Patriot FMFW-1500W/C User manual

This manual contains importatant information regarding your Patriot unit. Please read this manual thoroughly prior to equipment set-up,
operation and maintenance. Failure to comply with regular maintenance guidelines outlined in this manual may void the warranty.
INSTRUCTION MANUAL
FMFW-1500W/C
FULL SIZE COOKER/WARMER
PATRIOT

V.1.0 | August 2015
PATRIOT
WARNINGS
• Do not touch any hot surfaces
• Do not immerse unit, cord or plug in liquid at any time
• Unplug cord from outlet when not in use and before cleaning
• Plug only into a 3-hole grounded electrical outlet of appropriate voltage
• Do not operate unattended
• Do not use this unit for anything other than intended use
• Do not use outdoors
• Always use on a firm, dry and level surface at least 12” from walls or any other obstruction
• Do not use if unit has a damaged cord or plug, in the event the appliance malfunctions, or has
been damaged in any manner
• Keep children and animals away from unit
• Any incorrect installation, alterations, adjustments and/or improper maintenance can lead to
property loss and injury. All repairs should be done by authorized professionals only.
• Ensure that the designated power supply is adequate for continual usage and the voltage is
correct
• NEVER operate this unit without water
IMPORTANT NOTICE – TURN SWITCH TO THE MAXIMUM HEAT SETTING FOR 30 MINUTES TO PREHEAT.
AFTER 30 MINUTES TURN THE DIAL BACK TO KEEP FOOD WARM.
TO USE
1. Make sure the power supply you are using is adequate.
2. Fill the well with 4 quarts of water. (Do not fill with more than 4 quarts. If the water level is
too high, water may overflow when the food pan is inserted. Overflow will enter the electrical
compartment and cause a short circuit or electrical shock).
3. Plug the cord into a three hole grounded electrical outlet of appropriate voltage.
4. Preheat the water in the well by covering the well with an empty food container or cover. Set the
heat control to the maximum heat setting. Preheat for 30 minutes.
5. Place stainless steel food pan containing food into the food warmer.
6. Reduce the setting of the knob by ¼ and monitor food temperatures closely for food safety. The
United States Public Health Service recommends that food be held at a minimum of 140˚ F (and/
or in compliance with local health codes) to prevent bacteria growth. Maintain water level at 4
quarts. Periodically, (approximately every 2 hours) remove food pan and check the water level.
Add hot water if needed and adjust up or down as required by the food type.
HOT WATER AND STEAM IN THE WELL CAN SEVERELY BURN SKIN. USE PROTECTIVE GLOVES, MITTS OR
POTHOLDERS WHEN REMOVING FOOD CONTAINERS OR COVERS. HOT FOOD CAN ALSO CAUSE BURNS.
HANDLE FOOD CAREFULLY.
CLEANING - NOTE: To maintain cleanliness and increase service life, the food warmer should be
cleaned daily. Do not immerse the food warmer in water or any other liquid, if liquid enters the
electrical compartment it may cause a short circuit or electrical shock.
1. Before cleaning or attempting to move food warmer, unplug and let the unit cool completely.
2. Carefully empty the water from the well.
3. Wipe the entire unit with a clean soft cloth until it is completely dry.
4. To avoid damage to the well, do not use abrasive cleaners or scouring pads.
5. If soap or chemical cleaners are used, be sure they are completely rinsed away with clean water
immediately after cleaning. Chemical residue could damage or corrode the surfaces of the unit.
There are no serviceable parts within this appliance. To avoid serious injury or damage, never attempt to repair
the food warmer or replace a damaged cord yourself. Contact a professional repair service.

V.1.0 | August 2015
PATRIOT
Wiring Diagram for the Full Size Cooker/Warmer

V.1.0 | August 2015
PATRIOT
Parts Diagram and Replacement Parts for the Cooker/ Warmer
2
3
5
67
9
9
11
12
Food Warmer - FW-1200W and FW-1500W
Reference
Number
FW-1200W Part
Number
FW-1500W Part
Number Description
1 Water Pan
2FW-2 FW-2 Heating Element
3 Reflector Pan
5FW-5 FW-5 Power Cord and Strain Releif
6 Bottom Cover
7FW-7 FW-7 Rubber Foot
8 Shell
9FW-9 FW-9 Temperature Knob
11 FW-11 FW-11 Indicator Light - Red
12 FW-12 FW-12 Thermostat
13 Stand
14 Limiting Thermostat Stand
15 FW-15 FW-15 Limiting Thermostat
VER811
Food Warmer - FW-1200W and FW-1500W
Reference
Number
FW-1200W Part
Number
FW-1500W Part
Number
Description
1 Water Pan
2FW-2 FW-2 Heating Element
3 Reflector Pan
5FW-5 FW-5 Power Cord and Strain Releif
6 Bottom Cover
7FW-7 FW-7 Rubber Foot
8 Shell
9FW-9 FW-9 Temperature Knob
11 FW-11 FW-11 Indicator Light - Red
12 FW-12 FW-12 Thermostat
13 Stand
14 Limiting Thermostat Stand
15 FW-15 FW-15 Limiting Thermostat
VER811

V.1.0 | August 2015
PATRIOT
18 Month Limited Warranty
Patriot warrants its equipment against defects in materials and workmanship, subject to the following conditions:
Patriot Full Size Food Warmer is warranted for 18 months,effective from the date of purchase by the original owner.
A copy of the original receipt or other proof of purchase is required to obtain warranty coverage. This warranty applies
to the original owner only, and is not assignable.
Should any product fail to function in its intended manner under normal use within the limits defined in this
warranty, at Patriot’s discretion, such product will be repaired, replaced with arefurbished unit, or replaced with a new
unit by Patriot,after defective unit has been inspected and defect has been confirmed. Patriot does not assume any
liability for extended delays in replacing any item beyond its control. This warranty does not apply to rubber and non-
metallic synthetic parts that may need to be replaced due to normal usage, wear or lack of preventative maintenance.
This warranty covers products shipped into the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska
and Canada. Warranty coverage on products used outside the 48 contiguous United States, Hawaii and metropolitan
areas of Alaska and Canada may vary.
The following conditions are not covered by warranty:
• Equipment failure relating to improper installation, improper utility connection or supply and problems due to
improper ventilation.
• Equipment that has not properly been maintained, damage from improper cleaning, and water damage
to controls.
• Equipment that has not been used in an appropriate manner, or has been subject to misuse, neglect, abuse,
accident, alteration, negligence, damage during transit, delivery or installation, fire, flood, riot, or act of God.
• Equipment that has the model number or serial number removed or altered.
• Equipment on which the security seal has been broken.
If the equipment has been changed, altered, modified, or repaired without express written permission from Patriot, then
the manufacturer shall not be liable for any damages to any person or to any property, which may result from the use of
this equipment thereafter.
This equipment is intended for commercial use only and this warranty is void if equipment is used in other than a
commercial application.
For warranty and non-warranty related issues, technical support, purchase replacement parts and warranty registration
visit www.admiralcraft.com or call 1-800-223-7750 for technical support.Please have your model number, serial number
and proof of purchase ready. It is not necessary to contact the place where you originally purchased your product from.
“THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL WARRANTIES EXPRESSED OR IMPLIED
INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILTY OR FITNESS FOR PARTICULAR
PURPOSES AND CONSTITUES THE ENTIRE LIABILITY OF ACE. IN NO EVENT DOES THE LIMITED
WARRANTY EXTEND BEYOND THE TERMS STATED HEREIN.”
VER0714