McCulloch MC13538LT Owner's manual

REPAIR PARTS MANUAL
MODEL NO. MC13538LT (96012010300)
Lawn Tractor
www.mcculloch.biz
532 43 25-89

2
HOW TO USE THIS MANUAL
This manual is designed to provide the customer with a means to identify the parts on his/her tractor
when ordering repair parts. The illustrations may or may not represent the actual assemblies; therefore,
it is not recommended to use this manual as a guide to assemble or disassemble the tractor. Some
hardware and parts are drawn larger in order to more readily identify them.
Each tractor has its own model number.
The model number for your tractor can be found on the fender under the seat.
When ordering parts, always give the following information:
• Product - “Tractor”
• Model Number - “
MC13538LT (96012010300) ”
• Part Number
• Part Description
TABLE OF CONTENTS
SCHEMATIC ................................................................................................................ 3
ELECTRICAL............................................................................................................4-5
CHASSIS ..................................................................................................................6-7
DRIVE........................................................................................................................8-9
STEERING ............................................................................................................10-11
ENGINE.................................................................................................................12-13
MOWER DECK .....................................................................................................14-15
MOWER LIFT............................................................................................................. 16
SEAT .......................................................................................................................... 17
DECALS..................................................................................................................... 18

3
TRACTOR - - MODEL NUMBER MC13538LT (96012010300), PRODUCT NO. 960 12 01-03
SCHEMATIC
BATTERY
FUSE
AMMETER
(OPTIONAL)
RED RED
RED
RED
WHITE
BLACK
BLUE
BLACK
BLACK
BLACK/WHITE
BLACK
BLACK
BLUE
BLUE
BROWN
BLACK
BLACK
GRAY
GRAY
BLACK
D
IO
N
ELOS
M
A
STARTER
CLUTCH / BRAKE
(PEDAL UP)
SEAT SWITCH
(NOT OCCUPIED)
IGNITION
UNIT
HOUR
METER
FUEL
LINE
FUEL SHUT-OFF
SOLENOID
HEADLIGHTS
SM
B
GA1
A2
L
REVERSE SWITCH
SPARK PLUGS
GAP
(2 PLUGS
ON TWIN CYL. ENGINES)
(OPTIONAL)
NOT IN REVERSE
LIGHT SWITCH
SHORTING CONNECTOR
ATTACHMENT CLUTCH
(CLUTCH OFF)
REMOVABLE
CONNECTIONS
NOTE
YOUR TRACTOR IS
EQUIPPED WITH A SPECIAL
ALTERNATOR SYSTEM.
THE LIGHTS ARE NOT
CONNECTED TO THE
BATTERY, BUT HAVE THEIR
OWN ELECTRICAL SOURCE.
BECAUSE OF THIS, THE
BRIGHTNESS OF THE LIGHTS
WILL CHANGE WITH ENGINE
SPEED. AT IDLE THE LIGHTS
WILL DIM. AS THE ENGINE IS
SPEEDED UP, THE LIGHTS
WILL BECOME THEIR BRIGHTEST.
WIRING INSULATED CLIPS
NOTE: IF WIRING INSULATED CLIPS
WERE REMOVED FOR SERVICING OF
UNIT, THEY SHOULD BE RE-INSTALLED
TO PROPERLY SECURE YOUR WIRING.
IGNITION SWITCH
CIRCUITPOSITION
OFF B+A1
RUN/OVERRIDE
B+S+A1START
M+G+A1
B+A1RUN
“MAKE”
L+A2
NON-REMOVABLE
CONNECTIONS
SCH03
ORANGE
LIGHTING SYSTEM OUTPUT
5 AMP AC @ 3600 RPM STATOR
14 VOLTS AC MIN. @ 3600 RPM (LIGHTS OFF)
DIODE
28 VOLTS AC MIN. @ 3600 RPM
(CHARGING SYSTEM DISCONNECTED)
CHARGING SYSTEM OUTPUT
3AMPDC@3600RPM

4
TRACTOR - - MODEL NUMBER MC13538LT (96012010300), PRODUCT NO. 960 12 01-03
ELECTRICAL
L02
30
33 34
22
79 21
26
90
42
43
27
41
25
24
28
16
16
29
94
92
2
40
93

5
TRACTOR - - MODEL NUMBER MC13538LT (96012010300), PRODUCT NO. 960 12 01-03
ELECTRICAL
1 532 16 34-65 Battery 12 Volt 25 Amp
2 874 76 04-12 Bolt Hex Hd 1/4-20 unc x 3/4
8 532 17 66-89 Battery Box
16 532 17 61-38 Switch Interlock Push-In
21 532 17 56-88 Harness Asm. Light
22 532 00 41-52 Bulb Light
24 532 42 12-99 Cable Battery 6 Ga. 11" Red
25 532 42 12-97 Ground Rear Btry
26 532 17 51-58 Fuse
27 873 51 04-00 Nut Keps Hex 1/4-20 unc
28 532 42 12-98 Cable Ground 6 Ga. 12" Black
29 532 19 27-49 Switch Seat
30 532 19 33-50 Switch Ign
33 532 41 19-35 Key/Chain
34 532 11 07-12 Switch Light
40 532 19 74-28 Harness Ign
41 871 11 04-08 Bolt Blk Fin Hex 1/4-20
42 532 13 15-63 Cover Terminal Red
43 532 19 25-07 Solenoid
79 532 17 52-42 Socket Asm Bulb
90 532 18 04-49 Cover Terminal Battery
92 532 19 66-15 Harness Pigtail ROS
93 532 19 25-40 Screw Plastite 10-14 x 2.0
94 532 19 18-34 Module Reverse ROS
NOTE: All component dimensions given in U.S. inches
1 inch = 25.4 mm.
KEY PART
NO. NO. DESCRIPTION