Nu-Calgon ViroBlaster User manual

Indoor Air Quality Products
ViroBlaster™
Nu-Calgon Product Bulletin 3-144
2611 Schuetz Rd. • St. Louis, MO 63043 • 800-554-5499 • www.nucalgon.com
Calgon is a licensed trade name • (1120) 3-144
• Quickly and easily sanitize your space with
the use of EPA sanitizers and disinfectants
• High atomization density spray and strong
electrostatic capabilities for coverage
• Adjustable spray nozzle emits formula at a
range from 70-150ml per minute
• Rechargeable lithium ion battery provides
30 minutes of run time
• Static coverage of over 16 feet with a spray
distance of over 9 feet
• Heavy duty translucent bottle with ½ gallon
capacity
• Each ViroBlaster comes with a rechargeable
lithium ion battery and charger
Description
The ViroBlaster is a portable electrostatic mist sprayer
designed to quickly, easily, and effectively dispense a
variety of cleaners, sanitizers, and disinfectants. The
electrostatic method of the ViroBlaster helps the product
cling to surfaces much more efficiently than a standard
sprayer. The ViroBlaster uses a rechargeable lithium ion
battery to provide 30 minutes of use efficiently dispensing
product.
Applications
This product must be used in accordance to the following
directions by HVACR professionals only.
Use the ViroBlaster to properly clean and sanitize
classrooms, offices, living spaces, hotel rooms, medical
facilities, and more! The ViroBlaster can spray product at
a distance of over 9feet with a static coverage area of over
16 feet. The ViroBlaster has an adjustable atomizing nozzle
that can provide a range of spray from 70 to 150ml per
minute.
Packaging
ViroBlaster Portable Electrostatic Mist Sprayer 4780-0
Replacement Lithium Ion Battery 4780-1
Replacement Battery Charger 4780-2
Instructions
1. Take the product out of package and check if there are
any parts missing or damaged before using.
2. Check the battery gauge by holding the on/off switch
on the battery pack; if the battery level is less than 50%
(less than 2 LED lights on), please recharge it before
using.
3. Mount the battery pack onto the bottom of the sprayer.
4. Mix disinfectant or chemical liquids in proportion or use
ready-to-use formulas and fill into the 1.8L bottle. Then
screw the bottle onto the sprayer device.
5. Note: Do not fill and use corrosive liquid or ethyl alcohol
with this device.
6. Review the instructions from the solution that you will be
using through the ViroBlaster for proper and accurate
use.
7. Press the on/off switch on back of sprayer to start the
job. The nozzle can be rotated to adjust the spray from
0-150ml per minute.
Warnings and Maintenance
Your ViroBlaster should be stored in such a way to protect
it from freezing. Do not store this unit outdoors or in an
area where temperatures will fall below 0°C (32°F). This can
cause extensive damage to the unit and void the warranty.
After each time of use and before storage, the following
steps should be followed: After each time of use and before
long term storage, fill some clean water into the bottle to
run through the sprayer to clean the residual disinfectant or
chemicals inside the sprayer. Store in a cool, dry place away
from children. Wipe clean with a damp cloth as needed. Do
not immerse sprayer device in water. Remove the battery
pack from the sprayer and recharge it when needed.
FOR BATTERY:
Do not store the battery in elevated temperature for an
extended period of time. Do not put the battery with sharp
or fine metal wire or pins. These materials may touch both

2611 Schuetz Rd. • St. Louis, MO 63043 • 800-554-5499 • www.nucalgon.com
Calgon is a licensed trade name • (1120) 3-144
terminals of the battery and cause it to short circuit, leading to a burnout or explosion. Store the battery in a dry,
cool and well-ventilated place, protecting it from direct exposure to sunlight. The battery must be stored in a partial
state-of-charge, ideally 40-50% (2 LED lights on), recommended temperature 0°C ~25°C. If it is not regular use, be
sure to charge the battery to approximately 50% SOC instead of fully charged at least every 3 months. To charge the
battery, make sure to use the original mains charger included in the package. Using a different charger or improper
voltage may burn out the battery or cause serious injury.
Warranty Information
Our company will warranty the product for a period of 12 months from the date of purchase to be free of defects in
material or workmanship. Please keep your warranty card or original sales invoice to validate the warranty period.
If the product should become defective within the warranty period, we will repair or replace any defective parts free
of charge. The complete machine must be delivered prepaid to our company. Please include a complete description
of the problem, date of purchase, with original sales receipt and your name, address and telephone number.
The warranty does not include usual wear and tear, damage resulting from accident or unreasonable use of the
product, unauthorized repairs or parts that does not belong to the product.