Napoleon BIPRO 665 User manual
EN
FR
PG.31
WARNING
Do not try to light this appliance without
reading the “LIGHTING” instrucons secon of
this manual.
Do not store or use gasoline or other
ammable liquids or vapors in the vicinity of
this or any other appliance. An L.P. cylinder
not connected for use must not be stored in
the vicinity of this or any other appliance.
If the informaon in these instrucons is
not followed exactly, a re or explosion may
result, causing property damage, personal
injury or death.
DANGER
IF YOU SMELL GAS:
• Shut o gas to the appliance.
• Exnguish any open ame.
• Open lid.
• If odor connues, keep away from the
appliance and immediately call your gas
supplier or re department.
APPLY SERIAL NUMBER LABEL FROM CARTON
Serial No.
XXXXXX000000
MODEL NO.
BIPRO 665
This gas grill must be used only outdoors in a well-venlated space and must not be used inside a
building, garage, screened-in porch, gazebo or any other enclosed area.
WARNING! CABINET FRAME, CABINET AND COUNTER TOP MUST BE MADE FROM NON-COMBUSTIBLE MATERIAL.
N415-0307 APR 17.14
Noce to Installer: Leave these instrucons with the grill owner for future reference.
Adults and especially children should be alerted to the hazards of high surface temperatures.
Young children should be supervised near the gas grill.
Napoleon Group of Companies
214 Bayview Dr., Barrie, Ontario, Canada L4N 4Y8 Phone: 1-705-726-4278 Fax: (705)725-2564
www.napoleongrills.com
Customer service: 1-866-820-8686 or wecar[email protected]
www.napoleongrills.com
2
EN
All NAPOLEON gas grills are manufactured under the strict Standard of the world recognized ISO 9001-2008
NAPOLEON products are designed with superior components and materials, and are assembled by trained
Napoleon Gas Grill President’s Limited
Lifeme Warranty
NAPOLEON warrants that components in your new NAPOLEON product will be free from defects in
Stainless steel tube burners 10 years plus5
Stainless steel sear plates 5 years plus5
plus5
All other parts 2 years
plus5
Condions and Limitaons
Any damages to the gas grill due to weather damage, hail, rough handling, damaging chemicals or cleaners will not be the responsibility of
NAPOLEON.
www.napoleongrills.com
3
EN
WARNING! Failure to follow these instrucons could result in property damage, personal injury or
death. Read and follow all warnings and instrucons in this manual prior to operang grill.
Safe Operang Pracces
building, garage, screened-in porch, gazebo or any other enclosed area.
grill.
out of reach of children. Disconnected cylinders must not be stored in a building, garage or any other
enclosed area. Natural gas units must be disconnected from the supply when being stored indoors.
by the grill manufacturer.
and the built-in side burner BISB245.
Adults and especially children should be alerted to the hazards of high surface temperatures. Young
Do not light burners with lid closed.
Keep any electrical supply cord and fuel supply hose away from any heated surfaces.
Do not use a pressure washer to clean any part of the unit.
www.napoleongrills.com
4
EN
General Informaon
b
and ANSI
b
absence of local codes, install to the current
CALIFORNIA PROPOSITION 65
Propane Cylinder Specicaons
WARNING! If these instrucons are not followed exactly, a re causing death or serious injury
may occur.
WARNING! Do not store a spare propane cylinder on the shelf beneath the barbecue.
or serious injury may occur.
Gas Hook-Up Instrucons
WARNING! This grill is designed for non-combusble enclosures only, and must be installed and
serviced by a qualied installer to local codes.
WARNING! Cabinet frame, cabinet, and counter top must be made from non-combusble material.
WARNING! The pressure supplied to the grill must conform to what is listed on the rang plate of
the grill (11”WC for Propane, 7” WC for Natural Gas). If the supply pressure is greater, a regulator must
be installed.
Built In Propane Gas Hook-Up
manifold. Connect the other end of the connector to the gas piping. Ensure that the connector does not
-
the
www.napoleongrills.com
5
EN
to sup
enclose the gas grill. A propane cylinder can not be stored below the gas grill.
Built In Cylinder Enclosures
within
2
2
2
2
or
l
22
cylinder and 15 in
2
2
Every opening must be large enough to permit the entrance of a 1/8 in (3.2 mm) rod.
WARNING!
use of tools.
enclosure and the ground.
enclosure.
CYLINDER SIZE OPENING A AREA OPENING B AREA
20in2210in22
30in2215in22
5” (127mm)
MAXIMUM
1” (25.4mm)
MAXIMUM
OPENING
A
OPENING
B2” (51mm)
MINIMUM
PARTITION TO ISOLATE
CYLINDER FROM GRILL
NON LOCKING DOOR
34” (864mm)
RECOMMENDED
5” (127mm)
MAXIMUM
www.napoleongrills.com
6
EN
Built In Natural Gas Hook-Up
the other end of the connector to the gas piping. Ensure that the connector does not pass through a wall,
WARNING! Built in units are supplied with a drip pan which holds only a minimal amount of
grease. To prevent grease res, the pan must be cleaned aer each use.
WARNING! Access must be provided to the inside of the enclosure to make gas connecons.
DANGER! Read all instrucons carefully before operang the grill. Failure to follow these
instrucons exactly could result in a re causing serious injury or death.The enre installaon must be
leak tested before operang the grill.
Electrical Precauons
WARNING! Failure to follow these instrucons could result in property damage, personal injury or
death.
the outlet.
www.napoleongrills.com
7
EN
Lighng Instrucons
O Posion
WARNING!Open lid
WARNING! Ensure all burner controls are in the o posion. Slowly turn on the gas
supply valve.
Main Burner
Lighng
Smoker Burner
Lighng
Rear Burner Lighng
(if equipped)
Side Burner Lighng
(if equipped)
1. Open grill lid. 1. Open grill lid. 1. Open grill lid.
2. Push and turn any main
lights and then release.
2. Push and turn the side
3. If the pilot does not ignite,
then immediately turn the
3. Push and hold the
light with a match.
3. Push and turn the rear
burner control to the high
3. Push and hold the electronic
lights, or light with a match.
4. If the pilot and burner will
not ignite within 5 seconds,
dissipate. Either repeat steps
2 and 3 or light with a match.
4. If the burner will not
ignite within 5 seconds,
dissipate. Repeat step 2.
4. Push and hold the
burner lights, or light by match.
4. If the burner will not ignite
within 5 seconds, turn the
Repeat step 2.
match, clip the match into the
the lit match down through
the grill and sear plate while
turning the corresponding
5. If the burner will not ignite
within 5 seconds, turn the
Repeat step 3.
WARNING! The propane cylinder is equipped with an excess ow device. Unless all burners are
turned o prior to turning the cylinder on, only small ames and low heat will be achievable.
WARNING! Do not use rear burner while operang main burner.
Igniter
Le
Burner Le Centre
Burner
Rear
Burner Centre
Burner
Smoker Burner
Right
Burner
Right Centre
Burner
Light
www.napoleongrills.com
8
EN
Cooking Instrucons
Inial Lighng
Main Burner Use
Rear Burner Use (If Equipped)
WARNING! Barbecue sauce and salt can be corrosive and will cause rapid deterioraon of the gas
grill components unless cleaned regularly. When nished cooking disassemble rosserie components,
wash thoroughly with warm soapy water and store indoors.
Direct Cooking
Indirect Cooking
Smoker Burner
heat as required.
www.napoleongrills.com
9
EN
WARNING! Always wear protecve gloves and safety glasses when servicing your grill.
WARNING! To avoid the possibility of burns, maintenance should be done only when the grill is
cool. Avoid unprotected contact with hot surfaces. Ensure all burners are turned o. Clean grill in an
area where cleaning soluons will not harm decks, lawns, or paos. Do not use oven cleaner to clean
any part of this gas grill. Do not use a self-cleaning oven to clean cooking grids or any other parts of
the gas grill. Barbecue sauce and salt can be corrosive and will cause rapid deterioraon of the gas grill
components unless cleaned regularly.
Cleaning Instrucons
Note
Grids And Warming Rack
surface.
Control Panel
Cleaning Inside The Gas Grill
wire brush. Sweep all debris from inside the gas grill into the drip pan.
WARNING! Built in units are supplied with a drip pan which holds only a minimal amount of
grease. To prevent grease res, the pan must be cleaned aer each use.
Drip Pan
Cleaning The Outer Grill Surface:
stain
your Napoleon Grill dealer.
Lights
lens.
www.napoleongrills.com
10
EN
WARNING! Always wear protecve gloves and safety glasses when cleaning your grill.
WARNING! Turn o the gas at the source and disconnect the unit before servicing. To avoid the
possibility of burns, maintenance should be done only when the grill is cool. A leak test must be
performed annually and whenever any component of the gas train is replaced or gas smell is present.
Maintenance Instrucons
Light Blue
Burner
Burner Port
Combuson Air Adjustment
light blue and occasionally yellow.
Adjusng the air shuer
Main Tube Burner Rear Tube Burner Propane Full Open
Smoker Burner
*Infra-Red burners have no air adjustment.
installed.
www.napoleongrills.com
11
EN
Burner
CAUTION! Beware of Spiders.
debris and corrosion, use an opened paperclip or the supplied port maintenance bit to clean them. Drill
Reinstallaon
WARNING! Regulator Hose (when applicable): Check for abrasions’, melng, cuts, and cracks in the
hose. If any of these condions exist, do not use the gas grill. Have the part replaced by your Napoleon
Gas Grill dealer or qualied gas installer.
WARNING! When reinstalling the burner aer cleaning it is very
important that the valve/orice enters the burner tube before lighng your
gas grill. If the valve is not inside the burner tube a re or explosion could
occur.
Aluminum Casngs
surface to
WARINING! Always wear protecve gloves when changing the halogen bulb in the internal lights
of your grill.
Lights
Do not touch the halogen bulb with your bare hands.
The oil from your ngerps will reduce the life of the bulb.
www.napoleongrills.com
12
EN
Troubleshoong
Problem Possible Causes Soluon
For natural gas - undersized supply line.
Preheat grill with both main burners on high for 10
to 15 minutes.
heat.
Sear plates installed incorrectly.
plates and in drip pan.
Ensure sear plates are installed with the holes
Preheat grill with both main burners on high for 10
to 15 minutes.
Clean sear plates and drip pan regularly. Do not
line pan with aluminum foil. Refer to cleaning
Burners burn with yellow
smell of gas.
Possible spider web or other debris, or
burner, accompanied by the
smell of gas, and possibly
Main burner will not light
with the igniter, but will light
with a match.
Normal occurrence on hot days.
regulators will not be replaced.
Burners will not cross light
each other.
Clean or replace as required.
peeling inside lid or hood.
Grease build-up on inside surfaces.
Supply hose is pinched.
www.napoleongrills.com
13
EN
Problem Possible Causes Soluon
drippings and build-up. Ports are clogged.
or a weld failure in the burner housing.
minutes. Relight burner and burn on high for at
relight.
authorized Napoleon dealer to order a replacement
burner assembly.
Contact your authorized Napoleon dealer for
assembly.
Blown Fuse.
Faulty transformer.
corroded or loose.
Faulty igniter.
Dirty or corroded electrodes.
Replace fuse located on outlet line of transformer.
Replace if required.
Clean or replace as required.
Blown fuse.
Faulty transformer.
corroded or loose.
Replace fuse located on outlet line of transformer.
Replace if required.
www.napoleongrills.com
14
EN
KEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE YOUR WARRANTY.
Ordering Replacement Parts
Warranty Informaon
(Record informaon here for easy reference)
the factory directly for replacement parts and warranty claims. Our Customer Care Department is
1. Model and serial number of the unit.
1. Model and serial number of the unit.
www.napoleongrills.com
15
EN
Geng Started
1.
2.
3. Assemble the grill where it is to be used, lay down cardboard or a towel to protect parts from being
lost or damaged while assembling.
4.
using the grill.
5.
If you have any quesons about assembly or grill operaon or if there are damaged or missing parts
please call our Customer Care Department at 1-866-820-8686 between 9 AM and 5 PM (Eastern
Standard Time).
CAUTION! During unpacking and assembly we recommended you wear work gloves and safety
glasses for your protecon. Although we make every eort to make the assembly process as problem
free and safe as possible, it is characterisc of fabricated steel parts that the edges and corners might
be sharp and could cause cuts if handled incorrectly.
Flat and Phillips
Pliers
TOOLS REQUIRED FOR ASSEMBLY (tools not included)
www.napoleongrills.com
16
EN
BUILT-IN UNIT OPENING DIMENSIONS
MODEL OPENING DIMENSIONS NOTES
D
524mm
225mm
N370-0504 -LPG
324mm
419mm
114mm
WARNING! CABINET FRAME, CABINET AND COUNTER TOP MUST BE
MADE FROM NON-COMBUSTIBLE MATERIAL.
MINIMUM 10 SQ IN OF
VENTILATION REQUIRED
ON EACH END OF CABINET
W
W
H
H
D
W
HD
1¾”
(44mm)
BUILT-IN SIDEBURNER
GAS INLET OPENING
NON-COMBUSTIBLE MATERIAL
OUTDOOR GFI ELECTRICAL OUTLET
REC
OMMENDED - LOCATE ON SAME SIDE
OF GRILL AS ROTISSERIE BRACKET.
GAS INLET OPENING
Note: Accessory frames
overlap opening by 1 ¾”
on all 4 sides.
34” (864mm)
RECOMMENDED
5” (127mm)
1¾”
(44mm)
4”minimum
(102mm)
10”minimum
(254mm)
ELECTRICAL BOX OPENING
IF THE COUNTER TOP IS OVERHANGING THE EDGE OF
THE ENCLOSURE THE CORNERS MUST BE NOTCHED
A MINIMUM OF 1 3/16" (30 mm) TO ACCOMODATE
THE CONTROL PANEL END CAPS.
www.napoleongrills.com
17
EN
BUILT-IN ACCESSORY OPENING DIMENSIONS
Opening Dimensions
Part # Descripon Picture W H D
N370-0071
N370-0070
N370-0072
N370-0357SS
N370-0358SS
PF Style Stainless Steel Door
N370-0359 PF Style Stainless Steel Single
Drawer
www.napoleongrills.com
18
EN
Part # Descripon Picture W H D
Drawer
N370-0502
N370-0503
Double Door Small
Double Door Large
* Frames Protrude From Face Of
Cabinet By ¾”
N370-0504
N370-0505
Side Burner Propane
Side Burner Natural
minimum
Opening Dimensions
www.napoleongrills.com
19
EN
BI ACCESSORY DRAWER INSTRUCTIONS
BI ACCESSORY DOOR INSTRUCTIONS
ensure that the front of the enclosure is plumb.
www.napoleongrills.com
20
EN
BIPRO665 BUILT-IN INSTRUCTIONS
4” (102mm) minimum
10” (254mm)
maximum
7”
(178mm)
9⅝”
(244mm)
WARNING! Failure to follow these instrucons could result in property damage, personal injury or
death.
grounding plug or use with an adapter of 2 prongs.
APPLY A DAB OF SILICONE
TO EACH FLANGE TO
SECURE IN PLACE.
LOCATED INSIDE CABINET
Other manuals for BIPRO 665
2
Table of contents
Languages:
Other Napoleon Grill manuals
Napoleon
Napoleon PRESTIGE II 450 User manual
Napoleon
Napoleon ROGUE RXT625SIB User manual
Napoleon
Napoleon NK22CK-L User manual
Napoleon
Napoleon TQ285X User manual
Napoleon
Napoleon BIPRO 450 User manual
Napoleon
Napoleon PRO285E-BK-CE User manual
Napoleon
Napoleon PT600RB-INFRARED User manual
Napoleon
Napoleon ROGUE RXT625SIB-1 User manual
Napoleon
Napoleon TQ3225 User manual
Napoleon
Napoleon PRO665 User manual
Napoleon
Napoleon F365DPGT-AU User manual
Napoleon
Napoleon TQ285X User manual
Napoleon
Napoleon ROGUE Series User manual
Napoleon
Napoleon LEX 485 User manual
Napoleon
Napoleon Prestige PRO BIPRO825RBINSS-3 User manual
Napoleon
Napoleon PRO285XBK User manual
Napoleon
Napoleon PRESTIGE PRO 665 RSIB User manual
Napoleon
Napoleon TravelQ Series User manual
Napoleon
Napoleon P500RSIBPCH-3-DE User manual
Napoleon
Napoleon BILEX485 User manual
Popular Grill manuals by other brands
Del Mar
Del Mar DM10-016LP Care and use guide
BlueRhino
BlueRhino CBT801WA-UC-101 C ES Assembly
BlueRhino
BlueRhino UniFlame NSG3902B owner's manual
Master cook
Master cook SRGG41628 user manual
MrHeater
MrHeater Buddy Flex MH8CFLEX Operating instructions and owner's manual
Master cook
Master cook SRGG61202 user manual
