PRO Charging System IS2405 User manual

IS2405
24 Volt / 5 Amp
Fully Automatic
Lithium Charger
1-800-742-2740
www.dualpro.com

Introduction: Industrial Series 24 Volt 5 Amp (IS2405)
The IS2405 is a safe, fully automatic, efficient, multi-
stage full switching charger. It may be used in all parts
of the world with its advanced universal AC input (100
of 240VAC). The dual bi-color LED’s let you know the
condition of the battery and if there are any problems.
Instructions: LED Function:
LED Lights
Condition
Power
Green
AC Connection
Charge
Red
Batteries fast charging
Power
Green
AC Connection
Charge
Green
Ready for use
Power
Red
Error, short circuit, leads reversed,
Charge
Off
battery disconnected or battery
voltage is less than 5VDC
Caution:
If the “charge” LED remains red for more than 24 hours. Unplug
charger from AC power and check the batteries. There may be
a problem with the batteries. Call PCS Technical Support with
questions.
If the Power LED is red, unplug the charger from the
unit and unplug from AC (wall socket). Wait 10 seconds
and try again. If the Power LED remains red, call our
service department. Note that if the battery voltage is
less than 5 volts, the charger will not charge for safety
reasons. Battery replacement may be necessary.

Specifications:
Input:
100-240 VAC, 50/60HZ
Output:
24 Volt DC / 5 AMP
Safety Listings:
UL, CUL, CE, FCC Class B
Characteristics:
Universal AC input: 100-240V, 50-60Hz
Charge Condition: 29.4VDC
Absorption: 29.4VDC
Float Charge: 27.6VDC
•Reverse Polarity Protection
•Over Voltage Protection
•Short Circuit Protection
•Light Weight
•Small Size
Warranty:
The warranty is for a period of 2 years from the date
of purchase and covers manufacturers defects.
The charger will be replaced or repaired at the
manufacturer’s discretion. Proof of purchase is
required.

Safety Instructions:
To reduce risk of fire and electric shock, install in a
temperature and humidity controlled indoor area free
from dust and conductive contaminants. Disconnect
from AC power before cleaning. Make sure battery(s) are
clean and properly connected. Keep away from heat, fire,
and water.
There are no user serviceable parts on this charger. If
there is a problem or the cords have been damaged, it
must be serviced by a qualified service professional.
This device complies with part 15 of FCC Rules. Operation
is subject to the following 2 conditions: (1) This device
may not cause harmful interference, and (2) this device
must accept any interference received, including
interference that may cause undesired operation.
For Technical Support please contact:
Pro Charging Systems, LLC
1551 Heil Quaker Blvd.
Lavergne, TN 37086
Phone: [phone]
Website: www.dualpro.com