Majestic Saunas SA3212 User manual

SA3212
Rev. 5/16, Ver. 2
OWNER’S MANUAL
THREE-PERSON CORNER SAUNA
WITH CARBON HEATERS
Please Do Not Hesitate to
Contact Our Consumer Hotline
at 800-759-0977
with Any Questions That May
Arise During Assembly or
Use of This Product!

2
ASSEMBLY TIPS & WARNINGS
PARTS IDENTIFIER
ASSEMBLY INSTRUCTIONS
OPERATION INSTRUCTIONS
ENJOYING YOUR SAUNA
HEALTH & SAFETY WARNINGS
CLEANING & MAINTANENCE
TROUBLESHOOTING GUIDE
REPLACEMENT PARTS
WARRANTY INFORMATION
3
4
5-10
11
12
13
14
14-15
16-17
18
TABLE OF CONTENTS
The information contained in this manual is subject to change without notice.
If you would like a French version of this manual, please contact
our Customer Service Department at 800-759-0977 or [email protected]
Si vous voulez une version française d’un manuel, s'il vous plaît contacter
notre service à la clientèle au 800-759-0977 ou [e-mail]

3
• Before you begin, read all assembly instructions and safety warnings carefully.
•This sauna requires at least 3 adults to complete assembly.
•Remove all of the contents from boxes and verify that you have all of the parts shown on the Parts
Note: Some parts may be pre-installed or pre-assembled.
may not look exactly like your product.
• Retain this Owner’s Manual for future reference.
ELECTRICAL REQUIREMENTS
•We recommend consulting a licensed electrician and checking local ordinances before installing
ANY sauna.
• This sauna requires a 20 amp receptacle and a 20 amp circuit breaker.
may be required to accommodate 20 amp power.
•This sauna requires a dedicated circuit - No other appliances should share the same outlet with the
sauna.
CHOOSING A LOCATION
•This sauna should only be placed INDOORS on a dry, level surface.
•There should be a minimum of 5 inches clearance between the sauna and any wall.
• Make sure the main power cord will reach the outlet and remains easy to access.
•The sauna should only be used in a dry location as moisture will damage the wood and electrical
components.
combustible materials.
ASSEMBLY TIPS & WARNINGS

PARTS IDENTIFIER (NOT TO SCALE)
4
17
This manual is used for the assembly of several
sauna models; therefore, some images or drawings
may not look exactly like your product.
For replacement parts please call 800-759-0977.

1. Begin assembly by determining an appropriate location for your sauna – see ASSEMBLY
TIPS & WARNINGS for details. Attach the FRONT PANEL to the FLOOR by lining up the FRONT
PANEL with the groove in the front of the FLOOR.
2. Attach the LEFT PANEL to the FRONT PANEL by aligning the hooks and sliding the LEFT
PANEL down, locking it into place.
3. Attach the RIGHT PANEL to the FRONT PANEL by aligning the hooks and sliding the RIGHT
PANEL down, locking it into place.
ASSEMBLY INSTRUCTIONS
5

4. Attach the LEFT BACK PANEL to the FLOOR. Buckle the LEFT BACK PANEL to the LEFT PANEL.
5. Attach the RIGHT BACK PANEL to the FLOOR. Buckle the RIGHT BACK PANEL to the RIGHT
PANEL and to the LEFT BACK PANEL.
6. Attach the FLOOR HEATER to the FLOOR with 1-1/2” SCREWS. Connect the heater plug.
ASSEMBLY INSTRUCTIONS (CONT.)
6

7. Slide the LONG BENCH HEATER PANEL into place between the LEFT BACK PANEL and RIGHT
PANEL. Connect the heater plug. Note: It may be necessary to unbuckle the RIGHT PANEL from
the RIGHT BACK PANEL in order to slide the LONG BENCH HEATER PANEL into place.
8. Slide the SHORT BENCH HEATER PANEL into place between the LONG BENCH HEATER
PANEL and LEFT PANEL. Connect the heater plug. Note: Make sure the FLOOR HEATER cable is
placed through the groove in the bottom of the SHORT BENCH HEATER PANEL.
9. Attach LONG BENCH SEAT with 2” SCREWS.
ASSEMBLY INSTRUCTIONS (CONT.)
7

10. Attach SHORT BENCH SEAT with 2” SCREWS.
11. Lift the ROOF above the sauna, feeding the control panel and heater cables through the
corresponding holes. Feed the cables for the AM/FM CD PLAYER through the hole in the bot-
tom of the ROOF. Secure the ROOF to the sauna with 1-1/8”SCREWS. Connect the control
panel and heater plugs.
ASSEMBLY INSTRUCTIONS (CONT.)
8
12. Feed the main power cable through hole in ROOF and plug securely into receptacle on back
of POWER SUPPLY box . Secure the ROOF COVER with 3/4”SCREWS.

ASSEMBLY INSTRUCTIONS (CONT.)
14. Gently pull the cables for the AM/FM CD PLAYER through the opening in the front of the
STEREO SHELF. Attach the STEREO SHELF with 3/4” SCREWS.
15. Plug the controller and antenna into the back of the AM/FM CD PLAYER. Slide and lock the
AM/FM CD PLAYER into the STEREO SHELF.
16. Attach the MAGAZINE RACK with 1-1/2” SCREWS. Note: A sticker indicates the optimal posi-
tion for this accessory, but attaching it is optional. Consider the position carefully before driving
any screws into the sauna interior.
9
13. Attach the DOOR HANDLE to the GLASS DOOR by assembling parts (A) as shown (for top
GLASS
DOOR
OUTSIDEINSIDE
A
B
C

17. Attach the CUP HOLDER(S) with 3/4” SCREWS. Note: A sticker indicates the optimal position
for this accessory, but attaching it is optional. Consider the position carefully before driving any
screws into the sauna interior.
18. Attach the DOUBLE TOWEL HOOK with 3/4” SCREWS. Note: A sticker indicates the optimal
position for this accessory, but attaching it is optional. Consider the position carefully before driv-
ing any screws into the sauna interior.
19. Remove the back cover of the OXYGEN IONIZER by turning is as indicated. Unwrap and
install the fragrance patch, then reattach the back cover. Attach the OXYGEN IONIZER in the
designated position with 3/4”SCREWS. Plug the power cable into the OXYGEN IONIZER.
20. Plug the main power cable into a dedicated outlet. Note: No other appliances should share
the same outlet with this sauna.
The assembly of your sauna is now complete.
Please review the Operation Instructions and Health & Safety warnings before using your
sauna.
To ensure years of trouble-free use, follow the Cleaning & Maintenance guidelines carefully.
ASSEMBLY INSTRUCTIONS (CONT.)
10
CONGRATULATIONS!

DIGITAL CONTROL OPERATION INSTRUCTIONS
1. Press POWER to turn ON the sauna.
Left window displays temperature, the right one displays time.
2. Set the desired TEMPERATURE with the (+) and (-) buttons.
3. Press and hold both (+) and (-) to switch between °F (Fahrenheit)
and °C (Celsius).
4. Set the desired TIME with the (+) and (-) buttons.
6. When the TIME reaches 00, the heaters will turn OFF automatically.
You will hear a reminder beep when time reaches 1 minute left.
7. After your sauna session, press POWER to turn OFF the sauna.
DO NOT leave sauna unattended while power is on. If the sauna will
not be used for a long period of time, please unplug the power cord.
To extend the sauna use life, please shut down for 30 minutes after
3 hours of continuous use.
8a. Press the center light icon (see above) to turn ON the Color Therapy Light.
1. Press ION to release negatively charged ions to purify the air.
2. Press O3 to disinfect the air with ozone.
11
COLOR THERAPY LIGHT
OXYGEN IONIZER (Two-Person Models Only)
1,7
2,3
4
5
6
5. Press INSIDE or OUTSIDE to turn on or o the corresponding light.
8
8b. Color selection: continue pressing the therapy button for 2 seconds,right side will show “2n”,now the color
mode will change each time you press the button, meanwhile the left side will shows 1L thru 9L:
1L:quick color changing mode
2L:slow color changing mode
3L:white color, can be used as reading light
4L-9L:colorful mode
If the selection button isn’t pushed for 5 seconds, the screen will return to TIME and TEMPERATURE display mode.
If you want to set color light again, keep pressing the therapy button.
8c. Press the center light icon (see above) to turn OFF the Color Therapy Light.

ENJOYING YOUR SAUNA
1. Prior to initial use, wipe down all interior surfaces of the sauna with a damp cloth.
3. Always drink plenty of water before, during and after your sauna session to stay properly
hydrated.
4. A normal sauna session should last 30 minutes or less.
5. Allow approximately 25 to 45 minutes for the sauna to warm up before entering.
6. Perspiration will begin within 10 to 20 minutes after entering the sauna.
7. Limit the use of lotions or oils on your body while using your sauna. These products can
8. For spot treatment of a particular area, position that body part closer to the heater, allow-
ing for deeper heating in that area.
perspiration and maintain the cleanliness of your sauna.
freely.
11. Open the ceiling vent or the front door to allow fresh air into your sauna.
12. Allow your body to cool down following your sauna session, then rinse the perspiration
12

HEALTH & SAFETY WARNINGS
1. Review all instructions and warnings before operating your sauna. A sauna is not a toy. Seri-
ous injury may result from negligence, intentional misuse and failure to follow safety instruc-
tions.
2. Hyperthermia Danger: Hyperthermia occurs when the body absorbs more heat than it can
dissipate. When the elevated body temperatures are suciently high, hyperthermia is a medical
emergency and requires immediate treatment to prevent disability or death. It is very impor-
tant not to allow your body’s core temperature to rise above 103° F. Symptoms of hyperthermia
include dizziness, lethargy, drowsiness and fainting. The eects of hyperthermia may include
failure to perceive heat, failure to recognize the need to exit the sauna, unawareness of the im-
pending health hazard, physical inability to exit the sauna and unconsciousness.
3. If you are feeling uncomfortable, faint or dizzy, exit the sauna immediately.
4. Do not exceed recommended time and temperature guidelines.
5. Do not touch or interfere with the temperature sensor on the control panel.
6. Do not touch or spray water on the heater elements.
7. Do not use the sauna while under the inuence of drugs or alcohol.
8. Do not sleep inside the sauna.
9. Do not use the sauna immediately following strenuous exercise. Allow your body to cool
down for 30 minutes before entering the sauna.
10. Pets should never be placed in the sauna.
11. Pregnant women, children under the age of 6, the elderly and inrm should not use the
sauna.
12. Children over the age of 6 should always be supervised by an adult.
13. People with health problems including open wounds, fever, sunburn or dehydration should
not use the sauna.
14. People suering from obesity or with a history of heart disease, low or high blood pressure,
circulatory system problems or diabetes should consult a physician before using the sauna.
15. Consult a physician before using the sauna if you take any prescription medications.
16. Keep towels and combustible materials away from the heater elements.
17. Remove all towels and materials after your sauna session.
18. Never leave your sauna unattended while in use.
19. Always unplug the sauna and allow it to cool down before performing any cleaning or main-
tenance.
20. Always turn o and unplug the sauna when not in use.
13

CLEANING & MAINTENANCE
1. Always unplug the sauna and allow it to cool down before performing any cleaning or
maintenance.
2. Use furniture polish or furniture oil when cleaning the sauna exterior.
3. The sauna interior surfaces should only be wiped down with a damp cloth. Do NOT use
chemicals, abrasive cleaners or solvents on the unnished interior wood.
4. As with all natural wood products, variations in the color and the grain as well as irregu-
larities such as knots and ne cracks may be present. These characteristics are a part of the
natural beauty of the wood and should not be considered defective.
14
WARNING!
1. Check that the Main Power Cable is plugged into the wall outlet.
2. Check that the circuit breaker for the outlet has not tripped. If the breaker has tripped, check that the
amperage of the breaker is appropriate for your sauna.
3. Check all connections to the Power Supply Box.
4. Check for damage to the Main Power Cable; replace, if necessary.
5. Replace the Power Supply Box, if necessary.
1. Check that all the connections are tight.
2. Replace the Heater Element.
1. Check that all connections are tight.
2. Replace the Heater Circuit Board, if necessary.
Problem
Solution
Solution
Solution
Problem
Problem
THERE IS NO POWER TO THE SAUNA
ONE HEATER DOES NOT WORK
NONE OF THE HEATERS WORK
TROUBLESHOOTING GUIDE
• Always unplug the sauna and allow it to cool down before performing any maintenance.
• Repairs to the electrical components of the sauna should only be performed by a qualied service technician.
• Unauthorized repairs or alterations will void the manufacturer’s warranty.

TROUBLESHOOTING GUIDE (CONT.)
15
1. Check that all the connections are tight.
2. If the numbers are scrambled or the buttons are unresponsive,
replace the Control Panel.
3. If the temperature indicator does not work or reads “--” or “EP”, check all connections,
then replace the Control Panel if needed.
1. Check that all the connections are tight.
2. If one light does not work, replace the bulb.
during installation.
3. If neither the lights nor the radio are working, replace the Power Supply Box.
1. Check that all the connections are tight.
2. Check the fuse; replace if necessary.
3. Replace the radio.
4. If neither the radio nor the lights are working, replace the Power Supply Box.
1. Check that the volume is not turned all the way down and that the fader control is set correctly.
2. If only one speaker is working, check to see that the sound balance on the stereo is not set all the way
to one side.
3. Check that all the connections are tight.
4. Replace the speaker, if necessary.
1. Check that all the connections are tight.
2. Replace the Color Therapy Light or Color Therapy Control Panel, if necessary.
Problem
Problem
Problem
Problem
Problem
THE CONTROL PANEL DOES NOT WORK
THE LIGHTS ARE NOT WORKING
THE RADIO AND/OR CD PLAYER IS NOT WORKING
THE SPEAKERS ARE NOT WORKING
THE COLOR THERAPY LIGHTS ARE NOT WORKING
Solution
Solution
Solution
Solution
Solution
REPLACEMENT PARTS
the top of each page to make sure you’re using the correct list for your sauna. In the event that you need replacement
manufacturer. The use of unauthorized substitutes may damage your sauna or cause electrical hazards resulting in
4. If the temperature indicator reads "H" and the buzzer sounds, this is the built in
“high temperature protection”. Please turn o the sauna and let it cool down
before turning back on.

16
REPLACEMENT PARTS Rev. 5/16
REF. # DESCRIPTION PART NUMBER
1 FRONT PANEL with GLASS DOOR SAP5017
2 RIGHT PANEL SAP5018
3 LEFT PANEL SAP5019
4 LEFT BACK PANEL SAP5020
5 RIGHT BACK PANEL SAP5021
6 CONTROL PANEL SAP5008
7 ROOF SAP5022
8 ROOF COVER SAP4026
9 FLOOR SAP5023
10 GLASS DOOR SAP5010
10 GLASS CLIP - METAL SAP2537
10 DOOR MAGNET SAP25371
12 FLOOR HEATER SAP4120
13,14 330W HEATER ELEMENT – LEFT BACK PANEL SAP2418
13,14 330W HEATER ELEMENT – RIGHT BACK PANEL SAP2418
15 POWER SUPPLY BOX SAP24071
15 POWER SUPPLY RECEPTACLE SAP24073
15 HEATER CIRCUIT BOARD SAP2428
15 25 AMP OVERCURRENT PROTECTOR SAP2530
16,17 180W HEATER ELEMENT – LONG BENCH HEATER SAP2419
16,17 180W HEATER ELEMENT – SHORT BENCH HEATER SAP2419
18 STEREO SHELF SAP24024
19 AM/FM CD PLAYER with MP3 INPUT SAP24085
20 OXYGEN IONIZER SAP4409
21 BACKREST SAP2412
22 80W HEATER ELEMENT – FLOOR HEATER SAP2420
23 DOOR HANDLE SAP5007
24 EXTERIOR LIGHT BULB SAP2404
24,27 LIGHT HOUSING SAP2606
25 DOOR HINGE SAP24154
27 INTERIOR LIGHT BULB SAP2404
28 COLOR THERAPY LIGHT SAP5009
SPEAKER SAP2416
30 THERMOSTAT WIRE SAP25314
31 LONG BENCH SEAT SAP4121
32 LONG BENCH HEATER PANEL SAP4122
32 SHORT BENCH HEATER PANEL SAP4124
33 MAGAZINE RACK SAP2414
34 CUP HOLDER SAP2444
35 DOUBLE TOWEL HOOK SAP2460
36 MAIN POWER CABLE SAP2704
37 2” (50mm) SCREW SAP2411
37 1-1/2” (40mm) SCREW SAP2411
37 1-1/8” (30mm) SCREW SAP2411
37 3/4” (20mm) SCREW SAP2411
38 SHORT BENCH SEAT SAP4123
---
---
BUCKLE SAP2607
WOODEN POWER CABLE COVER SAP3128
Please see drawing on next page to assist in identifying parts.
SA3212 THREE-PERSON HEMLOCK CORNER MAJESTIC SAUNA
QTY.
1
1
1
1
1
1
1
1
1
1
2
2
1
2
2
1
1
1
1
1
1
1
1
1
3
1
1 SET
2
6
2
4
1
2
1
1
1
1
1
2
1
1
6
10
8
35
1
9
1
29,39
--- CONTROL PANEL WIRE (SHORT) SAP2536 1
--- CONTROL PANEL WIRE (LONG) SAP25361 1
--- CIRCUIT BOARD TO POWER SUPPLY BOX WIRE SAP24281 1

SAUNA WARRANTY REGISTRATION CARD
1. This sauna has a 7-Year Limited Warranty against defects in materials and workmanship from date of purchase. To receive the warranty,
the card below must be lled out completely and returned within thirty (30) days from date of purchase. This 7-Year Limited Warranty covers
the wood structure*. Heating elements and all electronics are covered by a 5-Year Limited Warranty. The radio/CD player (if included with
your sauna) is covered by a limited 1-Year Warranty. The light bulbs are covered for 90 days.
2. This product is intended to be utilized for private, non-commercial use. Blue Wave Products sauna must be used as directed in the
Product Operation Manual. Utilization of non-Blue Wave replacement parts or repairs which are not done by or under the direction of
Blue Wave Products, Inc. shall also void any warranties/guarantees, expressed or implied.
3. This warranty does not cover defects or damage due to improper installation, alteration, accident, installation of unauthorized
parts or any other event beyond the control of the Blue Wave Products. Defects or damage resulting from misuse, abuse or
negligence will void this warranty. This warranty does not cover scratching or damage that may result from normal usage.
4. Please notify Blue Wave Products in advance of any sauna warranty claim prior to shipping the sauna back. Contact our warranty
claim department at [email protected]. This warranty becomes valid at time of purchase and terminates either by
specied time frame listed above, owner transfer, or relocation.
5. Thiswarranty is nontransferable and is expressly limited to the repair or replacementof the defective product. During the warranty
period, Blue Wave Products shall repair or replace defective parts at no cost to the purchaser. Shipping charges and insurance are not
covered and are the responsibility of the purchaser. Labor charges and related expenses for removal, installation or replacement of
the product or components are not covered under this warranty.
6. If the warranty claim department determines that the item must be returned, it must be returned with freightprepaid and a receiptshowing
date of purchase, purchase price, and the dealer fromwhich the sauna was purchased. No warranty claim will be honored without a receipt.
7. Warranty claims will only be resolved with the repair of the current product, or shipment of a replacement product or parts at the
sole discretion of Blue Wave Products. NO REFUNDS will be given.
10. Improper installation, misuse or damages resulting from acts of nature will renderthis warranty nulland void.
11. This warranty is in lieu of all other warranties expressed or implied and no responsibility is assumed for future damage due to misuse.
This sauna is intended for INDOOR USE ONLY– outdoor installation of the sauna WILL VOID THE WARRANTY. Additional actions that will void
the warranty are: Use of lacquer or paints on any part of the sauna, placing sauna on non-approved surface, and outdoor applications.
*Surface cracks are NOT considered defects in material or workmanship, as they are normal characteristics of all wood. This includes
minor cracks due to wood expansion and contraction. Note: since the wood used in construction has been kiln dried, a certain amount
of expansion and contraction is expected in the wood within a sauna environment. Also, over time the sauna wood may darken or
change color tones. This color change is considered normal aging and is not covered under warranty.
To send in this warranty card:
Fill out below, detach and mail
to the following address:
BLUE WAVE PRODUCTS
1745 Wallace Ave. Suite B
St. Charles, IL 60174
SAUNA WARRANTY REGISTRATION FORM
Date Purchased: _____/_____/_____
Name: _____________________________________________________________________________________
Address: ___________________________________________________________________________________
City/State/Zip: ______________________________________________________________________________
Phone: ( ) ____________________________________ Email: ______________________________________
Purchased from: _____________________________________________________________________________
ItemNumber:____________________________________ PurchasePrice:_______________________________
Serial Number: ______________________________________________________________________________
To ensure product warranty, complete all informationand mail this card within 30 days of purchase.
8. Blue Wave Products reserves the right to make substitutions to warranty claims if parts are unavailable or obsolete.
9. Blue Wave Products shall not be liable for loss of use of the product or other consequential or incidental costs, expenses or
damages incurred by the consumer of any other use. The user assumes all risk of injury resulting from the use of this product.
For further warranty information
or inquiries, please call 800-759-0977