Qtx HZ-800 User manual

www.avsl.com 160.498UK Manual
HZ-800
HAZE MACHINE
Order ref: 160.498UK
User Manual
Caution: Please read this manual carefully before operating
Damage caused by misuse is not covered by the warranty
The HZ-800 is a high efficiency 800W haze machine capable of producing 12,000 cu.ft per
minute of haze to rapidly fill venues. The volume and speed of fill can be easily controlled
using the included wired controller with LCD panel or keyfob-style RF wireless remote. For
automated operation, a 2 channel DMX connection is also available. The fluid bottle can be
removed for easy refilling and there is a slot window to indicate the current fluid level.
•800W Haze Vaporiser
•Haze output ~12,000 cu.ft/min
•Wired Controller with button control and LCD display
•433Mhz keyfob-style RF wireless remote
•2-Channel DMX connections
•Removable fluid tank
In the box:
Please check the contents to ensure that the product has been received in good condition.
•HZ-800 Haze Machine
•Wired Controller
•RF Remote Control
•UK Mains Lead
•User Guide
If you find any accessory is missing or the machine has arrived with damage, please contact
your local dealer at once. Do not try to fix this item yourself or you will invalidate the
warranty. Please keep the original packaging and invoice for any possible replacement or
return demands.
Warnings:
1. To prevent risk of fire or electric shock, do not expose electrical parts to rain or
moisture.

www.avsl.com 160.498UK Manual
2. If liquids are spilled on areas other than inside the fluid tank, disconnect the mains,
allow the unit to dry out and have it checked by qualified personnel before further
use.
3. Avoid any impact, dropping or extreme pressure to the housing.
4. No user serviceable parts inside - do not open the case.
5. Allow the unit to acclimatise to room temperature before operating.
6. The HZ-800 has a built-in fluid container and should be operated in an upright
position. Ensure that the unit is positioned on a stable, non-slip surface.
Safety and Cleaning:
1. Check for correct mains voltage and condition of IEC lead before connecting to mains.
2. This unit must be earthed.
3. This unit uses a heating element –be aware that parts of the housing may be hot
during use!
4. Use a soft dry or slightly damp cloth to clean the casing.
5. Do not use strong solvents for cleaning the housing.
6. Clean the haze mechanism periodically by operating with distilled water instead of
haze.
7. It is also recommended to use fog machine cleaning fluid (160.670UK) periodically.
Recommended Fluids:
For the HZ-800 haze machine, we strongly recommend the following fluid which has been
specifically formulated to perform best with any heater-based haze machines.
QTX ref code
Description
Size
160.591UK
High quality professional haze fluid
5 Litre
160.596UK
Eco haze fluid
5 Litre
Rear Panel:

www.avsl.com 160.498UK Manual
Setting Up:
1. Unpack the HZ-800 unit.
2. Unscrew the top cap of the tank and remove to fill with haze fluid.
3. Replace the bottle and screw the cap securely, making sure that the pipe is fed down
to the bottom of the bottle to ensure a consistent flow of fluid.
4. Connect the wired remote controller to the socket on the rear panel.
5. If DMX is to be used for control, connect the DMX signal from the controller to the
DMX IN XLR connector. Any further DMX controlled units may be connected via the
DMX OUT XLR connector.
6. Connect the IEC mains plug and power the unit on.
7. The unit will begin the warming up process and the display panel on the wired remote
will display “Warm up”which normally takes around 3-5 minutes.
8. Once the unit is warm enough for use the display panel will change to “Ready”.
Operation:
Use the control buttons on the panel of the wired controller to operate the unit’s modes and
functions quickly and efficiently as below:
Button
Response
Function
Scrolls between DMX, Pump, Wind, Interval and
Duration modes
Up
Increase function or setting
Down
Decrease function or setting
Timer
Enter timer mode
Start/Stop
Turn pump on/off
Manual
Manually adjusts the fan speed
The LCD panel on the wired controller will display the following outputs:
Function
Display
Warm up state
Warm up or Ready
DMX address code
1-512
Pump settings
Pump
Fan settings
Wind
Time setting
Interval
Continuous smoke time setting
Duration
The small RF remote control supplied can also be used when wireless control of the unit is
needed. Its possible to increase and decrease the values of the pump (button A) and wind
(button B) settings using the remote control. As the receiver for the RF remote is fitted inside
the wired controller this must be connected and switched on for it to function correctly.

www.avsl.com 160.498UK Manual
If the LCD panel display is showing the DMX address, the unit will operate from DMX control
as follows:
0
Off
Channel 1 (start address)
1-255
Pump control 1-100%
Channel 2 (start address +1)
0-255
Fan speed slow to fast
Specifications:
Power supply
220-240Vac, 50/60Hz (IEC)
Fuse rating
5A
Power
800W
Warm up time
3-5 minutes
Remote control frequency
433.92Mhz
Haze output (approx.)
12,000 cu.ft (340m³) per minute
Tank capacity
1.2 litres
Dimensions
485 x 195 x 230 mm
Weight
4.9kg
Troubleshooting:
No power to main unit
Check mains voltage is correct and socket is switched on
or wired controller
Check IEC lead is OK and connected properly
Check mains fuse in IEC connector and fuse in plug top
If fuse blowing repeatedly, refer to qualified service personnel
Power to unit but no
Check fluid level in tank
haze output in manual
If fluid is OK and pump working, the lines may be blocked
or continuous mode
Check that output is not set to zero on the control panel
Check that output is not switched off on the keyfob remote
If blocked, clean with fog machine cleaner & distilled water
Check that if DMX mode is selected, the DMX channel is correct
In DMX mode, check that haze output is not set to zero
This product is classed as Electrical or Electronic equipment and should not be disposed with other household or
commercial waste at the end of its useful life. The goods must be disposed of according to your local council guidelines
Errors and omissions excepted.
Copyright© 2021 AVSL Group Ltd, Unit 2 Bridgewater Park, AVSL (Europe) Ltd, Unit 3D North Point House,
Taylor Road, Trafford Park, Manchester. M41 7JQ. North Point Bus. Park, New Mallow Road, Cork, Ireland.