Pioneer PDP 433CMX User manual

ORDER NO.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2003
ARP3156
T – ZZR MAR. 2003 Printed in Japan
PDP-433CMX
PLASMA DISPLAY
PDP-433MXE
PDP-433CMX
For details, refer to "Important symbols for good services".
Type Model Power Requirement Remarks
PDP-433CMX PDP-433MXE
LUCBW ?−AC100 - 120V
YVLDK −?AC100 - 240V
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Model No.
Part numbers and serial numbers of the main parts applicable to this service manual
SW POWER
SUPPLY
MODULE
(AXY1059)
Rear Case
(ANE1608) RGB ASSY (AWZ6744)
DIGITAL VIDEO
ASSY
(AWV1971)
X DRIVE ASSY
(AWV1985) Y DRIVE ASSY (AWZ6748)
PDP-433CMX/LUCBW 002201 –005131 –004721 –005011 –006121 –006811 –
PDP-433MXE/YVLDK 002201 –005131 –004721 –005011 –006121 –006811 –
The main parts having their serial numbers described in the table below are applicable to this service
manual. For details on replacing with the following parts, refer to Service Information for each part.

2PDP-433CMX
[ Important symbols for good services ]
In this manual, the symbols shown-below indicate that adjustments, settings or cleaning should be made securely.
When you find the procedures bearing any of the symbols, be sure to fulfill them:
2. Adjustments
To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable.
In accordance with the procedures or instructions described in this manual, adjustments should be performed.
3. Cleaning
For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning,
proper cleaning should be performed to restore their performances.
5. Lubricants, glues, and replacement parts
Appropriately applying grease or glue can maintain the product performances. But improper lubrication or applying
glue may lead to failures or troubles in the product. By following the instructions in this manual, be sure to apply the
prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed
ones should be used.
4. Shipping mode and shipping screws
To protect the product from damages or failures that may be caused during transit, the shipping mode should be set or
the shipping screws should be installed before shipping out in accordance with this manual, if necessary.
1. Product safety
You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and
should keep the safety during servicing by following the safety instructions described in this manual.

3
PDP-433CMX
............................
CONTENTS
3. SCHEMATIC DIAGRAM .................................................................................................................................. 4
3.1 OVERALL WIRING DIAGRAM(1/2) ......................................................................................................... 4
3.2 OVERALL WIRING DIAGRAM(2/2) ......................................................................................................... 6
3.3 SCAN (A) ASSY .................................................................................................................................... 26
3.4 SCAN (B) ASSY ...................................................................................................................................
3.5 X CONNECTOR A and B ASSYS .......................................................................................................... 34
30
3.6 BRIDGE A - D ASSYS ........................................................................................................................... 35
3.7 ADR CONNECT A ASSY........................................................................................................................ 36
3.8 ADR CONNECT B ASSY 38
3.9 ADR CONNECT C ASSY ........................................................................................................... .........................40
3.10 ADR CONNECT D ASSY......................................................................................................................................42
3.11 ADR RESONANCE ASSY......................................................................................................................................44
3.12 X DRIVE ASSY (1/3) .................................................................................................. ................................. 46
3.13 X DRIVE ASSY (2/3) ............................................................................................................................48
3.14 X DRIVE ASSY (3/3) ..................................................................................................................... 52
3.15 Y DRIVE ASSY (1/4) ............................................................................................................................
.......54
3.16 Y DRIVE ASSY (2/4) ............................................................................................................................ 56
3.17 Y DRIVE ASSY (3/4) ............................................................................................................................58
3.18 Y DRIVE ASSY (4/4) ............................................................................................................................ 60
3.19 SUB ADDRESS A ASSY...................................................................................................................... 62
3.20 SUB ADDRESS B ASSY .................................................................................................................. 64
3.21 SLOT CONNECTOR ASSY ............................................................................................................... 66
3.22 DIGITAL VIDEO ASSY (1/10) ...............................................................................................................
............................................................................................................... 68
3.23 DIGITAL VIDEO ASSY (2/10) ...
......
70
3.24 DIGITAL VIDEO ASSY (3/10) ............................................................................................................... 72
3.25 DIGITAL VIDEO ASSY (4/10) .................................................................................................................. 74
3.26 DIGITAL VIDEO ASSY (5/10) ......................................................................................................... 78
3.27 DIGITAL VIDEO ASSY (6/10) .............................................................................................................. 82
3.28 DIGITAL VIDEO ASSY (7/10) ..............................................................................................................
..............................................................................................................
..............................................................................................................
84
3.29 DIGITAL VIDEO ASSY (8/10)
............................................................................................................................................
...........................................
..............................................................
............................................................................................................................
...............................................................................................................
........................................................................
........................................................................................................................................
........................................................................................................................................
..........................................................................................................................
.............................................................................................................................................
...........................................................................................................
........................................................................................................................................
........................................................................................................................................
.......................................................................................................................
....................................................................................................................
...................................................................................................
86
3.30 DIGITAL VIDEO ASSY (9/10) 88
3.31 DIGITAL VIDEO ASSY (10/10).........................................................................................................................
...
90
3.32 I / O ASSY (1/2) ............................................................................................................................................................................................ ..92
3.32 I / O ASSY (2/2) .....................................................................................................................................94
3.34 RGB ASSY (1/10) .................................................................................................................................................. 96
3.35 RGB ASSY (2/10)......................................................................................................................................................98
3.36 RGB ASSY (3/10)..........................................................................................................................................................102
3.37 RGB ASSY (4/10)..................................................................................................................................106
3.38 RGB ASSY (5/10)
3.39 RGB ASSY (6/10)
3.41 RGB ASSY (8/10)
3.42 RGB ASSY (9/10)
3.43 RGB ASSY (10/10)
3.45 MX AUDIO ASSY
3.46 SW POWER SUPPLY MODULE(1/2)
3.47 SW POWER SUPPLY MODULE(2/2)
4.1 ADR RESONANCE ASSY
4.2 SCAN A ASSY
4.3 SCAN B ASSY
4.4 X CONNECTOR A and B ASSYS
4.5 BRIDGE A - D ASSYS
4.6 ADR CONNECT A - D ASSYS
4.7 SUB ADDRESS A, B and SLOT CONNECTOR ASSYS
4.8 X DRIVE ASSY
4.9 Y DRIVE ASSY
4.10 DIGITAL VIDEO ASSY
4.11 I / O ASSY
4.12 RGB ASSY
4.13 CONTROL, SP OUT L, SP OUT R, THERMAL SENSOR and IR ASSYS
4.14 SIDE KEY, CONNECTOR, MX LED and MX AUDIO ASSYS
............................
3.44 CONTROL, SP OUT L, MX LED, SIDE KEY, THERMAL SENSOR, KEY CONNECTOR, IR ASSYS
3.40 RGB ASSY (7/10)
...............................................................................................................................................110
4. PCB CONNECTION DIAGRAM
.................................................................................................................................
.................................................................................................................................
.................................................................................................................................
.................................................................................................................................
.................................................................................................................................
.................................................................................................................................
114
116
120
122
124
128
130
................................................................................................... 132
133
133
135
136
137
138
139
140
144
146
152
156
158
150
134
126
........................................................................................................................

4
1234
1234
C
D
F
A
B
E
PDP-433CMX
(4)
(4)
(1) (1)
(1)
(1) (1)
(120)
(23)
(4) J117 ADX2783-
J117 ADX2783-
(3)
J213(8)
ADD1195-
(4)
(6)
(3)
J207(55)
A
(10)
(30)
J109 ADX2787-
J201(50)ADD1183-
J119(13)
ADX2768-
J204(30) ADD1207-
J109
ADX2787-
J203(50)
ADD1198-
(1)
(15)
J102(3) ADX2738-
J102(15) ADX2738-
J102(5)
J205(55) ADD1202-
J110(3)
J113
ADX2778-
ADX2741-
ADX2738-
J116 ADX2783-
CONTACT
J206(55) ADD1200- J108(8) ADX2740-J212(55) ADD1201-
J211(55) ADD1199-
J102(3) ADX2738-
J101(12) ADX2771-
ADX2706-
J5203(10)
ADX2781-
(15)
CONTACT
J5204(10)
J104 ADX2786-
J109 ADX2787-
(23)
J116 ADX2783-
(4)
J202(50)ADD1183-
J107(12)ADX2702-
FAN
ADR CONNECT A
AWZ6678
AA1
AA BRIDGE A BGA3
BGA1
AWZ6728 AB2 ADR CONNECT B
AB1 AB3
AWZ6679 AC2
SCAN A
AWZ6724
SA2
SA1
THERMAL SENSOR
AWZ6696 TE1
SAA2 SAA3
SUB ADDRESS A
AWZ6692
SAA1
ADR RESONANCE
K1 K4 K5
AWZ6751
Y1
Y4
Y2
Y3
Y5
Y6
Y DRIVE
AWZ6748
D8 D9 D16 D10 D11
D1
D7
D2
D3
D4
D15
D14
D17D12 D13
D18
D6 DIGITAL VIDEO
AWV1971
P5 P3
P6
P2 P1
SW POWER SUPPLY
AXY1059
R2
R3
R4
R8
R1
R9 R6 R7
RGB
AWZ6744
SB1
SB2
SCAN B
AWZ6725
SIDE KEY
AWZ6637
SW1
KL1
KL2
KEY CONNECTOR
AWZ6695
RE1
IR
AWZ6643
C3 C1
CONTROL
AWZ6633
S
PR1
SP OUT R
AWZ6706
AWZ6681 AD2
AD1
AC3
AC1
AWZ6680
AC2
AWZ6730
SAB2 SAB1 SAB3
SUB ADDRESS B
AWZ6693
T1 T3 T4 T2 T5
T6
I/O
AWZ6631
K1
K5 K4
AWZ6751
AWZ6679
AB3
BGA2
K2
ADR CONNECT D ADR CONNECT C ADR CONNEC
BRIDGE C
BGC1
BGC3 BGC2
ADR RESONANCE
K2
ANG2469
HOT PLATE
ANG2469
VM1
(15)
CONTACT
HOT PLATE
3.1 OVERALL WIRING DIAGRAM (1/2)
3. SCHEMATIC DIAGRAM

5
5678
5678
C
D
F
A
B
E
PDP-433CMX
(4)
(1) (1)
(3)
J114(1)
ADX2709-
J111 ADX2788-
(5)
(1)(1)
(120)
X
2783-
J115(3) ADX2780-
J207(55) ADD1208-
(10)
J118 ADX2763-
(30)
)
ADD1207-
(5)
(1)
(1)
J106(2) ADX2693-
(6)
J111 ADX2788-
(6)
J105(2) ADX2692-
J118 ADX2763-
J208(55) ADD1205-
J116 ADX2783-
J103(13) ADX2779-
6
ADX2783-
ADX2781-
ADD1204-
(15)
J210(55)
(120)
(10)
(8)
J118
J115(3)
J118 ADX2763-
J109 ADX2787-
ADX2763-
ADX2780-
J104 ADX2786-
J112(13 ADX2784-
(4)
(4)
J117 ADX2783-
J104 ADX2786-
J209(55)ADD1206-
J118 ADX2763-
Wire rod connection
(One side middle connection
connector)
Wire rod connection
(Both ends housing)
Bridge Connector
Boad to Boad
FFC connection
Wire rod connection
(One side board inn connection)
FAN
BRIDGE B
AWZ6729
AC2
AC3
AC1
ADR CONNECT C
AWZ6680 ADR CONNECT D
AD1
AD2
AWZ6681
R RESONANCE K5
AWZ6751
P4
P7
P6
O
WER SUPPLY
Y
1059
R8
R1
R
7
4
4
S2
S1 S3
SLOT CONNECTOR
AWZ6634
V1
VIDEO SLOT
AWV1906-
A5 A6 A7
A1 A3
MX AUDIO
AWZ6644
X1
X2
X3
X4
X DRIVE
AWV1930
X
CONNECTOR
A
EA1
AWZ6726
EB1
X
CONNECTOR
B
AWZ6727
T
4T2 T5
T6
K4
A
WZ6751
AWZ6679
AB3 AB1 AA1
AA3 AWZ6678
SPL1 SP OUT L
AWZ6705
L1
MX LED
AWZ6642
BGB1
BGB3BGB2
K2
ADR CONNECT B ADR CONNECT A
RESONANCE
AWZ6731
BRIDGE D
BGD1
BGD3 BGD2
AB2
ANG2469
ANG2469
MAIN SW
MS1
MS2
INLET FILTER
IN1
IN2
K3
K3
VM1
FUSE
CONTACT
CONTACT
HOT PLATE
HOT PLATE
Note: When ordering service parts, be sure to refer to "EXPLODED VIEWS AND PARTS LIST"
or "PCB PARTS LIST".
For "EXPLODED VIEWS AND PARTS LIST" and "PCB PARTS LIST", refer to the service
manual ARP3155 for PDP-433CMX/LUCBW.

6
1234
1234
C
D
F
A
B
E
PDP-433CMX
3.2 OVERALL WIRING DIAGRAM (2/2)
7Connection Specifications of Each PCB
<SW POWER SUPPLY Module Connection Specification>
• SW POWER SUPPLY Module, MAIN SW and INLET Connection Specifications
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.
P1 B12B-PH-K-S 1 +13.5V 1 Connection by
wire rod
Connection by
wire rod
Connection by
wire rod
KM200NA12 RGB I/O T1
(JST) 2 GND 2
ADX2771-
(JST)
(JST)
(CN4003)
3 -9.0V 3
(J101)
4 GND 4
5 +6.5V 5
6 +6.5V 6
7 GND 7
8 GND 8
9 GND_STB 9
10 +5.0V_STB 10
11 GND_D 11
12 +12V 12
P2 B13B-PH-K-S 1 +12V 1 B13B-PH-SM3 DIGITAL VIDEO D1
(JST) 2 +12V 2 ADX2768- (CN1901)
3 GND_D 3 (J119)
4 GND_D 4
5 DIG-ADR PD 5
6 +5.0V_STB 6
7 GND_STB 7
8 SCL 8
9 SDA 9
10 POWER 10
11 NC 11
12 ACOFF 12
13 PD TRIGGER 13
P3 53052-1510 1 +15V 1 KM250MA15 Y DRIVE Y1
2 GND_D 2 ADX2738- (CN2201)
3 +13.5V 3 (J102)
4 -9.0V 4
5 Y DRIVE PD 5
6 Y DCDC PD 6
7 VOFS_ADJ 7
8NC8
9NC9
10 V SUS 10
11 V SUS 11
12 NC 12
13 SUS_GND 13
14 SUS_GND 14
15 NC 15

7
5678
5678
C
D
F
A
B
E
PDP-433CMX
P4 53052-1310 1 +15V 1 KM250MA13 X DRIVE X1
(CN3101)
2 GND_D 2 ADX2779-
3 X DRIVE PD 3 (J103)
4 X DCDC PD 4
5NC5
6NC6
7NC7
8 V SUS 8
9 V SUS 9
10 NC 10
11 SUS_GND 11
12 SUS_GND 12
13 NC 13
P5 B5B-PH-K-S 1 VADR 1 S3B-PH-SM3-TBB SUB ADDRESS A&B SAA2 (CN8801)
SAB2 (CN8901)
Pin arrangement
of SAA2 and SAB2
are common.
(JST) 2 VADR 2 ADX2738- ×2 (JST)
1: VADR
2: N.C
3: ADR.GND
3 NC 3 (J102)
4 ADR_GND 4
5 ADR_GND 5
P6
P7 B2P3-VH 1 L 1 Main SW MS1
K3(D)
K3(U)
(JST) 2 N 2 ADX2692-
VM1 B10B-PH-K-S 1 SW_L 1 B5B-PH-SM3-TBB ADR RES
(JST) 2 D_GND_L 2 (J118) (JST)
3 ADR_GND_L 3 ADX2763-
4 V_MID_L 4
5 V_ADR_L 5
6 NC 1 B5B-PH-SM3-TBB ADR RES
7 NC 2 (J118) (JST)
8 ADR_GND_U 3 ADX2763-
9 V_MID_U 4
10 V_ADR_U 5
SW1
SW2 1 L 1 −
−− −
INLET IN1
3N3 ADX2693-
(J106)
Terminal Panel
IN1
IN2 1 INLET EARTH 1 (ADX2709-)
(J114)
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection
Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection
Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection
Former CN num.
Connection by wire rod
Connection by wire rod
Connection by wire rod
Connection by wire rod
Connect with branch
Connection by wire
rod (J105)
Refer to the RGB I/O Assy connection specification
(Lower side)
(Uppewr side)
Connection by wire rod
Refer to the POWER SUPPLY Assy (above)
Connection by wire rod
Refer to the MAIN SW (above)
<MAIN SW Connection Specification>
<INLET Connection Specification>

8
1234
1234
C
D
F
A
B
E
PDP-433CMX
D2 AKM1201- -TFB 1 GND_D 50 FFC AKM1201- -TFB RGB R2
(CN1003) 2 GND_D 49 ADD1183- (CN5701)
3 NC 48 (J201)
4NC47
5 GND_D 46
6 GND_D 45
7 GA_RGB[9] 44
8 GB_RGB[9] 43
9 GA_RGB[8] 42
10 GB_RGB[8] 41
11 GA_RGB[7] 40
12 GB_RGB[7] 39
13 GA_RGB[6] 38
14 GB_RGB[6] 37
15 GA_RGB[5] 36
16 GB_RGB[5] 35
17 GA_RGB[4] 34
18 GB_RGB[4] 33
19 GA_RGB[3] 32
20 GB_RGB[3] 31
21 GA_RGB[2] 30
22 GB_RGB[2] 29
23 GA_RGB[1] 28
24 GB_RGB[1] 27
25 GA_RGB[0] 26
26 GB_RGB[0] 25
27 GND_D 24
28 GND_D 23
29 BA_RGB[9] 22
30 BB_RGB[9] 21
31 BA_RGB[8] 20
32 BB_RGB[8] 19
33 BA_RGB[7] 18
34 BB_RGB[7] 17
35 BA_RGB[6] 16
36 BB_RGB[6] 15
37 BA_RGB[5] 14
38 BB_RGB[5] 13
39 BA_RGB[4] 12
40 BB_RGB[4] 11
41 BA_RGB[3] 10
42 BB_RGB[3] 9
43 BA_RGB[2] 8
44 BB_RGB[2] 7
45 BA_RGB[1] 6
46 BB_RGB[1] 5
47 BA_RGB[0] 4
48 BB_RGB[0] 3
50 GND_D 1
49 GND_D 2
Refer to the POWER SUPPLY Assy connection specification
•DIGITAL VIDEO Assy Connection Specifications
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

9
5678
5678
C
D
F
A
B
E
PDP-433CMX
D3 AKM1201- -TFB 1 GND_D 50 FFC AKM1201- -TFB RGB R3
(CN1004) 2 GND_D 49 ADD1183- (CN5702)
3−48 (J202)
4 REM 47
5−46
6 RXD0/TXD0 45
7−44
8 TXD0/RXD0 43
9−42
10 −41
11 −40
12 −39
13 MOD_SW 38
14 −37
15 POWER 36
16 −35
17 REQ_MD 34
18 −33
19 PM_ST 32
20 PN_MUTE 31
21 −30
22 GND_D 29
23 VD 28
24 GND_D 27
25 HD 26
26 GND_D 25
27 DE 24
28 GND_D 23
29 VCLK 22
30 GND_D 21
31 RA_RGB[9] 20
32 RB_RGB[9] 19
33 RA_RGB[8] 18
34 RB_RGB[8] 17
35 RA_RGB[7] 16
36 RB_RGB[7] 15
37 RA_RGB[6] 14
38 RB_RGB[6] 13
39 RA_RGB[5] 12
40 RB_RGB[5] 11
41 RA_RGB[4] 10
42 RB_RGB[4] 9
43 RA_RGB[3] 8
44 RB_RGB[3] 7
45 RA_RGB[2] 6
46 RB_RGB[2] 5
47 RA_RGB[1] 4
48 RB_RGB[1] 3
49 RA_RGB[0] 2
50 RB_RGB[0] 1
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

10
1234
1234
C
D
F
A
B
E
PDP-433CMX
D4 B12B-PH-SM3-TBB 1 +3.3V_D 1 Connection by
wire rod KM200NA12 RGB R4
(CN1001) (JST) 2 +3.3V_D 2 ADX2702- (JST) (CN5704)
3 +3.3V_D 3 (J107)
4 GND_D 4
5 GND_D 5
6 GND_D 6
7 +2.5V_D 7
8 +2.5V_D 8
9 GND_D 9
10 GND_D 10
11 NC 11
12 GND_D 12
D6 AKM1201- -TFB 1 GND_D 50 FFC AKM1201- -TFB YDRIVE Y2
(CN1701) 2 YRSV3 49 ADD1198- (CN2001)
3 YRSV2 48 (J203)
4 GND_D 47
5 DEW_DET 46
6 SCAN_SI2 45
7 GND_D 44
8 SCAN_SI1 43
9 SCAN_AB 42
10 GND_D 41
11 SCAN_LE 40
12 SCAN_OC2_6 39
13 GND_D 38
14 SCAN_OC2_5 37
15 SCAN_OC2_4 36
16 GND_D 35
17 SCAN_OC2_3 34
18 SCAN_OC2_2 33
19 GND_D 32
20 SCAN_OC2_1 31
21 SCAN_OC1 30
22 GND_D 29
23 OE 28
24 SCAN_CLR 27
25 GND_D 26
26 SCAN_CLK 25
27 PN_MUTE 24
28 GND_D 23
29 YSOFT-D 22
30 YPR-U2 21
31 GND_D 20
32 YPR-U1 19
33 YOFS 18
34 GND_D 17
35 YCP-MSK 16
36 YSUS-MSK 15
37 GND_D 14
38 YSUS-G 13
39 YSUS-D 12
40 GND_D 11
41 YSUS-U 10
42 YSUS-B 9
43 GND_D 8
44 GND_D 7
45 GND_D 6
46 GND_D 5
47 +5.0V_D 4
48 +5.0V_D 3
49 +5.0V_D 2
50 +5.0V_D 1
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

11
5678
5678
C
D
F
A
B
E
PDP-433CMX
D7 KF050HA30L-TBB 1 GND_D 30 FFC KF050HA30L-TBB X DRIVE X2
(CN1702) 2 XRSV3 29 ADD1207- (CN3001)
3 GND_D 28 (J204)
4 XRSV2 27
5 GND_D 26
6 XRSV1 25
7 GND_D 24
8 PN_MUTE 23
9 GND_D 22
10 XNR-U 21
11 GND_D 20
12 XNR-D2 19
13 GND_D 18
14 XNR-D1 17
15 GND_D 16
16 XCP-MSK 15
17 GND_D 14
18 XSUS-MSK 13
19 GND_D 12
20 XSUS-G 11
21 GND_D 10
22 XSUS-D 9
23 GND_D 8
24 XSUS-U 7
25 GND_D 6
26 XSUS-B 5
27 GND_D 4
28 GND_D 3
29 +5.0V_D 2
30 +5.0V_D 1
D16 B8B-PH-SM3-TBB 1 ADRK PD 1 ADX2740- S8B-PH-SM3-TBB SUB ADR A SAA2
(CN1503) (JST) 2 ADR_D 2 (J108) (JST) (CN8802)
D17 B8B-PH-SM3-TBB 3 ADR_U 3 ADX2787- S8B-PH-SM3-TBB SUB ADR B SAB2
(CN1603) (JST) 4 ADR_B 4 (J109) (JST) (CN8902)
5 GND_D 5
D16,D17 6 +12V 6 Connection by
wire rod
Connection by
wire rod
SAA2,SAB2
Common use Common use7 ADRK EMG 7
8 V MID SW 8
D18 B3B-PH-SM3-TBB 1 +5.0V_D 1 B3B-PH-SM3-TBB SENSOR TE1
(CN1203) (JST) 2 TEMP 2 ADX2741- (JST) (CN8351)
3 GND_D 3 (J110)
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

12
1234
1234
C
D
F
A
B
E
PDP-433CMX
D8 AKM1202- -TFB 1 ADR_PD 55 ADD1202- AKM1202- -TFB ADR CON A AA1 (Upper side)
(CN1501) 2 DATA_B_A1 54 (J205) (Upper side)
(Upper side)
(Upper side)
(Upper side)
(CN6501)
D9 AKM1202- -TFB 3 GND_D 53 ADD1200- AKM1202- -TFB ADR CON B AB1 (Upper side)
(CN1502) 4 DATA_G_A1 52 (J206) (CN6551)
D10 AKM1202- -TFB 5 DATA_R_A1 51 ADD1208- AKM1202- -TFB ADR CON C AC1 (Upper side)
(CN1504) 6 GND_D 50 (J207) (CN6601)
D11 AKM1202- -TFB 7 DATA_B_A2 49 ADD1205- AKM1202- -TFB ADR CON D AD1 (Upper side)
(CN1505) 8 DATA_G_A2 48 (J208) (CN6651)
9 GND_D 47
10 DATA_R_A2 46 All FFC
11 DATA_B_B1 45
D8 - D11 12 GND_D 44 AA1 - AD1
Common use Common use13 DATA_G_B1 43
14 DATA_R_B1 42
15 GND_D 41
16 DATA_B_B2 40
17 DATA_G_B2 39
18 GND_D 38
19 DATA_R_B2 37
20 DATA_B_C1 36
21 GND_D 35
22 DATA_G_C1 34
23 DATA_R_C1 33
24 GND_D 32
25 DATA_B_C2 31
26 DATA_G_C2 30
27 GND_D 29
28 DATA_R_C2 28
29 DATA_B_D1 27
30 GND_D 26
31 DATA_G_D1 25
32 DATA_R_D1 24
33 GND_D 23
34 DATA_B_D2 22
35 DATA_G_D2 21
36 GND_D 20
37 DATA_R_D2 19
38 DATA_B_E1 18
39 GND_D 17
40 DATA_G_E1 16
41 DATA_R_E1 15
42 GND_D 14
43 DATA_B_E2 13
44 DATA_G_E2 12
45 GND_D 11
46 DATA_R_E2 10
47 ADR_HZ 9
48 ADR_HBLK 8
49 +5.0V_D 7
50 +3.3V_D 6
51 GND_D 5
52 ADR_LBLK 4
53 ADR_LE 3
54 GND_D 2
55 ADR_CLK 1
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

13
5678
5678
C
D
F
A
B
E
PDP-433CMX
D12 AKM1202- -TFB 1 ADR_PD 55 ADD1201- AKM1202- -TFB ADR CON D AD1 (Lower side)
(CN1601) 2 DATA_R_A1 54 (J212) (Lower side)
(Lower side)
(Lower side)
(Lower side)
(CN6651)
D13 AKM1202- -TFB 3 GND_D 53 ADD1199- AKM1202- -TFB ADR CON C AC1 (Lower side)
(CN1602) 4 DATA_G_A1 52 (J211) (CN6601)
D14 AKM1202- -TFB 5 DATA_B_A1 51 ADD1204- AKM1202- -TFB ADR CON B AB1 (Lower side)
(CN1604) 6 GND_D 50 (J210) (CN6551)
D15 AKM1202- -TFB 7 DATA_R_A2 49 ADD1206- AKM1202- -TFB ADR CON A AA1 (Lower side)
(CN1605) 8 DATA_G_A2 48 (J209) (CN6501)
9 GND_D 47
10 DATA_B_A2 46 All FFC
11 DATA_R_B1 45
D12 - D15 12 GND_D 44 AA1 - AD1
Common use 13 DATA_G_B1 43 Common use
14 DATA_B_B1 42
15 GND_D 41
16 DATA_R_B2 40
17 DATA_G_B2 39
18 GND_D 38
19 DATA_B_B2 37
20 DATA_R_C1 36
21 GND_D 35
22 DATA_G_C1 34
23 DATA_B_C1 33
24 GND_D 32
25 DATA_R_C2 31
26 DATA_G_C2 30
27 GND_D 29
28 DATA_B_C2 28
29 DATA_R_D1 27
30 GND_D 26
31 DATA_G_D1 25
32 DATA_B_D1 24
33 GND_D 23
34 DATA_R_D2 22
35 DATA_G_D2 21
36 GND_D 20
37 DATA_B_D2 19
38 DATA_R_E1 18
39 GND_D 17
40 DATA_G_E1 16
41 DATA_B_E1 15
42 GND_D 14
43 DATA_R_E2 13
44 DATA_G_E2 12
45 GND_D 11
46 DATA_B_E2 10
47 ADR_HZ 9
48 ADR_HBLK 8
49 +5.0V_D 7
50 +3.3V_D 6
51 GND_D 5
52 ADR_LBLK 4
53 ADR_LE 3
54 GND_D 2
55 ADR_CLK 1
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

14
1234
1234
C
D
F
A
B
E
PDP-433CMX
•RGB Assy Connection Specification
<RGB Assy connection specification>
R1 AKM1203- 1 GND 1 Boad to Boad AKP1219- SLOT I/F S2
(CN5201) (KEL) 2 GND 2 (KEL) (CN8102)
3 SIG1(Y) 3
4 GND 4
5 SIG2(CB) 5
6 GND 6
7 SIG3(CR) 7
8 GND 8
9 HD_PLD 9
10 GND 10
11 VD_PLD 11
12 GND 12
13 NC 13
14 GND 14
15 NC 15
16 GND 16
17 SLOT_ST 17
18 SDIN_SEL 18
19 FUT3 19
20 FUT2 20
21 NC 21
22 NC 22
23 VD_PLKU 23
24 GND 24
25 HD_PLKU 25
26 GND 26
27 VD_PLK 27
28 GND 28
29 HD_PLK 29
30 GND 30
31 GND 31
32 RB_PLK0 32
33 RB_PLK1 33
34 RB_PLK2 34
35 RB_PLK3 35
36 RB_PLK4 36
37 RB_PLK5 37
38 RB_PLK6 38
39 RB_PLK7 39
40 GND 40
41 GND 41
42 GB_PLK0 42
43 GB_PLK1 43
44 GB_PLK2 44
45 GB_PLK3 45
46 GB_PLK4 46
47 GB_PLK5 47
48 GB_PLK6 48
49 GB_PLK7 49
50 GND 50
51 GND 51
52 BB_PLK0 52
53 BB_PLK1 53
54 BB_PLK2 54
55 BB_PLK3 55
56 BB_PLK4 56
57 BB_PLK5 57
58 BB_PLK6 58
59 BB_PLK7 59
60 GND 60
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

15
5678
5678
C
D
F
A
B
E
PDP-433CMX
61 GND 61
62 GND 62
63 SCL 63
64 GND 64
65 SDA 65
66 GND 66
67 GND 67
68 GND 68
69 NC 69
70 GND 70
71 NC 71
72 GND 72
73 +5.0V_STB 73
74 GND 74
75 NC 75
76 NC 76
77 IN4DET 77
78 IN3DET 78
79 SLOT_ST2 79
80 SRIN 80
81 NC 81
82 NC 82
83 GND 83
84 GND 84
85 SCDT3 85
86 GND 86
87 DE_PLK 87
88 GND 88
89 CLK_PLK 89
90 GND 90
91 GND 91
92 BA_PLK7 92
93 BA_PLK6 93
94 BA_PLK5 94
95 BA_PLK4 95
96 BA_PLK3 96
97 BA_PLK2 97
98 BA_PLK1 98
99 BA_PLK0 99
100 GND 100
101 GND 101
102 GA_PLK7 102
103 GA_PLK6 103
104 GA_PLK5 104
105 GA_PLK4 105
106 GA_PLK3 106
107 GA_PLK2 107
108 GA_PLK1 108
109 GA_PLK0 109
110 GND 110
111 GND 111
112 RA_PLK7 112
113 RA_PLK6 113
114 RA_PLK5 114
115 RA_PLK4 115
116 RA_PLK3 116
117 RA_PLK2 117
118 RA_PLK1 118
119 RA_PLK0 119
120 GND 120
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

16
1234
1234
C
D
F
A
B
E
PDP-433CMX
R2
R3
R4
R6 Boad in 1 G 1 Connection by
Boad in wire rod
Connection by
Boad in wire rod
Connection by
wire rod
Connection by wire rod
Connection by wire rod
KM200NA10 RGB I/O T3
(J5203) 2 GND 2 ADX2706- (JST) (CN4004)
3B3
(J5203)
4 GND 4
5R5
6 GND 6
7 HD_RGB 7
8 GND 8
9 RGB_VD 9
10 GND 10
R7 Boad in 1 GND 1 KM200NA10 RGB I/O T4
(J5204) 2 +9.0V_PIC 2
ADX2781-
(JST) (CN4005)
3 GND 3
(J5204)
4 +3.3V_PLD 4
5 GND 5
6 +3.3V_AD 6
7 GND 7
8 +5.0V_AD/RGB 8
9 GND 9
10 NC 10
11 -5.0V_AD/RGB −
R8 B30B-KRWHK
1 (1 of column A)
2 (2 of column A)
3 (3 of column A)
4 (4 of column A)
5 (5 of column A)
6 (6 of column A)
7 (7 of column A)
8 (8 of column A)
9 (9 of column A)
10 (10 of column A)
11 (11 of column A)
12 (12 of column A)
13 (13 of column A)
14 (14 of column A)
15 (15 of column A)
IN1_VD 1 KM200NA15 RGB I/O T5
(CN5202) (JST) GND_STB 2 ADX2788- (JST) (CN4002)
IN1_HD 3 (J111)
GND_STB 4
IN1DET 5
A_MUTE2 6
A_MUTE1 7
EXT_INT 8
FIX_VAR 9
VOL 10
RGB_SEL 11
WP_SW 12
V+5V_STB 13
GND_STB 14
V+12V_PLD 15
NC −
NC −
*LED_G 1 S3B-PH-SM3-TBB MXLED L1
*LED_R 2 ADX2788- (JST) (CN8501)
GND_STB 3 (J111)
NC −
NC −
V+5.0V_AD/RGB 1 B6B-PH-SM3-TBB MXAUDIO A5
FAN 2 ADX2788- (JST) (CN8703)
FAN_NG 3 (J111)
TEMP3 4
AUDIO_NG 5
GND_STB 6
NC −
NC −
Refer to the DIGITAL VIDEO Assy connection specification
Refer to the DIGITAL VIDEO Assy connection specification
Refer to the DIGITAL VIDEO Assy connection specification
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.
16 (1 of column B)
17 (2 of column B)
21 (6 of column B)
22 (7 of column B)
29 (14 of column B)
30 (15 of column B)
18 (3 of column B)
19 (4 of column B)
20 (5 of column B)
23 (8 of column B)
24 (9 of column B)
25 (10 of column B)
26 (11 of column B)
27 (12 of column B)
28 (13 of column B)

17
1234
1234
C
D
F
A
B
E
PDP-433CMX
•I/O Assy Connection Specification
R9 KM200NA8 1 CB_MUTE 1 Connection by
wire rod
Connection by
wire rod
Connection by
wire rod
Connection by
wire rod
B8B-PH-SM3-TBB CONTROL C1
(CN5503) (JST) 2 REM_MP 2 ADX2787- (JST) (CN8006)
3 GND_STB 3 (J109)
4 V+5.0V_STB 4
5 RXD1 5
6 TXD1 6
7 KEYSCAN 7
8NC8
T1
T2 KM200NA13 1 SLOT_L 1 KM200NA13L SLOT I/F S1
(CN4001) (JST) 2 GND 2 ADX2784- (JST) (CN8103)
3 SLOT_R 3 (J112)
4 GND 4
5 +13.5V 5
6 GND 6
7 -9.0V 7
8 GND 8
9 +6.5V 9
10 +6.5V 10
11 GND 11
12 GND 12
13 +12V 13
T3
T4
T5
T6 KM200NA14 1 V+5.0V_STB 1 KM200NA10 MXAUDIO A1
(CN4006) (JST) 2 A_MUTE2 2 ADX2786- (JST) (CN8601)
3 GND 3 (J104)
4 AUDIO_LOUT 4
5 GND 5
6 AUDIO_ROUT 6
7 GND 7
8 GND 8
9 +15V 9
10 +15V 10
11 +15V 1 B7B-PH-SM3 POWER SUPPLY P6
12 +15V 2 ADX2786- (JST)
13 GND 3 (J104)
14 GND 4
−NC 5
−NC 6
−NC 7
Refer to the RGB Assy connection specification
Refer to the RGB Assy connection specification
Refer to the RGB Assy connection specification
Refer to the POWER SUPPLY Assy connection specification
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection Former
Part No. Connection
Former Assy Connection Former CN num.

18
1234
1234
C
D
F
A
B
E
PDP-433CMX
•SLOT I/F and VIDEO SLOT Assys Connection Specification
<SLOT I/F Assy connection specification>
S1
S2
S3 AKM1220- 162 GND 162 Boad to Boad −VIDEO SLOT V1
(CN8101) 161 RA_PLK0 161 (CN7401)
160 RA_PLK1 160
159 RA_PLK2 159
158 RA_PLK3 158
157 RA_PLK4 157
156 RA_PLK5 156
155 RA_PLK6 155
154 RA_PLK7 154
153 GND 153
152 GND 152
149 GA_PLK0 149
148 GA_PLK1 148
147 GA_PLK2 147
146 GA_PLK3 146
145 GA_PLK4 145
144 GA_PLK5 144
143 GA_PLK6 143
142 GA_PLK7 142
141 GND 141
140 GND 140
139 BA_PLK0 139
138 BA_PLK1 138
137 BA_PLK2 137
136 BA_PLK3 136
135 BA_PLK4 135
134 BA_PLK5 134
133 BA_PLK6 133
132 BA_PLK7 132
131 GND 131
130 CLK_PLK 130
129 GND 129
128 DE_PLK 128
127 GND 127
126 SCDT3 126
125 GND 125
124 GND 124
123 GND 123
122 +6.5V 122
121 +6.5V 121
120 SRIN 120
119 FUT1 119
118 IN4DET 118
117 IN5DET 117
116 +13.5V 116
115 +13.5V 115
114 +5V_STB 114
113 GND 113
112 -9.0V 112
111 GND 111
110 +12V 110
109 GND 109
108 GND 108
107 GND 107
Refer to the RGB I/O Assy connection specification
Refer to the RGB Assy connection specification
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.

19
5678
5678
C
D
F
A
B
E
PDP-433CMX
57 BB_PLK3 57
56 BB_PLK2 56
55 BB_PLK1 55
54 BB_PLK0 54
53 GND 53
52 GND 52
49 GB_PLK7 49
48 GB_PLK6 48
47 GB_PLK5 47
46 GB_PLK4 46
45 GB_PLK3 45
44 GB_PLK2 44
43 GB_PLK1 43
42 GB_PLK0 42
41 GND 41
40 GND 40
39 RB_PLK7 39
38 RB_PLK6 38
37 RB_PLK5 37
36 RB_PLK4 36
35 RB_PLK3 35
34 RB_PLK2 34
33 RB_PLK1 33
32 RB_PLK0 32
31 GND 31
30 GND 30
29 HD_PLK 29
28 GND 28
27 VD_PLK 27
26 GND 26
25 HD_PLKU 25
24 GND 24
23 VD_PLKU 23
22 +6.5V 22
21 +6.5V 21
20 FUT2 20
19 FUT3 19
18 SDIN_SEL 18
17 SLOT_ST 17
16 GND 16
15 SLOT_R 15
14 GND 14
13 SLOT_L 13
12 GND 12
11 VD_PLD 11
106 SDA 106
105 GND 105
104 SCL 104
103 GND 103
102 GND 102
101 GND 101
62 GND 62
61 BB_PLK7 61
60 BB_PLK6 60
59 BB_PLK5 59
58 BB_PLK4 58
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.

20
1234
1234
C
D
F
A
B
E
PDP-433CMX
10 GND 10
9HD_PLD 9
8GND 8
7SIG3(CR) 7
6GND 6
5SIG2(CB) 5
4GND 4
3SIG1(Y) 3
2GND 2
1GND 1
<VIDEO SLOT Assy connection specification>
V1 Refer to the SLOT I/F Assy connection specification (above)
Refer to the MX AUDIO Assy connection specification (above)
Refer to the MX AUDIO Assy connection specification (above)
Refer to the RGB I/O Assy connection specification
Refer to the RGB Assy connection specification
•MX AUDIO, SP OUT L and SP OUT R Assys Connection Specifications
<MX AUDIO Assy connection specification>
A1
A3 B8B-PH-SM3-TBB 1 L_OUT 1 Connection by wire rod
Connection by wire rod
Connection by wire rod
S6B-PH-SM3-TBB SP OUT L SPL1
(CN8604) (JST) 2 L_GND 2 ADX2787- (JST) (CN8152)
3 +5.0V_STB 3 (J109)
4 TEMPIII 4
5 GND 5
6 N.C 6
7 R_OUT 1 S3B-PH-SM3-TBB SP OUT R SPR1
8 R_GND 2(NC) ADX2787- (JST) (CN8177)
−3 (J109)
A5
A6 B3B-ZR-3.4 1 FAN_D 1 FAN
(CN8704) (JST) 2 FAN_PD 2 ADX2780- −−
3 GND 3 (J115)
A7 B3B-ZR-3.4 1 FAN_D 1 FAN
(CN8701) (JST) 2 FAN_PD 2 −− −
3 GND 3
<SP OUT L Assy connection specification>
SPL1
<SP OUT R Assy connection specification>
SPR1
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.
CN num Part No. Pin Pin Name to Pin Continuation Connection
Former Part No. Connection
Former Assy Connection Former CN num.