Nexgrill Stainless Steel Gas Grill 720-0050-LP User manual

Stainless Steel Gas Grill
USE AND CARE GUIDE
MODEL NO.: 720-0050-LP
®
Source
the
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-913-8999 FORASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE

TABLE OF CONTENTS
SECTION ONE
Safety Instructions…………………………1~5
Placement of the grill………………………5
SECTIONTWO
Installation of Side Shelves..………….….6
Installation of Side Door Handle………….7
Installation of Battery………………………7
Installation of Spice Tray and Dividing Shelf
………………………………………………..8
Installation of Rotisserie kit………………..8
Installation of Propane Tank ..…………..…9
To Match light the Gill…………………….. 10
SECTION THREE
Gas Hook-Up………………………………11
Leak Testing……………………………….12
Installer Final Check……………………...13
SECTION FOUR
Operating Instructions……………………14
Lighting Instructions……………………....15
Read this Care and Use Manual carefully
and completely before using your grill to
reduce the risk of fire, burn hazard or
other injury.
SECTION FIVE
Using the Side Burner……………………
Care & Maintenance ……………….
27
20
21
22
23~24
25~26
16
16
17
17~19
Care & Maintenance of Side Burner…..
Trouble Shooting…………………………
SECTION SIX
Exploded View……………………………..
Parts List …………………………………..
Grilling Hints………………………………..
Grill Cooking Chart ……………………….
Grill Recipe Suggestion ………………….
SECTION SEVEN
Limited Warranty ………………………….

SAFETY INSTRUCTIONS
***** WARNING *****
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open Lid.
4. If odor continues, immediately call your gas supplier or you
r
fire de
p
artment.
2. An LP cylinder not connected for use shall not be stored in
the vicinity of this or any other appliance.
FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance.
1

SAFETY INSTRUCTIONS
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS
WARNING
Do not try lighting this appliance without first reading
the “LIGHTING INSTRUCTIONS” section of this manual.
DO NOT USE ALUMINUM FOIL TO LINE THE GRIL
L
RACKS OR GRILL BOTTOM. This can severely upse
t
combustion airflow or trap excessive heat in the
control area.
INSECT WARNING!!! Spiders and insects can nest in the burners
of this and any other grill, and cause the gas to flow improperly.
This is a very dangerous condition, which can cause a fire to
occur behind and beneath the valve panel, thereby damaging the
grill and making it unsafe to operate. Inspect the grill twice a year.
LP Gas Cylinder must be fitted with Overfill Protection Device (OPD).
WARNING
a) DO NOT store a spare LP-gas cylinder under or near this appliance.
b) NEVER fill the cylinder beyond 80% full.
c) If the information in “a” and “b” is not followed exactly, a fire causing death
or serious injury may occur.
CAUTION: REMOVE THE
WARMING RACK WHEN USING THE
ROTISSERIE BURNER. THE HIGH
HEAT COMING FROM THE BURNER
MAY CAUSE THE WARMING RACK TO
BEND.
WARNING
ELECTRICAL GROUNDING INSTRUCTIONS
This appliance (rotisserie motor) is equipped
with a plug and should be plugged directly
into a properly grounded receptacle. DO NOT
cut or remove the grounding prong from this
plug.
Keep the rotisserie motor electric cord away
from the heated surfaces of the grill. When
not in use remove and store the motor in a
dry location
DO NOT LEAVE THE GRIL
L
UNATTENDED WHILE COOKING.
2

SAFETY INSTRUCTIONS
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS
WARNING: Always keep your face and body as far away from the burner as
possible when lighting.
WARNING: IMPORTANT!
BEFORE LIGHTING…
Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts,
wear, or abrasion, it must be replaced prior to use. Do not use the grill if the odor of
gas is present. Only the pressure regulator and hose assembly supplied with the unit
should be used. Never substitute regulators for those supplied with the grill. If a
replacement is necessary, contact the factory for proper replacement.
Screw the regulator onto the tank. Check the hose and regulator connections with a
soap and water solution before operating the grill.
Keep a spray bottle of soapy water near the gas
supply valve and check the connections before
each use.
Do not attempt to light the grill if odor of gas is
present. Call for service 1-800-913-8999.
ROTISSERIE DRIVE MOTOR
USE ONLY FOR OUTDOORS, DO NOT EXPOSE
TO RAIN.
CAUTION: TO ENSURE CONTINUED
PROTECTION AGAINST RISK OF ELECTRIC
SHOCK, CONNECT TO PROPERLY GROUNDED
OUTLETS ONLY, TO REDUCE THE RISK OF
ELECTRIC SHOCK, KEEP EXTENSION CORD
CONNECTION DRYAND OFF THE GROUND.
3

SAFETY INSTRUCTIONS
TESTED IN ACCORDANCE WITH ANSI Z21.58b
LATEST STANDARD and CGA 1.6b-2002
STANDARD FOR OUTDOOR COOKING GAS
APPLIANCES. THIS GRILL IS FOR OUTDOO
R
USE ONLY.
Check your local building codes for the prope
r
method of installation. In the absence of local
codes, with either the National Fuel Gas Code,
ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1,
Natural Gas and propane Installation Code.
Electrical Code, ANSI/NFPA 70.
CALIFORNIA PROPOSITION 65-WARNING
The burning of gas fuel generates some
byproducts, which are known by the State o
f
California to cause cancer or reproductive
harm. To minimize exposure to these
substances, always operate this unit according
to the use and care manual, ensuring you
provide good ventilation when cooking with
gas.
SAFETY PRACTICES TO AVOID PERSONAL INJURY
When properly cared for, your grill will give safe,
reliable service for many years. However,
extreme care must be used since the grill
produces intense heat and that can increase
accident potential. When using this appliance
basic safety practices must be followed,
including the following:
Do not repair or replace any part of the grill
unless specifically recommended in this manual.
A
ll other service should be referred to a qualified
technician.
This outdoor cooking gas appliance is not
intended to be installed in or on recreational
vehicles and/or boats.
CHILDREN SHOULD NOT BE LEFT ALONE OR
UNATTENDED IN AN AREA WHERE THE GRILL IS
BEING USED. NEVER ALLOW THEM TO SIT,
STAND OR PLAY ON OR AROUND THE GRILL A
T
ANY TIME.
DO NOT STORE ITEMS OF INTEREST TO
CHILDREN AROUND OR BELOW THE GRILL OR IN
THE CART. NEVER ALLOW CHILDREN TO CRAWL
INSIDE OF THE CART.
Never let clothing, pot holders or othe
r
flammable materials come in contact with or too
close to any grate, burner or hot surface until it
has cooled. Fabric may ignite and result in
personal injury.
For personal safety, wear proper apparel. Loose
fitting garments or sleeves should never be worn
while using this appliance. Some synthetic
fabrics are highly flammable and should not be
worn while cooking.
Only certain types of glass, heatproof glass
ceramic, earthenware, or other glazed
utensils are suitable for grill use. Theses
types of materials may break with sudden
temperature changes. Use only on low o
r
medium heat settings according to the
manufacturer’s directions.
Do not heat unopened food containers as a
build-up of pressure may cause the container to
burst.
Use a covered hand when opening the grill lid.
Never lean over an open grill.
WHEN LIGHTING A BURNER, ALWAYS PAY CLOSE
A
TTENTION TO WHAT YOU ARE DOING. BE
CERTAIN YOU ARE TURNING THE IGNITER
LABELED FOR THE BURNER YOU INTEND ON
USING.
4

SAFETY INSTRUCTIONS
When using the grill, do not touch the grill rack,
burner grate or immediate surroundings as
these areas become extremely hot and could
cause burns. Use only dry potholders. Moist o
r
damp potholders on hot surfaces may cause
burns from steam. Do not use a towel or bulk
y
cloth in place of potholders. Do not le
t
potholders touch hot portions of the grill rack.
Grease is flammable. Let hot grease cool
before attempting to handle it. Avoid letting
excess grease deposits collect in the grease
tray at the bottom of the grill’s firebox. Clean
often.
For proper lighting and performance of the
burners keep the burner ports clean. It is
necessary to clean them periodically fo
r
optimum performance. The burners will onl
y
operate in one position and must be mounted
correctly for safe operation.
Clean the grill with caution. Avoid steam burns;
do not use a wet sponge or cloth to clean the
grill while it is hot. Some cleaners produce
noxious fumes or can ignite if applied to a hot
surface.
Be sure all grill controls are turned off and the
grill is cool before using any type of aerosol
cleaner on or around the grill. The chemical
that produces the
spraying action could, in the presence of heat,
ignite or cause metal parts to corrode.
Do not use the grill for cooking excessively fatty
meats or products, which promote flare-ups. Do
not operate the grill
under unprotected combustible construction. Use
only in well ventilated areas. Do not use in
buildings, garages, sheds, breezeways or othe
r
such enclosed areas. THIS UNIT IS FO
R
OUTDOOR USE ONLY.
Keep the area surrounding the grill free from
combustible materials, trash, or combustible fluids
and vapors such as gasoline or charcoal lighte
r
fluid. Do not obstruct the flow of combustion and
ventilation air. If the unit is stored indoors ensure
that it is cool. If propane is used, the cylinder mus
t
be unhooked and the propane cylinder stored
outside in a well-ventilated area, out of the reach o
f
children.
NEVER USE A DENTED OR RUSTY PROPANE TANK
CLEARANCE
To Non-Combustible Construction
A
minimum of 3” clearance from the back o
f
the grill to non-combustible construction is
required for the lid to open fully.
DO NOT INSTALL THIS UNIT INTO
COMBUSTIBLE ENCLOSURES!
MINIMUM CLEARANCE:
24”Clearance from all sides to combustible
material.
LOCATION
When determining a suitable location take into
account concerns such as exposure to wind,
proximity to traffic paths and keeping any gas
supply lines as short as possible. Locate the grill
only in a well-ventilated area. Never locate the
grill in a building, garage, breezeway, shed o
r
other such enclosed areas. During heavy use,
the grill will produce a lot of smoke. Lock the
wheels after the grill is placed in a suitable
position.
5
PLACEMENT OF THE GRILL

INSTALLATION OF SIDE SHELVES
The screws for the side shelves mount are already screwed into the two sides of the
grill.
Remove the screws and install the right shelf as shown in the figure below.
Repeat the above step to install the left shelf on left side panel.
Source
the
Source
the
6

INSTALLATION OF SIDE DOOR HANDLE
Take out the side door handle assembly from hardware bag. Remove the screws from
side door handle, (see the figure below), attach on the door handle, and screw into the
holes of the side door of the grill.
Source
the
INSTALLATION OF BATTERY
In order to install the battery, remove the ignition button housing. Repeat the ignition
button housing after battery is installed. Please keep the positive pole facing toward you.
Tight the ignition button after installed the battery.
the
Source
7

INSTALLATION OF SPICE TRAY AND DIVIDING SHELF
Place the dividing shelf inside the left door.
INSTALLATION OF ROTISSERIE KIT
After install the rotisserie motor mount, Assemble the rotisserie skewer as shown in
the figure below.
the
Source
8