONNECT TO A CIRCUIT OPERATING AT MORE
THAN 150V TO GROUND ON EACH LEG.
ATTENZIONE
REPLACE FUSES WITH THE SAME SIZE, TYPE AND
RATING F1 = 2A, 250V
Min. Max.
T.D.S. ppm
ppm
ppm
2ppm
2ppm
pH
ppm
–ppm
N.B.:
EN
11
4. Machine Operation and Coffee Preparation
1) Starting the espresso machine
a) Filling the boilers with water
Note: It may happen that the air inside the
b) Turning the espresso machine on
2) Waiting for the espresso machine to heat to
operating temperature
happen anytime that the heating element
Fig.4
EN
12
Note:
5) Water pump
Note: When the heating element in the
6) Brewing coffee
Note:
EN
13
7) Controlling the brew process using volumetric
programming (AV model only)
8) General notes for coffee preparation
IMPORTANT
WARNING
DO NOT REMOVE THE FILTER HOLDER WHILE RELATIVE
GROUP IS BREWING HOT LIQUIDS. THE COFFEE BOILER
CONTAINS WATER AT ELEVATED TEMPERATURE. WATER
TEMPERATURE OVER 125°F / 52°C CAN CAUSE
SEVERE BURNS INSTANTLY OR DEATH FROM SCALDING.
EN
14
5. Dispensing Steam and Hot Water
1) Steaming milk or other liquids
2) Preparing tea and other hot drinks
EN
15
1) Cleaning groups and drain wells
and heat.
3) Cleaning the drain collector
4) Cleaning the body
6. Maintenance and Periodic Cleaning Operations
them.
5) Cleaning the hot water and steam nozzles
6) Cleaning the diffuser screen
Diuser
Screen
Group
Assembly
Diuser
Screw
CAUTION
THE MACHINE MUST NOT BE DIPPED IN NOR SPLASHED
WITH WATER IN ORDER TO CLEAN IT. FOR CLEANING
OPERATIONS, PLEASE FOLLOW THE INSTRUCTIONS
LISTED BELOW VERY CAREFULLY.
WARNING
NEVER REMOVE THE FILTER HOLDER WHEN WATER
IS BEING DELIVERED. THIS OPERATION CAN BE
EXTREMELY DANGEROUS SINCE THE HIGH PRESSURE
BUILT-UP INSIDE THE BLIND FILTER WOULD SPRAY
OUT HOT AND SLIGHTLY CAUSTIC WATER, WHICH MAY
CAUSE SEVERE BURNS. THE COFFEE BOILER CONTAINS
WATER AT ELEVATED TEMPERATURE.
WATER TEMPERATURE OVER 125°F / 52°C CAN CAUSE
SEVERE BURNS INSTANTLY OR DEATH FROM SCALDING.
WARNING
THE MACHINE MUST BE INSTALLED SO THAT QUALIFIED
TECHNICAL PERSONNEL CAN EASILY ACCESS IT FOR
EVENTUAL MAINTENANCE.
EN
16
7) Cleaning the gigler
8) Water Filter/Softener
Steam boiler draining:
trical mains.
WARNING
IN ORDER TO PREVENT CRACKS OR LEAKAGE: DO NOT
STORE OR INSTALL THE COFFEE MACHINE IN PLACES
WHERE TEMPERATURE MAY CAUSE WATER IN BOILER
OR HYDRAULIC SYSTEM TO FREEZE.
WARNING
IF THE ABOVE-MENTIONED INSTRUCTIONS ARE NOT
ADHERED TO THE MANUFACTURER CANNOT BE HELD
RESPONSIBLE FOR DAMAGE TO PERSONS OR THINGS.
EN
17
7. De-Commissioning and Demolition
1) De-commissioning and demolition
Disconnecting from the power outlet
Disconnecting from the water system
it.
Recycling notice: Warning for the protection of the
environment.
EN
18
8. Mandatory Maintenance and Check-up Operations
N.B. These periodic maintenance operations are not covered by warranty.
▪
▪
▪
▪
▪
▪
▪
▪
EVERY THREE/FOUR MONTHS
EVERY SIX/EIGHT MONTHS (in addition to the above)
EVERY YEAR (in addition to the above)
EVERY 3 YEARS (in addition to the above)
▪
▪
▪
▪
▪
▪
▪
▪
▪
▪
▪
▪
If AV Model:
▪
▪
If MP Model:
▪
▪
appliances.
▪
EN
19
“Barista” Programming
“Technical” Programming
Tea Water page 43
AV
9. Software Programming Guide
Other manuals for GB/5
6
This manual suits for next models
1
Table of contents
Other La Marzocco Coffee Maker manuals
La Marzocco
La Marzocco strada ep 1 User manual
La Marzocco
La Marzocco GB/5 Owner's manual
La Marzocco
La Marzocco SWIFT EPSB Programming manual
La Marzocco
La Marzocco Strada Instruction Manual
La Marzocco
La Marzocco linea mini User manual
La Marzocco
La Marzocco STRADA EE User manual
La Marzocco
La Marzocco GS/3 Operating instructions
La Marzocco
La Marzocco Linea Service manual
La Marzocco
La Marzocco GS/3 User manual
La Marzocco
La Marzocco Linea Classic Instruction sheet
La Marzocco
La Marzocco V1.0 User manual
La Marzocco
La Marzocco GB5 X Series User manual
La Marzocco
La Marzocco MICRA User manual
La Marzocco
La Marzocco STRADA MP Installation guide
La Marzocco
La Marzocco GB/5 User manual
La Marzocco
La Marzocco Linea PB User manual
La Marzocco
La Marzocco Strada AV User manual
La Marzocco
La Marzocco GS/3 User manual
La Marzocco
La Marzocco Linea PB User manual
La Marzocco
La Marzocco linea mini User manual
Popular Coffee Maker manuals by other brands
Siemens
Siemens TE506 Series Quick user guide
Jura Capresso
Jura Capresso IMPRESSA 68192 Operating instructions and warranty
DèLonghi
DèLonghi ESAM3550 Instructions for use
RUSTA
RUSTA 903013930301 manual
Bosch
Bosch TASSIMO vivy 2 TAS 140 Series instruction manual
Nespresso
Nespresso thermoplan AGUILA 220 user manual