Landscape Forms LEO User manual

INSTALLATIONPROCEDUREFORLIGHTPOLE:
1. Liftthelightpoleintopositionovertheinstalledanchors(refertoLEOanchorkit
installationguide)asshowninFig.1.Ensurethatthebaseplateisrestingonallfour
washers.
2. Installwasher,lockwasherandhexnutasshowninFig.2.
3. Plumbandlevelthepoleandtightenallanchors.
4. InstallclamponpoleasnotedinFig.3.
5. RemoveaccesspanelonluminairearmasshowninFig.4.Retainscrewsandwashers.
6. Usingahexkeysocketwithextension,installluminairetoclampasshowninFig.5.
7. Connectwiringtoconnectionterminalsintheluminaire.Refertowiringdiagramson
pages2and3.
8. Installthetopcaponthepole(shippedwiththepole).Iftheunithasatwistlock
receptacle,assemblethereceptacleandthetopcapasshowninFig.8andconnect
wiringbeforeinstallingthetopcap.Installprovidedshortingcaporphoto‐electric
control.
9. Replacetheaccesspanelontheluminairearm.
10. InstallthenutcoversasshowninFig.9orthecoverplateasshowninFig.10.
ToolsRequired
•Safetyglasses
•Wrenches,1‐1/8”
•Screwdrivers,Phillipsandstraightblade
•Wiringtoolsandconnectors
•Properpersonnel,craneorliftforhoistingunitontoanchors
•Level
•Dimmingcontrol,ifrequired
•Hexkeys
•5/16”hexkeysocketwith1‐1/2”extension.Flexdriveoruniversalishelpful.
•Twistlockphotoeye,ifrequired
LandscapeFormsisnotresponsibleforsitepreparationandfootings.Refertothe
installationguidefortheLEOlightanchorkitforinstallingtheanchorbolts.
CAUTION! Thisunitisheavy.Toavoidinjuryordamagetothefinish,werecommendusing
acraneorliftforhoistingtheunitontotheanchors.
WARNING! Polemountedluminairesmustbeattachedeitherbeforeorimmediately after
poleinstallation. Failuretodosomaycausevibrationdamagetothepoleandwillvoidthe
polewarranty.
Fig.1–Poleorientation
ASSEMBLEWITHCARE! Pangard IIPolyesterPowdercoat isastrong,long‐lastingfinish.Toprotectthis
finishduringassembly,placeunwrappedpowdercoated partsonpackagingfoamorothernon‐marring
surface.Donotplaceorslidepowdercoated partsonconcreteorotherhardortexturedsurface– thiswill
damagethefinishcausingrusttooccur.Usetouch‐uppaintonanygougesinthefinishcausedby
assemblytools.
Nutcoverwith1/4‐20
x5/8”buttonhead
capscrew
3/8‐16x1‐1/2”sockethead
capscrewwithlockwasher
Polewithbaseplate
12ft 16ft 20ft 25ft
Luminaire
22in 28in
22inClamp
Double
Single
28inClamp
Double
Single
Coverplate
assembly(optional)
Twistlockreceptacle,
optional
Polecap
Standard Fortwistlock
Fig.2– Installpole
Installation Guide
LEO Light
www.landscapeforms.com Ph: 800.521.2546
Date: May 19, 2017
Page 1 of 3
Includedcomponents
Shortingcapfor
Twistlock,
optional

Fig6.–luminairewiringconnection
Fig.5‐ Installluminaire
Fig.7– Installtopcap Fig.8– Installoptionaltwist
lockreceptacletotopcap
Installation Guide
LEO Light
www.landscapeforms.com Ph: 800.521.2546
Page 2 of 3
Fig.9– Installnutcovers
Fig.10– Installcoverplates
Fig.3– Installclamp Fig.4–Removeaccesspanel
Date: May 19, 2017

WIRINGDIAGRAM:28inluminaire,withouttwistlock
PROCEDUREFORWIRINGLEO:
TheLEOlightluminaireisassembledatthefactory.Thelightcartridgeismountedinto
theheadofthedomeandwillnotneedtoberemovedduringinstallation.TheLED
cartridgeiswiredtothedriver(locatedinthearmoftheluminaire)atthefactory.Useof
LEDdriversotherthanthesuppliedunitisnotrecommendedandwillvoidthewarranty.
Thewiringschematicsaretobeusedtoconnecttheunittolinevoltage.Itisthe
responsibilityoftheinstallertomakesurethatallconnectionsaremadeinaccordance
withtheNECandlocalbuildingcodes.Connectionhardwarenotincluded.
Line‐inwiresshouldbeconnectedtotheterminalblockasshown.Optionaldimming
controlisnotincluded.
Installation Guide
LEO Light
www.landscapeforms.com Ph: 800.521.2546
Page 3 of 3
WIRINGDIAGRAM:22inluminaire,withouttwistlock
Date: May 19, 2017