Pentair 560003 User manual

1
Important Notice
Attention Installer.
This manual contains important information about the installation, operation and safe use of this product.
This information should be given to the owner/operator of this equipment.
Before installing this product, read and follow all warning notices and instructions accompanying this product. Failure to follow
safety warnings and instructions can result in severe injury, death, or property damage. Call (800) 831-7133 for additional free
copies of these instructions.
WARNING
DANGER
RISK OF ELECTRICAL SHOCK OR ELECTROCUTION
This product must be installed by a licensed or certified electrician in accordance with the National Electrical Code and
all applicable local codes and ordinances. Improper installation will create an electrical hazard which could result in
death or serious injury to installer, or others due to electrical shock, and may also cause damage to property.
Fountain Niche Kit for Small Lights (P/N 560003)
Fountain Niche Kit for Large Lights (P/N 560002),
shown
WARNING
RISK OF ELECTRICAL SHOCK OR ELECTROCUTION
Do NOT use in a swimming pool, spa or other body of water involving immersed person use. USE ONLY with a
luminaire marked as a "submersible luminaire". A luminaire marked as a swimming pool or spa luminaire must
also be marked 'submersible luminaire' to be used with this fountain fixture.
Fountain Niche Kit for Small Lights
(P/N 560003)
is to be used ONLY with
Pentair Aquatic Systems
Luminaires with the following P/N's:
77181100, 77188100, 77182500,
77111100, 77114100, 77118100,
77313100, 77310100, 77161100,
77164100, 77168100, 77375100,
77360300, 77365000, 77362000,
640000, 640001, 640002, 640003, 640004,
78101200, 78104200, 78108200,
78107000, 78107500, 78104100,
78108100, 78107200, 78109100,
78105500, 78108500, 78566500.
Fountain Niche Kit for Large Lights
(P/N 560002)
is to be used ONLY with
Pentair Aquatic Systems
Luminaires with the following P/N's:
78354200, 78354400, 78356200,
78356008, 78356108, 78356400,
78356401, 600061, 600062, 78421100,
78424100, 78428100, 78928400,
78928500, 78927000, 78927900,
78441100, 78444100, 78448100,
78948900, 78949100, 78447100,
78449100, 78451100, 78454100,
78458100, 78958300, 78456300,
78457100, 78459100, 78444200,
78448200, 78941500, 78950100,
78454200, 78458200, 78958500,
78458300, 78858100, 78856900,
60100X.
FOUNTAIN LIGHT FIXTURE
NICHE MOUNT KIT FOR FOUNTAIN USE ONLY
INSTALLATION INSTRUCTIONS
Pentair Water Pool and Spa, Inc.
1620 Hawinkins Ave. Sanford, NC 27330 • (919) 566-8000
10951 West Los angeles Ave., Moorpark, CA 93021 • (805) 553-5000
IMPORTANT SAFETY INSTRUCTIONS
READ AND FOLLOW ALL INSTRUCTIONS
SAVE THESE INSTRUCTIONS
WARNING: Do not use this lighting
fixture in any body of water containing
plants, animals or other life-forms that
may be potentially harmed by brass/
copper or other metals.

2
Section I. InstallingFountainLightFixture—NicheMount
A. Preparatory steps which must be completed by the electrician before the light fixture is installed:
1. Verifythatthefountain meets the requirementsofthecurrent National Electrical Codeandalllocal codes and ordinances.
A licensed or certified electrician must install the electrical system to meet or exceed those requirements before the
underwaterlightisinstalled.
2. Verifythatthelightingcircuit
has a Ground Fault Circuit
Interrupter (GFCI) for line
voltage models and has an
appropriately rated circuit
breaker.
3. Thewetnichemustbeproperly
installed so that the top of the
underwater light's lens is at
least 2 inches below the
surface of the water.
4. Thewetnichemustbeproperly
electrically bonded and
grounded via the #8 AWG
ground connector located at
the rear of the niche.
B. Steps to perform after the
electrical system requirements
are met:
1. Assemblethescrewsandnuts
to the stainless steel face ring
of the light being used. See
Figure1.
2. Feedthecordthroughconduit
to the Junction Box, leaving
some length of cord at the
lightfixturetocoilaroundthe
light.Thislengthofcordaround
thelightallows the lighttobe
pulled out of the water and
serviced conveniently without having to disconnect the light from the J-Box.
3. Ensure that the length of exposed cord in the fountain is no more than 10 ft. (3 m).
4. Cut the cord at the Junction Box, leaving at least 6 inches of cord to make connections.
5. Strip 6 inches of the outer cord jacket to expose the three insulated wires – be careful not to damage the insulation
on the three inner wires.
6. Connect all three wires to the corresponding circuit wires in the Junction Box and secure the Junction Box cover
in place.
7. Place the light assembly into the niche and tighten special pilot screw.
8. Position and secure the rock guard with the acorn nuts provided. To ensure proper positioning, align the pilot screw
of the light with the pilot screw hole of the rock guard. Refer to Figure 1.
FountainNicheKitforLargeLights
Figure1.
Light
Rock
Guard
Rock
Guard
Screws
Retaining
Nut
Acorn
Nut
Niche
Pilot Screw
Pilot Screw Hole
Rock
Guard
Pilot Screw
Light
Rock
Guard
Screws
Retaining
Nut
Rock
Guard
Screws
Acorn
Nut
Niche
Pilot Screw Hole
FountainNicheKitforSmallLights
Rock
Guard
Light
Face Ring
Retaining
Nut
Acorn
Nut
Rock
Guard
Screw
AssemblyView

3
SAVE THESE INSTRUCTIONS
WARNING
Never operate this underwater light for more than 10 seconds unless it is totally submerged in water. Without total submersion, the
light assembly will get extremely hot, which may result in serious burns or in breakage of the lamp or lens. This may result in serious
injury to pool/spa users, installers, or bystanders, or in damage to property.
9. Fill the fountain until the light is completely submerged in water before operating it for more than 10 seconds. Entire
fixture must be at least 2 inches below water level.
10. Turn on main switch or circuit breaker, as well as the switch that operates the light itself, to check for proper
operation. Refer to Operating Instructions of the light.
12.00" DIA
2.70"
SectionII. TechnicalData
A. Replacement Parts
Item P/N Description
No.
1 570011 Fountain Niche Screw Kit
FountainNicheKitDimensionsforSmallLights FountainNicheKitDimensionsforLargeLights
7.25" DIA
1.85"
1

4
40
All Pentair trademarks and logos are owned by Pentair or by one of its global affiliates. Pentair is a registered trade-
markofPentairWater Pool and Spa,Inc.and/orits affiliated companies intheUnited States and/ orothercountries.Because
wearecontinuously improvingourproducts andservices,Pentair reservestheright tochangespecifications without prior
notice.Pentairis an equalopportunityemployer.
© 2019 Pentair Water Pool and Spa, Inc. All rights reserved. This document is subject to change without notice.
P/N 570021 REV. F 5/2019
1620 Hawkins Ave., Sanford, NC 27330 • (800) 831-7133 or (919) 566-8000
10951 West Los Angeles Ave., Moorpark, CA 93021 • (800) 831-7133 or (805) 553-5000
This manual suits for next models
1
Table of contents
Other Pentair Light Fixture manuals
Popular Light Fixture manuals by other brands

BARRON
BARRON TRACE-LITE AXB installation instructions

Beamz
Beamz Cobra 100H user manual

Lightolier
Lightolier SL203A specification

Cooper Lighting
Cooper Lighting Combolight Trimless V90229-1N installation instructions

Skoe
Skoe SKE-TKZ-Y04 user manual

Lightmaxx
Lightmaxx PLATINUM LINE LIG0007903-000 user manual

ENIM LIGHTING
ENIM LIGHTING STEELO 1.4m 40W 840 Mounting instruction

Lightolier
Lightolier Lytecaster 2000 series instruction sheet

Agrilight
Agrilight AVILED eco Installation and user manual

Visionary
Visionary INSURGENT VISH2 Series Operating instructions manual

Philips
Philips Calculite 8044 specification

MOOD
MOOD CIE90039 instruction manual