Pioneer GM-6100F User manual
PIONEER CORPORATION 4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O.Box 1760, Long Beach, CA 90801-1760 U.S.A.
PIONEER EUROPE NV Haven 1087 Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE.LTD. 253 Alexandra Road, #04-01, Singapore 159936
C PIONEER CORPORATION 2004 K-ZZB. DEC. 2004 Printed in Japan
ORDER NO.
CRT3370
BRIDGEABLE FOUR-CHANNEL POWER AMPLIFIER
GM-6100F/XU/EW
Service
Manual
GM-6100F/XU/EW
For details, refer to "Important check points for good servicing".
GM-6100F/XU/UC
GM-6100F/XU/ES
GM-6100F/XU/CN
GM-6150F/XU/UC
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
2
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
SAFETY INFORMATION
CAUTION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of
California to cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
-Service Precaution
You should conform to the regulations governing the product (safety, radio and noise, and other regulations),
and should keep the safety during servicing by following the safety instructions described in this manual.
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
3
5678
F
E
D
C
B
A
5678
GM-6100F/XU/EW
[Important Check Points for Good Servicing]
In this manual, procedures that must be performed during repairs are marked with the below symbol.
Please be sure to confirm and follow these procedures.
1. Product safety
Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by
following the safety instructions described in this manual.
1Use specified parts for repair.
Use genuine parts. Be sure to use important parts for safety.
2Do not perform modifications without proper instructions.
Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as
radio/TV interference and foreign noise.
3Make sure the soldering of repaired locations is properly performed.
When you solder while repairing, please be sure that there are no cold solder and other debris.
Soldering should be finished with the proper quantity. (Refer to the example)
4Make sure the screws are tightly fastened.
Please be sure that all screws are fastened, and that there are no loose screws.
5Make sure each connectors are correctly inserted.
Please be sure that all connectors are inserted, and that there are no imperfect insertion.
6Make sure the wiring cables are set to their original state.
Please replace the wiring and cables to the original state after repairs.
In addition, be sure that there are no pinched wires, etc.
7Make sure screws and soldering scraps do not remain inside the product.
Please check that neither solder debris nor screws remain inside the product.
8There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord.
Damaged power cords may lead to fire accidents, so please be sure that there are no damages.
If you find a damaged power cord, please exchange it with a suitable one.
9There should be no spark traces or similar marks on the power plug.
When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure
connections and suitable usage. Please exchange the power cord if necessary.
0Safe environment should be secured during servicing.
When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries.
Please pay attention to your surroundings and repair safely.
2. Adjustments
To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification.
Adjustments should be performed in accordance with the procedures/instructions described in this manual.
4. Cleaning
For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper
cleaning should be performed to restore their performances.
3. Lubricants, Glues, and Replacement parts
Use grease and adhesives that are equal to the specified substance.
Make sure the proper amount is applied.
5. Shipping mode and Shipping screws
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be
installed before shipment. Please be sure to follow this method especially if it is specified in this manual.
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
4
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
CONTENTS
SAFETY INFORMATION............................................2
1. SPECIFICATIONS.......................................................5
2. EXPLODED VIEWS AND PARTS LIST ......................6
2.1 PACKING..............................................................6
2.2 EXTERIOR............................................................8
3. SCHEMATIC DIAGRAM...........................................10
3.1 SCHEMATIC DIAGRAM(GUIDE PAGE) ............10
4. PCB CONNECTION DIAGRAM................................16
4.1 AMP UNIT..........................................................16
5. ELECTRICAL PARTS LIST........................................20
6. ADJUSTMENT.........................................................24
7. GENERAL INFORMATION.......................................25
7.1 DIAGNOSIS .......................................................25
7.1.1 DISASSEMBLY.........................................25
7.1.2 CONNECTOR FUNCTION DESCRIPTION ......27
8. OPERATIONS...........................................................28
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
5
5678
F
E
D
C
B
A
5678
GM-6100F/XU/EW
1. SPECIFICATIONS
Power source .......................................................................................................... 14.4 V DC (10.8 — 15.1 V allowable)
Grounding system .......................................................................................................................................... Negative type
Current consumption .................................................................................................... 35.0 A (at continuous power, 4 Ω)
Backup current.................................................................................................................................................. 3 mA or less
Average current drawn* ........................................................................................................ 9.0 A (4 Ωfor four channels)
15.0 A (4 Ωfor two channels)
Fuse ........................................................................................................................................................................ 25 A ×2
Dimensions ...................................................................................................................... 300 (W) ×60 (H) ×327 (D) mm
Weight .................................................................................................................... 4.7 kg (Leads for wiring not included)
Maximum power output .............................................................................................. 120 W ×4 (4 Ω) / 300 W ×2 (4 Ω)
Continuous power output ............................................................ 60 W ×4 (at 14.4 V, 4 Ω, 20 Hz — 20 kHz 0.2% THD)
150 W ×2 (at 14.4 V, 4 Ω, 20 Hz — 20 kHz 0.8% THD)
75 W ×4 (at 14.4 V, 2 Ω, 20 Hz — 20 kHz 0.8% THD)
Continuous power output (DIN power) .............................. 80 W ×4 (4 Ω) / 230 W ×2 (4 Ω) (DIN45324, +B=14.4 V)
Load impedance .......................................................................................................................... 4 Ω(2 — 8 Ωallowable)
(Bridge connection: 4 — 8 Ωallowable)
Frequency response ........................................................................................................ 10 Hz — 50 kHz (+0 dB, –1 dB)
Signal-to-noise ratio ...................................................................................................................... 95 dB (IEC-A network)
Distortion ............................................................................................................................................ 0.01% (10 W, 1 kHz)
Separation ...................................................................................................................................................... 70 dB (1 kHz)
Low pass filter .................................................................................................................. Cut off frequency: 40 — 120 Hz
Cut off slope: –12 dB/oct
High pass filter ................................................................................................................ Cut off frequency: 40 — 120 Hz
Cut off slope: –12 dB/oct
Gain control .................................................................................................................................. RCA: 200 mV — 6.5 V
Speaker: 0.8 — 26 V
Maximum input level / impedance ...................................................................................................... RCA: 6.5 V / 22 kΩ
Speaker: 26 V / 40 kΩ
Note:
• Specifications and the design are subject to possible modification without notice due to improvements.
*Average current drawn
• The average current drawn is nearly the maximum current drawn by this unit when an audio signal is input. Use this value when
working out total current drawn by multiple power amplifiers.
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
Part No.
Mark No. Description GM-6100F/XU/EW GM-6100F/XU/UC GM-6100F/XU/ES GM-6100F/XU/CN
1 Screw Assy CEA4835 CEA4835 CEA4835 CEA4835
2 Screw BYC40P180FZK BYC40P180FZK BYC40P180FZK BYC40P180FZK
* 3 Polyethylene Sheet CNM4338 CNM4338 CNM4338 CNM4338
4 Cord Assy CDE7737 CDE7737 CDE7737 CDE7737
5 Protector CHP2911 CHP2911 CHP2911 CHP2911
6 Polyethylene Bag CEG1317 CEG1351 CEG1317 CEG1317
7 Carton CHG5371 CHG5373 CHG5372 CHG5468
8 Contain Box CHL5371 CHL5373 CHL5372 CHL5468
9-1 Polyethylene Bag CEG1116 CEG1116 CEG1116 CEG1116
9-2 Owner’s Manual CRD3929 CRD3931 CRD3932 CRB2044
* 9-3 Warranty Card CRY1157 Not used Not used ARY7046
* 9-4 Card Not used ARY1048 Not used Not used
9-5 Owner’s Manual Not used Not used CRD3933 Not used
7
5678
F
E
D
C
B
A
5678
GM-6100F/XU/EW
-PACKING SECTION PARTS LIST
NOTE:
-Parts marked by “*” are generally unavailable because they are not in our Master Spare Parts List.
-The >mark found on some component parts indicates the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
-Screws adjacent to ∇mark on the product are used for disassembly.
-For the applying amount of lubricants or glue, follow the instructions in this manual.
( In the case of no amount instructions, apply as you think it appropriate.)
-Owner's Manual
Part No. Language
CRD3929 English, Spanish, German, French, Italian, Dutch
CRD3930 English, French, Spanish
CRD3931 English, French, Spanish
CRD3932 English, Spanish
CRD3933 Arabic, Portuguese(B)
CRB2044 Traditional Chinese
Part No.
Mark No. Description GM-6150F/XU/UC
1 Screw Assy CEA4835
2 Screw BYC40P180FZK
* 3 Polyethylene Sheet CNM4338
4 Cord Assy CDE7737
5 Protector CHP2911
6 Polyethylene Bag CEG1351
7 Carton CHG5374
8 Contain Box CHL5374
9-1 Polyethylene Bag CEG1116
9-2 Owner’s Manual CRD3930
* 9-3 Warranty Card CRY1070
* 9-4 Card Not used
9-5 Owner’s Manual Not used
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
7
32
11
7
12
2
2
2
5
2
2
2
2
2
89
1
1
1
5
55
5
1
1
1
34 34
5
2
3
3
13 27
29 28
29
20
23
38
38
23
26
24
28 15 1515
15
14
28
28 22 36
31 18
19
35
25
15
29
29
28
28
14
15
15
15
15
35
22
21
30 16
17
4
3
3
3
4
44
3
10
12
12
33
33
6
A
37
8
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
2.2 EXTERIOR
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
9
5678
F
E
D
C
B
A
5678
GM-6100F/XU/EW
1 Screw BBZ30P060FTC
2 Screw BBZ30P080FZK
3 Screw BBZ30P100FZK
4 Screw BBZ30P120FTC
5 Screw BSZ30P050FZK
* 6 Badge See Contrast table(2)
7 Screw CBA1810
8 Panel See Contrast table(2)
9 Case CNB3074
10 Panel See Contrast table(2)
11 Heat Sink See Contrast table(2)
12 Spacer CNV8256
13 Amp Unit See Contrast table(2)
14 Screw BBZ30P060FZK
15 Screw BBZ30P080FZK
16 Pin Jack(CN851) See Contrast table(2)
17 Pin Jack(CN852) See Contrast table(2)
18 Terminal(CN601) See Contrast table(2)
19 Terminal(CN301) See Contrast table(2)
20 Connector(CN853) CKM1334
21 Holder CND2457
22 Terminal CND2458
23 Holder CND2466
24 Spacer CNM9570
25 Insulator CNM9285
26 Sub Heat Sink CNR1783
27 Sub Heat Sink CNR1782
28 Screw IMS30P050FZK
29 Screw PPZ30P100FSN
30 Screw PPZ30P100FZK
31 Terminal(CN604) VNF1084
32 Lighting Conductor Unit CXC4334
33 Screw IBZ30P060FTC
34 Screw PPZ30P100FZK
35 Choke Coil(L902,903) CTH1326
>36 Fuse(F101,102)(25A) CEK1329
37 Sheet CNM9571
38 Holder See Contrast table(2)
Mark No. Description Part No. Mark No. Description Part No.
-EXTERIOR SECTION PARTS LIST
(2) CONTRAST TABLE
GM-6100F/XU/EW, GM-6100F/XU/UC, GM-6100F/XU/ES,GM-6100F/XU/CN and GM-6150F/XU/UC are constructed the
same except for the following:
Part No.
Mark No. Description GM-6100F/XU/EW GM-6100F/XU/UC GM-6100F/XU/ES GM-6100F/XU/CN
* 6 Badge CAH1919 CAH1919 CAH1916 CAH1916
8 Panel CNB3066 CNB3068 CNB3069 CNB3069
10 Panel CNB3129 CNB3070 CNB3128 CNB3128
11 Heat Sink CNR1769 CNR1769 CNR1770 CNR1770
13 Amp Unit CWH1273 CWH1274 CWH1274 CWH1274
16 Pin Jack(CN851) CKB1067 CKB1066 CKB1066 CKB1066
17 Pin Jack(CN852) CKB1069 CKB1068 CKB1068 CKB1068
18 Terminal(CN601) CKE1054 CKE1055 CKE1055 CKE1055
19 Terminal(CN301) CKE1058 CKE1059 CKE1059 CKE1059
38 Holder CND2466 Not used Not used Not used
Part No.
Mark No. Description GM-6150F/XU/UC
* 6 Badge CAH1917
8 Panel CNB3067
10 Panel CNB3115
11 Heat Sink CNR1793
13 Amp Unit CWH1273
16 Pin Jack(CN851) CKB1067
17 Pin Jack(CN852) CKB1069
18 Terminal(CN601) CKE1054
19 Terminal(CN301) CKE1058
38 Holder CND2466
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
A-aA-a A-bA-b
A-aA-a A-bA-b
A-bA-b
A-aA-a
Large size
SCH diagram
Guide page
Detailed page
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or
"ELECTRICAL PARTS LIST". A-a
A
GM-6100F/XU/EW
GM-6150F/XU/UC
GM-6100F/XU/UC
GM-6100F/XU/ES
GM-6100F/XU/CN
A
B
AA
AA
BB
B
B
BB
B
B
AA
AA
B FREQ
B FREQ
A FREQ
A FREQ
0dB
0dB
0dB
+18.5dBs(MAX) +18.3dBs +18.3dBs
10
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
3. SCHEMATIC DIAGRAM
3.1 SCHEMATIC DIAGRAM(GUIDE PAGE)
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
11
5678
F
E
D
C
B
A
5678
GM-6100F/XU/EW
A-b
A-a A-b
A-a A-b
A-b
A-a
A
Decimal points for resistor
and capacitor fixed values
are expressed as :
2.2 2R2
0.022 R022
←
←
The >mark found on some component parts indicates
the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of
identical designation.
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
NOTE :
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
AAMP UNIT
>
>
A GAIN
B GAIN
BFC
-1.7dB ~ -30.5dB AMP +40dB
-12.2dBs
+27.8dBs
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
A-a A-b
A-a
A-a
A-b
GM-6100F/XU/EW
GM-6150F/XU/UC
GM-6100F/XU/UC
GM-6100F/XU/ES
GM-6100F/XU/CN
A
B
AA
BB
BB
B
B
AA
AA
A FREQ
A FREQ
B FREQ
0dB
0dB
0dB
+18.5dBs(MAX) +18.3dBs +18.3dBs
12
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
14
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
A-a A-b
A-b
Decimal points for resistor
and capacitor fixed values
are expressed as :
2.2 2R2
0.022 R022
←
←
The >mark found on some component parts indicates
the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of
identical designation.
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
NOTE :
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
AAMP UNIT
B GAIN
A GAIN
-1.7dB ~ -30.5dB AMP +40dB
-12.2dBs
+27.8dBs
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
4. PCB CONNECTION DIAGRAM
4.1 AMP UNIT
Capacitor
Connector
P.C.Board Chip Part
A
AAMP UNIT
SIDE B
SIDE A
NOTE FOR PCB DIAGRAMS
1.The parts mounted on this PCB
include all necessary parts for
several destination.
For further information for
respective destinations, be sure
to check with the schematic dia-
gram.
2.Viewpoint of PCB diagrams
15
26
37
48
3 2 1 3 2 1 3 2 1 3 2 1 3 2 1 3 2 1
SPEAKER OUTPUT
POWER SUPPLY
16
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
17
5678
F
E
D
C
B
A
5678
GM-6100F/XU/EW
A
SIDE A
2 1
78
56
34
12
4
87
3
12
56
AL
AR
BR BL
RL
6
4
5
3
B GAIN
B FREQ
A GAIN
A FREQ
INPUT SELECT
B LPF/HPF
SPEAKER INPUT
RCA INPUT
RCA OUTPUT
A LPF/HPF
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
Unit Number : CWH1273(EW,6150F/UC)
Unit Number : CWH1274(UC,ES,CN)
Unit Name : Amp Unit
MISCELLANEOUS
IC 121 (B,279,42) IC NJM4558MD
IC 122 (B,280,81) IC NJM4558MD
IC 123 (B,280,164) IC NJM4558MD
IC 124 (B,277,194) IC NJM4558MD
IC 125 (B,283,59) IC NJM4558MD
IC 126 (B,291,90) IC NJM4558MD
IC 127 (B,292,164) IC NJM4558MD
IC 128 (B,283,183) IC NJM4558MD
IC 601 (A,148,92) IC PA2027A
IC 851 (B,298,38) IC NJM2068MD
IC 852 (B,275,108) IC NJM2068MD
IC 853 (B,276,145) IC NJM2068MD
IC 854 (B,298,196) IC NJM2068MD
IC 901 (B,150,60) IC UPC494GS
Q 301 (B,261,76) Transistor 2SA1163
Q 302 (B,223,92) Transistor 2SA1163
Q 303 (B,258,161) Transistor 2SA1163
Q 304 (B,221,148) Transistor 2SA1163
Q 305 (B,256,76) Transistor 2SA1163
Q 306 (B,218,92) Transistor 2SA1163
Q 307 (B,253,161) Transistor 2SA1163
Q 308 (B,215,148) Transistor 2SA1163
Q 309 (B,261,83) Transistor 2SC2713
Q 310 (B,223,100) Transistor 2SC2713
Q 311 (B,258,153) Transistor 2SC2713
Q 312 (B,221,140) Transistor 2SC2713
Q 313 (B,256,83) Transistor 2SC2713
Q 314 (B,218,100) Transistor 2SC2713
Q 315 (B,253,153) Transistor 2SC2713
Q 316 (B,216,140) Transistor 2SC2713
Q 317 (B,250,83) Transistor 2SC2713
Q 318 (B,210,100) Transistor 2SC2713
Q 319 (B,245,153) Transistor 2SC2713
Q 320 (B,206,140) Transistor 2SC2713
Q 321 (B,260,65) Transistor 2SA1163
Q 322 (B,223,81) Transistor 2SA1163
Q 323 (B,260,171) Transistor 2SA1163
Q 324 (B,222,159) Transistor 2SA1163
Q 325 (B,248,72) Transistor 2SC2713
Q 326 (B,210,89) Transistor 2SC2713
Q 327 (B,245,164) Transistor 2SC2713
Q 328 (B,207,151) Transistor 2SC2713
Q 329 (A,247,37) Transistor 2SD1684
Q 330 (A,198,37) Transistor 2SD1684
Q 331 (A,242,203) Transistor 2SD1684
Q 332 (A,193,203) Transistor 2SD1684
Q 333 (A,264,40) Transistor 2SD2439
Q 334 (A,187,40) Transistor 2SD2439
Q 335 (A,253,200) Transistor 2SD2439
Q 336 (A,176,200) Transistor 2SD2439
Q 337 (A,236,40) Transistor 2SB1588
Q 338 (A,215,40) Transistor 2SB1588
Q 339 (A,225,200) Transistor 2SB1588
Q 340 (A,204,200) Transistor 2SB1588
Q 601 (B,132,101) Transistor 2SC4081
Q 602 (B,137,98) Transistor 2SA1576A
Q 603 (A,121,89) Transistor 2SB1243
Q 604 (B,131,88) Transistor DTA124EU
Q 605 (B,265,90) Transistor 2SC4081
Q 606 (B,231,95) Transistor 2SC4081
Q 607 (B,264,157) Transistor 2SC4081
Q 608 (B,230,146) Transistor 2SC4081
Q 651 (B,238,72) Transistor 2SC2713
Q 652 (B,200,89) Transistor 2SC2713
Q 653 (B,237,164) Transistor 2SC2713
Q 654 (B,200,151) Transistor 2SC2713
Q 655 (B,148,183) Transistor 2SA1576A
Q 656 (B,150,190) Transistor 2SC4081
Q 657 (B,152,183) Transistor 2SC4081
Q 658 (B,156,185) Transistor 2SC4081
Q 659 (B,154,194) Transistor 2SA1576A
Q 701 (B,142,89) Transistor DTA114EU
Q 702 (B,136,88) Transistor DTC114TU
Q 703 (B,150,89) Transistor 2SC4081
Q 704 (B,152,81) Transistor DTC114TU
Q 901 (B,139,72) Transistor 2SA1576A
Q 902 (B,125,64) Transistor 2SD1766
Q 903 (B,133,57) Transistor 2SB1188
Q 904 (B,125,57) Transistor 2SB1188
Q 905 (B,133,64) Transistor 2SD1766
Q 906 (A,61,37) Transistor FKV550N
Q 907 (A,106,37) Transistor FKV550N
Q 908 (A,76,37) Transistor FKV550N
Q 909 (A,121,37) Transistor FKV550N
Q 910 (A,91,37) Transistor FKV550N
Q 911 (A,136,37) Transistor FKV550N
Q 912 (A,129,204) Transistor 2SD2395
Q 913 (A,109,204) Transistor 2SB1566
D 301 (B,246,76) Diode MA111
D 302 (B,207,93) Diode MA111
D 303 (B,244,160) Diode MA111
D 304 (B,206,147) Diode MA111
D 305 (B,246,79) Diode MA111
D 306 (B,207,95) Diode MA111
D 307 (B,244,157) Diode MA111
=====Circuit Symbol and No.===Part Name Part No.
--- ------ ------------------------------------------ ------------------------- =====Circuit Symbol and No.===Part Name Part No.
--- ------ ------------------------------------------ -------------------------
A
20
1234
1234
F
E
D
C
B
A
GM-6100F/XU/EW
NOTE:
Parts whose parts numbers are omitted are subject to being not supplied.
The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
The >mark found on some component parts indicatesthe importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of identical designation.
Meaning of the figures and others in the parentheses in the parts list.
Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding
PC board.
IC 301 (A, 91, 111) IC NJM2068V
5. ELECTRICAL PARTS LIST
w
w
w
.
x
i
a
o
y
u
1
6
3
.
c
o
m
Q
Q
3
7
6
3
1
5
1
5
0
9
9
2
8
9
4
2
9
8
T
E
L
1
3
9
4
2
2
9
6
5
1
3
9
9
2
8
9
4
2
9
8
0
5
1
5
1
3
6
7
3
Q
Q
TEL 13942296513 QQ 376315150 892498299
TEL 13942296513 QQ 376315150 892498299
http://www.xiaoyu163.com
http://www.xiaoyu163.com
Other manuals for GM-6100F
2
This manual suits for next models
1
Table of contents
Other Pioneer Car Amplifier manuals
Pioneer
Pioneer Audio System Power Amplifier User manual
Pioneer
Pioneer GM-X364 User manual
Pioneer
Pioneer GM-D9500F User manual
Pioneer
Pioneer GM-A6604 User manual
Pioneer
Pioneer GM-D500M User manual
Pioneer
Pioneer GM-40 User manual
Pioneer
Pioneer GM-520T User manual
Pioneer
Pioneer GM-X564 User manual
Pioneer
Pioneer LEXUS RX330 User manual
Pioneer
Pioneer GM-5200T User manual
Pioneer
Pioneer GM-43A User manual
Pioneer
Pioneer PRS-D4000F - Premier Amplifier User manual
Pioneer
Pioneer GM-5300T User manual
Pioneer
Pioneer GM-A4604 User manual
Pioneer
Pioneer Premier PRS-D4100F User manual
Pioneer
Pioneer GM5100T - 760 Watts Power Amplifier User manual
Pioneer
Pioneer GM-DX871/XEVUC User manual
Pioneer
Pioneer GM-X944 User manual
Pioneer
Pioneer Lexus RX300 User manual
Pioneer
Pioneer GM-3500T User manual
Popular Car Amplifier manuals by other brands
Orion
Orion 12000 owner's manual
Rockford Fosgate
Rockford Fosgate Power 1001bd Installation and operation
Kenwood
Kenwood KAC-5203 instruction manual
Pyle
Pyle PLMRA1000D user manual
Linear Power
Linear Power 2202 Owner's operation manual and installation guide
Rockford Fosgate
Rockford Fosgate Power Elite T15002 Installation and operation