Philips FWM2200/55 User manual

Version 1.0
3140 038 60120
Published by LZ 1312 Subject to modification
©Copyright 2013 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval
system or transmitted, in any form or by any means, electronic, mechanical, photocopying,
or otherwise without the prior permission of Philips.
FWM2200/55
CONTENTS
-------------------------------------------------1-1--1-10
Safety Instruction
Technical specification
--------------------------------------------------------------2-1
Version variation ---------------------------------------------------------------2-2
Block diagram-------------------------------------------------------------------3-1
Wiring diagram ----------------------------------------------------------------3-2
Circuit diagram-----------------------------------------------------------4-1--4-4
LCD+KEY LINE IN+AUX CD+USB BOARD
top & bottom layout------------------------------------------------------5-1--5-5
Exploded diagram -------------------------------------------------------------6-1
---------------------------------------------------7-1--7-5
Disassembly drawing
Mini Hi-Fi system
FWM2200X/78

1-1
TECHNICAL SPECIFICATION
Diemensions with Boxes ( wxhxd) W705xH371xD292xmm
CHECK: Douglas
Units in Masstercarton
NAME :
Diemensions without Boxes ( wxhxd ) W220xH312xD248mm
Weight ( inclusive packing )9.5Kg
CABINET
Weight ( exclusive packing & batery )7.8Kg
Material : HIPS / ABS / PMMA
Units in Dealercarton
Finshing : Chrome Plate
VOLUME (KNOB)
PLAY (BUTTON)
|<< (BUTTON)
SPK(RIGHT)
SPK(LEFT)
TUNER (BUTTON)
DSC (BUTTON)
AUX/MP3 LINK (BUTTON)
MP3 LINK(JACK)
ALBUM PRESET ˉ
DBB (BUTTON)
STOP (BUTTON)
Description
ALBUM PRESET ˇ(BUTTON)
Page
FRONT CABINET
OPEN/CLOSE (BUTTON)
USB (JACK)
(BUTTON)MAX SOUND (BUTTON)
17
DISC (BUTTON)
USB (BUTTON)
(BUTTON)>>| (BUTTON)
POWER ON/OFF (BUTTON)
8
9
15
16
18
19
20
DEPICTION
6
7
Pos
1
2
3
Remarks :
1
4
5
14
10
11
12
13
GENERAL PART 1 - FRONT PANNEL SPECICFICATION
Remark :
Class No Ver
1
FWM2200 MICRO SYSTEM
Issued Date
2013-3-22
2
3
A4
DATE :2013-3-22 YUSAN INDUSTRIES LTD
10 SH 190 - 1





































1-2
TECHNICAL SPECIFICATION
AUX IN JACK
V
e
r
1
2
3
6
DEPICTIONP os DescriptionP age
3L eft / Right Speaker Socket
4
5A .C. Voltage Selector
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
1A M ANTENNA SOCKET
2F .M. PIG TAIL ANTENNA
25
26
Diemensions without Boxes ( wxhxd ) W220xH312xD248mmF inshing :Chrome Plate
CABINET
Diemensions with Boxes ( wxhxd ) W705xH371xD292xmm Material :HIPS / ABS / PMMA
Weight ( inclusive packing )9.5Kg Units in Masstercarton
Weight ( exclusive packing & batery )7.8KgU nits in Dealercarton
GENERAL PART 1 - BACK PANNEL SPECICFICATION
Class No
FWM2200 MICRO SYSTEM
Issued Date
2013-3-22᮹
SH 190 - 2
DATE : 2013-3-22᮹YUSAN INDUSTRIES LTD
NAME : 1 0
CHECK: Douglas











1-3
TECHNICAL SPECIFICATION
LIFETIME : 7 Years
GENERAL DESCRIPTION
MP3-USB Mini Hi Fi System with Digital PLL Tuner , CD-MP3, 100 W+-1dB *2 /per channel Universal Class D Power Amplifier
Aux In,mp3 paly in , Remote Control
Supply + Amplifier
Loudspeaker Boxes USB Clock
CD / MP3
I
X
Class
Tuner
X
X
X
III
II
X
4,5
4
9
6
55
EN 60065
Page
8
7
SAFETY requirements
Version
Safety
EMC
78
EN 60065
PERFORMANCE CLASSES
RADIATION / IMMUNITY requirments ( EMC )
CLIMATIC requirements
ALL climates
: + 5 Dregree till + 35 Degree
MODERATE climates
: + N.A till N.A Degree
POWER SUPPLY
MAINS ( A.C. )
120/230 Vac
230VAC
Version
Voltage Selection
55/78
yes
Frequency
50/60Hz
POWER CONSUMER
FWM2200/55/77/78
( DEMO mode " OFF " ) , NOM. A, INPUT
Stadby :
< = 10W
@ 1/8 Prated , NOM. A, INPUT
Maximum :
/
Q and R according to Product Division Rules
Quality : 0.4 % ( Major ) 1.5 % ( Mirror )
Reliability : 2.0 % ( C 42 )
ECO Power mode :
< = 2W
Tested according to General Test Instruction refer to PHILIPS standary ( UAN -D1591 )
Measured according to PHILIPS standary ( UAN - L1059 ) unless other wise stated
All not mentioned date, please refer to PHILIPS standary ( XUW - 0010 - jun 2001 )
DERIVED
REMARKS
APPROBATION
2
* power out 100W+-1dB * /per channel
GENERAL PART 1 - GENERAL SPECICFICATION
Remarks
Issued Date
1
2013-3-22¨
Class No
FWM2200 MICRO SYSTEM
Ver
A4
YUSAN INDUSTRIES LTD
SH 190 - 3
3
NAME : Luochide
10
CHECK: Douglas
DATE :2013-3-22¨
/

1-4
TECHNICAL SPECIFICATION
:
:
:
:
:
:
¡´+-4dB
¡´+-5dB
MP3 LINK
650mV 1KHz Ref
Normal
Limit
ELECTRICAL DATA
TECHNIAL DESCRIPTION
Total power 200W, matching SPEAKER of 100W+-1dB x 2 channel 6 ohm load.
GENERAL PART
OUTPUT stage Protection : Yes Temperature : YES Shorcircuit : Yes
LoudSpeaker D.C. Protection : Yes.
INDICATORS
Standby Mode Indicator : LCD display Clock active
ECO Mode Indiicator : LCD turns off, ECO - Standby LED turn on (Only for 12/05/37)
dB
DBB
OFF
Hum ( Volume Minimun - )
< 0.6
µW
DSC :
Rock, Jazz, Optimal, Techno
Channel Differencer at -46dB
3
µW
VAC :
N/A
Channel Separation ( at 1 kHz )
¡35
dB
SIS :
N/A
Residual Noise ( Volume Minimun )
<0.07
dB
INTERCONNECTS
Input Sensitity(±2 dB)rated ouput power at 1 kHz and 10kHz.
Line Output Voltage ( *1 )
WOOX :
N/A
Signal / Noise ( weighted )
¡55
CD
0 dB track ( Audio Disc 1, Trk 35 )
Subwoofer Out
N.A
Tuner
FM MODE 75KZH -CD 6dB
Line Out ( Left / Right )
N.A
OUTPUT POWER ( * 1ch ) At THD = 10% (Measured with 20Hz-22KHz filter),
USB
0 dB track ( 1K 0dB)
Headphone
700mV, RL = 32§
AUX
Nor:2000mV
Digital Coaxial Out
N.A
TAPE
NC
Booster Out
N.A
mp3 in
Nor:650mV Lim: 350mV ~ 800mV
Digital Coaxial Out
N.A
¡´+-5dB
Power output ( RMS )
2 channel
100W*2 Measure 1ch
USB
0dB
SOURCE BALANCE (Measured with 20Hz-22KHz filter) BiAmp
Location
Condition
¡´+-4dB
¡´+-5dB
0dB
REF
¡´+-4dB
FM
Euro 40KHz Dev. USA 75KHz Dev.
CD
0dB
with rated input signal in AUX mode; DSC OFF mode with DBB OFF
Rated Impedance :4 ohm
Remarks
( *1 ) Electrical parameters are to be measuremend at specker terminals across 6 Ohm load ( pure resistor )
IS off unless specified otherwise
2
GENERAL PART 1 - TECHNAICAL SPECICFICATION
Issued Date
Class No
FWM2200 MICRO SYSTEM
Ver
A4
1
2013-3-22¨
3
CHECK: Douglas
DATE : 2013-3-22¨
YUSAN INDUSTRIES LTD
NAME : Luochide
10
SH 190 - 4

1-5
TECHNICAL SPECIFICATION
Set DSC to Flat mode
Adjust volume to obtain 500mW across 6 ohm load at 1ch speaker ouput
AUDIO SIGNAL PROCESSING
Micro Hi-Fi System with PLL Tuner ,USB, CD-MP3, 100W+-1dB*2 channel (1speaker load) Class D Digital Power Amplifier
1 ) DSC ( Digital Sound Control )
Input sinewave 2000mV at 1kHz to R/L channel of AUX-IN socket
The 500mW will be used as 0dB reference
Inject sinewave 2000MV to AUX - IN socket with frequencies indicated below :
Inject sinewave 650MV to MP3-LINK socket with frequencies indicated below :
Tabel 1a ( Tolerance ± 3dB )
Frequency DSC Modes with DBB Off
JAZZ DBB Off ROCK DBB Off TECHNO DBB ON OPTIMAL DBB ON
100 Hz -5dB +5 dB -2 dB + 5 dB
+2dB + 6 dB -4 dB10 kHz
1 kHz 0 + 2 dB -2 dB 0
0dB
2 ) DBB ( Dynamic Bass Boot )
Frequency DBB OFF DBB ON
0
Remarks
GENERAL PART 1 - AUDIO SIGNAL SPECICFICATION ( 1 )
Ver
A4
2
1
SH 190 - 5
CHECK: Douglas DATE : 2013-3-22᮹YUSAN INDUSTRIES LTD
NAME : Luochide 10
3
FWM2200 MICRO SYSTEM
Issued DateClass No
Play CD testing signal of 1KHZ
+5dB
Set DSC to FLAT mode and switch off DBB
Adjust volume level will be as 0 dB reference.
Tabel 2 ( Tolerance ± 3dB )
2013-3-22᮹
100HZ

1-6
TECHNICAL SPECIFICATION
Timer Setting : Clock and Timer
TECHNIAL DESCRIPTION
SOFTWARE IMPLEMENTED CLOCK / TIMER FUNCTION WITH 32.768Khz QUARTZ OSCILLATOR.
GENERAL PART
,1',&$7256
Timer Wakeup Mode : LAST SETTING (MODE)
Remarks Time Setting : for 24hrs (05/12/98/55/79/96/77/78) ,for 12 hrs (37/ )
Volume at Wakeup : Last Setting
1R嘅RI嘅7LPHU嘅6HWWLQJ V : 1
&ORFN嘅$FFXUDF\ : Normal: 1 sec/day Limit : 2 sec/day
1
'LVSOD\嘅7\SH 嘅嘅嘅嘅嘅嘅嘅嘅嘅/&'
Remark
CLOCK / TIMMER SPECICFICATION
Class No
FWM2200 MICRO SYSTEM
Ver Issued Date
NAME : Luochide 10
2013-3-22᮹
2
3
SH 190 - 6
DATE : 2013-3-22᮹YUSAN INDUSTRIES LTDCHECK: Douglas
A4

1-7
TECHNICAL SPECIFICATION
GENERAL PART
TECHNIAL DESCRIPTION
CD + MP3 - Part Specifications
CD mechnism refer to Philips standard specification
Measurement are directly done at the connector on CDC board
OhmsOutput Resistance
UnitDescription
Extern
Filter
Nom Lim
Vrms
dB
No / /
//
YES 0 -3
Frequency Response ( 125 Hz - 16 kHz ) YES 0 -3
dB
Crosstalk ( 125Hz to 16kHz ) No
Output Voltage - Unloaded ( 0dB , 1 kHz ) No
dB
Channel Unbalance
Yes 60 50
65 55 dBA
Signal to Noise Ratio ( Unweighted ) dB
Signal to Noise Ratio ( A - weighted ) Yes
Yes 60 50
Crosstalk ( 1kHz )
Emphasis -
No 400 500
36 30 dB
nW
///
Hum & Noise ( *1 )
3
2
1 2013-3-22᮹
Class No
FWM2200 MICRO SYSTEM
Remark
CD / MP3 SPECICFICATION
Issued Date
A4
Ver
CHECK: Douglas DATE :2013-3-22᮹YUSAN INDUSTRIES LTD
NAME :Luochide 10 SH 190 - 7

1-8
TECHNICAL SPECIFICATION
2
IF
/
/
NAME : Luochide
10
Issued Date
1
2013-3-22¨
WAVE RANGE
TOLERANCE
TUNING GRID
Remarks
MHz
TECHNIAL DESCRIPTION
TUNER using Digital PLL Tuner SI4730D60
GENERAL PART
AERIAL
FM : PIGTAIL ANT 1200MM
FM 87.5 - 108 MHz
50KHZ
MW 530 - 1710 kHz
10KHz
Unit
MW : AM LOOP ANTENNA AH42-20001P-A D145x120mm
INDICATORS
ELECTRICAL DATA
- 3 dB Limiting Point
/
A.M
Nom
Limit
Unit
F.M.
Nom
Limit
/
dBf
Channel Unbalance
: 0
-3
dB
Channel Unbalance
: 0
-3
dB
dBf
AGC Figure of Merit
: 30
25
dB
Distortion ( RF 1mV, Frq Dev.75 kHz )
: 3
: 25
7
%
Distortion ( RF 50mV, M 80% )
: 3
7
%
Stereo - 46 dB Quieting
: 46
49
IF
/
/
kHz
Search tuning sensitivity
60
72
dBV/m
IF Rejection
dB
Large Signal
Selectivity
S3 / S9 / 300kHz
dB
18
dB
Search tuning sensitivity
28
37
dBf
Crosstalk (RF1mV, Freq Dev.40kHz )
/
Wave Range
Noise Limited Sensitivity 26 dB
Image Rejection
dB
MW 600 kHz
Nom.
1500uV/M
/
1000mV/M
/
Lim.
4000uV/M
/
/
500mV/M
MW 1400 kHz
Nom.
1500uV/M
Lim.
/
/
/
1000mV/M
/
4000uV/M
/
/
/
500mV/M
FM 98 MHz
Nom.
18dBf
Lim.
22dBf
/
108 dBf
25
30
/
/
/
116 dBf
TUNER SPECICFICATION
Class No
FWM2200 MICRO SYSTEM
Ver
3
A4
DATE : 2013-3-22¨
YUSAN INDUSTRIES LTD
CHECK: Douglas
SH 190 - 8

1-9
TECHNICAL SPECIFICATION
TECHNIAL DESCRIPTION
USB
Measurment are directly done at the connector on the board
Channel Unbalance < = +/- 3 dB
GENERAL PART
Measurement are directly done at the connector on CDC board
Description Specification
Output Resistance < = 1.5 kOhm
Output Voltage RL = 33 k ohm ( )dB, 1 Khz ) 830mVrms +/- 1.5dB
THD + Noise ( 0dB, 1Khz ) <= 0.7 %
Signal to Noise Ratio ( 0dB,1kHz ) >= 65dBA ( A - weighted )
Channel Crosstalk ( 100Hz - 16,000 Hz ) >= 35 dB
( 0 dB, 1 KHz ) >= 40 dB
Frequency Response ( +/- 3dB ), reference 1kHz 100Hz - 10kHz
Description Specification
2
Remarks :
USB SPECICFICATION
Issued Date
12013-3-22᮹
Class No
FWM2200 MICRO SYSTEM
Ver
3
CHECK: Douglas DATE :2013-3-22᮹YUSAN INDUSTRIES LTD
NAME : Luochide 10 SH 190 - 9 A4