Outdoor Plus OPT-TT M Series User manual

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 1
TOP TORCHES
STAINLESS STEEL / CORTEN
OPT-TT(X)M
INSTALLER: Leave this manual with the appliance
CONSUMER: Retain this manual for future reference.

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 3
 AVERTISSEMENT
 AVERTISSEMENT
 AVERTISSEMENT
WARNING
WARNING
WARNING
Do not store or use gasoline, or other
ammable vapors and liquids, in the vicinity of
this or any other appliance.
An LP-cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
Improper installation, adjustment, alteration,
service, or lack of maintenance can cause injury
or property damage.
Read the installation, operating, and
maintenance instructions thoroughly before
installing or servicing this equipment.
FOR OUTDOOR USE ONLY.
Ne pas entreposer ne utilizer de l’essence ni
d’autres vapuers ou liquids inammables dans
le voisinage de l’appareil, ne de tout autre
appareil. Une bouteille de propane qui n’est
pas raccordee en vue de son utilisation, ne doit
pas etre entreposee dans le voisiange de cet
appariel ou de tout autre appreil.
Une installation, un ajustement, une
modication, une réparation ou un entretien
inapproprié peuvent être la cause de blessures
ou de dommages.
Veuillez lire attentivement les instructions
d’installation, d’utilisation et d’entretien avant
d’installer ou de réparer ce matériel.
POUR USAGE A L’EXTERIEUR SEULEMENT.
SAFETY WARNINGS
 AVERTISSEMENTWARNING
For use with natural gas or liquid propane only.
Do not use charcoal or other solid fuel in gas
burning appliances.
Do not use your re feature for cooking.
Always adhere to the specied clearances listed in
this manual.
Never allow clothing or other ammable materials
come in contact with any hot surface until it has
fully cooled.
Never wear loose tting or hanging garments
while using your re pit. Fabric may ignite and
result in personal injury.
Pour utilisation avec du gaz naturel ou du propane
liquide seulement.
N’utilisez pas de charbon de bois ou d’autres
combustibles solides dans les appareils à gaz.
N’utilisez pas votre caractéristique de feu pour
cuisiner.
Respectez toujours les dégagements spéciés
dans ce manuel.
Ne laissez jamais des vêtements ou d’autres
matériaux inammables entrer en contact avec
une surface chaude avant d’avoir complètement
refroidi
Ne portez jamais de vêtements amples ou
suspendus lorsque vous utilisez votre foyer. Le
tissu peut s’enammer et entraîner des blessures.
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 4
 AVERTISSEMENT
 AVERTISSEMENT
WARNING
WARNING
If you smell gas:
õShut o gas to the appliance
õExtinguish any open ame
õIf odor continues, keep away from the
appliance and immediately call your gas
supplier or re department.
Si’l y une odeur de gaz:
õCoupez l’admission de gaz de l’appareil.
õÉteindre toute amme nue.
õSi l’odeur persiste, éloignez-vous de
l’appareil et appelez immédiatement le
fournisseur de gaz ou le service d’incendie.
SAFETY WARNINGS
For use with natural gas or liquid propane only.
Do not use charcoal or other solid fuel in gas
burning appliances.
Do not use your re feature for cooking.
Always adhere to the specied clearances listed in
this manual.
Never allow clothing or other ammable materials
come in contact with any hot surface until it has
fully cooled.
Never wear loose tting or hanging garments
while using your re pit. Fabric may ignite and
result in personal injury.
Pour utilisation avec du gaz naturel ou du propane
liquide seulement.
N’utilisez pas de charbon de bois ou d’autres
combustibles solides dans les appareils à gaz.
N’utilisez pas votre caractéristique de feu pour
cuisiner.
Respectez toujours les dégagements spéciés
dans ce manuel.
Ne laissez jamais des vêtements ou d’autres
matériaux inammables entrer en contact avec
une surface chaude avant d’avoir complètement
refroidi
Ne portez jamais de vêtements amples ou
suspendus lorsque vous utilisez votre foyer. Le
tissu peut s’enammer et entraîner des blessures.
Carbon Monoxide Hazard
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in enclosed
space such as a camper, tent, car or
home.
MONOXYDE DE CARBONE
Cette appareil peut produire du monoxyde de
carbone, un gaz inodore.
L’utilisation de cet appareil dan des espaces
clos peut entrainer la mort.
Ne jamais utiliser cet appareil dans
un espace clos comme un véhicule de
camping, une tente, une automobile ou
une maison.
 AVERTISSEMENTWARNING
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 5
WARNING
California Proposition 65 Warning: Chemicals known to the State of California to cause cancer, birth
defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane,
butane and other fuels. Always operate this unit as described in the owner’s manual and in well ventilated
areas.
SAFETY WARNINGS
WARNING
Installation must conform with local codes or, in the absence of local codes, with the
National Fuel Gas Code, ANSI Z223.1 / NFPA 54, or International Fuel Gas Code.
The appliance, when installed, must be electrically grounded in accordance with local codes or, in
the absence of local codes, with the National Electric Code, ANSI/NFPA 70, if applicable.
 BURN HAZARD
 SAFETY
While the re unit is operating, the outside surface may reach high temperatures which may cause burns.
Never leave children unattended in the area where the re unit is being used. Close supervision of children
is necessary when any appliance is used near children. Never leave the re pit unattended when in use.
Do not reach over your re unit when hot or in use.
Keep all electrical supply cords away from the heated areas of the re pit.
Clothing or other ammable materials should not be hung from the appliance, or placed on or near the
appliance.
DANGER
Propane gas source to the re pit must be regulated.
Do not operate if regulator has been removed. Fire or explosion can occur.
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 6
GENERAL INFORMATIONS
Fuel Type - Before making gas connections ensure appliance being installed is compatible with the available gas
type. Check the label on the appliance to con rm appliance gas type requirement.
Gas Pressure - Proper input gas pressures are required for optimum appliance performance.
GAS PRESSURE REQUIREMENTS
Natural Gas
Minimum 3.5” W.C. - Nominal: 7.0” W.C. - Maximum 1/2” PSI (14.0” W.C.)
Liquid Propane:
Minimum 8.0” W.C. - Nominal: 11.0” W.C. - Maximum 1/2” PSI (14.0” W.C.)
ELECTRICAL REQUIREMENTS
The All Weather Electronic Ignition System operates on 24 Volts AC power ONLY
DO NOT Attempt to Power using 110 Volts AC Power – Damage WILL RESULT
Acceptable Input Voltages to Supplied 24 Volt AC Transformer: 110 / 210 / 220 / 240 / 480 Volt AC
Supplied 24 Volt AC Transformer compatible with all voltages listed above
Read label on supplied transformer for proper connection information
Recommended Wire Size: 12 gauge wire for all installations
CLEARANCE FROM COMBUSTIBLES
Warning - Provide adequate clearance
from combustibles as shown below.
INSTALLATION & MAINTENANCE
We suggest that our products be
serviced by a professional certi ed
in the U.S. By the National Fireplace
Institute as a NFI Specialists
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 7
INSTALLATION
INSTALLATION OF BASE POLE
12”
8’
Note: Installation should be done by a quali ed service technician that is locally licensed.
OPTION 1
Manual gas shut o located at torch
Manual Gas
Shuto Valve
Base Pole
Base Pole
Manual Gas
Shuto Valve
Electrical
Conduit
Electrical
Conduit
Gas Line Gas Line
Landscape
Box
OPTION 2
Manual gas shut o located on torch
pole (Requires you to drill a hole)
TIKI TORCH MANUAL SHUT OFF OPTIONS
Torch Head
Black Pole
Base Pole
Manual Gas
Shuto Valve
Base Pole
Base Pole
Manual Gas
Shuto Valve
Landscape
Box
Diagram 1 shows ½” gas stub stubbed up inside a hole.
The hole is 12” deep.
STEP 1
DIAGRAM 1 DIAGRAM 2
Diagram 2 shows the Base Pole. Slide it over the Gas stub
Adjust the height of the Base Pole so that the tapered
top end of the Base Pole ended up above grade.
Do this to make the connection between the Base Pole
and the Tiki Pole easier later on.
STEP 2
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 8
INSTALLATION
STEP 3
If you are installing the Manual Gas Shuto on the Tiki Pole
(Option 2 from page 7)  rst remove the handle from the Ball
Valve and then install the ball valve on the ½” gas riser as shown
in diagram 3.
The use of pipe dope or Gas Te on tape is highly recommended
to prevent a possible gas leak.
STEP 4
Once the Manual Gas Shuto is installed, measure from the
center of the Gas Shuto to the top of the Black Base Pole.
This dimension we shall refer to as measurement “A”.
See diagram 4
STEP 5
Temporarily install the longer pole and measure from the
seam between the Base Pole and the top of the long tiki
pole. This dimension we will refer to as measurement “B”.
DIAGRAM 3
DIAGRAM 4
DIAGRAM 5
A
Base Pole
Inner Sleeve
B
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 9
INSTALLATION
STEP 6
Install ½” gas hose to your gas riser (or manual gas
shuto valve) so that the end of the ½” gas line is 1”
SHORTER than the pole (measurement “B” from the
previous page)
In addition, bring the wires previously installed
up along the gas line and tape it to the gas line in
anticipation of installing the longer tiki pole.
STEP 7
As shown in diagram 6, Measure from
the bottom of the long tiki pole up to
measurement “A” and mark the pole. Then
drill a 1” diameter hole in the side of the pole
for the Manual Gas Shuto Valve.
STEP 9
Next install the Manual Gas Shuto Valve as shown in diagram 7.
A A
DIAGRAM 6
DIAGRAM 7
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 10
INSTALLATION THE TORCH HEAD
STEP 10
STEP 9
Insert the pole into the torch head.
Secure by tightening the 3 set screws
in the base of the torch head.
See diagram 10.
Connect the gas line to the head of the tiki torch.
Do NOT use pipe dope or plumbers tape on  ared
connections. Ensure connections are tight to
prevent any gas leaks.
DIAGRAM 10
DIAGRAM 9
GAS LINE
GAS LINE
COUPLING
COUPLING
HEX BOLT
ALLEN WRENCH
HEX BOLT
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 11
MAINTENANCE
õKeep any debris out of the burning area, clean as needed.
WARNING: Installation and repair should be done by a qualied service person. Fire feature should be inspected
prior to use and at least annually by a qualied service person.
WARNING: Ensure gas and power (if applicable) are shut o and re pit is cool before servicing.
FIRE PIT OPERATION
WARNING: before use, be sure to test all gas connections for leaks. Do not use torches if there is any evidence of
leaking gas. If leaking gas suspected, turn o the main gas supply and repair immediately.
WARNING: Wind and gusty conditions will aect the ame in an unpredictable manner. If conditions exist that are
not safe for patrons, turn the torches o.
WARNING: solid fuels shall not be burned in the re pit. Leaves, sticks, wood, paper, clothing, food material, should
be kept away from the re pit. Fire pit is not for cooking. Make sure that there is no vegetation or other objects over
the top or sides of the re pit that could interfere with safe operation. See clearances at the end of this document
WARNING: when torch is not in operation turn o gas valve.
IMPORTANT: Initial Start Up: It may be necessary to purge air in gas lines after system installation.
START UP
SHUT DOWN
õSTOP! Read the safety information on “What to do if you smell gas. (Pg. 4)
õEnsure torch is clear of people, debris, that all covers are removed and the feature is safe to start.
õPlace long handled lighter or match while burning on top or in the torch.
õSlowly turn “ON” gas valve
õAfter torch ignites, remove lighter or match.
õAdjust ame to desired height
õIf the torch does not ignite, turn valve o and allow gas to clear the repeat steps 3-7.
õNever alter the design of the torch
õEnsure torch, children and patrons are supervised by a responsible adult that is familiar with emergency shut down.
õFlammable materials should not be placed on or near the re pit.
õTurn “OFF” gas valve.
Will Not Light
Air in gas line If new install, may take several attempts to purge air
Debris n gas line Conrm gas line is clear (insulation, dirt, plastic, excessive pipe sealer etc..)
Improper gas pressure Conrm proper gas pressure found
Will Not Stay Lit
Improper gas pressure Conrm proper gas pressure found (Section 1)
Improperly applied media Review media
Noise
Whistling Sound Change ex line routing. Conrm whistle free lines are being used.
TROUBLE SHOOTING
Below are some potential causes and countermeasures to the symptoms indicated in bold. If still unable to resolve
issue, please contact your retailer or certied technician.
TOP TORCHES

THEOUTDOORPLUS.COM 235 EAST MAIN ST 909.460.5579
PAGE 12
ONE YEAR LIMITED WARRANTY
The Outdoor Plus Company (TOP) warranties their re pits and re pit components against manufacturing
defects that prevent safe and correct function as follows:
õElectronics, Gas Valve, & Pilot Assembly: Commercial-6mos; Residential- 1 yr.
õStainless Steel Pan, Fire Ring, & Valve Box: Commercial-1yr.; Residential 3yrs.
õThis warranty is non-transferable.
õDecorative stones and decorative glass are not covered by this warranty.
õWarranty is void if the components have been subject to but not limited to negligence, alteration, misuse,
and/or prohibited applications.
õNatural gas lines must be installed by a licensed plumber only or local gas company agent.
If a part proves to be defective under normal use, the part will be repaired or replaced. Our obligation under
this warranty is to repair or replace defective parts at our discretion. If we determine that repair of a covered
item is not feasible, we reserve the right to replace the defective merchandise with merchandise equal in value
to the original purchase price. Warranty repair or replacement are the sole discretion of The Outdoor Plus and
this warranty does not cover costs therein, including but not limited to: freight, removal, re-installation, etc.
There will be no charge for parts on a covered item, however, cost of labor is the responsibility of the owner.
Shipping and handling charges will apply to all warranted replacement parts. The service agent may assess a
reasonable travel or mileage charge per service call.
For more information regarding the warranty please send any questions to [email protected].
CLEARANCE FROM COMBUSTIBLES
Fire Pit Clearances from Structures and Combustibles
Under Valve Box When Applicable - 2” For Drainage
Open ame to Floor - 18”
Sides Surrounding Fire Pit - 48”
Overhead Clearance - 96”
TOP TORCHES