Percy Doughty & Co HELIOS User manual

1
HELIOS
MULTI FUEL STOVE
APPROVED - CONFORMING TO EN13240:2001 and
EN13240 A2:2004
INSTALLATION AND OPERATING INSTRUCTIONS
STOVES MUST BE FITTED BY APPROVED, QUALIFIED AND
COMPETENT INSTALLERS
PLEASE LEAVE THIS BOOKLET WITH THE HOUSEHOLDER
Gallery Stoves operate at very high temperatures. All persons
including children and the infirm should be warned of this and not
allowed to touch any surfaces whilst in use. The operator must use
the glove provided.
www.percydoughty.com
HELIOS INSTRUCTION –REV. E –OCTOBER 2016

2
CONTENTS
STOVE CONTROLS, OUTPUT & EFFICIENCY PAGE 03
COMPONENT PARTS PAGE 04
INSTALLATION PAGE 05
OPERATION PAGE 10
GENRAL MAINTENANCE PAGE 16
SAFETY NOTES & TROUBLESHOOTING PAGE 18
STOVE ACCESSORIES PAGE 21

3
YOUR STOVE: OPERATING CONTROLS, OUTPUT AND EFFICIENCY
Outputs stated are under ideal test conditions carried out at SGS Environmental Services in the
Netherlands. Variations may occur due to installation, atmospheric conditions and fuel quality.
HELIOS 5 CB
FUEL
WOOD
ANTHRACITE
EFFICIENCY
82.8%
83.4%
FLUE GAS TEMPERATURE
224 ˚C
214˚C
EMISSION OF CO @ 13% O2
0.33%
0.25%
RATED OUTPUT
4.6kW
WEIGHT
53kg
Secondary Air Control
Primary Air Control
Tertiary Air Holes

4
COMPONENT PARTS
Many spare parts are stocked –please refer to your retailer or supplier if you
require any replacement parts.
Please only use components made specifically for your stove.
ITEM
DESCRIPTION
ITEM
DESCRIPTION
1
Stove body
8
Flue blanking plate
2
Hinge set
9
Primary air slide assembly
3
Door casting
10
Fuel retaining bar
4
Side brick
11
Baffle plate
5
Rear brick
12
Ash Pan
6
Grate
13
Handle/latch assembly
7
Flue collar
14
Door glass retaining clip
15
Door glass

5
INSTALLATION, OPERATION AND MAINTENANCE
IMPORTANT: THIS APPLIANCE MUST BE INSTALLED BY A COMPETENT PERSON AND THE
INSTALLATION MUST COMPLY WITH BS8303 –CODE OF PRACTICE FOR INSTALLATION OF
DOMESTIC HEATING AND COOKING APPLIANCES BURNING SOLID MINERAL FUEL, NATIONAL
BUILDING REGULATIONS, LOCAL BY-LAWS AND STANDARDS AND THE REQUIREMENTS OF THE
HEALTH AND SAFETY AT WORK ACT - IN PARTICULAR:
HANDLING –ADEQUATE FACILITIES MUST BE AVAILABLE FOR LOADING, UNLOADING AND SITE
HANDLING.
FIRE CEMENT –SOME TYPES ARE CAUSTIC AND SHOULD NOT BE ALLOWED TO COME INTO
CONTACT WITH THE SKIN. IN CASE OF CONTACT WASH IMMEDIATELY WITH PLENTY OF WATER.
ASBESTOS –THESE STOVES CONTAIN NO ASBESTOS. IF THERE IS A POSSIBILITY OF DISTURBING
ANY ASBESTOS IN THE COURSE OF INSTALLATION THEN PLEASE SEEK THE GUIDANCE OF A
SPECIALIST AND USE APPROPRIATE PROTECTIVE EQUIPMENT.
METAL PARTS –WHEN INSTALLING OR SERVICING THIS STOVE CARE SHOULD BE TAKEN TO AVOID
THE POSSIBILITY OF PERSONAL INJURY
UNLESS THE INSTALLER IS QUALIFIED TO APPROVE INSTALLATION THEN APPROVAL MUST BE
SOUGHT FROM YOUR LOCAL BUILDING CONTROL DEPARTMENT. THE SUPPLIERS ACCEPT NO
RESPONSIBILITY IF THIS ADVICE IS NOT FOLLOWED. THIS APPLIANCE HAS BEEN EXTENSIVELY
TESTED FOR SAFETY AND EFFICIENCY, DO NOT ATTEMPT TO MODIFY IT. ALWAYS USE GENUINE
REPLACEMENT PARTS AS RECOMMENDED BY YOUR SUPPLIER. FAILURE TO ADHERE TO THIS
ADVICE WILL INVALIDATE YOUR GUARANTEE.
TRY TO AVOID FITTING THE STOVE INTO A ROOM WITH AN EXTRACTOR FAN. IF THIS IS
UNAVOIDABLE THEN SEEK SPECIALIST ADVICE TO ENSURE THAT THE INSTALLATION IS TESTED
FOR SAFETY. A SUITABLE TEST COMPRISES CHECKING FOR SPILLAGE IF THE ROOM WHERE THE
APPLIANCE IS FITTED IS SUBJECTED TO THE GREATEST POSSIBLE DEPRESSURISATION. THIS
MEANS FIRING THE APPLIANCE WITH ALL THE EXTRACT FANS IN THE BUILDING OPERATING AT
THEIR MAXIMUM AND WITH ALL DOORS, ADJUSTABLE VENTILATORS AND WINDOWS CLOSED.
IF SPILLAGE OCCURS THEN ADDITIONAL PERMANENT VENTILATION DIRECT FROM OUTSIDE WILL
BE REQUIRED. ONCE THE ADDITIONAL VENTILATION IS FITTED, RETEST AS NOTED ABOVE,
DO NOT FIT AN EXTRACTOR FAN INTO THE SAME ROOM AS THE STOVE AFTER IT HAS BEEN
INSTALLED AS IT MAY CAUSE THE STOVE TO EMIT FUMES
IT IS ESSENTIAL AND REQUIRED BY BUILDING REGULATIONS THAT A CARBON MONOXIDE (CO)
ALARM IS INSTALLED IN THE SAME ROOM AS THIS STOVE.
THIS STOVE MUST HAVE ITS OWN CHIMNEY AND MUST NOT SHARE A CHIMNEY WITH ANOTHER
APPLIANCE.
THIS STOVE IS FOR INTERMITTENT USE ONLY AND SHOULD BE SHUT DOWN OVERNIGHT.
VENTILATION MAY BE REQUIRED INTO YOUR ROOM, PLEASE SEE PAGE 9.