Raritan 221551 User manual

1-800-352-5630
www.raritaneng. com
Description:
Multifunction Momentary Control:
Multifunction momentary control includes a
Switch panel, controller and cable.
Operation:
1. Press and hold “FILL” to add water
to the bowl
2. Press and hold “Empty” to evacuate the
bowl
3. Press and hold “Flush” to bring water in
while bowl is evacuating
Multifunction Momentary Control can also be
congured with SEA/FRESH switch.
EMPTY
FLUSH
FILL
1
Installation and Maintenance Instructions
MULTIFUNCTION MOMENTARY CONTROL
THE FOLLOWING ARE CAUTIONARY STATEMENTS THAT MUST BE READ AND
FOLLOWED DURING BOTH INSTALLATION AND OPERATION.
WARNING: Raritan Engineering Company, Inc. recommends that a qualied person or electrician install this
product. Equipment damage, injury to personnel or death could result from improper installation.
Raritan Engineering Company, Inc. accepts no responsibility or liability for damage to equip-
ment, injury or death to personnel that may result from improper installation or operation of this
product.
WARNING: HAZARD OF SHOCK OR FIRE
Always use recommended fuse, circuit breaker and wire size.
DO NOT install in the area requiring “Ignition protected” devices.
Part # 221551
Width= 1.5” (38.1)
Height= 3” (76.2)
Depth= 1.5” (38.1)
L483 0216jlc

Mounting controls:
A. Mounting control box:
1. Locate a place for control box near toilet. Do not install
box more than six feet away to avoid excessive voltage
drop
2. Route wires between toilet and control
B. Switch Panel:
1. Cut out a hole per Fig. 1, mark
mounting holes using wall plate as guide.
2. Route wire to the toilet and control.
3. Secure control using sealant with two
screws.
C. Sea/fresh control:
1. Follow Switch Panel instructions above.
Fig.1
WIRING
2
Pressurized Freshwater Model - Recommended Wire and Fuse/Circuit Breaker Size
Sea Water Model - Recommended Wire and Fuse/Circuit Breaker Size
NOTES: for Wiring
1. Distances are from source to unit and back to source.
2. Distance from power source to remote intake pump MUST be
included when determining total distance.Same wire size MUST be
used for lower base and remote intake pump.
3. Recommended conductor wire minimum AWG (mm2) for 3% volt-
age drop.
4. Recommended conductor sizes are based on 105oC rated insulation.
Refer to ABYC Standards for other insulation ratings.
5. For 120/240 VAC units use 12VDC specications from transformer
to unit.
Feet 10 15 20 25 30 40 50
Meter 3.1 4.6 6.1 7.6 9.2 12.2 15.2
CONVERSIONS
Wire - AWG to mm2
Feet to Meters
AWG 16 14 12 10 86 4 2
mm21.5 2.5 4.0 6.0 10.0 16.0 25.0 35.0
Units
Voltage
Circuit
Breaker/fuse
size (amps)
Discharge
Amp. draw
Remote Pump
Only
Amp. draw
15
feet
20
feet
30
feet
40
feet
50
feet
Atlantes
Marine Elegance 12 VDC 30 18 10 10 AWG 8 AWG 6 AWG 6 AWG 4 AWG
SeaEra 25 13 10
Atlantes
Marine Elegance 24 VDC 20 10 514 AWG 14 AWG 12 AWG 10 AWG 10 AWG
SeaEra 15 7.5 5
Units
Voltage
Circuit
Breaker/fuse
size (amps)
Amp.
draw
10
feet
15
feet
20
feet
30
feet
40
feet
50
feet
Atlantes
Marine Elegance 12 VDC
25 18 12 AWG 10 AWG 10 AWG 8 AWG 6 AWG 6 AWG
SeaEra 25 13
Atlantes
Marine Elegance 24 VDC
15 10 14 AWG 12 AWG 10 AWG 10 AWG 8 AWG 6 AWG
SeaEra 15 7.5
L483 0216jlc

WIRING
3
Fig. 2 WIRING FOR MULTIFUNCTION MOMENTARY CONTROL,
FRESHWATER MODEL
WIRING
WARNING: Hazard of Shock and Fire
• Alwaysuseproperwire,wireconnectors
andfuse/circuitbreaker.SeeSpecication
Chart.
• Securewireproperly.
• Donotconnectappliancestotoiletcircuit.
• Makesurepowerisobeforeproceeding.
• Use proper wire terminals for all wire
connections.
1. Determine proper wire size by measuring
distance from:
• Power Source to push button to toilet
motor and back to power source.
• Remote pump units - also include
distance from power source for remote
pump to remote pump and back. Same
wire gauge must be used for both
discharge and remote pump.
To start Electroscan from toilet control, run
a wire from “to MSD “ to terminal marked
“EXT TRIG” inside Electroscan control mod-
ule (black box).
To start toilet equipped with Smart toilet
control from Electroscan, connect “Head1” to
“FROM MSD “.
For Lectra/San MC, EC call Raritan Customer
Service
MSD OPERATION
2. Select proper wire and fuse/circuit breaker
size from Specications on specication
page.
3. Install fuse/circuit breaker in positive line
at source.
4. Wire control to the toilet and battery using
one of the following wiring diagrams.
FLUSH
EMPTY
FILL
DISCHARGE
PUMP
BLACK
(12AWG)
RED
(12AWG)
SEE
RECOMMENDED
WIRE SIZE
BLACK
(16AWG)
FUSE/
CIRCUIT BREAKER
BATTERY
BLUE
(16AWG)
SEE
RECOMMENDED
WIRE SIZE
WATER
VALVE
FILL/EMPTY SWITCH
WIRE
JUMPER
GRAY
CABLE
FILL
WHITE
EMPTY
BLACK
IN+
RED
IN PUMP / VALVE - IN PUMP / VALVE +
BATT +
DISCH - DISCH +
TO MSD
BATT -
SF IN VALVE - SF IN VALVE +
SEA/FRESH SWITCH
FILL/EMPTY
SWITCH
R WB WBR
221551
2 1
43
L483 0216jlc

4
Fig. 4
WIRING FOR MULTIFUNCTION MOMENTARY CONTROL WITH SEA FRESH
For limited warranty terms and conditions please refer to toilet manual
Fig. 3
WIRING FOR MULTIFUNCTION MOMENTARY CONTROL WITH REMOTE PUMP
FLUSH
EMPTY
FILL
IN PUMP / VALVE - IN PUMP / VALVE +
BATT +
DISCH - DISCH +
TO MSD
BATT -
SF IN VALVE - SF IN VALVE +
SEA/FRESH SWITCH
FILL/EMPTY
SWITCH
R WB WBR
SEE
RECOMMENDED
WIRE SIZE
SEE
RECOMMENDED
WIRE SIZE
BATTERY
FUSE/
CIRCUIT BREAKER
GRAY
CABLE
FILL
WHITE
EMPTY
BLACK
IN+
RED
WIRE
JUMPER
FILL/EMPTY SWITCH
BLACK
(14AWG)
RED/ORANGE
(14AWG)
BLACK
(12AWG)
RED
(12AWG)
DISCHARGE
PUMP
SEE
RECOMMENDED
WIRE SIZE
221551
2 1
43
FLUSH
EMPTY
FILL
FRESH
SEA
SEE
RECOMMENDED
WIRE SIZE
SEE
RECOMMENDED
WIRE SIZE
BATTERY
FUSE/
CIRCUIT BREAKER
GRAY
CABLE
FILL
WHITE
EMPTY
BLACK
IN+
RED
WIRE
JUMPER
FILL/EMPTY SWITCH
BLACK
(16AWG)
BLUE
(16AWG)
BLACK
(12AWG)
RED
(12AWG)
DISCHARGE
PUMP
WATER
VALVE
GRAY
CABLE
INTAKE WATER
SELECTOR SWITCH
IN+
RED
FRESH
WHITE
SEA
BLACK
BLACK
(14AWG)
RED/ORANGE
(14AWG)
SEE
RECOMMENDED
WIRE SIZE
IN PUMP / VALVE - IN PUMP / VALVE +
BATT +
DISCH - DISCH +
TO MSD
BATT -
SF IN VALVE - SF IN VALVE +
SEA/FRESH SWITCH
FILL/EMPTY
SWITCH
R WB WBR
221551
2 1
43
3
L12
L483 0216jlc
530 Orange Street, Millville, NJ 08332 USA
Telephone: [phone] FAX: [phone]
www.raritaneng.com
Fort Lauderdale, FL
Telephone: [phone]