Radio Shack 23-149A Operating and maintenance instructions

For RadioShack Cat. No. : 23-149A, 23-449
MATERIAL SAFETY DATA SHEET Date: 3 Jan, 2003
Identity (As Used on Label and List) Note: Blank spaces are not permitted if may item is not applicable or no
GP100AAKC information is available, the space must be marked to indicate that.
Section I
Manufacturer's Name Emergency Telephone Number
GPI International Ltd. / GP Batteries (U.S.A.) Inc.
Address (Number, Street, City, State, and ZIP Code) Telephone Number for information
8/F, Gold Peak Building, 30 Kwai Wing Road, Kwai Chung, N.T. Hong Kong (852) 2484 3333
11235 West Bernardo Court, San Diego, CA92127-1638, U.S.A. [phone]
Section II - Hazardous Ingredients/Identity Information
Hazardous Components:
Description: Approximate % of total weight
Ni(OH)2 (Nickel Hydroxide) ; 20 Wt%
30%KOH Solution (Potassium Hydroxide) ; 12 Wt%
Mercury ;<5 ppm
Lead ; Nil
cadmium ; 17 Wt%
Section III - Physical/Chemical Characteristics
Boiling point Specific Gravity (H2O=1)
N.A. N.A.
Vapor Pressure (mm Hg) Melting Point
N.A. N.A.
Vapor Density (AIR =1) Evaporation Rate
N.A. (Butyl Acetate =1) N.A.
Solubility in Water
N.A.
Appearance and Odor
Cylindrial Shape, odorless
Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
N.A. N.A. N.A. N.A.
Extingushing Media
N.A.
Special Fire Fighting Procedures
N.A.
Unusual Fire and Explosion Hazards
When exposed to excess heat, cell may burst

Section V - Reactivity Data
Stability Unstable Conditions to Avoid
Stable X
Incompatibility (Materials to Avoid)
Hazardous Decomposition or Byproducts
When heated, battery may emit hazardous vapours of KOH/NaOH & Hg.
Hazardous May Occur Conditions to Avoid
reactions
Will Not Occur X
Section VI - Health Hazard Data
Route(s) of Entry Inhalation? Skin? Ingestion?
N.A. N.A. N.A.
Health Hazard (Acute and Chronic)
N.A.
Carcinogenicity NTP? LARC Monographs? OSHA Regulated?
N.A. N.A. N.A.
Signs and Symptoms of Exposure
In case of electolyte leakage, skin will be itchly when contaminated by electrolyte.
Medical Conditions
Generally Aggravated by Exposure N.A.
Emergency and First Aid Procedures
In the event that electrolytes gets on skin, wash immediately with water. For eye contact, flush with copious amounts of water for 15 minutes
and see physian.
Section VII - Precautions for Safe Handling and Use
Steps to Be Taken in Case Material is Released or Spilled
Use neoprene, rubber latex-nitrile gloves when handling leakers. If liquid from leaker comes in contact with skin, wash immediately with
water. For eye contact, flush with copious amounts of water for 15 minutes and see physian.
Waste Disposal Method
Do not incinerate since battery may explode.
Precaution to Be Taken in Handling and Storing
The battery is extremely sensitive to adverse effect of humidity. Be sure to store them in a place which is dry and subject to little temperature
change. Do not place near the boiler or radiator, nor expose to the direct sunlight. Do not dispose of the battery in fire. Do not charge the battery.
Do not short-circuit the battery. Do not put in backward position. Do not disassemble the battery, handling in such manner can cause the battery
to explode, leak and injury.
Other Precautions
Install batteries in accordance with equipment instructions. Replace all batteries in equipment at the same time. Do not mix battery systems of
different types. Do not carry batteries loose in your pocket or carrying bag. Check batteries periodically when in use.
Section VIII - Control Measures
Respiratory Protection (Specify Type)
Ventilation Local Exhausts Special
N.A. N.A.
Mechanical (General) Other
N.A. N.A.
Protective Gloves Eye Protection
N.A. N.A.
Other Protective Clothing or Equipment
N.A.
Work/Hygenic Practices
N.A.