Patriot FMSG-811E User manual

This manual contains importatant information regarding your Patriot unit. Please read this manual thoroughly prior to equipment set-up,
operation and maintenance. Failure to comply with regular maintenance guidelines outlined in this manual may void the warranty.
PATRIOT
INSTRUCTION MANUAL
FMSG-811E, FMSG-811E/F
PANINI GRILLS

V.1.0 | October 2014
PATRIOT
WARNINGS
•Do not touch any hot surfaces
•Do not immerse unit, cord or plug in liquid at any time
•Unplug cord from outlet when not in use and before cleaning
•Plug only into a 3-hole grounded electrical outlet of appropiate voltage
•Do not operate unattended
•Do not use this unit for anything other than intended use
•Do not use outdoors
•Keep children and animals away from unit
•Always cook on a firm, dry and level surface at least 12” from walls or any other obstruction
•Do not use unit with a damaged cord or plug, in the event the appliance malfunctions, or has
been damaged in any manner
•Any incorrect installation, alterations, adjustments and/or improper maintenance can lead to
property loss and injury. All repairs should be done by authorized professionals only
•Ensure that the power supply you are using is adequate for continual grill usage and the voltage
is correct.
•Do not jam materials or place heavy objects on grill, as this may cause damage
In order to protect the plates of your new grill during transportation, a layer of food-safe wax
was coated on the surface prior to shipment. This wax is harmless, but must be removed
before you begin to use. To remove, preheat the grill until the wax liquefies. Next, carefully
wipe away the melted wax with a clean, soft cloth. Once all of the wax is removed you can
begin to use your grill.
TO USE
1. Plug the power cord into the appropriately rated outlet.
2. The power light will illuminate.
3. Once desired temperature is set, the Heating Indicator will come on. Warm-up time is
approximately 7-8 minutes. The Heating indicator will cycle at set temperature.
4. For normal use, it is recommended that the temperature range be 395°F-485°F.
5. When the surface reaches the designated temperature, lift top grill using black handle and
lightly grease grill plates with vegetable oil. Place food on grill and lightly press handle down.
Excess oil will collect in the oil collection tray. Remove food when cooked. The heaters will
automatically cycle as needed.
CLEANING – NOTE: To maintain cleanliness and increase service life, the grills should be cleaned
daily. Do not immerse the grill in water or any other liquid.
• Before cleaning or attempting to move grill, unplug and let the unit cool completely
• Wipe the entire unit with a clean soft cloth until it is completely dry
• To avoid damage, do not use abrasive cleaners or scouring pads
• If soap or chemical cleaners are used, be sure they are completely rinsed away with clear water
immediately after cleaning. Chemical residue could damage or corrode the surfaces of the unit.
• Store in a dry and clean area when not in use

V.1.0 | October 2014
PATRIOT
TROUBLESHOOTING
Problem: Grill plates do not heat even though power indicators are lit
Possible Causes: Defective controller or Defective heater
Action: Replace controller or Replace heater(s)
Problem: Temperature cannot be controlled
Possible Causes: Defective temperature controller
Action: Replace temperature controller
Problem: Heating indicator appears normal, but power indicators are not lit
Possible Causes: Defective power indicator(s)
Action: Replace power indicator(s)
HANDLE TENSION ADJUSTMENT

V.1.0 | October 2014
PATRIOT
Wiring Diagram for the Panini Grills

V.1.0 | October 2014
PATRIOT
Parts Diagram and Replacement Parts for the Panini Grills

V.1.0 | October 2014
PATRIOT
Replacement Parts for the Panini Grills
Reference
Number
1
2
3
4
5
7
8
9
10
11
12
13
14
15
16
17
19
20
21
22
23
24
25
26
SG-811E and SG-811E/F
Part Number
DF6SG-1
TH-1201
DF6SG-3
SG-5
SG-7
SG1E-8
SG-9
SG-10
SG1E-15
SG-16
SG1E-17
SG1E-19
SG1E-20
SG-22
SG1E-24
SG-26
Description
Heat Indicator - Orange
Thermostat Regulator
Power Indicator - Green
Body
Torsional Spring w/Screws
Adjustbale Tension Base w/Screw
Axis Cover
Axis Holding Pin
Power Supply Cord
Bottom Plate - Cast Iron
Top Plate Cover w/ Screws
Upper Mounting Plate
Top Plate - Cast Iron
Upper Heating Element
Wire Tube
Upper Axis w/Clips
Handle Frame with Grip & Back Axis
Oil Collector
Lower Mounting Plate
Rubber Foot
Element Plate
Bottom Heating Element
Bottom Cover w/Screws
Thermostat Knob

V.1.0 | October 2014
PATRIOT
One Year Limited Warranty
Patriot warrants its equipment against defects in materials and workmanship, subject to the following conditions:
Patriot is warranted for one year, effective from the date of purchase by the original owner. A copy of the original
receipt or other proof of purchase is required to obtain warranty coverage. This warranty applies to the original owner
only, and is not assignable.
Should any product fail to function in its intended manner under normal use within the limits defined in this
warranty, at Patriot’s discretion, such product will be repaired, replaced with a refurbished unit, or replaced with a new
unit by Patriot, after defective unit has been inspected and defect has been confirmed. Patriot does not assume any
liability for extended delays in replacing any item beyond its control. This warranty does not apply to rubber and non-
metallic synthetic parts that may need to be replaced due to normal usage, wear or lack of preventative maintenance.
This warranty covers products shipped into the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska
and Canada. Warranty coverage on products used outside the 48 contiguous United States, Hawaii and metropolitan
areas of Alaska and Canada may vary.
The following conditions are not covered by warranty:
• Equipment failure relating to improper installation, improper utility connection or supply and problems due to
improper ventilation.
• Equipment that has not properly been maintained, damage from improper cleaning, and water damage
to controls.
• Equipment that has not been used in an appropriate manner, or has been subject to misuse, neglect, abuse,
accident, alteration, negligence, damage during transit, delivery or installation, fire, flood, riot, or act of God.
• Equipment that has the model number or serial number removed or altered.
• Equipment on which the security seal has been broken.
If the equipment has been changed, altered, modified, or repaired without express written permission from Patriot, then
the manufacturer shall not be liable for any damages to any person or to any property, which may result from the use of
this equipment thereafter.
This equipment is intended for commercial use only and this warranty is void if equipment is used in other than a
commercial application.
For warranty and non-warranty related issues, technical support, purchase replacement parts and warranty registration
visit www.admiralcraft.com or call 1-800-223-7750 for technical support. Please have your model number, serial number
and proof of purchase ready. It is not necessary to contact the place where you originally purchased your product from.
“THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL WARRANTIES EXPRESSED OR IMPLIED
INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILTY OR FITNESS FOR PARTICULAR
PURPOSES AND CONSTITUES THE ENTIRE LIABILITY OF ACE. IN NO EVENT DOES THE LIMITED
WARRANTY EXTENDBEYOND THE TERMS STATED HEREIN.”