Playcore UltraPlay Early Play UP147 User manual

Issued/Revised:
1
800.458.5872 www.ultraplay.com
01-20-12
UP147 - IN-GROUND PACKAGE FOR THE BIG OUTDOORS
(USED ON MODEL #UP146)
Parts List
PART NUMBER
QTYDESCRIPTION
403202
5
SUPPORT PIPE
Items listed below Hardware Complete line are included with Hardware Complete Number
Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store
Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any
Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end
protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.
Promptly cut-off flush, file smooth, and treat to prevent corrosion.
Unless Otherwise Specified, All Units of Measure are Each
INSTALLATION INSTRUCTIONS:
UP147
1. Dig footing holes as shown in Bottom & Elevation Views. Note: Site must be level and clean of debris.
2. Attach Fence Wall, Support Pipe, and Ramp Support using 3/8" x 1" P.B.H.C.S. w/Patch, 3/8" Flat Washer, and 3/8"
Barrel Nut. See detail 049.
2. Attach Rabbit Wall, Support Pipe, and Ramp Support using 3/8" x 1" P.B.H.C.S. w/Patch, 3/8" Flat Washer, and 3/8" Barrel Nut.
See detail 049.
3. Attach Mailbox Panel, Small Fence Wall, and Support Pipe using 3/8" x 2 1/4" P.B.H.C.S. w/Patch, 3/8" Flat Washer, and
3/8" Barrel Nut. See detail 050.
4. Attach Tree Panel, Tree Wall, and Support Pipe using 3/8" x 2 1/4" P.B.H.C.S. w/Patch, 3/8" Flat Washer, and 3/8" Barrel Nut.
See detail 050.
5. Plumb & level the entire assembly and tighten all fasteners.
6. Pour concrete footing with 4” to the top and taper away from posts for water drainage. Allow to cure at least 48 hours before use.
Note: Temporary bracing may be required until concrete cures.
MAINTENANCE PROCEDURE:
Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately
put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and
touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate
depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,
maintenance, and repair records for each public-use playground equipment.

Issued/Revised:
2
800.458.5872 www.ultraplay.com
01-20-12
UP147 - IN-GROUND PACKAGE FOR THE BIG OUTDOORS
(USED ON MODEL #UP146)
THE BIG OUTDOORS
THE BIG OUTDOORS
050
049
SUPPORT PIPE
(403202)
SUPPORT PIPE
(403202)
SUPPORT PIPE
(403202)
SUPPORT PIPE
(403202)
049
TREE
PANEL
TREE
WALL
RABBIT
WALL
FENCE
WALL
SMALL FENCE
WALL
MAILBOX
PANEL

Issued/Revised:
3
800.458.5872 www.ultraplay.com
01-20-12
UP147 - IN-GROUND PACKAGE FOR THE BIG OUTDOORS
(USED ON MODEL #UP146)
35 3/16 in
[89.37 cm]
58 1/8 in
[147.63 cm]
25 3/8 in
[64.45 cm]
32 13/16 in
[83.35 cm]
n10 in
[25.40 cm]
12" DEEP
[30.48 cm]
TYP. CONCRETE REQ'D:
0.100 CUBIC YARDS
0.075 CUBIC METERS
BOTTOM VIEW
ELEVATION VIEW
RESILIENT SURFACE
CONCRETE
FOOTING
BRICK OR EQUIVALENT
18 in
[45.72 cm]
6 in
[15.24 cm]
26 3/4 in
[67.88 cm]
SHOCK ABSORBING PROPERTIES OF
SURFACING MATERIALS VARY. IF YOU
DETERMINE THAT LESS THAN 10" OF SURFACING
IS REQUIRED, MAKE-UP THE DIFFERENCE IN
ELEVATION WITH EARTH BEFORE APPLYING
SURFACING. IF MORE THAN 10" IS REQUIRED. MAKE
UP THE DIFFERENCE BY REDUCING THE DEPTH OF
THE GROUNDHOLE BY NO MORE THAN 2".

Issued/Revised:
4
UP147 - IN-GROUND PACKAGE FOR THE BIG OUTDOORS
(USED ON MODEL #UP146)
2
1
34
2
5
1
CM
0
INCH0
10961114815
712 13
4
365
01-20-12
800.458.5872 www.ultraplay.com
049
3/8" x 1" P.B.H.C.S.
w/PATCH (812050)
3/8" FLAT WASHER
(817410)
RAMP
SUPPORT
WALL
ASS'Y
SUPPORT PIPE
(403202)
3/8" BARREL NUT
(804804)
050
3/8" BARREL NUT
(804804)
SUPPORT PIPE
(403202)
WALL
ASS'Y
PANEL
3/8" FLAT WASHER
(817410)
3/8" x 2 1/4"
P.B.H.C.S. w/PATCH
(812056)