PEERLESS CE41 User manual

Commercial and Industrial Ovens
If replacements parts are needed,
be sure to give the model number when ordering, including prex and sufx letters.
Please retain this manual for future reference
Model # Serial #
new standard lImIted parts & labor warranty
Peerless products are guaranteed against manufacturing defects for one
year from date of installation for parts and labor. All SC Series ovens qualify
for two years parts and labor. Proper start-up procedures must be followed
and warranty card submitted to activate either warranty. If warranty is not
activated, parts will be covered until the term of the warranty expires but labor
will not be covered. Excluded from this warranty are any claims related to
items that should have been performed at the time of installation such as:
improper utility connections, poor methods of venting, checking gas pressure
and calibration of controls, also excluded are normal maintenance items such
as adjustments to pilots, burners and cleaning related issues.
When making a claim for warranty service, during a claim inspection by
Peerless or its service representative, it is determined that the equipment
has not been used in an appropriate manner, has been modied, or has not
been properly maintained, or has been subject to misuse, abuse, has not
been properly installed / calibrated* or misapplication, neglect, accident,
damage during transit, re, ood, riot, or act of God, then this warranty shall
be VOID.
* Warranty terms are VOID if instructions provided with equipment are not
followed.
ovens
CE41 CE51 CE61 CE121 CE131
B, P & I MODELS • VENTLESS VL30 & VL50
P.O. Box 859  Sandusky, Ohio 44870  [phone]  FAX [phone]
www.Peerlessovens.com  oceeerlessovens.com
INSTRUCTION MANUAL
Conforms to
ANSI/UL Std. 197
and
Cert. to CAN/CSA Std.
C22.2 No. 109
table of contents
Congratulations ..................................... 1
Set Up Instructions (all models). . . . . . . . . . . . . . . . . . . . . . . . . 2
CE Series Operation Instructions ... . . . . . . . . . . . . . . . . . . . . 3
CE Series Troubleshooting .... . . . . . . . . . . . . . . . . . . . . . . . . 4
CE Series Suggested Maintenance. . . . . . . . . . . . . . . . . . . . . . 5
Parts Replacements Instructions ........................ 6
Parts List CE 131 IE ................................. 7
Parts List CEIE Electric Series B, P Models .... . . . . . . . . . . . 8
Parts List B121IE .................................... 9
DTB Temperature Controller
..........................
10
Wiring Diagram CE61 Single Phase
....................
12
Wiring Diagram CE61 Three Phase
....................
13
Wiring Diagram CE41/51 Single Phase. . . . . . . . . . . . . . . . . . .14
Wiring Diagram CE41/51 Three Phase
..................
15
Wiring Diagram CE131 Single Phase
...................
16
Wiring Diagram CE131 Three Phase
...................
17
Wiring Diagram B121
...............................
18
Ventless Models Operating Instructions
.................
19
Ventless Models Safety Precautions
....................
20
Ventless Models Maintenance
.........................
22
Ventless Models Guidelines
..........................
23
1/2019
ELECTRIC OVENS

TABLE OF CONTENTS
Congratulations ................................... 1
Set Up Instructions (all models) ....................... 2
CE Series Operation Instructions ...................... 3
CE Series Troubleshooting ........................... 4
CE Series Suggested Maintenance. . . . . . . . . . . . . . . . . . . . . 5
Parts Replacements Instructions....................... 6
Parts List CE 131 IE ................................ 7
Parts List CEIE Electric Series B, P Models .............. 8
Parts List B121E ................................... 9
DTB Temperature Controller ......................... 10
Wiring Diagram CE61 Single Phase, Gefran Controller .... 12
Wiring Diagram CE61 Single Phase, Love Controller .... 12A
Wiring Diagram CE61 Three Phase, Gefran Controller .... 13
Wiring Diagram CE 61 Three Phase, Love Controller .... 13A
Wiring Diagram CE41/51 Single Phase, Gefran Controller . 14
Wiring Diagram CE41/51 Single Phase, Love Controller .. 14A
Wiring Diagram CE41/51 Three Phase, Gefran Controller .. 15
Wiring Diagram CE41/51 Three Phase, Love Controller .. 15A
Wiring Diagram CE131 Single Phase, Gefran Controller ... 16
Wiring Diagram CE131 Single Phase, Love Controller ... 16A
Wiring Diagram CE131 Three Phase, Gefran Controller ... 17
Wiring Diagram CE131 Three Phase, Love Controller .... 17A
Wiring Diagram B121 Gefran Controller ................ 18
Wiring Diagram B121 Love Controller ................ 18A
Ventless Models Operating Instructions ................ 19
Ventless Models Safety Precautions ................... 20
Ventless Models Maintenance........................ 22
Ventless Models Guidelines ......................... 23
11/2021

!"#$%&'()&'*"#+,on your selection of this piece of cooking equipment.
er the years we hae deeloped what we consider the nest euipment
on the market today.
Please read these instructions before attempting installation. Set up and
start up should be performed by a ualied serice professional, electrician
and someone considered a professional in the installation of such
equipment or all the terms and conditions in our Limited Warranty will be
rendered void. If in doubt, call Peerless for the nearest Service Agency.
Retain this manual for future use.
1
-./,0.1/,23-450
o not store or use gasoline or other ammable apors or
liquids in the vicinity of this or any other appliance.
63/7879
Improper installation, adjustment, alteration, service or
maintenance can cause property damage, injury or death.
Read the installation, operating and maintenance instructions
thoroughly before installing or servicing this equipment.

2
!"#$%&$'(!#)%*#'+(!
,-..$/.001$2034.$+54678
9:$%6;1<=4$+546
Check to be sure owners manual, handles and
legs and brackets (required for stacked units) are
packed inside. Check unit for possible damage
during transit. Notify Peerless immediately if any
damage is found.
>:$&.<;4$0546$?6$?=7$@41A<646=$.0;<=?06:$
$$$$Level unit using the adjustable legs provided.
B:$C4D$'67=<..<=?06
Mount legs on the side of the unit while blocked,
(refer to Figure 1) NOTE: Ovens can be lightened
by remoing sheles and bafes, if desired ach
leg has four mounting bolts, packed inside oven.
After completing Step 1, proceed to the other two
legs. (refer to Figure 2)
B:$/[email protected]$7=<;G7
Locate the stacking brackets and legs with each
unit.
H:$2?6?AEA$*.4<1<6;4
6” from sides and rear from combustible and non-
combustible construction.
"C"*#)'*-C$I++JK%&
9: ith oen in place, hae a ualied electrician permanently wire unit
>:$Each unit comes with calrod elements. Check rating plate for amperage
load to determine wire size for proper installation.
B:$Counter models can be 120V or 220V. Floor models are 220V, single
(standard) or three phase (optional).
H:$Access to hook-up is located on the back cover. Remove top portion to
reveal terminal block for hook-up.
L: Be sure to use a separate case ground.
Figure 1
Figure 2

!"#$"%&"$#'("%)*&+,#&+$*%-!*&'+$
.-%+#'//
lease note or the rst hour of operation the burn off will occur he
unit will smoke considerable during this period. Burn off is oil residue and
insulation break in. Allow for good ventilation during this time. There is no
danger if you follow these directions and proceed with care and caution.
01##*234#54#657789#:;<6=>
?1##$96#=546358893#@53#A9:<39A#69BC93D6239
Industrial 0 to 500 degrees
Bake 0 to 550 degrees
Pizza 0 to 650 degrees
* Press ENTER when setting or changing temperature
E1##)885;#D6#89D:6#549#F0G#>523#@53#C39>9D61#A longer preheat is better for
complete stabilization of your unit.
H1##!"I0#.J#&#D4A#(#K5A98:#'48L
Your oven is equipped with a variable power control for the top deck only.
Set controller for desired temperature and adjust the top to balance top
and bottom decks as needed.
M1##To learn how to use this feature, start by setting the top heat control
at 10 and reduce to balance
I1##*234#5@@#657789#65#:>26#A5;4#24<61#Cooling fan may run until a safe
controller temperature is reached. It will then shut down automatically.
3

4
ce serIes troubleshootInG GuIde
problem cause remedy
Unit on, but will not heat One or more elements not working Replace bad elements
Loss of one or more legs of Call electrician to
power source restore power
Bad solid state relay (SSR) Replace
Unit power is off Toggle switch off Turn on
Unit in high limit shut down Controller bad
SSR stuck
Replace
Fan not working Clean fan or replace
In Fan Limit shut down
Blown Fuses Call service tech or
electrician for
assistance
Fan is off Bad fan Replace
Bad fan switch Replace
Blown fuses Call for assistance

!
ce serIes suGGested maIntenance
daIly "#$%&#''&()*+$(,&-'(#.#/'(&#0(#$
monthly 1'(#.&#0+2.,&'+3(0&40+.5&#.,&4#.&4+0&#--262'#57+.&
& +4&'7.58&,7058&+0&90(#$(:
oven InterIor ;%(&7.5(07+0&+4&<+20&2.75&7$&#'267.7=(,&$5(('&#.,&62$5&
/(&50(#5(,&375%&-#0(:&1'(#.&/<&2$7.9&67',&,(5(09(.5$&
#.,&#&/07''+&5<*(&*#,:&>($5&5+&0(6+?(&$*7''#9(&
766(,7#5('<&5+&#?+7,&-#0/+.7=7.9&+4&5%(&$*7'':
@A&BA;&CDE&1FEGH1IJ&1JEIBEKD8&$2-%&#$&
“Easy Off” as this type of cleaner will damage the
#'267.7=(,&-+#57.9:
oven exterIor "7*(&375%&,#6*(.(,&-'+5%&#.,&#&67',&,(5(09(.5:&
o not use abrasies on oen nish or it will scratch
staInless steel ;+&0(6+?(&.+06#'&,7058&90(#$(8&2$(&67',&,(5(09(.5&
#**'7(,&375%&#&$*+.9(&+0&-'+5%:&@0<&5%+0+29%'<:
pIzza decks& L7==#&$5+.($&62$5&/(&50(#5(,&375%&-#0(:&
1'(#.&375%&#&,(-M&/02$%&5%#5&-#.&/(&*20-%#$(,&40+6&
#.<&4++,&$(0?7-(&(N27*6(.5&,(#'(0:&"7*(&375%&#&3(''&
302.9&,#6*&-'+5%&5+&0(6+?(&,2$5&+0&0($7,2(:&@A&BA;&
1JEIB&"H;F&"I;EKO&@(-M$&37''&-0#-M:
Important
1'(#.&<+20&4#.&*(07+,7-#''<:&@705<&4#.$&37''&-#2$(&
$%25&,+3.$&5+&*0+5(-5&5%(&2.75P$&-+.50+''(0:

ce serIes parts replacement InstructIons
controller !"#$%&&'$()*+%,)-%.'+
) /',%0')#$+'.#)%&)1%.'+)*+%&()(%)2$$'##)$%&(+%1
) /',%0')$%&(+%11'+)2&3),%4&()+'-12$','&(
) 52+'*4116)+'-12$')."+'#)(%)(7')-+%-'+)('+,"&21#
solId state relay) !"#$%&&'$()*+%,)-%.'+
) /',%0')82$9)$%0'+
) /',%0')+'126)2&3),%4&()+'-12$','&(
) 52+'*4116)+'-12$')."+'#)(%)(7')-+%-'+)('+,"&21#
calrod elements) !"#$%&&'$()*+%,)-%.'+
) /',%0')82$9)$%0'+
) /',%0')."+'#)*+%,)3'#"+'3)'1','&(
) :-'&)3%%+;)+',%0')*2#('&'+#)2&3)+',%0')#(%&')
) )))))2&3)#(''1)3'$9
) /',%0')'1','&(#
) /'0'+#')-+%$'34+'
coolInG fan !"#$%&&'$()*+%,)-%.'+
) /',%0')#$+'.#)%&)1%.'+)*+%&()(%)2$$'##)*2&
) /',%0')*2&)2&3),%4&()+'-12$','&()*2&
) <&-14=)%13)*2&)2&3)-14=)"&)&'.)*2&
) /'-12$')*+%&(
door hInGe pIns)>"&=')-12$')2##',816)"#)*2#('&'3)(%)3%%+)*+2,'
) /',%0')3%%+).'"=7(#;)8%(7)#"3'#
) /',%0')#$+'.#)2&3),%0')3%%+)*%+.2+3)'&%4=7)
) )))))(%)#1"3')7"&=')-"&)$1'2+)%*)*+2,'
) ?&#'+()&'.)-"&)2&3),%4&()(%)*+2,')4#"&=)&'.)
) )))))#$+'.#)-+%0"3'3
) :13)4&"(#),26)+'@4"+')3+"11"&=)%4()%*)(7')#$+'.)
) )))))7'23#)2&3)3+"11"&=)&'.)7%1'#
) ?&)(7"#)$2#';)6%4),26)720')(%)+%(2(')7"&='#
A

!
ce131Ie electronIc models parts lIst
1/25/2019
CE131IE ELECTRONIC MODELS (2013 - PRESENT)
"#$%&%% #'()*+,-.)/),-*+,''(+ % 0&12322
"#$%&%1 4,55'(/67.*)8 % 0%9322
"#$%&%& :;6(/8,'<(+6 1 0%=322
"#$%&%> :;6(6 1 01%322
"#$%&%9 ",,'.-5/:?-/@/&A/112B % 0C2322
"#$%&%C Fan Guard % 0%2322
"#$%&%! :?-/",-*+,'/67.*)8DE#E$/"F % 0&C322
"#$%&%= 48(+G,),;H'(/ % 0=9322
"#$%&%I JJK/ % 0%I9322
"#$%&12 4(+G.-?'/L',)M % 0>2322
"#$%&1% "?'+,</('(G(-*6/112B > 0I9322
"#$%&11 1222N/O(?*.-5/('(G(-*6/112B > 0I9322
"#$%&1& PQ(-/R,,+/",GH'(*(/7.*8/O?-<'(/DJ*?.-'(66F % 0%I9322
"#$%&1> J*?.-'(66/J*(('/S,7(+/:+,-*/E?-(' % 0%29322
"#$%&19 R,,+/O?-<'( % 0>9322
"#$%&1C O.-5(/E.-/T66(GU'V/DJ,'</.-/E?.+6WF 1 0%%2322
"#$%&1! %X1A/E.YY?/R()M6/D&/+(Z;.+(<F > 0%19322
"#$%&1= S,7(+/O(?*(+/O,'<(+/?-</L?[['( > 0%29322
"#$%&1I E((+'(66/\?G(H'?*( % 011322
"#$%&&2 $-6*+;)*.,-/]?-;?' % 0%9322
"#$%&&% L?)M/",Q(+ % 099322
"#$%&&1 >A/S(56D6(*/,[/>F > 0%19322
"#$%&&& PQ(-/R,,+/7(.58*6 % 0C9322
"#$%&&> O.58/S.G.*/D&C2^F/JV-6V6 % 099322
"#$%&&9 :?-/'.G.*/67.*)8DE#E$/"F % 0&C322
PEERLESS 1 1/25/2019

!
!"#"$"%"!&'()#!$$$*"'#"*$+,$-$.(/"%*$-0'&*$%#*&
CEIE "ELECTRONIC" SERIES B, P MODELS
-0'&$1 /"*!'#-&#() !"23 !"43 !"53 %678$-96:;
"#$%& #'()*+,-.)/),-*+,''(+ 0 & 0 10%2%%
"#$%0 3,44'(/56.*)7 0 & 0 &82%%
"#$%1 9:5(/;,'<(+5 0 0 0 &!2%%
"#$%= 9:5(5 0 0 0 0&2%%
"#$%8 3(+>.-?'/@',)A & & & =%2%%
"#$%B "?'+,</;(?*(+ = = B C82%%
"#$%D ",,'.-4/9?- & & & B%2%%
"#$%! Fan Guard & & & &%2%%
"#$%C EEF/ & & & &C82%%
"#$&% 37(+>,),:G'(/H,+/#'()*+,-.)/",-*+,''(+ & & & !82%%
"#$&& IGG(+/EEF/ & &C82%%
"#$&0 J,*(-*.,>(*(+ & 8%2%%
"#$&1 J,*(-*.,>(*(+/K-,L & =%2%%
"#$&=MN 9?-/E6.*)7 & & & 1B2%%
"#$&=M@ 9?-/O.>.*/E6.*)7 & & & 1B2%%
"#$&8 $-5.<(/O,6(+/9+,-* & & & !82%%
"#$&B O,6(+/;(?*(+/;,'<(+/?-</@?HH'(5 & & & &8%2%%
"#$&D PQ(-/R,,+/",>G'(*(/6.*7/;?-<'(/SE*?.-'(55T & & 0 1C82%%
"#$&! ;.-4(/J.-/N55(>L'U/SE,'</.-/J?.+5VT 0 0 = &&%2%%
"#$&C PQ(-/R,,+/W(.47*5 0 0 = B82%%
"#$0% Oven Door Gasket -X? -X? -X? -X?
"#$0& PQ(-/R,,+/;?-<'( & & 0 =82%%
"#$00 E*?.-'(55/E*(('/O,6(+/9+,-*/J?-(' & & 0 &C82%%
"#$01 DY/O(45/SE(*/,H/=T/@'?)A 0%82%%
"#$0= &!Y/O(45/SE(*/,H/=T/@'?)A 0=82%%
"#$08 0!Y/O(45/SE(*/,H/=T/@'?)A 0C82%%
"#$0B &Y/J.ZZ?/R()A/S&M/0J)52/R()AT/J/>,<('5 & 0 BD82%%
"#$0D E*(('/R()A/@/[,<('5 & & & 0C82%%
"#$0! J((+'(55/\?>(G'?*( & & 002%%
"#$0C E*?.-'(55/E*(('/9+,-*/3+.> & & !82%%
"#$1% $-5*+:)*.,-/[?-:?' & & &82%%
"#$1& ;.47/O.>.* 0 1 C82%%
"#$10 @?)A/",Q(+ & & !82%%
PEERLESS 1 1/25/2019
1/25/2019

!
!"#"$%&""'()&##'(&*+,%-.&/012.&-$.2
B121IE 100V, 200V MODELS
/012&3 ,%.41$/2$+5 6789 -:;7&/<:=>
"#$%&%'% #()*+,-./*0*-.+,-((), % 1&2322
"#$%&%'& 4-55()067/+*8 % %9322
"#$%&%'1 :;6)08-(<),6 & %=322
"#$%&%'> :;6)6 & &%322
"#$%&%'9? @--(/.50:A.0'0&&2B % C2322
"#$%&%'9" @--(/.50:A.0'0%%2B % C2322
"#$%&%'C Fan Guard % %2322
"#$%&%'D :A.0@-.+,-(067/+*8 % 1C322
"#$%&%'= 48),E-*-;F()0 % =9322
"#$%&%'! GGH0 % %!9322
"#$%&%'%2 4),E/.A(0"(-*I % >2322
"#$%&%'%% %222J0K)A+/.50#()E).+60%&2B > !9322
"#$%&%'%& &222J0K)A+/.50)()E).+60&&2B > !9322
"#$%&%'%1 LM).0N--,0@-EF()+)07/+80KA.<()0OG+A/.()66P % %!9322
"#$%&%'%> G+A/.()660G+))(0Q-7),0:,-.+0RA.)( % %29322
"#$%&%'%9 N--,0KA.<() % >9322
"#$%&%'%C K/.5)0R/.0?66)ES(T0OG-(<0/.0FA/,6UP & %%2322
"#$%&%'%D %V&W0R/XXA0N)*I60O&0,)Y;/,)<P & %&9322
"#$%&%'%= Q-7),0K)A+),0K-(<),0A.<0"AZZ() > %29322
"#$%&%'%! R)),()660[AE)F(A+) % &&322
"#$%&%'&2 $.6+,;*+/-.0\A.;A( % %9322
"#$%&%'&% "A*I0@-M), % 99322
"#$%&%'&& >W0Q)56O6)+0-Z0>P > %&9322
"#$%&%'&1 @-,< % C9322
"#$%&%'&> K/580Q/E/+0O1C2]P % 99322
"#$%&%'&9 %W0R$^^?0G4L[# % &D9
0
PEERLESS 1 1/25/2019
1/25/2019

dtb temperature controller
10

11

9-14-15
12
ce61 b, I, & p 1 phase 220v wIrInG dIaGram
F. h.
F. h.
FAN
h.L.
CONT.
3.90K
RESISTOR
RED
F. S . L.S.
YELLOW ThC.
15 10 5
14 9 4
13 8 3
12 7 2
11 6 1
T. B . LINE
10
PC
SSR
21
10 PC RELAY
SSR RELAY
T.B. TERMINAL BLOCK
H.L. HiGH LiMiT
T.S. TOGGLE SWiTcH
F. h. FUSE hOLDER
CLAROSTAT
CONT. CONTROLLER
ThC ThERMOCOUPLE
CLARoSTAT
2 KOLMS
Gefran Controller 11-2021
5 KOLMS
_ 2
_ 1
_ _
_ _
23 20
24 19

9-14-15
12
ce61 b, I, & p 1 phase 220v wIrInG dIaGram
F. h.
F. h.
FAN
h.L.
CONT.
3.90K
RESISTOR
RED
F. S . L.S.
YELLOW ThC.
15 10 5
14 9 4
13 8 3
12 7 2
11 6 1
T. B . LINE
10
PC
SSR
21
10 PC RELAY
SSR RELAY
T.B. TERMINAL BLOCK
H.L. HiGH LiMiT
T.S. TOGGLE SWiTcH
F. h. FUSE hOLDER
CLAROSTAT
CONT. CONTROLLER
ThC ThERMOCOUPLE
CLARoSTAT
2 KOLMS
Love Controller
12A

9-30-15
13
ce61 b, I & p 3 phase wIrInG dIaGram
CONTROLLER
15 10 5
14 9 4
13 3
12 2
11 1
RED T.C.
YELLOW
TO #2
TO #1
FAN
F. S . L.S.
h.L.
3.90K RESISTOR
F. h.
F. h.
2 KOLMS
SSR
SSR
10
PCV
RED
WhITE
BLACK
Love Controller
Gefran Controller 11-2021
_ 2
_ 1
_ 6
_ 5
23 20
24 19
5 KOLMS
CLARoSTAT
1
2

9-30-15
13
ce61 b, I & p 3 phase wIrInG dIaGram
CONTROLLER
15 10 5
14 9 4
13 3
12 2
11 1
RED T.C.
YELLOW
TO #2
TO #1
FAN
F. S . L.S.
h.L.
3.90K RESISTOR
F. h.
F. h.
2 KOLMS
SSR
SSR
10
PCV
RED
WhITE
BLACK
Love Controller
13A