Philips FWT6600 User manual

all
TABLE OF CONTENTS Page
Technical specification ...........................................................1-16
Safety instruction......................................................................2-1
ESD protection..........................................................................2-4
Set Block diagram ....................................................................3-1
Set Wiring diagram...................................................................4-1
Disassembly diagram...............................................................5-1
Main board
Circuit diagram........................................................................6-1
Layout diagram.......................................................................6-2
Display board
Circuit diagram........................................................................7-1
Layout diagram.......................................................................7-2
CD board
Circuit diagram........................................................................8-1
Layout diagram.......................................................................8-2
MCU board
Circuit diagram........................................................................9-1
Layout diagram.......................................................................9-2
Tuner board
Circuit diagram......................................................................11-1
Layout diagram.....................................................................11-2
AMP board
Circuit diagram....................................................10-1..10-2..10-3
Layout diagram.............................................................10-4..10-5
Mechanical Exploded view......................................................12-1
©Copyright 2013 Philips Consumer Electronics B.V. Eindhoven, The Netherlands
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without
the prior permission of Philips.
Published by LX 1 Service Audio Printed in The Netherlands Subject to modification
Version 1.0
Mini Hi-Fi System FWT6600/
317 3140 038 60220

1-2
Type /Versions:
Features
Board in used: Service policy
Main BOARD
Display BOARD
* TIPS : C -- Component Lever Repair.
M -- Module Lever Repair
√
-- Used
Feature diffrence
RDS
VOLTAGE SELECTOR
ECO STANDBY - DARK
Type /Versions:
FWM6600
VERSION VARIATION
Amp BOARD
Key BOARD
(LATAM)
Mic BOARD
MCU BOARD
FWM6600
/55
Tuner BOARD
CD BOARD
/55
Location of PC Boards
Technical Specification and Connection Facilities
C/M
C/M
C/M
C/M
C/M
C/M
(ARGENTINA)
x/77 x/78
x/77 x/78
(BRAZIL)
SMPS BOARD M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
C/M
M M
C/M
C/M
C/M
C/M
C/M
C/M
CD PART
Amp Board SMPS Board
EQ Board
MIC/PC IN/AUDIO IN Board
MCU Board
BT Board
USB Board
Display Board
Light Board
Key Board
Main Board
Tuner Board
CD Board
AC Cord

No. Descrpitopn Page
 *(1(5$/3$57)52173$11(/63(&,&),&$7,21 
 *(1(5$/3$57%$&.3$11(/63(&,&),&$7,21 
 *(1(5$/3$57*(1(5$/63(&,&),&$7,21 
 *(1(5$/3$577(&+1,&$/63(&,&),&$7,21 
 *(1(5$/3$57,32'6,*1$63(&,&),&$7,21 
 *(1(5$/3$57$8',26,*1$/63(&,&),&$7,21 
 *(1(5$/3$57&/2&.7,0(563(&,&),&$7,21 
 *(1(5$/3$5786%6,*1$/63(&,&),&$7,21 
 *(1(5$/3$57781(563(&,&),&$7,21$OO 
 *(1(5$/3$57&'0363(&,&),&$7,21 
 *(1(5$/3$579(56,2129(59,(:63(&,&),&$7,21 
FWT6600 SH 190 Contact List
1-3

1-4
26
4
5
Pos
1
2
3
8
DEPICTION
9
10
11
12
6
7
MAX SOUND
27
17
18
19
20
21
22
13
14
MIC 1 JACK
15
16
23
24
25
IR LENS
AUX/LINE
TUNER
DISC3
OPEN/CLOSE
>||(PLAY/PAUSE)
|<TITLE PRESET
Description
DISC2
Page
DISC CHANGE
DISC1
TITLE>|PRESET
DISPLAY
PROGRAM/TIMER
DBB
VAC
OTPIMAL
MIC VOL
ROCK
MIC2 JACK
LINE IN
USB JACK
JAZZ
USB RECORD
ECHO VOL
TECHNO
NAME : A411 1 SH 190 - 1
Issued DateVer
1
FWT6600/ All Version
2
3
Remark :
Class No
23-Sep-11
POWER ON/OF
<<ALBUM--SEARCH.TUNING
35
31
32
33
27
28
DISC
IS
MODE34
STOP
USB JACK
38
36
37
29
30
1 used into
Units in Dealercarton
Remarks :
GENERAL PART 1 - FRONT PANNEL SPECICFICATION
LIGHT
USB DEL
Diemensions with Boxes ( wxhxd ) 265mm X 382mm X 345mm
USB
Weight ( exclusive packing & batery )26KG
Finshing : Chrome Plate
VFD DISPLAY
Material : HIPS / ABS / POM / V2 / SAN
39
CABINET
Diemensions without Boxes ( wxhxd ) 1250mm X 340mm X 495
Weight ( inclusive packing )8.505KG
VOL
Units in Masstercarton
ALBUM>>SERCH.TUNING
KT CHECK: DATE :

1-5
1 F.M. Anntena
2
27
25
26
23
24
22
17
18
19
20
21
14
15
16
11
12
13
7FAN
LOW /HIGH Left / Right Speaker Socket8
9
10
DEPICTION Pos Description Page
5ACINTPUT
4
A.M. Antenna
6 SubWoofer Socket
3 Aux Input
A.C. Voltage Selector
Ver
1
2
Class No
GENERAL PART 1 - BACK PANNEL SPECICFICATION
Issued Date
FWT6600/ All Version
23-Sep-11
Weight ( exclusive packing & batery )26Kg Units in Dealercarton
Diemensions without Boxes ( wxhxd ) 1250mm X 340mm X 495mm Finshing : Chrome Plate
Weight ( inclusive packing )8.5Kg Units in Masstercarton
27
28
Diemensions with Boxes ( wxhxd )265mm X 382 mm X 345 mm Material :HIPS
CABINET
3
2
DATE :KT CHECK:
SH 190 - 2 A4NAME : 11

1-6
DATE :
NAME : ZC.ZENG
KT CHECK
11 SH 190 - 3 A4
3
3
POWER Consumption of FWT6600
CLIMATIC requirements
ALL climates : + 5 Dregree till + 35 Degree
/ 61, /93
No
60Hz, 50Hz
No
60Hz ±5%
No
MODERATE climates : + N.A till N.A Degree
REMARKS APPROBATION
Tested according to General Test Instruction refer to PHILIPS standary ( UAN -D1591 )
Measured according to PHILIPS standary ( UAN - L1059 ) unless other wise stated
All not mentioned date, please refer to PHILIPS standary ( XUW - 0010 - JUNE 2001 )
DERIVED
1
2
Remarks
Issued Date
<= 0.5W
Quality : 0.8 % ( Major ) 2.0 % ( Mirror )
Reliability : 3.0 % ( C 42 )
ECO Power mode :(without display,mafter 15
minute of auto ) <= 0.5W Ref. to CRS Ref. to CRS
/61 /93
GENERAL PART 1 - GENERAL SPECICFICATION
23-Sep-11
Class No
FWT6600 All Version
Ver
/ 37
120W/150W @ 0.2A
@ 1/8 Prated , NOM. A, INPUT 120W 120W 120W 120W
Maximum : 120W/150W @ 0.1A 120W/150W @ 0.1A 120W/150W @ 0.1A
< 1W
( DEMO mode " OFF " ) , NOM. A, INPUT 15w 15w
Standby mode with clock display(after 15 minute) < 1W Ref. to CRS Ref. to CRS
Frequency 60/50Hz 50Hz
/ 12/ 05 / 55/77/78/98
50Hz
XX
EN 60065
Page
III
EN 60065 CISPR 13
/55
9
EN 55013 / EN 55020
SAFETY requirements
811
GENERAL DESCRIPTION
MP3-USB Mini Hi FiSystem with Digital Tuner, 3CD/MP3
(2x235W+1x300W) For FWT6600 Power Amplifier,VFD Display,Aux in ,Remote control
Subwoofer Boxes of 8 Ohm x 1
XXI
Class Tuner Supply + Amplifier
N/A
XX
Clockipod CD-mp3Recorder
LIFETIME : 7 Years
No
USB
EN 60065
Yes
/ 12 /05
127 / 240 Vac
± 15 %
Voltage Selection
FCC99
/98
/05
Version
PERFORMANCE CLASSES
POWER SUPPLY
MAINS ( A.C. ) 120 Vac (110V-10%,
120V ±10%)
/ 55 /98 / 79
240 Vac
± 10 %
Version Safety EMC
/12 EN 60065 EN 55013 / EN 55020
CISPR 13
EN 60065 CISPR 13
/79
/ 37
230 Vac
± 10 %
220 Vac
f10 %
RADIATION / IMMUNITY requirments ( EMC ) for 12 version only
/37 UL 60065
II
10 3-6 5

:
:
:
:
:
:
1-7
ELECTRICAL DATA (Main computer )
dB
CD 0 dB track ( Audio Disc 1, Trk 35 ) Subwoofer Out yes
DSC : Techno, Pop, Jazz, Optimal˄n/a Rock˅Channel Differencer at -40dB 3
Standby Mode Indicator : VFD display Clock active
Hum ( Volume control from min. till max. – 20 dB) < 200MAX YES
TECHNIAL DESCRIPTION
Total power 800W, matching LOUDSPEAKER of 2 x 3R+1 x 8R only 800W. INPUT SOURCE, CD/MPǃTUNERǃUSB ǃAUXǃPC(LINE) INPUTǃ
3DSC ( Digital Sound Control ). IS ( Incredible Sound )
GENERAL PART
INDICATORS
ECO Mode Indiicator : VTD turns off, ECO - Standby LED turn on
nW
Residual Noise ( Volume Minium ) < 60
OUTPUT stage Protection : Yes Temperature : Yes Shorcircuit : Yes
LoudSpeaker D.C. Protection : Yes.
Tuner FM 67.5KHZ AM80% Modulation -6dB Line Out ( Left / Right ) N.A
dB
INTERCONNECTS
Input Sensitity(±2 dB)rated ouput power at 1 kHz and 10kHz. Line Output Voltage ( *1 )
nW
VAC : N/A Channel Separation ( at 1 kHz ) ı5dB
IS : YES
WOOX : N/A Signal / Noise ( unweighted ) ı55
µWSubwoofer Out Hum( Volume minmun) <4
Digital Coaxial Out N.A
USB 0 dB track ( Audio Disc 1, Trk 35 ) Headphone N/A
SD 0 dB track
OUTPUT POWER ( * 1 ) At THD = 10% (Measured with 20Hz-20KHz filter), both channels driven ( Low channel at 1KHz, High channel at 10k Subwoofer channel at 63HZ)
Power output ( RMS ) NA
Rated Impedance
FL/FR channel : 3 Ohms at 30Hz to 10 KHz
Power output ( RMS )
NA
Subwoofer channel 300W per channel( Lim '-1dB )
( *1 ) Electrical parameters are to be measuremend at specker terminals across 3 Ohm load ( pure resistor )
10% Power output ( RMS )
loading 3 ohm of FL/FR channel˄1khz)
loading 8 ohm of SUB channel (63Hz)
AMP power test for One channel load
FL/FR channel 250W per channel ( Lim '-1dB )
A4
(*2)
GENERAL PART 1 - TECHNAICAL SPECICFICATION
Issued Date
3
KT
Ver
CHECK
11 4
DATE :
SH 190 - 4NAME : ZC.ZENG
IS off and OSM unless specified otherwise
Measuremend output power only for AUX model and CD model of used audio analyzer equipment.
One channel signal input ( L or R ), two channel load ( < Low ch. L + High ch. L > or < Low ch. R + High ch. R > )
LOUDSPEAKER ( BOXES ) Please to package document of Speaker Box Assy
Subwoofer : 8 Ohm at 40HZ to 125HZ
Remarks
with rated input signal in AUX mode; DSC setting in Jazz mode with DBB OFF
N.A
AUX/ PC
0 dB track
Nor: 2V Lim: 1.5V ~ 2.5V for /55 Booster Out
support
DCK3060
Dock
Nor: 600mV Lim: 350mV ~ 900mV for /37
2
23-Sep-11
Class No
FWT6600/ All Version 1

TECHNIAL DESCRIPTION
Bluetooth Function
GENERAL PART
1-8
Bluetooth Version : Ver2.1 + EDR
YES
Bluetooth SPECICFICATION
Class No
FWT6600 All Version
Ver
REMARKS
Receive HSP N/A Noise Reduction System : No
Receive A2DP: N/A
Transmit A2DP: N/A Remote Controlled :
Unit
Display : N/A
INDICATORS
Bluetooth Flashing : Yes
Frequency Response 125-16khz f dB
ELECTRICAL DATA
Bluetooth at Module level: Mobile Phone lim
dB
S/N (A-weighted) ı  dBA
S/N (Unweighted) ı 
dB
Channel Separation ı  dB
Level Diff ? f
λ
Bluetooth at Set Level Mobile Phone
Distortion ˘
10%THD OUTPUT POWER(EQ:FLAT) \ 125± 3dB W
meter
Issued Date
110-Jul-10
Connected distance 8~10
2
3
CHECK: DATE :
NAME : TAN DATE : SH 190 - 9

1-9
6.1+4-
Tabel 1b ( Tolerance ± 3dB )
5.4-06-5.2-
12 kHz 0-2 -6
+17
60 Hz
+15
DSC Modes with DBB Off ,MAX OFF
Pop
+12
1+1+5.0-5.0+0zHk1
12 kHz
1.5
SAMBA/OptimalTECHNO/Jungle
Tabel 1b ( Tolerance ± 3dB )
0
Frequency
0
Refence level for DSC'S with DBB on=500mW at the speaker terminal .
Inject sine wave 500mV-2.4V to AUX-IN socket with frequencies indicated in Table 1.
For Subwoofer 60HZ @ 8R
Tabel 1a ( Tolerance ± 3dB )
Frequency lamitpO/ABMASKCORZZAJ
+12+7
+22
JAZZ ROCK
DSC Modes with DBB 2 ON ,MAX OFF
Pop
2 ) DBB ( Dynamic Bass Boot )
15.0-5.0+zHk1
+17
60 Hz
+12
+14
Tabel 1a ( Tolerance ± 3dB )
AUDIO SIGNAL PROCESSING
MP3-USB Mini Hi Fi System with Digital Tuner ,3 CDC-MP3, (2×235W+300W)only FWM663 Universal Class D Power Amplifier
1 ) DSC ( Digital Sound Control )
Select AUX as input source with the following set conditions:
Inject sine wave 500mV-2.5V at 1 KHz to L/R channels of AUX-IN socket(input level 600mV for /37/05/12,2V-2.5V for /55/77/78 ).
Set DSC to JAZZ(Flat) mode and switch off DBB.
Refence level for DSC's without DBB OFF=500mW.
Frequency DSC Modes with DBB 1 ON ,MAX OFF
Pop
+17
JAZZ ROCK TECHNO/Jungle SAMBA/Optimal
TECHNO/Jungle
22+12+22+61+
60 Hz
+10
12 kHz
0
5.1+4+1+zHk21
-3
SAMBA/Optimal
42
-3
6.0+5.0+5.0-
+25+22 +25 +25
JAZZ ROCK TECHNO/Jungle
+0.6
+1.6
Tabel 1b ( Tolerance ± 3dB )
+1
-1
-4
25.11
-5 -4.5
-3 8
Frequency Subwoofer
DBB 3DBB 1 DBB 2
hcRF/LFhcRF/LF
VAC Mode FL/FR ch
DBB OFF
2
3
5.3202-
102-
12 7 17
Subwoofer
S
ubwoofe
r
refoowbuShcRF/LF
16 24
24 17 2791914
5231517013
Cinema
Hall
20
-6
1-5-7-9-
1 KHz
Concert
6-6-7-
19
60 Hz
Concert
Hall 14
12K Hz
4
Cinema
Hall
Cinema -5.5
2
Concert
5.0+5.0-
1kHz
Tabel 2 ( Tolerance ± 3dB ) NO TEST
1kHz
Select AUX as input source with the following set conditions :
Inject sine wave 500mV-2.5V at 1kHz to L/R channels of AUX - IN socket(input level 600mV for /37/05/12,2V-2.5V for /55/77/78 ).
60 Hz
-1
Set VAC to JAZZ(Flat) mode and switch off DBB of Reference level,
Frequency DSC Modes with DBB 3 ON ,MAX OFF
Pop
0+1
1
Issued Date
KT
Ver
2
For Subwoofer 60HZ @ 8R ;FR/FL 1Khz @3R
+25
Reference level for the test is 500mW on the speaker terminals.
CHECK
Class No
FWT6600/ All Version
DATE :
NAME : ZC.ZENG
11 6
GENERAL PART 1 - GENERAL SPECICFICATION
A4
3
SH 190 - 6
23-Sep-11

1-10
DBB 2
DBB 1
Hall DBB 1
Cinema
DBB Level preset DBB Level presetVAC MODE
Concert DBB OFF
3 ) IS ( Incredible Sound )
Select AUX as input source.
Inject sine wave 600mV-2.5V at 1kHz to AUX-IN socket, one channel at a time (input level 600mV for /37/05/12;2V-2.5V for /55/77/78 )
DBB OFF
DBB 1
Set DSC to JAZZ ( Flat ) mode and switch of DBB, OSM & INCREDIBLE SURROUND.
Adjust volume level to obtain 500mW across 3 OHM load at L/R speaker output.
-7.0 dB
-1 dB
- - 1.0 dB -2V60 Hz
Table 3 ( Tolerence ± 4 dB )
AUDIO SIGNAL PROCESSING
MP3-USB Mini Hi Fi System with Digital Tuner , 3 CDC-MP3,(2×235W+300W)only FWT6600, Universal Class D Power Amplifier
FREQ INPUT LEVEL OUTPUT LEVEL
+2.0 dB -15.0 dB
Inject sine wave 2V to AUX-IN socket withfrequency indicated in Table 3 .
LEFT RIGHT LEFT RIGHT
IS OFF IS ON
12 kHz
01 kHz
- 0.5 dB + 3.0 dB
+ 3.5 dB
-
2V -
2V
-
PoP
DBB 3
as show in Table 4.
Note : The above specs also apply to right channel.
4 ) DSC Mode ( Jazz , POPˈRock, Techno and Optimal )
The VAC modes are software controlled by switching the combination between DBB and DSC modes
0
LEFT RIGHT
DSC MODE
Samba/Optimal
Rock
Jazz
Techno
Class No
-
DBB 1

Max ON
Max OFF
+8
1 kHz
GENERAL PART 1 - AUDIO SIGNAL SPECICFICATION ( 2 )
NAME : ZC.ZENG 11 7 SH 190 - 7 A4
Max OFF Max ON
60 Hz -1 +18
12 kHz -1 
KT CHECK DATE :
FR/FL˄at stereo mode) SUB˄at stereo mode)
The 1W level will be used as 0 dB reference
Inject sine wave 2V-2.5V to AUX-IN socket withfrequency indicated in Table 5 .
FREQ
2
FWM/6500/ All Version
Ver Issued Date
3
+27
123-Sep-11
Set DSC to JAZZ ( Flat ) mode and switch of DBB, OSM & INCREDIBLE SURROUND.
Adjust volume level to obtain 500mW across 3 OHM load at L/R speaker output.
Note : When these modes are activ DBB and DSC will not be displayed
5 ) MAX ( Maximum Sound ) ( Tolerence ± 3 dB )
Select AUX as input source.
Inject sine wave 600mV-2.5V at 1kHz to AUX-IN socket, one channel at a time (input level 600mV for /37/05/12;2V-2.5V for /55/77/78 )